Abstract
Activated carbon has attracted much attention in the remediation of heavy metal pollution; however, it is still a challenge to explore a cheap and efficient activated carbon for the removal of chromium(VI) from water. In this study, based on the concept of “treating pollution with waste,” a high adsorption performance activated carbon was prepared by in situ carbonization and activation of soybean straw residue with potassium hydroxide as a chemical activator for the purpose of enhancing Cr(VI) removal capacity. The structure and property of the generated soybean straw-based activated carbon (SSAC) was characterized by SEM, FTIR, BET analysis, and XPS. The influence factors (i.e., pH, adsorbent dosage, initial Cr(VI) concentration) on the removal of Cr(VI) by SSAC were studied by batch experiments. Results revealed that SSAC not only exhibited porosity with a huge specific surface area of 1800.28 m2 g−1 but also had abundant electron-donating groups (such as C = C, C–OH) on the surface to reduce Cr(VI) to Cr(III), which both promoted a high adsorption capability with the maximum Cr(VI) adsorption capacity of 294.12 mg g−1 at pH = 2. The adsorption process was in accordance with the Langmuir model and the pseudo second-order model corresponding to monolayer and chemical adsorption, respectively, and it was spontaneous and endothermic. As for the study of mechanism, reduction and electrostatic adsorption may dominate the removal of Cr(VI) by SSAC. All these results indicated that SSAC had the potential to efficiently remove Cr(VI) in aqueous solutions, which may be a promising adsorbent to provide a potential solution for solving the problems of heavy metal pollution and straw agricultural residue disposal.
Graphical abstract
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
Data Availability
All data generated or analyzed during this study are included in this published article.
References
Al-Gaashani, R., Najjar, A., Zakaria, Y., Mansour, & Atieh, S. M. (2019). XPS and structural studies of high quality graphene oxide and reduced graphene oxide prepared by different chemical oxidation methods. Ceramics International, 45, 14439–14448. https://doi.org/10.1016/j.ceramint.2019.04.165.
AL-Othman, Z., Ali, R., & Naushad, M. (2012). Hexavalent chromium removal from aqueous medium by activated carbon prepared from peanut shell: Adsorption kinetics, equilibrium and thermodynamic studies. Chemical Engineering Journal, 184, 238–247. https://doi.org/10.1016/j.cej.2012.01.048.
Altun, T., & Pehlivan, E. (2012). Removal of Cr(VI) from aqueous solutions by modified walnut shells. Food Chemistry, 132, 693–700. https://doi.org/10.1016/j.foodchem.2011.10.099.
Awual, M. (2019). Novel conjugated hybrid material for efficient lead(II) capturing from contaminated wastewater. Materials Science & Engineering C-Materials for Biological Applications, 101, 686–695. https://doi.org/10.1016/j.msec.2019.04.015.
Bedia, J., Belver, C., Ponce, S., Rodriguez, J., & Rodriguez, J. J. (2018). Adsorption of antipyrine by activated carbons from FeCl3-activation of Tara gum. Chemical Engineering Journal, 333, 58–65. https://doi.org/10.1016/j.cej.2017.09.161.
Cabrera, E., Munoz, M., Martin, R., Caro, I., Curbelo, C., & Diaz, A. (2015). Comparison of industrially viable pretreatments to enhance soybean straw biodegradability. Bioresource Technology, 194, 1–6. https://doi.org/10.1016/j.biortech.2015.06.090.
Cai, W., Gu, M., Jin, W., & Zhou, J. (2019). CTAB-functionalized C@SiO2 double-shelled hollow microspheres with enhanced and selective adsorption performance for Cr(VI). Journal of Alloys and Compounds, 777, 1304–1312. https://doi.org/10.1016/j.jallcom.2018.11.070.
Chen, D., Li, W., Wu, Y., Zhu, Q., Lu, Z., & Du, G. (2013). Preparation and characterization of chitosan/montmorillonite magnetic microspheres and its application for the removal of Cr(VI). Chemical Engineering Journal, 221, 8–15. https://doi.org/10.1016/j.cej.2013.01.089.
Cieslak-Golonka, M. (1996). Toxic and mutagenic effects of chromium (VI). Polyhedron, 15, 3667–3918. https://doi.org/10.1016/0277-5387(96)00141-6.
de Bittencourt, M., Novack, A., Scherer, J., Mazur, L., Marinho, B., da Silva, A., de Souza, A., & de Souza, S. (2020). Application of FeCl3 and TiO2-coated algae as innovative biophotocatalysts for Cr(VI) removal from aqueous solution: A process intensification strategy. Journal of Cleaner Production, 268(122164), 122164. https://doi.org/10.1016/j.jclepro.2020.122164.
El-Hendawy, A. (2006). Variation in the FTIR spectra of a biomass under impregnation, carbonization and oxidation conditions. Journal of Analytical and Applied Pyrolysis, 75, 159–166. https://doi.org/10.1016/j.jaap.2005.05.004.
Fan, L., Wan, W., Wang, X., Cai, J., Chen, F., Chen, W., Ji, L., Luo, H., & Cheng, L. (2019). Adsorption removal of Cr(VI) with activated carbon prepared by co-pyrolysis of rice straw and sewage sludge with ZnCl2 activation. Water, Air, & Soil Pollution, 230, 233. https://doi.org/10.1007/s11270-019-4305-8.
Ghadikolaei, N., Kowsari, E., Balou, S., & Moradi, A. (2019). Preparation of porous biomass-derived hydrothermal carbon modified with terminal amino hyperbranched polymer for prominent Cr(VI) removal from water. Bioresource Technology, 288, 121545. https://doi.org/10.1016/j.biortech.2019.121545.
Godlewska, P., Siatecka, A., Konczak, M., & Oleszczuk, P. (2019). Adsorption capacity of phenanthrene and pyrene to engineered carbon-based adsorbents produced from sewage sludge or sewage sludge-biomass mixture in various gaseous conditions. Bioresource Technology, 280, 421–429. https://doi.org/10.1016/j.biortech.2019.02.021.
Goswami, M., & Borah, L. (2014). Equilibrium modeling, kinetic and thermodynamic studies on the adsorption of Cr(VI) using activated carbon derived from matured tea leaves. Journal of Porous Material, 21, 1025–1034. https://doi.org/10.1007/s10934-014-9852-1.
Gottipati, R., & Mishra, S. (2016). Preparation of microporous activated carbon from Aegle Marmelos fruit shell and its application in removal of chromium(VI) from aqueous phase. Journal of Industrial and Engineering Chemistry, 36, 355–363. https://doi.org/10.1016/j.jiec.2016.03.005.
Hefne, J., Mekhemer, W., Alandis, N., Aldayel, O., & Alajyan, T. (2008). Kinetic and thermodynamic study of the adsorption of Pb (II) from aqueous solution to the natural and treated bentonite. International Journal of Physical Sciences, 3, 281–288.
Hoan, N., Thu, N., Van Duc, H., Cuong, N., Khieu, D., & Vo, V. (2016). Fe3O4/reduced graphene oxide nanocomposite: Synthesis and its application for toxic metal ion removal. Journal of Chemistry, 2016. https://doi.org/10.1155/2016/2418172.
Hosseinzadeh, H., & Ramin, S. (2018). Effective removal of copper from aqueous solutions by modified magnetic chitosan/graphene oxide nanocomposites. International Journal of Biological Macromolecules, 113, 859–868. https://doi.org/10.1016/j.ijbiomac.2018.03.028.
Hu, X., Wang, J., Liu, Y., Li, X., Zeng, G., Bao, Z., Zeng, X., Chen, A., & Long, F. (2011). Adsorption of chromium(VI) by ethylenediamine modified cross-linked magnetic chitosan resin: Isotherms, kinetics and thermodynamics. Journal of Hazardous Materials, 185, 306–314. https://doi.org/10.1016/j.jhazmat.2010.09.034.
Hu, B., He, M., & Chen, B. (2015). Nanometer-sized materials for solid-phase extraction of trace elements. Analytical and Bioanalytical Chemisty, 407, 2685–2710. https://doi.org/10.1007/s00216-014-8429-9.
Hu, Z., Omer, A., Ouyang, X., & Yu, D. (2018). Fabrication of carboxylated cellulose nanocrystal sodium alginate hydrogel beads for adsorption of Pb(II) from aqueous solution. International Journal of Biological Macromolecules, 108, 149–157. https://doi.org/10.1016/j.ijbiomac.2017.11.171.
Jin, J., & Li, S. (2018). HNO3 modified biochars for uranium (VI) removal from aqueous solution. Bioresource Technology, 256, 247–253. https://doi.org/10.1016/j.biortech.2018.02.022.
Jrobby, R., Jha, P., Yadav, A., & Desai, N. (2008). Biosorption and biotransformation of hexavalent chromium [Cr(VI)]: A comprehensive review. Chemosphere, 207, 255–266. https://doi.org/10.1016/j.chemosphere.2018.05.050.
Kanojia, R., Junaid, M., & Murthy, R. (1998). Embryo and fetotoxicity of hexavalent chromium: A long-term study. Toxicology Letters, 95, 165–172. https://doi.org/10.1016/S0378-4274(98)00034-4.
Karthikeyan, T., Rajgopal, S., & Miranda, L. (2005). Chromium(VI) adsorption from aqueous solution by Hevea brasilinesis sawdust activated carbon. Journal of Hazardous Materials, 124, 192–199. https://doi.org/10.1016/j.jhazmat.2005.05.003.
Kaveeshwar, A., Kumar, P., Revellame, E., Gang, D., Zappi, M., & Subramaniam, R. (2018). Adsorption properties and mechanism of barium(II) and strontium(II) removal from fracking wastewater using pecan shell based activated carbon. Journal of Cleaner Production, 193, 1–13. https://doi.org/10.1016/j.jclepro.2018.05.041.
Kumara, A., Thakur, A., & Panesar, P. (2019). Extraction of hexavalent chromium by environmentally benign green emulsion liquid membrane using tridodecyamine as an extractant. Journal of Industrial and Engineering Chemistry, 70, 394–401. https://doi.org/10.1016/j.jiec.2018.11.002.
Kwon, G., Bhatnagar, A., Wang, H., Kwon, E., & Song, H. (2020). A review of recent advancements in utilization of biomass and industrial wastes into engineered biochar. Journal of Hazardous Materials, 400, 123–242. https://doi.org/10.1016/j.jhazmat.2020.123242.
Leng, S., Li, W., Han, C., Chen, L., Chen, J., Fan, L., Lu, Q., Li, J., Leng, L., & Zhou, W. (2020). Aqueous phase recirculation during hydrothermal carbonization of microalgae and soybean straw: A comparison study. Bioresource Technology, 298, 122502. https://doi.org/10.1016/j.biortech.2019.122502.
Li, C., Chen, H., & Li, Z. (2004). Adsorptive removal of Cr(VI) by Fe-modified steam exploded wheat straw. Process Biochemistry, 39, 541–545. https://doi.org/10.1016/S0032-9592(03)00087-6.
Li, Y., Tsend, N., Li, T., Liu, H., Yang, R., Gai, X., Wang, H., & Shan, S. (2019). Microwave assisted hydrothermal preparation of rice straw hydrochars for adsorption of organics and heavy metals. Bioresource Technology, 273, 136–143. https://doi.org/10.1016/j.biortech.2018.10.056.
Liu, H., Sun, Y., Yu, T., Zhang, J., Zhang, X., Zhang, H., Zhao, K., & Wei, J. (2019). Plant-mediated biosynthesis of iron nanoparticles calcium alginate hydrogel membrane and its eminent performance in removal of Cr(VI). Chemical Engineering Journal, 378, 122120. https://doi.org/10.1016/j.cej.2019.122120.
Lv, D., Liu, Y., Zhou, J., Yang, K., Lou, Z., Baig, S., & Xu, X. (2018). Application of EDTA-functionalized bamboo activated carbon (BAC) for Pb(II) and Cu(II) removal from aqueous solutions. Applied Surface Science, 428, 648–658. https://doi.org/10.1016/j.apsusc.2017.09.151.
Martelli-Tosi, M., Masson, M., Silva, N., Esposto, B., Barros, T., Assic, O., & Tapia-Blacido, D. (2018). Soybean straw nanocellulose produced by enzymatic or acid treatment as a reinforcing filler in soy protein isolate films. Carbohydrate Polymers, 198, 61–68. https://doi.org/10.1016/j.carbpol.2018.06.053.
Mnasri-Ghnimi, S., & Frini-Srasra, N. (2019). Removal of heavy metals from aqueous solutions by adsorption using single and mixed pillared clays. Apply Clay Science, 179, 105151. https://doi.org/10.1016/j.clay.2019.105151.
Mortazavian, S., An, H., Chun, D., & Moon, J. (2018). Activated carbon impregnated by zero-valent iron nanoparticles (AC/nZVI) optimized for simultaneous adsorption and reduction of aqueous hexavalent chromium: Material characterizations and kinetic studies. Chemical Engineering Journal, 353, 781–795. https://doi.org/10.1016/j.cej.2018.07.170.
Nasrullah, A., Bhat, A., Naeem, A., Isa, M., & Danish, M. (2018). High surface area mesoporous activated carbon-alginate beads for efficient removal of methylene blue. International Journal of Biological Macromolecules, 107, 1792–1799. https://doi.org/10.1016/j.ijbiomac.2017.10.045.
Niazi, N., Lashanizadegan, A., & Sharififard, H. (2018). Chestnut oak shells activated carbon: Preparation, characterization and application for Cr(VI) removal from dilute aqueous solutions. Journal of Cleaner Production, 185, 554–561. https://doi.org/10.1016/j.jclepro.2018.03.026.
Norouzia, S., Heidari, M., Alipour, V., Rahmanian, O., Fazlzdeh, M., Mohammadi-Moghadam, F., Nourmoradi, H., Goudarzi, B., & Dindarloo, K. (2018). Preparation, characterization and Cr(VI) adsorption evaluation of NaOH activated carbon produced from Date Press Cake: An agro-industrial waste. Bioresource Technology, 258, 48–56. https://doi.org/10.1016/j.biortech.2018.02.106.
Nourmoradi, H., & Avazpour, M. (2016). Surfactant modified montmorillonite as a low cost adsorbent for 4-chlorophenol: Equilibrium, kinetic and thermodynamic study. Journal of the Taiwan Institute of Chemical Engineers, 59, 244–251. https://doi.org/10.1016/j.jtice.2015.07.030.
Ouyang, J., Zhou, L., Liu, Z., Heng, J., & Chen, W. (2020). Biomass-derived activated carbons for the removal of pharmaceutical mircopollutants from wastewater: A review. Separation and Purification Technology, 253, 117536. https://doi.org/10.1016/j.seppur.2020.117536.
Park, D., Lim, S., Yun, Y., & Park, J. (2007). Reliable evidences that the removal mechanism of hexavalent chromium by natural biomaterials is adsorption-coupled reduction. Chemosphere, 2, 298–305. https://doi.org/10.1016/j.chemosphere.2007.06.007.
Qiu, Y., Zhang, Q., Gao, B., Li, M., Fan, Z., Sang, W., Hao, H., & Wei, X. (2020). Removal mechanisms of Cr(VI) and Cr(III) by biochar supported nanosized zerovalent iron: Synergy of adsorption, reduction and transformation. Environmental Pollution, 265, 115018. https://doi.org/10.1016/j.envpol.2020.115018.
Qu, J., Wang, Y., Tian, X., Jiang, Z., Deng, F., Tao, Y., Jiang, Q., Wang, L., & Zhang, Y. (2021). KOH-activated porous biochar with high specific surface area for adsorptive removal of chromium(VI) and naphthalene from water: Affecting factors, mechanisms and reusability exploration. Journal of Hazardous Materials, 401, 123292. https://doi.org/10.1016/j.jhazmat.2020.123292.
Saber, A., Tafazzoli, M., Mortazavian, S., & James, D. (2018). Investigation of kinetics and absorption isotherm models for hydroponic phytoremediation of waters contaminated with sulfate. Journal of Environmental Management, 207, 276–291. https://doi.org/10.1016/j.jenvman.2017.11.039.
Tu, B., Wen, R., Wang, K., Cheng, Y., Deng, Y., Cao, W., Zhang, K., & Tao, H. (2020). Efficient removal of aqueous hexavalent chromium by activated carbon derived from Bermuda grass. The Journal of Colloid and Interface Science, 560, 649–658. https://doi.org/10.1016/j.jcis.2019.10.103.
Vlyssides, A., & Israelites, C. (1997). Detoxification of tannery waste liquors with an electrolysis system. Environmental Pollution, 97, 147–152. https://doi.org/10.1016/S0269-7491(97)00062-6.
Wan, C., Zhou, Y., & Li, Y. (2011). Liquid hot water and alkaline pretreatment of soybean straw for improving cellulose digestibility. Bioresource Technology, 102, 6254–6259. https://doi.org/10.1016/j.biortech.2011.02.075.
Wang, N., Jin, R., Ome, A., & Ouyang, X. (2017). Adsorption of Pb(II) from fish sauce using carboxylated cellulose nanocrystal Isotherm, kinetics, and thermodynamic studies. International Journal of Biological Macromolecules, 102, 232–240. https://doi.org/10.1016/j.ijbiomac.2017.03.150.
Wang, T., Zheng, L., Liu, Y., Tang, W., Fang, T., & Xing, B. (2020). A novel ternary magnetic Fe3O4/g-C3N4/Carbon layer composite for efficient removal of Cr(VI): A combined approach using both batch experiments and theoretical calculation. Science of the Total Environment, 730, 138928. https://doi.org/10.1016/j.scitotenv.2020.138928.
Wei, S., Li, D., Huang, Z., Huang, Y., & Wang, F. (2013). High-capacity adsorption of Cr(VI) from aqueous solution using a hierarchical porous carbon obtained from pig bone. Bioresource Technology, 134, 407–411. https://doi.org/10.1016/j.biortech.2013.02.040.
Wen, R., Tu, B., Guo, X., Hao, X., Wu, X., & Tao, H. (2020). An ion release controlled Cr(VI) treatment agent: Nano zero-valent iron/carbon/alginate composite gel. International Journal of Biological Macromolecules, 146, 692–704. https://doi.org/10.1016/j.ijbiomac.2019.12.168.
Yang, J., Yu, M., & Chen, W. (2015). Adsorption of hexavalent chromium from aqueous solution by activated carbon prepared from longan seed: Kinetics, equilibrium and thermodynamics. Journal of Industrial and Engineering Chemistry, 21, 414–422. https://doi.org/10.1016/j.jiec.2014.02.054.
Yu, P., Wang, X., Zhang, K., Wu, M., Wu, Q., Liu, J., Yang, J., & Zhang, J. (2020). Continuous purification of simulated wastewater based on rice straw composites for oil/water separation and removal of heavy metal ions. Cellulose, 27, 5223–5239. https://doi.org/10.1007/s10570-020-03135-4.
Zhang, J., & Zheng, P. (2015). A preliminary investigation of the mechanism of hexavalent chromium removal by corn-bran residue and derived chars. RSC Advances, 5, 17768–17774. https://doi.org/10.1039/c4ra12351d.
Zhang, H., Tang, Y., Cai, D., Liu, X., Wang, X., Huang, Q., & Yu, Z. (2010). Hexavalent chromium removal from aqueous solution by algal bloom residue derived activated carbon: Equilibrium and kinetic studies. Journal of Hazardous Materials, 181, 801–808. https://doi.org/10.1016/j.jhazmat.2010.05.084.
Zhang, J., Chen, S., Zhang, H., & Wang, X. (2017a). Removal behaviors and mechanisms of hexavalent chromium from aqueous solution by cephalosporin residue and derived chars. Bioresource Technology, 238, 484–491. https://doi.org/10.1016/j.biortech.2017.04.081.
Zhang, L., Zhao, Y., Zhong, L., Wang, Y., Chai, S., Yang, T., & Han, X. (2017b). Cu2S-Cu-TiO2mesoporous carbon composites for the degradation of high concentration of methyl orange under visible light. Applied Clay Science, 422, 1093–1101. https://doi.org/10.1016/j.apsusc.2017.05.100.
Zhou, Y., He, Y., Xiang, Y., Meng, S., Liu, X., Yu, J., Yang, J., Zhang, J., Qin, P., & Luo, L. (2019). Single and simultaneous adsorption of pefloxacin and Cu(II) ions from aqueous solutions by oxidized multiwalled carbon nanotube. Science of the Total Environment, 646, 29–36. https://doi.org/10.1016/j.scitotenv.2018.07.267.
Funding
This work was supported by the University Synergy Innovation Program of Anhui Province (GXXT-2020–075), the Anhui Laboratory of Molecule-Based Materials (fzj19011), and the Natural Science Foundation of China (No. 21707001).
Author information
Authors and Affiliations
Contributions
Xiaohong Guo: conceptualization, methodology, software, writing-original draft, writing-reviewing, and editing; Weiwei Hu: investigation, data curation, reviewing, and editing; Zheng Gu: data curation, reviewing, and editing; Jiali Li: formal analysis, validation, reviewing, and editing; Zongfan Xie: formal analysis, reviewing, and editing; Caixia Fang: visualization, reviewing, and editing; Haisheng Tao: writing-review-revise, editing, supervision, and project administration.
Corresponding author
Ethics declarations
Competing Interests
The authors declare no competing interests.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Supplementary Information
Below is the link to the electronic supplementary material.
Rights and permissions
About this article
Cite this article
Guo, X., Hu, W., Gu, Z. et al. Enhanced removal of aqueous chromium(VI) by KOH-activated soybean straw-based carbon. Water Air Soil Pollut 232, 484 (2021). https://doi.org/10.1007/s11270-021-05435-2
Received:
Accepted:
Published:
DOI: https://doi.org/10.1007/s11270-021-05435-2