Abstract
Background
Tyrosinase is a bifunctional enzyme that catalyzes both the hydroxylation of monophenols to o-diphenols (monophenolase activity) and the subsequent oxidation of the diphenols to o-quinones (diphenolase activity). Due to the potential applications of tyrosinase in biotechnology, in particular in biocatalysis and for biosensors, it is desirable to develop a suitable low-cost process for efficient production of this enzyme. So far, the best production yield reported for tyrosinase was about 1 g L-1, which was achieved by cultivating the filamentous fungus Trichoderma reesei for 6 days.
Results
In this work, tyrosinase from Verrucomicrobium spinosum was expressed in Escherichia coli and its production was studied in both batch and fed-batch cultivations. Effects of various key cultivation parameters on tyrosinase production were first examined in batch cultures to identify optimal conditions. It was found that a culture temperature of 32 °C and induction at the late growth stage were favorable, leading to a highest tyrosinase activity of 0.76 U mL-1. The fed-batch process was performed by using an exponential feeding strategy to achieve high cell density. With the fed-batch process, a final biomass concentration of 37 g L-1 (based on optical density) and a tyrosinase activity of 13 U mL-1 were obtained in 28 hours, leading to a yield of active tyrosinase of about 3 g L-1. The highest overall volumetric productivity of 103 mg of active tyrosinase per liter and hour (corresponding to 464 mU L-1 h-1) was determined, which is approximately 15 times higher than that obtained in batch cultures.
Conclusions
We have successfully expressed and produced gram quantities per liter of active tyrosinase in recombinant E. coli by optimizing the expression conditions and fed-batch cultivation strategy. Exponential feed of substrate helped to prolong the exponential phase of growth, to reduce the fermentation time and thus the cost. A specific tyrosinase production rate of 103 mg L−1 h−1 and a maximum volumetric activity of 464 mU L−1 h-1 were achieved in this study. These levels have not been reported previously.
Similar content being viewed by others
Background
Tyrosinase is a bifunctional enzyme that catalyzes both the hydroxylation of monophenols to o-diphenols (monophenolase activity) and the subsequent oxidation of the diphenols to o-quinones (diphenolase activity) [1]. Tyrosinase is essential for many living organisms to carry out various functions, including melanin biosynthesis as defense against the harmful effects of UV light [2–4]. In plants, it is required for the biosynthesis of phenolic polymers such as lignin, flavinoids, and tannins [5]. Tyrosinases also play an important role in the regulation of the oxidation-reduction potential of cell respiration and in wound healing in plants [6, 7].
Due to the ability of tyrosinases to react with phenols, these enzymes have been proposed for the uses in a variety of biotechnological, biosensor and biocatalysis applications [1, 8, 9]. For example, tyrosinases can be applied in detoxification of phenol-containing wastewater and contaminant soils [10], synthesis of L-3,4-dihydroxyphenylalanine (L-DOPA), one of the preferred drugs for the treatment of Parkinson‘s disease [11], or as additives in food processes due to their cross-linking abilities [12, 13]. Tailoring polymers, e.g. grafting of silk proteins onto chitosan via tyrosinase reactions have also been reported [14, 15]. Immobilized tyrosinase has been investigated as an electrochemical biosensor for a range of phenolic compounds [16]. The enzyme can react with exposed tyrosyl side chains in polypeptides, and the reactive quinones formed allow for protein-protein cross-linking [17–21].
Tyrosinases have been isolated and purified from various sources such as animals, plants, fungi, and bacteria [2, 22–25]. The commercial production of tyrosinase is mostly reported from the common mushroom Agaricus bisporus. Extensive research has been carried out by using this mushroom tyrosinase because of its commercial availability. However, the use of tyrosinase from this source is problematic as the enzyme exhibits relatively low solvent and temperature stability, as compared to some bacterial tyrosinases [26–28]. Moreover, commercial tyrosinases are typically contaminated with other enzymes for example different isoforms, resulting in preparations of variable quality and activity [29]. Almost all reported tyrosinase-producing microbial (both fungal and bacterial) strains also produce other polyphenol oxidases such as peroxidase and laccase [30]. The presence of laccase and peroxidase along with tyrosinase imposes serious problems for commercial usage [31]. All these enzymes can use tyrosine as substrate but produce different products, resulting in reduced yield as well as increased cost for the downstream process. Recently, it was reported that a new Actinomycetes isolate produced only tyrosinase and did not exhibit peroxidase or laccase activities [30]. The production yield of tyrosinase was about 4.8 U mL-1 after 48 h incubation, which is still far too low to be applied for commercial purposes.
The recombinant production of tyrosinases becomes an attractive alternative to obtain large amounts of protein. Recombinant strains offer the possibility of a higher protein production level, better growth, and consequently, an improved productivity when compared to non-recombinant production systems. However, tyrosinases appear to be difficult to express in recombinant hosts and only a few examples have been reported. The human tyrosinase has been expressed mostly as insoluble protein in inclusion bodies in Escherichia coli[32, 33]. Tyrosinase from Pycnoporus sanguineus was expressed in Aspergillus niger[34], and the Streptomyces castaneoglobisporus tyrosinase was expressed in a complex with its “caddy” protein, ORF378, in E. coli[35]. Tyrosinase production has also been reported for the filamentous fungus Trichoderma reesei[36]. Overexpression of the tyrosinase gene allowed the native host T. reesei to produce about 1 g L-1 tyrosinase in laboratory-scale batch fermentation after 6 days of cultivation [36]. Since growth of filamentous fungi is slow compared with most single-cell microorganisms, Pichia pastoris carrying the tyrosinase gene of T. reesei was tested and yielded 24 mg L-1 active recombinant tyrosinase in 3 days [37]. The E. coli recombinant was also used as host to produce tyrosinase from Streptomyces sp. REN-21, and 54 mg L-1 of the enzyme were obtained in the cytoplasm after 16 h incubation [26]. Recently, we have overexpressed and characterized the tyrosinase from Verrucomicrobium spinosum in E. coli[38]. However, even though the yield of this enzyme (150 mg L-1) was higher than those reported from other bacterial tyrosinases (unpublished data), we considered this yield could be further improved.
E. coli is commonly used as host for the rapid and economical production of recombinant proteins. Different cultivation techniques have been developed to increase the final biomass concentration [39, 40]. However, high-level production of functional proteins in E. coli may not be a routine matter and is sometimes challenging. Not every protein can be produced efficiently due to the unique structural features of the protein, its folding pathways and its degradation by host cell proteases [41]. Since useful recombinant proteins have to be biologically active, the objectives for production should include not only maximization of the amount of recombinant protein, but also of total enzyme activity.
The current work is based on the successful cloning of the tyrosinase gene from V. spinosum in E. coli and its purification and characterization [38]. The objective of this work was to develop a suitable strategy for efficient production of active tyrosinase in E. coli. The effect of temperature, inducer isopropyl-beta-D-thiogalactopyranosides (IPTG) concentrations and the starting time of induction in different operation modes (batch and fed-batch) were investigated. About 3 g L-1 active tyrosinase were obtained after 28 hours of incubation under the developed conditions. To our knowledge, this is the best yield and productivity ever reported for recombinant tyrosinase.
Results and discussion
Production of tyrosinase in batch culture
In order to establish an efficient production process for tyrosinase, preliminary optimization studies were performed in shake flasks. This allowed the selection of the best production host, growth temperature, time for induction and inducer concentration by using conventional methodology with changing one variable at a time.
Influence of different host strains on tyrosinase production
To reach efficient tyrosinase production, cells with high growth rate, high maximum biomass and high level tyrosinase activity are desired. However, overproduction of a protein often hinders the growth of bacterial cells and vice versa[42]. Thus, it is plausible to let the cells grow to a high cell density, and then induce expression of the relevant gene so that the protein of interest will be produced. In this study, E. coli DH5α, JM109 and BLR were transformed with pMFvpt which contains the gene encoding the cytoplasmic full-length tyrosinase (53.5 kDa) of Verrucomicrobium spinosum[38]. The obtained recombinants were cultivated in shake flasks at 37°C and 150 rpm, and induced with 1 mM IPTG at the early exponential growth phase (OD600 ≈ 0.6). The cultivations were continued for 24 h and samples were taken periodically for measurement of cell density and tyrosinase activity. The results are summarized in Table 1. Although the DH5α recombinant exhibited the highest tyrosinase production, the growth rate was more than 2 fold lower than that obtained with two other tested hosts. Furthermore, the expression of the tyrosinase gene could not be controlled in recombinant DH5α because DH5α does not have the repressor protein LacIq and enables constitutive expression of tyrosinase gene from the T5 promoter / lac operator element in pMFvpt. BLR exhibited uncontrolled expression and very low activity of tyrosinase. By contrast, the JM109 recombinant showed controlled expression due to the presence of the LacIq repressor, even though the total tyrosinase production was lower than that in DH5α. Furthermore, the JM109 recombinant exhibited a high growth rate of 0.6 h-1. In order to reach high cell density, high growth rate and controlled production of the relevant protein are desired. Thus, in this study JM109 recombinant was chosen for further investigations.
Influence of oxygen supply on tyrosinase production
To investigate the influence of oxygen on tyrosinase production, experiments were conducted by comparing the cultures in baffled and non-baffled shake flasks. It was found that the total tyrosinase activity increased with an increase of cell density (Figure 1). Compared with the non-baffled culture, the baffled culture led to a higher final cell density and consequently to a higher total tyrosinase activity. Thus, sufficient oxygen supply is advantageous for tyrosinase production. These data demonstrated that tyrosinase production is associated with cell density: the volumetric tyrosinase activity increased in the same manner as the exponential growth of the cells (Figure 1).
Time course of cell growth and tyrosinase activity influenced by O 2 . The freshly transformed E. coli JM109 (pMFvpt) recombinant cells were grown in shake flasks at 37°C and induced at the early exponential growth phase with 1.0 mM IPTG. The arrow indicates the time of IPTG induction. Data points are the averages of the results of duplicate measurements.
Influence of induction stage on tyrosinase production
The influence of different concentrations of IPTG on cell growth and tyrosinase production was first tested. It was found that the biomass, the growth rate and the total tyrosinase activities were not influenced significantly by the tested IPTG concentrations between 0.1 mM and 1.0 mM (data not shown).
As mentioned above, overexpression of a protein places an additional metabolic burden on the energy of the cells, carbon and amino acid pools, which may result in reduced cell growth. This can be avoided by employing inducible expression systems. The culture conditions at the time of induction can affect the efficiency of induction. In this study, IPTG induction was initiated at different growth stages, i.e. in the early-, mid- or late-exponential growth phase (Figure 2 and Table 2). Figure 2 shows that early induction led to immediate tyrosinase production within 6 h of cultivation. However, the tyrosinase band on the SDS-PAG disappeared after 12 h of cultivation, indicating the enzyme was either degraded or diluted with the increase of biomass. Induction at the mid-growth phase resulted in the production of tyrosinase after 2 h induction. The tyrosinase levels increased with cultivation time and reached the maximum at the end of cultivation (24 h) (Figure 2). Induction at the late-growth phase gave a high level of tyrosinase already after 4 h of induction (i.e. after 12 h of growth) and prolonged cultivation did not cause significant increase of the enzyme (Figure 2). The best stage for induction was thus the late-exponential growth phase: even though the growth rate and maximal biomass were similar to those of induction at mid-growth stage, the total tyrosinase activity was about 1.6 fold higher than in the latter case (Table 2). The early induction led to the lowest growth rate and lowest maximal biomass. The total tyrosinase activity was also 10–15 fold lower than that at mid- or late-growth phase induction (Table 2).
Influence of induction stages on tyrosinase production. The freshly transformed E. coli JM109 (pMFvpt) recombinant cells were grown in shake flasks at 37°C and induced with 1 mM IPTG at the early (from the beginning of the cultivation), mid (6 h cultivation) or late (8 h cultivation) growth phase. The extracts of E. coli JM109 (pMFvpt) were prepared and analyzed by SDS-PAGE. Lanes 1–4, samples from induction at the beginning of the cultivation; Lanes 5–8, samples from induction at mid-growth phase; lanes 9–11, samples from induction at late-growth phase. The arrow indicates the position of tyrosinase in the gel. Molecular weight standards are shown on the left.
Investigation of the induction stage is an important parameter for the development of the optimized protein production, especially when a strong promoter system is used, which was the case in this study. Induction of a strong promoter often leads to a sudden burst of protein synthesis which may inhibit cell growth due to a severe metabolic burden [43]. This can be well demonstrated by the results obtained here: early induction led to a reduced growth rate (Table 2).
Influence of temperature on tyrosinase production
For high cell density cultures, temperature control is very important due to considerable heat release at high viscosity. Temperature should support cell growth as well as product formation. In this study, time courses at temperatures of 25, 30, 32, and 37°C were followed. Decreasing the temperature from 37°C to 25°C led to decrease of grow rate, as expected. At 25°C only about half of the growth rate reached at 37°C was achieved (Table 3). The impact of the incubation temperature on tyrosinase production could also be clearly seen in Table 3. The best tyrosinase production (0.76 U mL-1) was observed at 32°C. An increase from 32°C to 37°C resulted in about 2 fold lower enzyme production, while the shift of incubation temperature from 32°C to 30°C reduced the enzyme production 3.5 fold (Table 3). Decrease of temperature from 32°C to 25°C caused a more than 5 fold reduction of the total enzyme yield. Time course experiments at different temperatures allowed to quickly optimize expression conditions for high level production of tyrosinase.
Tyrosinase production using fed-batch cultivation
Different processes focusing on nutrient feeding strategies have been developed to grow cells to high cell densities and to overproduce proteins [44]. The most important function of such strategies is to prevent overfeeding, as inhibitory concentrations of the feed components can accumulate in the fermenter, or underfeeding, by which the organism is starved for essential nutrients. The method of choice depends on many different factors, including the metabolism of the organism, the potential for production of inhibitory substrates and induction conditions. Batch [45], continuous [46], and a variety of fed-batch processes [39, 47] have been reported for growing cells to high densities. Among these, fed-batch is the most commonly used method to produce recombinant proteins [44].
Using exponential feeding would allow the culture to be kept in an extended exponential growth phase even at high cell density. In our case, production of recombinant tyrosinase is correlated with cell density during the growth (Figure 1). It was therefore decided to apply an exponential forward-feed strategy. Experiments were performed in a 1 L controlled bioreactor. Cells were first grown in batch medium at the optimal temperature of 32°C with glycerol as the carbon source. Batch growth, which preceded the fed-batch cultivation, resulted in a maximum growth rate of 0.4 h−1. Feeding started after 16 h of batch growth when glycerol was completely consumed (Figure 3A). The exponential mass-flow rate of glycerol in the feeding solution was set at 0.3 h−1. When OD600 reached about 34 (at 22 h of cultivation), cells were induced with 1.25 mM IPTG, and tyrosinase activity was followed with time. Figure 3B shows the growth profile and the total tyrosinase activity as a function of time during the fed-batch phase. The culture appeared to grow with a growth rate of 0.28 h−1. The difference between the feeding rate of 0.3 h−1 and the growth rate of 0.28 h−1 can be explained by the fact that glycerol was not only used for growth, but also for cell maintenance. It was also observed that when the feeding was stopped manually on purpose, the dissolved oxygen concentration instantly increased sharply (Figure 3A). This suggests that during the fed-batch mode the growing cells immediately consumed any glycerol that was added to the culture. The exponential growth phase lasted until the cell density reached 37 g L-1 (OD600 of 102) after 28 h of incubation, after which there was very little change in the cell density (Figure 3B). This was mainly due to the limitation of the bioreactor capacity: the dissolved oxygen could not be further increased even by using pure oxygen. Production of active tyrosinase increased steadily from 0 to 13 U mL-1 after 6 h induction, and increased only slightly from 13 to 13.6 U mL-1 with the prolongation from 28 to 40 h (Figure 3B). The obtained activity of 13 U mL-1 corresponded to 2.89 g L-1 of active tyrosinase in the culture based on our previous findings that the specific activity of purified tyrosinase is about 4.5 U mg-1[38]. Compared with the previously reported process where 1 g L-1 tyrosinase was produced in 6 days [36], the process established in this study allowed production of almost 3 g L-1 active tyrosinase in 28 hours, which is about 15 fold higher with respect to process productivity.
Tyrosinase production of freshly transformed E. coli JM109 (pMFvpt) during the fed-batch cultivation. Cells were grown at 32°C and induced with 1.25 mM IPTG at an OD600 value of 34. (A) Example of the fed-batch process applied in this study. The time course of the dissolved oxygen (pO2) (blue color), pure oxygen input (red color) and the OD600 values (green color) is shown. The dashed arrow indicates the time when feeding started; the solid arrow indicates the onset of induction. (B) Time-profiles of cell density (OD600) and volumetric activity (U mL-1) of tyrosinase during the fed-batch cultivation. The dashed arrow indicates the time when feeding started, the solid arrow indicates the onset of induction. (C) SDS-PAGE of proteins prepared from extracts of E. coli JM109 (pMFvpt). Samples were taken after 22 h just before induction (lanes 1, 4 and 7), after 28 h (6 h induction, lanes 2, 5 and 8), and after 40 h (18 h induction, lanes 3, 6 and 9). Lanes 1–3, insoluble proteins; Lanes 4–6, soluble proteins; lanes 7–9, total proteins. The arrow indicates the position of tyrosinase in the gel. Molecular weight standards are shown on the left.
The optimal setting of the value for the feeding rate plays an important role in obtaining long-lasting fed-batch growth of E. coli cells. The feeding rate should maintain optimum cellular health, which is required to overcome the metabolic stress associated with recombinant protein expression [48]. A too high feeding rate would lead to accumulation of glycerol very early during the fed-batch, a premature slowdown of growth and, therefore, a short cultivation time. A too low feeding rate may lead to prolonged cultivation time before reaching high cell density, thus resulting in a low process productivity. It has been reported that a specific growth rate of 0.3 h−1 prevents several negative effects, such as increased cell lysis, higher levels of endotoxin accumulation and membrane stiffness, which are characteristics of cells at low specific growth rates [49, 50]. An exponential feeding strategy to maintain a specific growth rate of 0.3 h−1 was therefore used in this study. A feeding rate of 0.4 h−1 was also tested and resulted in overfeeding and foaming problems (data not shown).
The tyrosinase content was further analyzed by SDS-PAGE (Figure 3C). The soluble tyrosinase was clearly predominant in the total soluble protein fraction after 6 h of induction and was maintained for at least another 12 h (Figure 3C). Compared to the batch cultures in shake flasks, the fed-batch approach resulted in an improvement of 17 fold of the yield of active tyrosinase from 0.17 g L−1 to 2.89 g L−1, and 15 fold of the overall volumetric productivity from 31.7 mU L−1 h-1 (corresponding to 7.1 mg L−1 h−1) to 464.3 mU L−1 h-1 (corresponding to 103.2 mg L−1 h−1) (Table 4). These results demonstrate that it was possible to obtain a high tyrosinase production even at high cell densities.
No significant change in activity was observed even 12 h after the highest cell density in the fed batch experiment was reached (Figure 3B). Previously it has been observed that loss of tyrosinase activity due to proteolytic activity in recombinant Streptomyces was detected during all phases of batch culture, especially in stationary phase [51]. When the tyrosinase of S. antibioticus was expressed in E. coli, the activity of intracellular tyrosinase decreased with time [52]. The results obtained in this study suggest that V. spinosum tyrosinase produced in E. coli is stable, at least during the 40 hour cultivation tested here. This will undoubtedly simplify the purification of this enzyme.
Stability of tyrosinase expression
During this study, we encountered loss of tyrosinase gene expression: when the starting inoculum was taken from a single colony on a plate which was stored at 4°C for more than 24 h, or from −80°C frozen stock, the recombinant cells lost the ability to produce tyrosinase under the tested conditions (Figure 4A). The cells were analyzed by SDS-PAGE and at the same time used for plasmid preparation. No tyrosinase band could be detected on the SDS-Gel (Figure 4B), even though resistance towards ampicillin conferred by the plasmid pMFvpt was detected in more than 95% of all cells (data not shown). For comparison, the purified plasmid was transformed freshly into E. coli JM109 cells and the resulting recombinant was used for tyrosinase production. In this case, tyrosinase production and activity were restored (Figures 4A and 4B). We have no proven explanation for this phenomenon. It is possible that the tyrosinase gene on the plasmid pMFvpt was lost. In order to obtain good expression of tyrosinase, the plasmid pMFvpt was always transformed freshly into E. coli JM109 cells during the entire study.
Loss of tyrosinase expression in E. coli JM109 (pMFvpt). The cells were grown in shake flasks at 32°C and induced with 1.0 mM IPTG. (A) Time profile of cell growth and tyrosinase activity of E. coli JM109 freshly transformed with pMFvpt and E. coli JM109 (pMFvpt) stored at 4°C for 24 h. The arrow indicates the onset of IPTG induction. (B) SDS-PAGE of total proteins prepared from E. coli JM109 (pMFvpt) cells. Samples were taken after 4 h just before induction (lanes 1 and 5), after 7 h (3 h induction, lanes 2 and 6), after 8 h (4 h induction, lanes 3 and 7), and after 24 h (20 h induction, lanes 4 and 8). Lanes 1–4, samples of freshly transformed E. coli JM109 (pMFvpt); Lanes 5–8, samples of 24 h old E. coli JM109 (pMFvpt). The arrow indicates the position of tyrosinase in the gel. Molecular weight standards are shown on the left.
Conclusion
In conclusion, we have successfully expressed and produced gram quantities per liter of active tyrosinase in recombinant E. coli by optimizing the expression conditions and fed-batch cultivation strategy. Fed-batch feeding was performed by exponential forward-feed mode which has the potential of reducing the fermentation time and thus cost. The recommended fermentation protocol is summarized in Table 5. In this protocol, exponential feed of substrate helped to increase the exponential phase of growth, thereby allowing a high cell density of 37 g L-1. This in turn helped in achieving a final concentration of about 3 g L-1 of soluble, active recombinant tyrosinase, which is 17 fold higher than that achieved in shake flasks. A specific tyrosinase production rate of 103 mg L−1 h−1 and a maximum volumetric activity of 464 mU L−1 h-1 were achieved in this study. These levels have not been reported previously.
Since tyrosinase has potential for a broad range of applications, it is expected that an efficient production process will facilitate its actual usage. This work demonstrated an effective process of a bacterial tyrosinase production in the laboratory scale. Further improvement such as in the yield of active enzyme and validation of the scalability of the process are still needed.
Methods
Bacterial strains and plasmid
E. coli DH5α (E. coli Genetic Stock Center), BLR (Novagen) and JM109 (New England BioLabs) were tested as hosts for tyrosinase production. The plasmid pMFvpt, which contains the gene encoding the cytoplasmic full-length tyrosinase (53.5 kDa) of V. spinosum, was used to produce the recombinant tyrosinase [38].
Materials
All chemicals used were purchased from Sigma–Aldrich (Buchs Switzerland) unless otherwise stated.
Media
Luria broth (LB), 5 g yeast extract, 10 g tryptone, and 5 g NaCl per liter, was used for pre-inoculum cultures. It was supplemented with ampicillin to a final concentration of 0.1 mg mL-1.
The medium for batch cultures in shake flasks contained (g L-1): glycerol 10, NZ-amine 5, (NH4)2HPO4 4, KH2PO4 5, K2HPO4 7.4, MgSO4 * 7H2O 1.2, thiamine HCl 0.015, ampicillin 0.1 and 10 mL of trace element solution (TES). TES contained (g l-1): CaCl2 * 2H2O 5, FeCl3*4H2O 7, Zn(CH3COO)2 * 2H2O 1.3, MnCl2 * 4H2O 1.5, CoCl2 * 6H2O 0.25, H3BO3 0.3, Na2MoO4 * 2H2O 0.25, ethylenediaminetetraacetic acid (EDTA) 1.25 and 10 mL of concentrated HCl. Cells were induced with isopropyl β-D-1-thiogalactopyranoside (IPTG) under the conditions described in the Results section. Thiamine, ampicillin, TES and IPTG were filter-sterilized (0.2 μm, Millipore).
The medium for batch cultures in the bioreactor contained (g L-1): glycerol 20, NZ-Amine 5, (NH4)2HPO4 4, KH2PO4 13.3, (NH4)2SO4 1, MgSO4 * 7H2O 1.2, thiamine HCl 0.015, ampicillin 0.1 and 10 ml of TES containing additional 0.15 g l-1 CuCl2 * 4H2O. The feed medium contained (g L-1): glycerol 500, NZ-Amine 100, MgSO4 * 7H2O 13.5 and (NH4)2SO4 50.
Cultivation conditions
Plasmid pMFvpt was transformed into E. coli competent cells by chemical CaCl2 method [53]. The freshly transformed cells were used to inoculate a 10 mL LB pre-culture in a 50 mL flask. The cells were incubated at 37°C and 150 rpm overnight. The pre-culture was then used to inoculate 200 mL of batch medium in a 1 L shake flask with a dilution of 1:20 (v/v). It was incubated at 150 rpm and different temperatures as described in the Results section. Growth and product formation were monitored by periodically taking samples, from which cells were harvested by centrifugation at 12’000 g for 2 min at 4°C. A final OD600 of 7–8 was routinely achieved.
For the experiment of testing oxygen influence, 1 L baffled (with 4 baffles indented into the base, Schott Duran) and non-baffled Erlenmeyer flasks (Schott Duran) were used.
For bioreactor experiments, the cells freshly transformed with plasmid pMFvpt were grown in shake flasks in LB medium for 12 h at 37°C and 150 rpm. The bioreactors were inoculated with a 1:20 (v/v) dilution of the pre-culture. The cells were grown in a 600 mL (total volume 1.4 L) computer controlled bioreactor (Infors AG, Bottmingen, CH) equipped with standard control units. Tyrosinase expression was induced by 1.25 mM IPTG. The pH was maintained at 6.90 ± 0.05 by proportional–integral (PI) controlled addition of 4 M NaOH / 28% NH4OH 1 / 1 (v/v), and the temperature was set to 32.0°C ± 0.5°C. In order to avoid oxygen limitation the dissolved oxygen (DO) level was stabilized to above 30% saturation by stirrer speed and aeration rate control. If necessary, 1’200 rpm (rotation per minute) and 1–2 vvm (volume per volume per minute) of air enriched with pure oxygen by a PI controller were applied to keep the DO above 30%. Foaming was suppressed by addition of 10–100 μl antifoam suspension (PPG 2000). Feeding was started after the batch ended, as indicated by a sudden increase of the DO-signal. The feed medium was fed exponentially into the fermenter using a variable speed peristaltic pump.
Tyrosinase activity
Samples were diluted to OD600 = 1, and 1 ml was centrifuged at 12’000 g for 2 min. The pellet was washed once with 1 ml and resuspended in 0.5 ml 0.1 M Tris–HCl (pH 8). The suspension was sonicated for 10 s with 10% power (Branson Ultrasonics Corp., Danbury, CT, USA), and centrifuged at 12’000 g for 2 min. The supernatant was analyzed for tyrosinase activity by measuring dopachrome formation [38, 54]. One unit is defined as 1 μmol dopachrome formed per minute. The protein concentrations in the supernatant were quantified using the Bradford method.
SDS-PAGE
SDS-PAGE analysis was performed using standard methods [55] and gels were subsequently stained with Coomassie brilliant blue. The PageRuler plus prestained protein ladder (Fermentas, GmbH) was used as a marker in all gels.
Cell growth
The cell growth was followed by measuring the optical density at 600 nm (Spectronic Genesys 6, Thermo Electron Corp., UK) and correlated to cell dry weight (cdw) with a ratio cdw / OD = 0.36.
Reproducibility
All measurements for growth and tyrosinase activity were performed at least in duplicates. The data presented in this report are the average values.
References
Fairhead M, Thöny-Meyer L: Bacterial tyrosinases: old enzymes with new relevance to biotechnology. New Biotechnol. 2012, 29 (2): 183-191. 10.1016/j.nbt.2011.05.007.
Claus H, Decker H: Bacterial tyrosinases. Syst Appl Microbiol. 2006, 29 (1): 3-14. 10.1016/j.syapm.2005.07.012.
del Marmol V, Beermann F: Tyrosinase and related proteins in mammalian pigmentation. FEBS Lett. 1996, 381 (3): 165-168. 10.1016/0014-5793(96)00109-3.
Halaouli S, Asther M, Sigoillot JC, Hamdi M, Lomascolo A: Fungal tyrosinases: new prospects in molecular characteristics, bioengineering and biotechnological applications. J Appl Microbiol. 2006, 100 (2): 219-232. 10.1111/j.1365-2672.2006.02866.x.
Marusek CM, Trobaugh NM, Flurkey WH, Inlow JK: Comparative analysis of polyphenol oxidase from plant and fungal species. J Inorg Biochem. 2006, 100 (1): 108-123. 10.1016/j.jinorgbio.2005.10.008.
Mayer AM: Polyphenol oxidases in plants and fungi: Going places? A review. Phytochemistry. 2006, 67 (21): 2318-2331. 10.1016/j.phytochem.2006.08.006.
Walker JRL, Ferrar PH: Diphenol oxidases, enzyme-catalysed browning and plant disease resistance. Biotechnol Genet Eng Rev. 1998, 15: 457-498. Edited by Tombs MP
Jus S, Kokol V, Guebitz GM: Tyrosinase-catalysed coupling of functional molecules onto protein fibres. Enzyme Microb Technol. 2008, 42 (7): 535-542. 10.1016/j.enzmictec.2008.02.012.
Jus S, Kokol V, Guebitz GM: Tyrosinase-catalysed coating of wool fibres with different protein-based biomaterials. J Biomat Sci-Polym E. 2009, 20 (2): 253-269. 10.1163/156856209X404523.
Martorell MM, Pajot HF, Rovati JI, Figueroa LIC: Optimization of culture medium composition for manganese peroxidase and tyrosinase production during Reactive Black 5 decolourization by the yeast Trichosporon akiyoshidainum. Yeast. 2012, 29 (3–4): 137-144.
Seetharam G, Saville BA: L-DOPA production from tyrosinase immobilized on zeolite. Enzyme Microb Technol. 2002, 31 (6): 747-753. 10.1016/S0141-0229(02)00182-5.
Lantto R, Puolanne E, Kruus K, Buchert J, Autio K: Tyrosinase-aided protein cross-linking: Effects on gel formation of chicken breast myofibrils and texture and water-holding of chicken breast meat homogenate gels. J Agric Food Chem. 2007, 55 (4): 1248-1255. 10.1021/jf0623485.
Selinheimo E, Autio K, Krijus K, Buchert J: Elucidating the mechanism of laccase and tyrosinase in wheat bread making. J Agric Food Chem. 2007, 55 (15): 6357-6365. 10.1021/jf0703349.
Anghileri A, Lantto R, Kruus K, Arosio C, Freddi G: Tyrosinase-catalyzed grafting of sericin peptides onto chitosan and production of protein-polysaccharide bioconjugates. J Biotechnol. 2007, 127 (3): 508-519. 10.1016/j.jbiotec.2006.07.021.
Freddi G, Anghileri A, Sampaio S, Buchert J, Monti P, Taddei P: Tyrosinase-catalyzed modification of Bombyx mori silk fibroin: Grafting of chitosan under heterogeneous reaction conditions. J Biotechnol. 2006, 125 (2): 281-294. 10.1016/j.jbiotec.2006.03.003.
Gu BX, Xu CX, Zhu GP, Liu SQ, Chen LY, Li XS: Tyrosinase immobilization on ZnO Nanorods for phenol detection. J Phys Chem B. 2009, 113 (1): 377-381. 10.1021/jp808001c.
Fairhead M, Thöny-Meyer L: Cross-linking and immobilisation of different proteins with recombinant Verrucomicrobium spinosum tyrosinase. J Biotechnol. 2010, 150 (4): 546-551. 10.1016/j.jbiotec.2010.10.068.
Lewandowski AT, Small DA, Chen TH, Payne GF, Bentley WE: Tyrosine-based “activatable pro-tag”: Enzyme-catalyzed protein capture and release. Biotechnol Bioeng. 2006, 93 (6): 1207-1215. 10.1002/bit.20840.
Thalmann CR, Lotzbeyer T: Enzymatic cross-linking of proteins with tyrosinase. Eur Food Res Technol. 2002, 214 (4): 276-281. 10.1007/s00217-001-0455-0.
Monogioudi E, Creusot N, Kruus K, Gruppen H, Buchert J, Mattinen M-L: Cross-linking of beta-casein by Trichoderma reesei tyrosinase and Streptoverticillium mobaraense transglutaminase followed by SEC-MALLS. Food Hydrocolloid. 2009, 23 (7): 2008-2015. 10.1016/j.foodhyd.2009.03.011.
Jus S, Stachel I, Schloegl W, Pretzler M, Friess W, Meyer M, Birner-Gruenberger R, Guebitz GM: Cross-linking of collagen with laccases and tyrosinases. Mater Sci Eng C-Mater Biol Appl. 2011, 31 (5): 1068-1077. 10.1016/j.msec.2011.03.007.
Halaouli S, Asther M, Kruus K, Guo L, Hamdi M, Sigoillot JC, Lomascolo A: Characterization of a new tyrosinase from Pycnoporus species with high potential for food technological applications. J Appl Microbiol. 2005, 98 (2): 332-343. 10.1111/j.1365-2672.2004.02481.x.
Hearing VJ: Mammalian monophenol monooxygenase (tyrosinase) - purification, properties, and reactions catalyzed. Methods Enzymol. 1987, 142: 154-165.
Lerch KLE: Purification and characterization of a tyrosinase from Streptomyces glaucescens. Eur J Biochem. 1972, 31 (3): 427-437. 10.1111/j.1432-1033.1972.tb02549.x.
Gasparetti C, Faccio G, Arvas M, Buchert J, Saloheimo M, Kruus K: Discovery of a new tyrosinase-like enzyme family lacking a C-terminally processed domain: production and characterization of an Aspergillus oryzae catechol oxidase. Appl Microbiol Biotechnol. 2010, 86 (1): 213-226. 10.1007/s00253-009-2258-3.
Ito M, Inouye K: Catalytic properties of an organic solvent-resistant tyrosinase from Streptomyces sp REN-21 and its high-level production in E. coli. J Biochem. 2005, 138 (4): 355-362. 10.1093/jb/mvi150.
Liu N, Zhang T, Wang YJ, Huang YP, Ou JH, Shen P: A heat inducible tyrosinase with distinct properties from Bacillus thuringiensis. Lett Appl Microbiol. 2004, 39 (5): 407-412. 10.1111/j.1472-765X.2004.01599.x.
Shuster V, Fishman A: Isolation, cloning and characterization of a tyrosinase with improved activity in organic solvents from Bacillus megaterium. J Mol Microbiol Biotechnol. 2009, 17 (4): 188-200. 10.1159/000233506.
Flurkey A, Cooksey J, Reddy A, Spoonmore K, Rescigno A, Inlow J, Flurkey WH: Enzyme, protein, carbohydrate, and phenolic contaminants in commercial tyrosinase preparations: Potential problems affecting tyrosinase activity and inhibition studies. J Agric Food Chem. 2008, 56 (12): 4760-4768. 10.1021/jf800109a.
Sambasiva Rao KRS, Tripathy NK, Mahalaxmi Y, Prakasham RS: Laccase- and peroxidase-free tyrosinase production by isolated microbial strain. J Microbiol Biotechnol. 2012, 22 (2): 207-214. 10.4014/jmb.1106.06031.
Kumar M, Flurkey WH: Activity, isoenzymes and purity of mushroom tyrosinase in commercial preparations. Phytochemistry. 1991, 30 (12): 3899-3902. 10.1016/0031-9422(91)83430-S.
Chen G-H, Chen W-M, Huang Y-C, Jiang S-T: Expression of recombinant mature human tyrosinase from Escherichia coli and exhibition of its activity without phosphorylation or glycosylation. J Agric Food Chem. 2012, 60 (11): 2838-2843. 10.1021/jf205021g.
Kong KH, Park SY, Hong MP, Cho SH: Expression and characterization of human tyrosinase from a bacterial expression system. Comp Biochem Physiol B Biochem Mol Biol. 2000, 125 (4): 563-569. 10.1016/S0305-0491(00)00163-2.
Halaouli S, Record E, Casalot L, Hamdi M, Sigoillot JC, Asther M, Lomascolo A: Cloning and characterization of a tyrosinase gene from the white-rot fungus Pycnoporus sanguineus, and overproduction of the recombinant protein in Aspergillus niger. Appl Microbiol Biotechnol. 2006, 70 (5): 580-589. 10.1007/s00253-005-0109-4.
Kohashi PY, Kumagai T, Matoba Y, Yamamoto A, Maruyama M, Sugiyama M: An efficient method for the overexpression and purification of active tyrosinase from Streptomyces castaneoglobisporus. Protein Expr Purif. 2004, 34 (2): 202-207. 10.1016/j.pep.2003.11.015.
Selinheimo E, Saloheimo M, Ahola E, Westerholm-Parvinen A, Kalkkinen N, Buchert J, Kruus K: Production and characterization of a secreted, C-terminally processed tyrosinase from the filamentous fungus Trichoderma reesei. FEBS J. 2006, 273 (18): 4322-4335. 10.1111/j.1742-4658.2006.05429.x.
Westerholm-Parvinen A, Selinheimo E, Boer H, Kalkkinen N, Mattinen M, Saloheimo M: Expression of the Trichoderma reesei tyrosinase 2 in Pichia pastoris: Isotopic labeling and physicochemical characterization. Protein Expr Purif. 2007, 55 (1): 147-158. 10.1016/j.pep.2007.04.014.
Fairhead M, Thöny-Meyer L: Role of the C-terminal extension in a bacterial tyrosinase. FEBS J. 2010, 277 (9): 2083-2095. 10.1111/j.1742-4658.2010.07621.x.
Riesenberg D, Guthke R: High-cell-density cultivation of microorganisms. Appl Microbiol Biotechnol. 1999, 51 (4): 422-430. 10.1007/s002530051412.
Shiloach J, Fass R: Growing E. coli to high cell density - A historical perspective on method development. Biotechnol Adv. 2005, 23 (5): 345-357. 10.1016/j.biotechadv.2005.04.004.
Makrides SC: Strategies for achieving high-level expression of genes in Escherichia coli. Microbiol Mol Biol Rev. 1996, 60 (3): 512-
Shojaosadati SA, Kolaei SMV, Babaeipour V, Farnoud AM: Recent advances in high cell density cultivation for production of recombinant protein. Iranian J Biotechnol. 2008, 6: 63-84.
Hoffmann F, Weber J, Rinas U: Metabolic adaptation of Escherichia coli during temperature-induced recombinant protein production: 1. Readjustment of metabolic enzyme synthesis. Biotechnol Bioeng. 2002, 80 (3): 313-319. 10.1002/bit.10379.
Jana S, Deb JK: Strategies for efficient production of heterologous proteins in Escherichia coli. Appl Microbiol Biotechnol. 2005, 67 (3): 289-298. 10.1007/s00253-004-1814-0.
Castrillo JI, Kaliterna J, Weusthuis RA, VanDijken JP, Pronk JT: High-cell-density cultivation of yeasts on disaccharides in oxygen-limited batch cultures. Biotechnol Bioeng. 1996, 49 (6): 621-628. 10.1002/(SICI)1097-0290(19960320)49:6<621::AID-BIT3>3.3.CO;2-V.
Domingues L, Lima N, Teixeira JA: Contamination of a high-cell-density continuous bioreactor. Biotechnol Bioeng. 2000, 68 (5): 584-587. 10.1002/(SICI)1097-0290(20000605)68:5<584::AID-BIT14>3.0.CO;2-1.
Lee SY: High cell-density culture of Escherichia coli. Trends Biotechnol. 1996, 14 (3): 98-105. 10.1016/0167-7799(96)80930-9.
Sanden AM, Prytz I, Tubulekas I, Forberg C, Le H, Hektor A, Neubauer P, Pragai Z, Harwood C, Ward A: Limiting factors in Escherichia coli fed-batch production of recombinant proteins. Biotechnol Bioeng. 2003, 81 (2): 158-166. 10.1002/bit.10457.
Shokri A, Sanden AM, Larsson G: Growth rate-dependent changes in Escherichia coli membrane structure and protein leakage. Appl Microbiol Biotechnol. 2002, 58 (3): 386-392. 10.1007/s00253-001-0889-0.
Shokri A, Sanden AM, Larsson G: Cell and process design for targeting of recombinant protein into the culture medium of Escherichia coli. Appl Microbiol Biotechnol. 2003, 60 (6): 654-664.
Gardner AR, Cadman TW: Product deactivation in recombinant streptomyces. Biotechnol Bioeng. 1990, 36 (3): 243-251. 10.1002/bit.260360305.
Han K, Hong J, Lim HC, Kim CH, Park Y, Cho JM: Tyrosinase production in recombinant E. coli containing trp promoter and ubiquitin sequence. Ann NY Acad Sci. 1994, 721: 30-42. 10.1111/j.1749-6632.1994.tb47374.x.
Sambrook J, Russel DW: Molecular Cloning: A Laboratory Manual. 2001, New York: Cold Spring Harbor Laboratory Press, 3
Fling M, Horowitz NH, Heinemann SF: The isolation and properties of crystalline tyrosinase from Neurospora. J Biol Chem. 1963, 238: 2045-2053.
Laemmli UK: Cleavage of structural proteins during assembly of head of bacteriophage-T4. Nature. 1970, 227 (5259): 680-10.1038/227680a0.
Acknowledgements
We thank Dr. Renate Reiss for critically reading the manuscript.
Author information
Authors and Affiliations
Corresponding author
Additional information
Competing interests
The authors declare that they have no competing interests.
Authors’ contributions
QR participated in the design and coordination of the study, and drafted the manuscript. BH participated in the design of the fed-batch study and performed the batch and fed-batch experiments. MF carried out the construction of different E. coli recombinants. LTM conceived the study and helped to draft the manuscript. All authors read and approved the final manuscript.
Authors’ original submitted files for images
Below are the links to the authors’ original submitted files for images.
Rights and permissions
This article is published under license to BioMed Central Ltd. This is an Open Access article distributed under the terms of the Creative Commons Attribution License (http://creativecommons.org/licenses/by/2.0), which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.
About this article
Cite this article
Ren, Q., Henes, B., Fairhead, M. et al. High level production of tyrosinase in recombinant Escherichia coli. BMC Biotechnol 13, 18 (2013). https://doi.org/10.1186/1472-6750-13-18
Received:
Accepted:
Published:
DOI: https://doi.org/10.1186/1472-6750-13-18