The methods of optical and scanning electron microscopy and x-ray spectrum microanalysis are used to study and to compare the special features of formation of metastable trialuminides under rapid crystallization of superheated melts of the Al – Hf – Sc and Al – Hf – Ti systems. Heating of such melts by over 100°C above the liquidus temperature yields Aln(Hf1–xScx) and Aln(Hf1–x Tix) aluminides with a cubic lattice of structural type L12.
Similar content being viewed by others
Notes
Here and below in the paper the content of elements is given is atomic percent.
References
M. E. Fine, “Precipitation hardening of aluminum alloys,” Metall. Trans. A, 6(4), 625 – 630 (1975).
K. E. Knipling, D. C. Dunald, and D. N. Seidman, “Nucleation and precipitation strengthening in dilute Al – Ti and Al – Zr alloys,” Metall. Mater. Trans. A, 38A, 2552 – 2563 (2007).
K. E. Knipling, D. C. Dunald, and D. N. Seidman, “Precipitation evolution in Al – Zr and Al – Zr – Ti alloys during isothermal aging at 375 – 425°C,” Acta Mater., 56, 114 – 127 (2008).
K. E. Knipling, D. C. Dunald, and D. N. Seidman, “Precipitation evolution in Al – Zr and Al – Zr – Ti alloys during aging at 450 – 600°C,” Acta Mater., 56, 1182 – 1195 (2008).
K. E. Knipling, D. C. Dunald, and D. N. Seidman, “Precipitation evolution in Al – 0.1Sc, Al – 0.1Zr and Al – 0.1Sc – 0.1Zr (at.%) alloys during isochronal aging,” Acta Mater., 58, 5184 – 5195 (2010).
V. V. Zakharov, “About alloying of aluminum alloys with transition metals,” Metalloved. Term. Obrab. Met., No. 2, 3 – 8 (2017).
Y. Du, Y. A. Chang, B. Huang, et al., “Diffusion coefficients of some solutes in fcc and liquid Al: critical evaluation and correlation,” Mater. Sci. Eng. A, 363(1 – 2), 140 – 151 (2003).
J. Royset and N. Ryum, “Scandium in aluminum alloys,” Int. Mater. Rev., 50(1), 19 – 44 (2005).
A. E. Carlsson and P. J. Meschter, “Relative stability of Ll2 , D022 and D023 structures in MAl3 compounds,” J. Mater. Res., 4(5), 1060 – 1063 (1989).
G. Ghosh and M. Asta, “First-principles calculation of structural energetics of Al – TM (MT = Ti, Zr, Hf) intermetallics,” Acta Mater., 53, 3225 – 3252 (2005).
S. Srinivasan, P. B. Desch, and R. B. Schwarz, “Metastable phases in the Al3 X (X = Ti, Zr, and Hf) intermetallic system,” Scr. Metall. Mater., 25(11), 2513 – 2516 (1991).
I. G. Brodova, V. M. Zamyatin, P. S. Poppel, et al., “Conditions of formation of metastable phases in crystallization of Al – Zr alloys,” Rasplavy, 2(6), 23 – 27 (1988).
I. G. Brodova, I. V. Polents, V. O. Esin, and B. M. Lobov, “Laws of formation of cast structure of supercooled Al – Ti alloys,” Fiz. Met. Metalloved., No. 1, 84 – 89 (1992).
A. F. Norman and P. Tsakiropoulos, “Rapid solidification of Al – Hf alloys — solidification, microstructures and decomposition of solid-solutions,” Int. J. Rapid Solid., 6(3 – 4), 185 – 213 (1991).
P. Malek, M. Janecek, B. Smola, et al., “Structure and properties of rapidly solidified Al – Zr – Ti alloys,” J. Mater. Sci., 35, 2625 – 2633 (2000).
E. A. Popova, A. B. Shubin, P. V. Kotenkov, et al., “Al – Ti – Zr master alloys: structure formation,” Russian Metallurgy (Metally), No. 5, 357 – 361 (2012).
E. A. Popova, P. V. Kotenkov, E. A. Pastushkov, and A. B. Shubin, “Master alloys Al – Sc – Zr, Al – Sc – Ti, and Al – Ti – Zr: their manufacture, composition, and structure,” Russian Metallurgy (Metally), No. 8, 590 – 594 (2013).
E. A. Popova, P. V. Kotenkov, and A. B. Shubin, “Formation of aluminides with Ll2 cubic lattice in alloys of the Al – Zr – Y, Al – Ti – Y systems,” Metalloved. Term. Obrab. Met., No. 9, 14 – 18 (2018).
J. L. Murray, A. J. McAlister, and D. J. Kahan, “The Al – Hf (aluminum–hafnium) system,” J. Phase Equil., 19(4), 376 – 379 (1998).
H. W. Kerr, J. Cisse, and G. F. Boiling, “On equilibrium and nonequilibrium peritectic transformation,” Acta Metall., 22, 677 – 686 (1974).
J. L. Murray, “The Al – Sc (aluminum–scandium) system,” J. Phase Equil., 19(4), 380 – 384 (1998).
E. A. Popova, P. V. Kotenkov, A. B. Shubin, and E. A. Pastukhov, “Special features of structure of Al – Hf – Sc master alloys,” Izv. Vysh. Ucheb. Zaved., Tsvet. Metall., No. 5, 69 – 74 (2017).
E. A. Popova, P. V. Kotenkov, and A. B. Shubin, “Formation of metastable aluminides in alloys of the Al – Hf – Ti system,” Tsvet. Met., No. 11(899), 65 – 70 (2017).
O. Setiukov and I. Fridlyander, “Peculiarities of Ti dendritic segregation in aluminum alloys,” in: Aluminum Alloys: Their Physical and Mechanical Properties, Mater. Sci. Forum, France (1996), pp. 195 – 200.
H. Hallem, B. Forbord, and K. Marthinsen, “An investigation of cast structures in Al – Hf – (Sc) – (Zr) alloys and their subsequent effect on recrystallization resistance and cold rolling,” Mater. Forum, 28, 240 – 245 (2004).
The work has been performed within State Assignment to IMET UrO RAN and with the use of the equipment of the “Ural-M” Collective Use Center.
Author information
Authors and Affiliations
Corresponding author
Additional information
Translated from Metallovedenie i Termicheskaya Obrabotka Metallov, No. 12, pp. 38 – 42, December, 2019.
Rights and permissions
About this article
Cite this article
Popova, E.A., Kotenkov, P.V. & Gilev, I.O. Formation of Metastable Aluminides in Alloys of Al – Hf – Sc (Ti) Systems. Met Sci Heat Treat 61, 782–786 (2020). https://doi.org/10.1007/s11041-020-00500-9
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11041-020-00500-9