Abstract
The large deformation of nonlinear soft rock caused by the interaction between water and rock is a prominent problem faced in engineering rock masses. Furthermore, the strength softening mechanism of rocks under the action of water is relatively complex. Based on this, this study considered the deep sandstone strata of the Shandong Wanfu coal mine to investigate the strength softening and microscopic mechanism under the action of different water contents. In addition, it explored the pore structure, mineral composition, and internal fracture expansion in sandstone water absorption. Experimental studies were performed using nuclear magnetic resonance, scanning electron microscopy (SEM), X-ray diffraction (XRD), and computerized tomography scanners (CT). The experimental results showed that with the increase of water absorption time, the increment of mass and spectral area of fine sandstone increased and the compressive strength of specimens decreased. Based on the mathematical expressions between water content of specimens and water absorption time and compressive strength, the exponential relationship between compressive strength of fine sandstone and water absorption time was established. The stress change stages of fine sandstone were divided into relatively stable stage, rapid softening stage, and decelerating softening stage. Due to the dissolution of hydrophilic minerals and adherents in water, the percentage of micropores increases and then decreases, and the percentage of mesopores and macropores decreases and then increases, based on which the model diagram of the change of water absorption microstructure of the rock is constructed. According to the change law of mechanical strength of fine sandstone under the action of different water content, the mathematical expression of compressive strength and water content is established. Based on the results of water absorption stage division of fine sandstone, the fracture porosity is introduced, and it is concluded that the decrease of three-dimensional fracture porosity of fine sandstone is mainly concentrated in the rapid water absorption stage. The failure mode gradually changed from tensile–shear composite failure to single shear failure with an increase in water content. The fractal characteristic analysis of the fractures in the horizontal and vertical sections showed that the fractal dimension gradually decreased with an increase in water content. Finally, a curve relationship between the fractal dimension and water content was established.
Highlights
-
The microstructure and spatial fracture modes under the action of different water content were studied.
-
A microstructure model of the rock water absorption process was established.
-
With an increase in water content, the proportion of cracks in the plane of fracture porosity gradually decreased.
-
Based on the fracture shape, the relationship between the fractal dimension and water content was established.
Similar content being viewed by others
Data Availability
All data generated or analyzed during this study are included in this article.
References
Ai T, Zhang R, Zhou HW, Pei JL (2014) Box-counting methods to directly estimate the fractal dimension of a rock surface. Appl Surf Sci 314:610–621. https://doi.org/10.1016/j.apsusc.2014.06.152
Aral İF, Boy R, Dinçer AR (2021) Effects of freeze-thawing cycles on the physical and mechanical properties of basaltic and dolomitic rocks evaluated with a decay function model. Bull Eng Geol Environ 80:2955–2962. https://doi.org/10.1007/s10064-021-02132-6
Balushi FA, Taleghani AD (2022) Digital rock analysis to estimate stress-sensitive rock permeabilities. Comput Struct. https://doi.org/10.1016/j.compgeo.2022.104960
Basu A, Mishra DA, Roychowdhury K (2013) Rock failure modes under uniaxial compression, Brazilian, and point load tests. Bull Eng Geol Environ 72:457–475. https://doi.org/10.1007/s10064-013-0505-4
Baud P, Zhu WL, Wong TF (2000) Failure mode and weakening effect of water on sandstone. J Geophys Res: Solid Earth 105(B7):16371–16389. https://doi.org/10.1029/2000JB900087
Bi J, Ning L, Zhao Y, Wu ZJ, Wang CL (2023) Analysis of the microscopic evolution of rock damage based on real-time nuclear magnetic resonance. Rock Mech Rock Eng. https://doi.org/10.1007/s00603-023-03238-x
Boone MN, Dewanckele J, Boone MA, Cnudde V, Silversmit G, Van RE, Jacobs P, Vincze L, Hoorebek LV (2011) Three-dimensional phase separation and identification in granite. Geosphere. https://doi.org/10.1130/GES00562.1
Buffiere JY, Maire E, Adrien J, Masse JP, Boller E (2010) In situ experiments with X ray tomography: an attractive tool for experimental mechanics. Exp Mech 50:289–305. https://doi.org/10.1007/s11340-010-9333-7
Burshtein L-S (1969) Effect of moisture on the strength and deformability of sandstone. Sov Min Sci 5(5):573–576. https://doi.org/10.1007/BF02501278
Cardona A, Finkbeiner T, Santamarina JC (2021) Natural rock fractures: from aperture to fluid flow. Rock Mech Rock Eng 54:5827–5844. https://doi.org/10.1007/s00603-021-02565-1
Celik MY, Kacmaz AU (2016) The investigation of static and dynamic capillary by water absorption in porous building stones under normal and salty water conditions. Environ Earth Sci 75(4):307. https://doi.org/10.1007/s12665-015-5132-x
Cherblanc F, Berthonneau J, Bromblet P, Huon V (2016) Influence of water content on the mechanical behaviour of limestone: role of the clay minerals content. Rock Mech Rock Eng 49:2033–2042. https://doi.org/10.1007/s00603-015-0911-y
Dewanckele J, De Kock T, Boone MA, Cnudde V, Brabant L, Boone MN, Fronteau G, Hoorebeke LV, Jacobs P (2012) 4D imaging and quantification of pore structure modifications inside natural building stones by means of high resolution X-ray CT. Sci Total Environ 416:436–448. https://doi.org/10.1016/j.scitotenv.2011.11.018
Dinçer İ, Bostancı M (2019) Capillary water absorption characteristics of some Cappadocian ignimbrites and the role of capillarity on their deterioration. Environ Earth Sci 78:7. https://doi.org/10.1007/s12665-018-7993-2
Duda M, Renner J (2012) The weakening effect of water on the brittle failure strength of sandstone. Geophys J Int 192(3):1091–1108. https://doi.org/10.1093/gji/ggs090
Elsayed M, Isah A, Hiba M, Hassan A, Al-Garadi K, Mahmoud M, El-Husseiny A, Radwan AE (2022) A review on the applications of nuclear magnetic resonance (NMR) in the oil and gas industry: laboratory and field-scale measurements. J Petrol Explor Prod Technol 12:2747–2784. https://doi.org/10.1007/s13202-022-01476-3
Erguler ZA, Erguler GK (2015) The effect of particle size on acid mine drainage generation: Kinetic column tests. Miner Eng 76:154–167. https://doi.org/10.1016/j.mineng.2014.10.002
Erguler ZA, Ulusay R (2009) Water-induced variations in mechanical properties of clay-bearing rocks. Int J Rock Mech Min 46(2):355–370. https://doi.org/10.1016/j.ijrmms.2008.07.002
Fan LF, Fan YD, XiY Gao JW (2022) Spatial failure mode analysis of frozen sandstone under uniaxial compression based on ct technology. Rock Mech Rock Eng. https://doi.org/10.1007/s00603-022-02859-y
Freiberg U, Kohl S (2021) Box dimension of fractal attractors and their numerical computation. Commu Nonlinear Sci. https://doi.org/10.1016/j.cnsns.2020.105615
Ghamgosar M, Erarslan N, Williams DJ (2017) Experimental investigation of fracture process zone in rocks damaged under cyclic loadings. Exp Mech 57:97–113. https://doi.org/10.1007/s11340-016-0216-4
Ghobadi MH, Babazadeh R (2015) Experimental studies on the effects of cyclic freezing-thawing, salt crystallization, and thermal shock on the physical and mechanical characteristics of selected sandstones. Rock Mech Rock Eng 48:1001–1016. https://doi.org/10.1007/s00603-014-0609-6
Guo HY, Li B, Zhang YM, Wang XB, Zhang F (2015) Hydrophilic characteristics of soft rock in deep mines. Int J Min Sci Technol 25(2):177–183. https://doi.org/10.1016/j.ijmst.2015.02.003
Guo HY, Zhao J, Liu PY (2018) Experimental studies and chemical analysis of water on weakening behaviors of deep soft rock. Chin J Rock Mech Eng. https://doi.org/10.13722/j.cnki.jrme.2017.1178
Hadizadeh J, Law RD (1991) Water-weakening of sandstone and quartzite deformed at various stress and strain rates. Int J Rock Mech Min and Geo Abs 28(5):431–439. https://doi.org/10.1016/0148-9062(91)90081-V
Hamed LR, Saad I, Tharmakulasingam S, Aous N, Reji M, Vidhyasaharan S, Hamid R (2022) FracDetect: A novel algorithm for 3D fracture detection in digital fractured rocks. J Hydrology. https://doi.org/10.1016/j.jhydrol.2022.127482
He MC, Zhou L, Li DJ, Wang CG, Nie W (2008) Experimental research on hydrophilic characteristics of mudstone in deep well. Chin J Rock Mech Eng 27(6):1113–1120
Heggheim T, Manland MV, Risnes RT, Austad (2005) A chemical induced enhanced weakening of chalk by seawater. J Petrol Sci Eng 46(3):171–184. https://doi.org/10.1016/j.petrol.2004.12.001
Hodot B (1966) Outburst of coal and coalbed gas (Chinese translation). China Coal Industry Press, Beijing
Jafar Q, Christoph HA (2022) A comparative study of micro-CT and mercury intrusion techniques for predicting permeability and surface area evolution during chemical dissolution. Adv Water Resour 168:104301
Ju Y, Xi CD, Zhang Y, Mao LT, Gao F, Xie HP (2018) Laboratory in situ CT observation of the evolution of 3D fracture networks in Coal subjected to confining pressures and axial compressive loads: a novel approach. Rock Mech Rock Eng 51(11):3361–3375. https://doi.org/10.1007/s00603-018-1459-4
Lang YX, Liang ZZ, Dong Z, Wu N (2022) Mechanical behavior of porous rock based on the 3D digital image reconstruction and parallel computation. Environ Earth Sci 81:438. https://doi.org/10.1007/s12665-022-10566-8
Li DJ, Wang GL, Han LQ, Liu PY, He MC, Yang GX, Tai QM, Chen C (2011) Analysis of microscopic pore structures of rocks before and after water absorption. Int J Min Sci Technol 21(2):287–293. https://doi.org/10.1016/j.mstc.2011.02.002
Li DX, Wang EY, Kong XG, Ali M, Wang DM (2019) Mechanical behaviors and acoustic emission fractal characteristics of coal specimens with a pre-existing flaw of various inclinations under uniaxial compression. Int J Rock Mech Min 116:38–51. https://doi.org/10.1016/j.ijrmms.2019.03.022
Li SG, Wu YM, Huo RK, Song ZP, Fujii Y, Shen YJ (2021) Mechanical properties of acid-corroded sandstone under uniaxial compression. Rock Mech Rock Eng 54:289–302. https://doi.org/10.1007/s00603-020-02262-5
Liu Z, He XF, Zhou CY (2019) Influence mechanism of different flow patterns on the softening of red-bed soft rock. J Mar Sci Eng 7(5):155. https://doi.org/10.3390/jmse7050155
Mao WZ, Lv Q, Zheng J, Peng Y (2022) Analysis of mineral composition and meso-structure of granite using CT images. J Eng Geol. https://doi.org/10.1354/j.cnki.jeg.2020-121
Masoumi H, Horne J, Timms W (2017) Establishing empirical relationships for the effects of water content on the mechanical behavior of gosford sandstone. Rock Mech Rock Eng 50(8):2235–2242. https://doi.org/10.1007/s00603-017-1243-x
Matteson A, Tomanic JP, Herron MM, Allen DF, Kenyon WE (2000) NMR relaxation of clay/brine mixtures. Spe Reserv Eval Eng 3:602–603. https://doi.org/10.2118/66185-PA
Mayka SR, Matthias H, Celso PF, Andreas W, Viviane SSS (2018) Fractal dimensions of pore spaces in unconventional reservoir rocks using X-ray nano- and micro-computed tomography. J Nat Gas Sci Eng 55:298–311. https://doi.org/10.1016/j.jngse.2018.05.011
Meng LD, Han LJ, Zhu HX, Dong WL, Li W (2021) Study on the influence of formation temperature on the water absorption and weathering of swelling rock in marine coal Mines. KSCE J Civ Eng. https://doi.org/10.1007/s12205-021-5375-x
Miao CY, Yang L, Xu YZ, Yang K (2021) Experimental study on strength softening behaviors and micro-mechanisms of sandstone based on nuclear magnetic resonance. Chin J Rock Mech Eng 40(11):2189–2198. https://doi.org/10.13722/j.cnki.jrme.2021.0304
Michael K, Otto ER, Jürgen P, Joachim P, Gerold B, Claus K, John LH (1991) Toward a better understanding of fractality in nature. Computers Graphics 15(4):583–596
Nie Y, Sheikh A, Griffith M, Visintin P (2022) A damage-plasticity based interface model for simulating in-plane/out-of-plane response of masonry structural panels. Comput Struct. https://doi.org/10.1016/j.compstruc.2021.106721
Ozcelik Y, Ozguven A (2014) Water absorption and drying features of different natural building stones. Constr Build Mater 63:257–270. https://doi.org/10.1016/j.conbuildmat.2014.04.030
Panigrahy C, Seal A, Mahato NK (2019) Quantitative texture measurement of gray-scale images: Fractal dimension using an improved differential box counting method. Measurement. https://doi.org/10.1016/j.measurement.2019.106859
Park J, Hyun CU, Park HD (2015) Changes in microstructure and physical properties of rocks caused by artificial freeze–thaw action. Bull Eng Geol Environ 74:555–565. https://doi.org/10.1007/s10064-014-0630-8
Purswani P, Karpyn ZT, Enab K, Xue Y, Huang XL (2020) Evaluation of image segmentation techniques for image-based rock property estimation. J Pet Sci Eng. https://doi.org/10.1016/j.petrol.2020.107890
Reiner J, Chen C, Vaziri R, Poursartip A (2022) Combining digital image correlation and phased-array ultrasonics for non-destructive testing of translaminar fracture in composite laminates. Compos Part A Appl Sci Manuf. https://doi.org/10.1016/j.compositesa.2022.107060
Rutqvist J, Stephansson O (2003) The role of hydromechanical coupling in fractured rock engineering. Hydrogeol J 11:7–40. https://doi.org/10.1007/s10040-002-0241-5
Sok RM, Varslot T, Ghous A, Latham S, Sheppard AP, Knackstedt MA (2010) Pore scale characterization of carbonates at multiple scales: integration of Micro-CT, BSEM and FIBSEM. Petrophysics, 51 (6):379–87. http://hdl.handle.net/1885/59024
Sun XM, Shi FK, Luan ZQ, Yang L, Ding JX, He LS, Zhang Y (2023) Constitutive model and microscopic mechanism for sandstone strength softening damage. Rock Mech Rock Eng 56:797–813. https://doi.org/10.1007/s00603-022-03096-z
Van Geet M, Swennen R (2001) Quantitative 3D-fracture analysis by means of microfocus X-ray computer tomography (μ-CT): an example from coal. Geophys Res Lett 28(17):3333–3336. https://doi.org/10.1029/2001GL013247
Volokitin Y, Looyestijn W, Slijkerman W, Hofman JP (2001) A practical approach to obtain primary drainage capillary pressure curves from NMR core and log data. Petrophysics 42(4):334–343
Walsh JB (1981) Effect of pore pressure and confining pressure on fracture permeability. Int J Rock Mech Min Sci Geomech Abstr 18(5):429–435. https://doi.org/10.1016/0148-9062(81)90006-1
Wang Y, Hou ZQ, Hu YZ (2018) In situ X-ray micro-CT for investigation of damage evolution in black shale under uniaxial compression. Environ Earth Sci 77(20):1–12. https://doi.org/10.1007/s12665-018-7904-6
Wang G, Shen JN, Liu SM, Jiang CH, Qin XJ (2019) Three-dimensional modeling and analysis of macro-pore structure of coal using combined X-ray CT imaging and fractal theory. Int J Rock Mech Min. https://doi.org/10.1016/j.ijrmms.2019.104082
Wang G, Chen XC, Wang SB, Chen H (2022) Influence of fracture connectivity and shape on water seepage of low-rank coal based on CT 3D reconstruction. J Nat Gas Sci Eng 102:1875–5100. https://doi.org/10.1016/j.jngse.2022.104584
Wasantha PLP, Ranjith PG (2014) Water-weakening behavior of Hawkesbury sandstone in brittle regime. Eng Geol 178:91–101. https://doi.org/10.1016/j.enggeo.2014.05.015
Weerakone WMSB, Wong RCK, Kantzas A (2017) Morphological characterization of induced fracture in sandstone using X-ray computed tomography scanning. Geotech Test J 35(3):460–468
Xu YL, Li XL, Wu XK, Zheng W, Zhou B, Tong J (2022) Experimental study on pore fluid characteristics of fractured sandstone based on nuclear magnetic resonance technology. J Petroleum Sci Eng. https://doi.org/10.1016/j.petrol.2022.110408
Yang SQ, Ju Y, Gao F, Gui YL (2016) Strength, deformability and X-ray micro-CT observations of deeply buried marble under different confining pressures. Rock Mech Rock Eng 49(11):4227–4244. https://doi.org/10.1007/s00603-016-1040-y
Zhang N, Wang SD, Zhang ZY, Guo L, Huang C, He MC (2022) Study on water absorption characteristics and influencing factors of coal measures sedimentary rocks in Yixin coal mine. Chin J Rock Mech Eng. https://doi.org/10.13722/j.cnki.jrme.2021.0437
Zhao P, Wang L, Xu C, Fu J, Shi Y, Mao Z, Xiao D (2020) Nuclear magnetic resonance surface relaxivity and its advanced application in calculating pore size distributions. Mar Pet Geol 111:66–74. https://doi.org/10.1016/j.marpetgeo.2019.08.002
Zheng SJ, Yao YB, Liu DM, Cai YD, Liu Y (2018) Characterizations of full-scale pore size distribution, porosity and permeability of coals: A novel methodology by nuclear magnetic resonance and fractal analysis theory. Int J Coal Geol 196:148–158. https://doi.org/10.1016/j.coal.2018.07.008
Acknowledgements
This work was supported by the National Natural Science Foundation of China (Grant No. 52174096,51874311,51904306), the Special Fund of Basic Research and Operating of China University of Mining & Technology-Beijing (Grant No. 2022YJSSB03).
Author information
Authors and Affiliations
Corresponding authors
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Sun, X., Shi, F., Ding, J. et al. Study on Microscopic Mechanism and Failure Mode of Water–Rock Coupling in Fine Sandstone Under Uniaxial Compression. Rock Mech Rock Eng 56, 6823–6842 (2023). https://doi.org/10.1007/s00603-023-03428-7
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00603-023-03428-7