Skip to main content
SpringerLink
Log in

Comparative evaluation of biomarkers of occupational exposure to toluene

  • Original Article
  • Published:
International Archives of Occupational and Environmental Health Aims and scope Submit manuscript

Abstract

Objectives

This study was initiated to make comparative evaluation of five proposed urinary markers of occupational exposure to toluene, i.e., benzyl alcohol, benzylmercapturic acid, o-cresol, hippuric acid and un-metabolized toluene.

Methods

In practice, six plants in Japan were surveyed, and 122 Japanese workers (mostly printers; all men) together with 12 occupationally nonexposed control subjects (to be called controls; all men) agreed to participate in the study. Surveys were conducted in the second half of working weeks. Time-weighted average exposure (about 8 h) to toluene and other solvents were monitored by diffusive sampling. End-of-shift urine samples were collected and analyzed for the five markers by the methods previously described; simultaneous determination of o-cresol was possible by the method originally developed for benzyl alcohol analysis.

Results

The toluene concentration in the six plants was such that the grand geometric mean (GM) for the 122 cases was 10.4 ppm with the maximum of 121 ppm. Other solvents coexposed included ethyl acetate (26 ppm as GM), methyl ethyl ketone (26 ppm), butyl acetate (1 ppm) and xylenes (1 ppm). By simple regression analysis, hippuric acid correlated most closely with toluene in air (r = 0.85 for non-corrected observed values) followed by un-metabolized toluene (r = 0.83) and o-cresol (r = 0.81). In a plant where toluene in air was low (i.e., 2 ppm as GM), however, un-metabolized toluene and benzylmercapturic acid in urine showed better correlation with air-borne toluene (r = 0.79 and 0.61, respectively) than hippuric acid (r = 0.12) or o-cresol (r = 0.17). Benzyl alcohol tended to increase only when toluene exposure was intense. Correction for creatinine concentration or specific gravity of urine did not improve the correlation in any case. Multiple regression analysis showed that solvents other than toluene did not affect the levels of o-cresol, hippuric acid or un-metabolized toluene. Levels of benzylmercapturic acid and un-metabolized toluene were below the limits of detection [limit of detections (LODs); 0.2 and 2 μg/l, respectively] in the urine from the control subjects.

Conclusions

In over-all evaluation, hippuric acid, followed by un-metabolized toluene and o-cresol, is the marker of choice for occupational toluene exposure. When toluene exposure level is low (e.g., 2 ppm), un-metabolized toluene and benzylmercapturic acid in urine may be better indicators. Detection of un-metabolized toluene or benzylmercapturic acid in urine at the levels in excess of the LODs may be taken as a positive evidence of toluene exposure, because their levels in urine from the controls are below the LODs. The value of benzyl alcohol as an exposure marker should be limited.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1

Similar content being viewed by others

References

  • American Conference of Governmental Industiral Hygienists (2006) Documentation of TLVs and BEIs. ACGIH, Cincinnati

  • Angerer J, Krämer A (1997) Occupational chronic exposure to organic solvents XVII. Ambient and biological monitoring of workers exposed to toluene. Int Arch Occup Environ Health 69:91–96

    Article  PubMed  CAS  Google Scholar 

  • Angerer J, Schildbach M, Krämer A (1998) S-p-Toluylmercapturic acid in the urine of workers exposed to toluene: a new biomarker for toluene exposure. Arch Toxicol 72:119–123

    Article  PubMed  CAS  Google Scholar 

  • Buchwald H (1964) The expression of urine analysis results—Observations on the use of specific gravity correction. Ann Occup Hyg 7:125–136

    PubMed  CAS  Google Scholar 

  • Çok I, Dagdelen A, Gökçe E (2003) Determination of urinary hippuric acid and o-cresol levels as biological indicators of toluene exposure in shoe-workers and glue sniffers. Biomarkers 8:119–127

    Article  PubMed  CAS  Google Scholar 

  • De Rosa E, Brugnone F, Bartolucci GB, Perbellini L, Bellomo ML, Gori GP, Sigon M, Corona PC (1985) The validity of urinary metabolites as indicators of low exposures to toluene. Int Arch Occup Environ Health 56:135–145

    Article  PubMed  Google Scholar 

  • De Rosa E, Bartolucci GB, Sigon M, Callegaro R, Perbellini L, Brugnone F (1987) Hippuric acid and ortho-cresol as biological indicators of occupational exposure to toluene. Am J Ind Med 11:529–537

    Article  PubMed  Google Scholar 

  • Deutsche Forschungsgemeinschaft (2006) List of MAK and BAT values, 2006. Wiley-VCH, Weiheim

  • Hasegawa K, Shiojima S, Koizumi A, Ikeda M (1983) Hippuric acid and o-cresol in the urine of workers exposed to toluene. Int Arch Occup Environ Health 52:197–208

    Article  PubMed  CAS  Google Scholar 

  • Hirayama T, Ikeda M (1979) Applicability of activated carbon felt to the dosimetry of solvent vapor mixture. Am Ind Hyg Assoc J 40:1091–1096

    PubMed  CAS  Google Scholar 

  • Ichihara K (1990) Comparison of two regression parameters. In: Statistics for bioscience (in Japanese). Nankodo, Tokyo, pp 218–223

  • Ikeda M (1996) Selected solvents. 4.6 Toluene. In: Mikheev MI (ed) Biological monitoring of chemical exposure in the workplace, vol 1, chap 4. World Health Organization, Geneva, pp 205–217

  • Ikeda M (1999) Solvents in urine as exposure markers. Toxicol Lett 108:99–106

    Article  PubMed  CAS  Google Scholar 

  • Ikeda M, Ohtsuji H (1969) Significance of urinary hippuric acid determination as an index of toluene exposure. Br J Ind Med 26:244–246

    PubMed  CAS  Google Scholar 

  • Inoue O, Seiji K, Watanabe T, Kasahara M, Nakatsuka H, Yin S-N, Li G-L, Cai S-X, Jin C, Ikeda M (1986) Possible ethnic difference in toluene metabolism: A comparative study among Chinese, Turkish and Japanese solvent workers. Toxicol Lett 34:167–174

    Article  PubMed  CAS  Google Scholar 

  • Inoue O, Seiji K, Watanabe T, Chen Z, Huang M-Y, Xu X-P, Qiao X, Ikeda M (1994) Effects of smoking and drinking habits on urinary o-cresol excretion after occupational exposure to toluene vapor among Chinese works. Am J Ind Med 25:697–708

    Article  PubMed  CAS  Google Scholar 

  • Inoue O, Kanno E, Kudo S, Kakizaki M, Kataoka M, Kawai T, Ukai H, Ikeda M (1998) High-pressure liquid chromatographic determination of toluene in urine as a marker of occupational exposure to toluene. Int Arch Occup Environ Health 71:302–308

    Article  PubMed  CAS  Google Scholar 

  • Inoue O, Kanno E, Yusa T, Kakizaki M, Ukai H, Okamoto S, Higashikawa K, Ikeda M (2002) Urinary benzylmercapturic acid as a marker of occupational exposure to toluene. Int Arch Occup Environ Health 75: 341–347

    Article  PubMed  CAS  Google Scholar 

  • Inoue O, Kanno E, Kasai K, Ukai H, Okamoto S, Ikeda M (2004) Benzylmercapturic acid is superior to hippuric acid and o-cresol as a urinary marker of occupational exposure to toluene. Toxicol Lett 147:177–186

    Article  PubMed  CAS  Google Scholar 

  • Jackson S (1966) Creatinine in urine as an index of urinary excretion rate. Health Phys 12:341–350

    Article  Google Scholar 

  • Japan Society for Occupational Health (2006) Recommendation of occupational exposure limits (2006–2007). Jpn J Ind Health 48:290–306

    Google Scholar 

  • Kawai T, Yasugi T, Mizunuma K, Horiguchi S, Ikeda M (1992a) Urinalysis vs. blood analysis, as a tool for biological monitoring of solvent exposure. Toxicol Lett 63:333–343

    Article  PubMed  CAS  Google Scholar 

  • Kawai T, Yasugi T, Mizunuma K, Horiguchi S, Iguchi H, Uchida Y, Iwami O, Ikeda M (1992b) Comparative evaluation of urinalysis and blood analysis as means of detecting exposure to organic solvents at low concentrations. Int Arch Occup Environ Health 64:223–234

    Article  PubMed  CAS  Google Scholar 

  • Kawai T, Mizunuma K, Okada Y, Horiguchi S, Ikeda M (1996) Toluene itself as the best urinary marker of toluene exposure. Int Arch Occup Environ Health 68:289–297

    Article  PubMed  CAS  Google Scholar 

  • Kawai T, Yamauchi T, Miyama Y, Sakurai H, Ukai H, Takada S, Ohashi F, Ikeda M (2007) Benzyl alcohol as a marker of occupational exposure to toluene. Ind Health 95:143–150

    Article  Google Scholar 

  • Lauwerys R (1983) Toluene. In: Alessio L, Berlin A, Roi R, Boni M (eds) Human biological monitoring of industrial chemicals, vol 1. Joint Reserch Centre Ispra Establishment, CEC, pp 159–175

  • Levine L, Fahy JP (1945) Evaluation of urinary lead concentrations. I. The significance of the specific gravity. J Ind Hyg Toxicol 27:217–223

    CAS  Google Scholar 

  • Löf A, Wigaeus Hjelm E, Colmsjö A, Lundmark B-O, Norström Å, Sato A (1993) Toxicokinetics of toluene and urinary excretion of hippuric acid after human exposure to 2H8-toluene. Br J Ind Med 50:55–59

    PubMed  Google Scholar 

  • Maestri L, Ghittori S, Imbriani M (1997) Determination of specific mercapturic acids as an index of exposure to environmental benzene, toluene, and styrene. Ind Health 35:489–501

    PubMed  CAS  Google Scholar 

  • Michitsuji H, Ohara A, Yamaguchi K, Fujiki Y (1987) Effect of intake of refreshments in excretion of hippuric acid in urine (in Japanese with English abstract). Matsushita Med J 26:105–116

    Google Scholar 

  • Moon C-S, Lee J-T, Chun J-H, Ikeda M (2001) Use of solvents in industries in Korea; experience in Sinpyeong-Jangrim industrial complex. Int Arch Occup Envion Health 74:148–152

    Article  CAS  Google Scholar 

  • Nise G (1992) Urinary excretion of o-cresol and hippuric acid after toluene exposure in rotogravure printing. Int Arch Occup Envion Health 63:377–381

    Article  CAS  Google Scholar 

  • Ogata M, Taguchi T (1987) Quantitation of urinary metabolites of toluene, xylene, styrene, ethylbenzene, benzene and phenol by automated high performance liquid chromatography. Int Arch Occup Environ Health 59:263–272

    Article  PubMed  CAS  Google Scholar 

  • Ong CN (1999) Reference values and action levels of biological monitoring in occupational exposure. Toxicol Lett 108:127–135

    Article  PubMed  CAS  Google Scholar 

  • Pierce CH, Dills RL, Morgan MS, Vicini P, Kalman DA (1998) Biological monitoring of controlled toluene exposure. Int Arch Occup Environ Health 71:433–444

    Article  PubMed  CAS  Google Scholar 

  • Pierce CH, Chen Y, Dills RL, Kalman DA, Morgen MS (2002) Toluene metabolites as biological indicators of exposure. Toxicol Lett 129:65–67

    Article  PubMed  CAS  Google Scholar 

  • Pierce CH, Chen Y, Hurtle WR, Morgan MS (2004) Exponential modeling, washout curve reconstruction, and estimation of half-life of toluene and its metabolites. J Toxicol Environ Health A67:1131–1158

    Article  CAS  Google Scholar 

  • Rainsford SG, Lloyd Davies TA (1965) Urinary excretion of phenol by men exposed to benzene; a screening test. Br J Ind Med 22:21–26

    PubMed  CAS  Google Scholar 

  • Samoto H, Fukui Y, Ukai H, Okamoto S, Takada S, Ohashi F, Moriguchi J, Ezaki T, Ikeda M. (2006) Field survey on types of organic solvents used in enterprises of various sizes. Int Arch Occup Environ Health 79:558–567

    Article  PubMed  Google Scholar 

  • Siqueira ME, Paiva MJ (2002) Hippuric acid in urine: reference values. Rev Saúde Pública 36:723–727

    Article  PubMed  Google Scholar 

  • Skender L, Brčić I, Karačić V (2004) Urine analysis for the evaluation of environmental exposures to aromatic hydrocarbons. Arch Environ Health 59:237–244

    Article  PubMed  CAS  Google Scholar 

  • Sugita M, Aikawa H, Suzuki K, Yamasaki T, Minowa H, Etoh R, Kasuga H (1988) Urinary hippuric acid excretion in everyday life. Tokai J Exp Clin Med 13:185–190

    PubMed  CAS  Google Scholar 

  • Takeuchi A, Kawai T, Zhang Z-W, Miyama Y, Sakamoto K, Higashikawa K, Ikeda M (2002) Toluene, xylenes and xylene isomers in urine as biological indicators of low-level exposure to each solvent; a comparative study. Int Arch Occup Environ Health 75:387–393

    Article  PubMed  CAS  Google Scholar 

  • Truchon G, Tardif R, Brodeur J (1999) o-Cresol: A good indicator of exposure to low levels of toluene. Appl Occup Environ Hyg 14:677–681

    Article  PubMed  CAS  Google Scholar 

  • Ukai H, Inui S, Takada S, Dendo J, Ogawa J, Isobe K, Ashida T, Tamura M, Tabuki K, Ikeda M (1997) Types of organic solvents used in small- to medium-scale industries in Japan: a nation-wide field survey. Int Arch Occup Environ Health 70:385–592

    Article  PubMed  CAS  Google Scholar 

  • Villanueva MB, Jonai H, Kanno S, Takeuchi Y (1994) Dietary sources and background levels of hippuric acid in urine; comparison of Philippine and Japanese levels. Ind Health 32:339–346

    Article  Google Scholar 

  • Yasugi T, Kawai T, Mizunuma K, Kishi R, Harabuchi I, Yuasa J, Eguchi T, Sugimoto R, Seiji K, Ikeda M (1994) Exposure monitoring and health effect studies of workers occupationally exposed to cyclohexane vapor. Int Arch Occup Environ Health 65:343–350

    Article  PubMed  CAS  Google Scholar 

  • Yasugi T, Endo G, Monna T, Odachi T, Yamaoka K, Kawai T, Horiguchi S, Ikeda M (1998) Types of organic solvents used in workplaces and work environment conditions with special references to reproducibility of work environment classification. Ind Health 36:223–233

    PubMed  CAS  Google Scholar 

Download references

Acknowledgments

The authors are grateful to Dr. T. Sugita, Professor K. Sakamoto and Professor S. Horiguchi of Osaka Occupational Health Service Center, Japan Industrial Safety and Health Association, Osaka, for their interest in and support to this work.

Author information

Authors and Affiliations

  1. Kyoto Industrial Health Association, 67 Nishinokyo-Kitatsuboicho, Nakagyo-ku, Kyoto, 604-8472, Japan

    Hirohiko Ukai, Yoshinari Fukui, Fumiko Ohashi, Satoru Okamoto, Shiro Takada & Masayuki Ikeda

  2. Osaka Occupational Health Service Center, Japan Industrial Safety and Health Association, Nishi-ku, Osaka, 550-0001, Japan

    Toshio Kawai

  3. Tohoku Rosai Hospital, 4-3-1 Dainohara, Aoba-ku, Sendai, 981-8563, Japan

    Osamu Inoue

  4. Department of Hygiene, School of Medicine, Wakayama Medical University, Wakayama, 641-8509, Japan

    Yuki Maejima

  5. Occupational Health Research and Development Center, Japan Industrial Safety and Health Association, Minato-ku, Tokyo, 108-0014, Japan

    Haruhiko Sakurai

Authors
  1. Hirohiko Ukai
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Toshio Kawai
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Osamu Inoue
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Yuki Maejima
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. Yoshinari Fukui
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. Fumiko Ohashi
    View author publications

    You can also search for this author in PubMed Google Scholar

  7. Satoru Okamoto
    View author publications

    You can also search for this author in PubMed Google Scholar

  8. Shiro Takada
    View author publications

    You can also search for this author in PubMed Google Scholar

  9. Haruhiko Sakurai
    View author publications

    You can also search for this author in PubMed Google Scholar

  10. Masayuki Ikeda
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Masayuki Ikeda.

Rights and permissions

Reprints and permissions

About this article

Cite this article

Ukai, H., Kawai, T., Inoue, O. et al. Comparative evaluation of biomarkers of occupational exposure to toluene. Int Arch Occup Environ Health 81, 81–93 (2007). https://doi.org/10.1007/s00420-007-0193-0

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s00420-007-0193-0

Keywords

Search

Navigation