Abstract
Water inrush from separated layers (WISL) is a new type of hydraulic hazard, which causes severe damage in coal mines. In this study, a new risk zoning method, which considers the theory of subjectivity, objectivity, and variable weight, is proposed for WISL during mining. First, the formation mechanism of separated layers (SLs) and evolution conditions of WISL were systematically investigated based on the engineering geological conditions. Then, Cuimu coal mine, located in Ordos basin, China, was taken as the study case, and eight primary factors were selected for overburden conditions, mining-induced disturbance, and water abundance of aquifer. Subsequently, on the basis of analytic hierarchy process (AHP), entropy weight method (EWM), and variable-weight method (VWM), a mathematical model is proposed for risk zoning for WISL in Cuimu coal mine. Finally, the new method was compared with the previous method to verify its validity in assessing the risk of WISL; then, some protection methods are proposed to effectively control WISL in coal mines. As a result, the study area is divided into five parts: high danger zone (HDZ), middle danger zone (MDZ), low danger zone (LDZ), middle zone (MZ), and safe zone (SZ). According to the collected field data in working faces, it is verified that the proposed zoning method (AHP-EWM-VWM) is more accurate than the conventional method for risk evaluation of WISL; constructing drain holes, limiting mining height as well as velocity, and monitoring the water table of primary aquifer are effective methods for predicting and preventing WISL in coal mines. This study is considerably beneficial to avoid the damage caused by WISL during mining.
Similar content being viewed by others
References
Adhikary DP, Guo H (2015) Modelling of Longwall Mining-Induced Strata Permeability Change.[J]. Rock Mechanics and Rock Engineering: 345-359
Avila P, Mota A, Bastos J, Patrício L, Pires A, Castro H, Cruz-Cunha MM, Varela L (2021) Framework for a risk assessment model to apply in virtual/collaborative enterprises[J]. Procedia Computer Science 181:612–618
Aykut T (2021) Determination of groundwater potential zones using Geographical Information Systems (GIS) and Analytic Hierarchy Process (AHP) between Edirne-Kalkansogut (northwestern Turkey)[J]. Groundw Sustain Dev 12:100545
Behrooz Ghabraie GR, Barbatob J, Smitha JV (2017) A predictive methodology for multi-seam mining induced subsidence[J]. Int J Rock Mech Min Sci 93:280–294
Bhat SA, Kumar A (2018) Performance evaluation of outsourcing decision using a BSC and fuzzy AHP approach: A case of the Indian coal mining organization by M., Modak, K., Pathak, K. K., Ghosh [Resour. Policy 52 (2017) 181–191]: Suggested modification[J]. Resources Policy, 55: 29-30
Chand P, Thakkar JJ, Ghosh KK (2018) Analysis of supply chain complexity drivers for Indian mining equipment manufacturing companies combining SAP-LAP and AHP[J]. Res Policy 59:389–410
Cui HM, Gu YD, Sui KM, Li HX (2004) A note on the axiom system of state variable-weights[J]. Journal of Beijing University 40-41:1–7
Di Giuseppe MG, Troiano A, Patella D, Piochi M, Carlino S (2018) A geophysical k -means cluster analysis of the Solfatara-Pisciarelli volcano-geothermal system, Campi Flegrei (Naples, Italy)[J]. J Appl Geophys 156:44–54
Dong L, Shengyou L, Al ZGE (2017) Typical roof water disasters and its prevention & control technology in the north of Ordos Basin[J]. J China Coal Soc 12(42):3249–3254
Fan K, Li W, Wang Q, Liu S, Xue S, Xie C, Wang Z (2019) Formation mechanism and prediction method of water inrush from separated layers within coal seam mining: a case study in the Shilawusu mining area, China[J]. Eng Fail Anal 103:158–172
Fang DC, Liu GL, Lp Z. (2004) The application of information entropy in investment decision.[J]. Value Eng: 2-115
Feng M, Mao X, Bai H, Miao X (2007) Analysis of water insulating effect of compound water-resisting key strata in deep mining[J]. J China Univ Min Technol 17(1):1–5
Guan W, Wang C, Wang S, Zhu K, Dong G (2017) Inrush-accidents-oriented graphic method to identify the sources of water-inrush from coal-seam roof strata[J]. Journal of Mining & Safety Engineering 34(1)
Gupta P, Mehlawat M K, Aggarwal U, Charles V. (2018) An integrated AHP-DEA multi-objective optimization model for sustainable transportation in mining industry[J]. Resources Policy: 101180
He J, Li W, Liu Y, Yang Z, Liu S, Li L (2018) An improved method for determining the position of overlying separated strata in mining[J]. Eng Fail Anal 83:17–29
Hu X, Li W, Cao D, Liu M (2012) Index of multiple factors and expected height of fully mechanized water flowing fractured zone[J]. J China Coal Soc 37(4):613–620
Hu X, Wang L, Lu Y, Yu M (2014) Analysis of insidious fault activation and water inrush from the mining floor[J]. Int J Min Sci Technol 24(4):477–483
Jiang H, Li L, Rong X, Wang M, Xia Y, Zhang Z (2017) Model test to investigate waterproof-resistant slab minimum safety thickness for water inrush geohazards[J]. Tunn Undergr Space Technol 62:35–42
Kratcsch H (1983) Mining Subsidence Engineering[M]. Springer Verlag, Berlin
Lawson HE, Tesarik D, Larson MK, Habte A (2017) Effects of overburden characteristics on dynamic failure in underground coal mining[J]. Int J Min Sci Technol 2017(27):121–129
Li HX (2004) Fuzzy decision making based on variable-weights [J]. Math Comput Model.: 23-39, 163-179
Li B. (2014) Vulnerability assessment of coal floor groundwater bursting based on variable-weight theory-a case in the typical mineral region of Yuxin, doctoral dissertation[J]. J. China Univ. Min. Technol., Beijing, China,: 79-85
Li T, Wang Y. (2011) Biological image fusion using a NSCT based variable-weight method[J]. Information Fusion: 12-2011
Li W, Li X, Sun R (2008) Preliminary study on “dynamic water inrush” in coal mining under extremely thick and hard strata[J]. J Eng Geol:S1–S446
Li M, Wang H, Wang D, Shao Z, He S (2020) Risk assessment of gas explosion in coal mines based on fuzzy AHP and bayesian network[J]. Process Saf Environ Prot 135:207–218
Lin C, Zhang M, Zhou Z, Li L, Shi S, Chen Y, Dai W (2020) A new quantitative method for risk assessment of water inrush in karst tunnels based on variable weight function and improved cloud model[J]. Tunn Undergr Space Technol 95:103136
Liu T (1981) Coal mine ground movement and strata failure[M]. Coal Industry Publication House, Beijing
Liu W (1998) Penalty incentive utility in variable-weight synthesis.[J]. Syst. Eng. Theory 14-18:41–47
Liu Q, Jiwen H (2011) Research on method of water-resisting coefficient for distinguishing floor water inrush danger [J]. Procedia Earth and Planetary Science 3:238–245
Liu H, Pei X, Jia D, Sun F, Guo T (2017) Connotation, application and prospect of the fourth-generation separated layer water injection technology[J]. Pet Explor Dev 44(4):644–651
Liu S, Li W, Wang Q (2018a) Zoning method for environmental engineering geological patterns in underground coal mining areas[J]. Sci Total Environ 634:1064–1076
Liu S, Li W, Wang Q, He J, Xue S (2018b) Water inrush risk zoning and water conservation mining technology in the Shennan Mining Area, Shaanxi, China[J]. Arab J Sci Eng 43(1):321–333
Lou J, Xu G (2018) Research on roof disaster mechanism and prevention under soft water–enriched roof in Yonglong Coalfield[J]. Coal Science and Technology 7(46):10–18
Lu Q, Li X, Li W, Chen W, Li L, Liu S (2018) Risk evaluation of bed-separation water inrush: a case study in the Yangliu Coal Mine, China[J]. Mine Water Environ 37(2):288–299
Ma D, Rezania M, Yu H, Bai H (2017) Variations of hydraulic properties of granular sandstones during water inrush: Effect of small particle migration[J]. Eng Geol 217:61–70
Ma D, Duan H, Li X, Li Z, Zhou Z, Li T (2019) Effects of seepage-induced erosion on nonlinear hydraulic properties of broken red sandstones[J]. Tunn Undergr Space Technol 91:102993
Majhi SK, Biswal S (2018) Optimal cluster analysis using hybrid K-means and ant lion optimizer[J]. Karbala International Journal of Modern Science 4(4):347–360
Mills KW, Garratt O, Blacka BG, Daigle LC, Rippon AC, Walker RJ (2016) Measurement of shear movements in the overburden strata ahead of longwall mining[J]. Int J Min Sci Technol 26(1):97–102
Mou N X. (2012) ArcGIS10 Geography Information System Tutorial[M]. Surveying and Mapping Press, Beijing, pp. 105–153
Niu Q, Yu L, Jie Q, Li X (2020) An urban eco-environmental sensitive areas assessment method based on variable weights combination[J]. Environ Dev Sustain 22(3):2069–2085
Palchik V (1989) Analytical and empirical prognosis of rock foliation in rock masses[J]. Journal of Coal Ukraine 7:45–46
Palchik V (2003) Formation of fractured zones in overburden due to longwall mining[J]. Environ Geol 1(44):28–38
Palchik V (2005) Localization of mining-induced horizontal fractures along rock layer interfaces in overburden: field measurements and prediction[J]. Environ Geol 1(48):68–80
Peng S (1984) Coal mine strata control[M]. China Coal Industry Press, Beijing
Peng L, Yang X, Sun X (2011) Analysis and control on anomaly water inrush in roof of fully-mechanized mining field[J]. Mining Science and Technology (China) 21(1):89–92
Poulsen BA, Deepak A, Guo H (2018) Simulating mining-induced strata permeability changes[J]. Eng Geol 2018(237):208–216
Puller JW, Mills KW, Jeffrey RG, Walker RJ (2016) In-situ stress measurements and stress change monitoring to monitor overburden caving behaviour and hydraulic fracture pre-conditioning[J]. Int J Min Sci Technol 26(1):103–110
Qian M, Shi P (2003) Mine pressure and rock formation control[M]. China University of Mining and Technology Press, Xuzhou
Qiao W, Li W, Zhao C (2009) Water inrush coefficient-unit inflow method for water inrush evaluation of coal mine floor[J]. Chin J Rock Mech Eng 28(12)
Qiao W, Wenping LI, Sun Ruhua EA (2011a) Formation mechanism of dynamic impact failure zone of super dynamic water inrush in coal mine[J]. J Geotech Eng:11–33
Qiao W, Li W, Li X. (2011b) Mechanism of ―Hydrostatic Water-Inrush and Countermeasuresfor Water Inrush in Roof Bed Separation of A Mining Face[J]. Journal of Mining and Safety: 21-28.
Qiao W, Huang Y, Yuan Z (2014) Formation and prevention of water inrush form roof bed separation with full-mechanized caving mining of ultra thick coal seam[J]. Journal of Rock Mechanics and Engineering 2014:10–33
Qiao W, Wang Z, Li W, Lv Y, Li L. (2021) Formation mechanism, disaster-causing mechanism and prevention technology of roof bed separation water disaster in coal mine[J]. Journal of China Coal Society
Rafiqulislam M, Hayashi D, Kamruzzaman ABM (2009) Finite element modeling of stress distributions and problems for multi-slice longwall mining in Bangladesh, with special reference to the Barapukuria coal mine [J]. Int J Coal Geol 72-78:91–109
Saaty TL (1980) The analytic hierarchy process[M]. McGraw- Hill, New York
Shannon CE (1948) A mathematical theory of communications.[J]. ATT Tech J: 23-27
Shu Z, He B, Li L (2020) Study on mechanism of separation strata water-inrush induced by impact energy of key strata abrupt breaking[J]. Coal Science and Technology 5(48):149–156
Shuning D, Yadong J, Al WHE (2020) Prevention and control technology and application of roof water disaster in Jurassic coal field of Ordos Basin[J]. J China Coal Soc 7(45):2367–2375
Sun J (2017) Mechanics criterion and factors affecting overburden stability in solid dense filling mining[J]. Int J Min Sci Technol 27(3):407–413
Sun J, Hu Y, Zhao G (2017) Relationship between water inrush from coal seam floors and main roof weighting[J]. Int J Min Sci Technol 27(5):873–881
Sun Y, Zuo J, Karakus M, Wang J. (2019) Investigation of movement and damage of integral overburden during shallow coal seam mining[J]. International journal of rock mechanics and mining sciences (Oxford, England : 1997), 117: 63-75
Sun Q, Zhang J, Li M, Zhou N (2020) Experimental evaluation of physical, mechanical, and permeability parameters of key aquiclude strata in a typical mining area of China[J]. J Clean Prod 267:122109
Wang M, Xu P, Li J, Zhao K. (2014) A novel set pair analysis method based on variable-weights for liquefaction evaluation[J]. Nat Hazards: 70-72
Wang X, Yao M, Zhang J, Zhao W, Huang P (2019a) Evaluation of water bursting in coal seam floor basedon improved AHP and fuzzy variable set theory[J]. Journal of Mining & Safety Engineering 36(3)
Wang Y, Jin Z, Deng C, Wang X, Chen X, Zhang X (2019b) Comprehensive decision making with fuzzy compromised variable weights and its application on maintenance order for entries in underground coal mine[J]. International Journal of Fuzzy Systems 21(5):1379–1388
Wang L, Kong H, Karakus M (2020) Hazard assessment of groundwater inrush in crushed rock mass: An experimental investigation of mass-loss-induced change of fluid flow behavior[J]. Eng Geol 277:105812
Wu Q, Huang X, Al DDE (2000) “Three maps-two predictions” method to evaluate water bursting conditions on roof coal[J]. J China Coal Soc 1(25):60–65
Wu Q, Liu Y, Al LDE (2011a) Prediction of floor water inrush: the application of gis-based AHP vulnerable index method to Donghuantuo coal mine, China[J]. .Rock Mechanics and Rock Engineering: 44-45
Wu Q, Fan Z, Liu S, Zhang Y, Sun W (2011b) Water-richness evaluation method of water-filled aquifer based on the principle of information fusion with GIS: Water-richness index method[J]. J China Coal Soc 36(7)
Wu Q, Fan Z, Zhang Z, Zhou W (2014) Evaluation and zoning of groundwater hazards in Pingshuo No. 1 underground coal mine, Shanxi Province, China[J]. Hydrogeol J 22(7):1693–1705
Wu Q, Li B, Yulong C (2016) Vulnerability assessment of groundwater inrush from underlying aquifers based on variable weight model and its application[J]. Water Resour Manag 30(10):3331–3345
Wu Q, Zhao D, Wang Y, Shen J, Mu W, Liu H (2017) Method for assessing coal-floor water-inrush risk based on the variable-weight model and unascertained measure theory[J]. Hydrogeol J 25(7):2089–2103
Xu J, Qian M, Jin H (2004) Study and application of bed separation distribution and development in the process of strata movement[J]. Chinese Journal of Geotechnical Engineering 5(24):632–636
Xu Q, Chen J, Xiao M (2020) Analysis of unsteady seepage field and surrounding rock stability of underground cavern excavation[J]. Tunn Undergr Space Technol 97:103239
Xu H, Croot P, Zhang C (2021) Discovering hidden spatial patterns and their associations with controlling factors for potentially toxic elements in topsoil using hot spot analysis and K-means clustering analysis[J]. Environ Int 151:106456
Yan Z, Wang X, Fu Y (2012) Study on Early Warning Model of Coal Mining Engineering with Fuzzy AHP[J]. Systems Engineering Procedia 5:113–118
Yang W, Jin L, Zhang X (2019) Simulation test on mixed water and sand inrush disaster induced by mining under the thin bedrock[J]. J Loss Prev Process Ind 57:1–6
Zeng Y, Wu Q, Liu S, Zhai Y, Lian H, Zhang W (2018) Evaluation of a coal seam roof water inrush: case study in the Wangjialing coal mine, China[J]. Mine Water Environ 37(1):174–184
Zhai H, Jeng D, Guo Z, Liang Z (2021) Impact of two-dimensional seepage flow on sediment incipient motion under waves[J]. Appl Ocean Res 108:102510
Zhang S, Zhang M, Gt C. (2010) The science and technology evaluation model based on entropy weight and empirical research during the 10th five-year of China[J].: 1-34
Zhang D, Fan G, Ma L, Wang X (2011) Aquifer protection during longwall mining of shallow coal seams: a case study in the Shendong Coalfield of China.[J]. Int J Coal Geol 82-86:190–196
Zhang J, Wu Q, Mu W, Du Y, Tu K (2019) Integrating the hierarchy-variable-weight model with collaboration-competition theory for assessing coal-floor water-inrush risk[J]. Environ Earth Sci 78(6)
Zhu Y, Li H. (1999) Axiomatic system of state variable-weights and construction of equilibrium function.[J]. Syst Eng Theory Pract 17-19, 116-118.
Zhu E, Zhang Y, Wen P, Liu F (2019) Fast and stable clustering analysis based on Grid-mapping K-means algorithm and new clustering validity index[J]. Neurocomputing 363:149–170
Acknowledgements
The authors appreciate the anonymous reviewers who help to improve the manuscript.
Funding
This research was funded by the Fundamental Research Funds for the Central Universities, grant no. 2017XKZD07; the Fundamental Research Funds of the National Natural Science of China, grant nos. 41772302 and 51504136; and the Priority Academic Program Development of Jiangsu Higher Education Institutions.
Author information
Authors and Affiliations
Corresponding authors
Ethics declarations
Conflict of interest
The authors declare that they have no competing interests.
Additional information
Responsible Editor: Zeynal Abiddin Erguler
Rights and permissions
About this article
Cite this article
Liu, M., Qiao, W., Meng, Q. et al. A new risk zoning method for water inrush from separated layers at coal mines: a case study, Cuimu coal mine, China. Arab J Geosci 14, 2544 (2021). https://doi.org/10.1007/s12517-021-08584-0
Received:
Accepted:
Published:
DOI: https://doi.org/10.1007/s12517-021-08584-0