Abstract
Silica nanoparticles were synthesized by the sol–gel method in alcoholic solution under microwave irradiation in the presence of an ammonium catalyst. The effect of the reaction time, the reaction temperature, water and ammonium concentrations on particle size and conversion (measured by light scattering and FTIR respectively) were analyzed using multivariate analysis. The results showed that water and ammonium concentrations are the main factors that control the particle size and the conversion. Both properties increase with water and ammonium concentration. Moreover, comparing with the results obtained using traditional heating, the microwave heating gave rise to higher reaction rate and narrower dispersion of the particle size.
Similar content being viewed by others
References
Stöber W, Fink A, Bohn E (1968) J Colloid Interface Sci 26:62
Brinker CJ, Scherer GW (1990) Sol–gel science. Academic Press, New York
Lindberg R, Sundholm G, Pettersen B, Sjöblom J, Friberg SE (1997) Colloids Surf A 123–124:549
Hartlen KD, Athanasopoulos APT, Kitaev V (2008) Langmuir 24:1714
Kim KD, Kim HT (2002) J Sol–Gel Sci Technol 25:183
Zhao M, Zheng L, Bai X, Li N, Yu L (2009) Colloids Surf A 346:229–236
Nüchter M, Ondruschka B, Bonrath W, Gum A (2004) Green Chem 6:128
Tompsett GA, Conner WC, Yngvesson KS (2006) Chem Phys Chem 7:296
Rao KJ, Vaidhyanathan B, Ganguli M, Ramakrishan PA (1999) Chem Mater 11:882
Inada M, Nishinosono A, Kamada K, Enemoto N, Hojo J (2008) J Mater Sci 43:2362
Corradi AB, Bondioli F, Ferrari AM, Focher B, Leonelli C (2006) Powder Technol 167:45
Celer EB, Jaroniec M (2006) J Am Chem Soc 128:14408
De G, Karmakar B, Ganguli D (2000) J Mater Chem 10:2289
Wu C, Wu Y, Xu T, Yang WJ (2006) Non-Cryst Solids 352:5642
Kaluz AL, Surca-Vuk A, Orel B, Drazia G, Pelicon P (2001) J Sol–Gel Sci Technol 20:61
Wen J, Wilkes GS (1996) Chem Mater 8:1668
Acknowledgement
The authors would like to thank the financial support of the Ministerio de Educación y Ciencia (INTERHYBRID project, nº MAT2005-08033-C02-01).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Mily, E., González, A., Iruin, J.J. et al. Silica nanoparticles obtained by microwave assisted sol–gel process: multivariate analysis of the size and conversion dependence. J Sol-Gel Sci Technol 53, 667–672 (2010). https://doi.org/10.1007/s10971-010-2148-2
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10971-010-2148-2