Abstract
Background
Ogataea (Hansenula) polymorpha is one of the most thermotolerant xylose-fermenting yeast species reported to date. Several metabolic engineering approaches have been successfully demonstrated to improve high-temperature alcoholic fermentation by O. polymorpha. Further improvement of ethanol production from xylose in O. polymorpha depends on the identification of bottlenecks in the xylose conversion pathway to ethanol.
Results
Involvement of peroxisomal enzymes in xylose metabolism has not been described to date. Here, we found that peroxisomal transketolase (known also as dihydroxyacetone synthase) and peroxisomal transaldolase (enzyme with unknown function) in the thermotolerant methylotrophic yeast, Ogataea (Hansenula) polymorpha, are required for xylose alcoholic fermentation, but not for growth on this pentose sugar. Mutants with knockout of DAS1 and TAL2 coding for peroxisomal transketolase and peroxisomal transaldolase, respectively, normally grow on xylose. However, these mutants were found to be unable to support ethanol production. The O. polymorpha mutant with the TAL1 knockout (coding for cytosolic transaldolase) normally grew on glucose and did not grow on xylose; this defect was rescued by overexpression of TAL2. The conditional mutant, pYNR1-TKL1, that expresses the cytosolic transketolase gene under control of the ammonium repressible nitrate reductase promoter did not grow on xylose and grew poorly on glucose media supplemented with ammonium. Overexpression of DAS1 only partially restored the defects displayed by the pYNR1-TKL1 mutant. The mutants defective in peroxisome biogenesis, pex3Δ and pex6Δ, showed normal growth on xylose, but were unable to ferment this sugar. Moreover, the pex3Δ mutant of the non-methylotrophic yeast, Scheffersomyces (Pichia) stipitis, normally grows on and ferments xylose. Separate overexpression or co-overexpression of DAS1 and TAL2 in the wild-type strain increased ethanol synthesis from xylose 2 to 4 times with no effect on the alcoholic fermentation of glucose. Overexpression of TKL1 and TAL1 also elevated ethanol production from xylose. Finally, co-overexpression of DAS1 and TAL2 in the best previously isolated O. polymorpha xylose to ethanol producer led to increase in ethanol accumulation up to 16.5 g/L at 45 °C; or 30–40 times more ethanol than is produced by the wild-type strain.
Conclusions
Our results indicate the importance of the peroxisomal enzymes, transketolase (dihydroxyacetone synthase, Das1), and transaldolase (Tal2), in the xylose alcoholic fermentation of O. polymorpha.
Similar content being viewed by others
Background
Peroxisomes are defined as organelles that typically contain the H2O2-generating enzymes, oxidase, and catalase. Most peroxisomes from yeasts to humans contain enzymes conducting fatty acid β-oxidation. Peroxisomes in fungi and plants also harbor some enzymes from the glyoxylic acid cycle [1,2,3]. However, the peroxisome is a metabolically versatile organelle containing enzymes catalyzing numerous catabolic and some biosynthetic reactions. In filamentous fungi, peroxisomes contain some enzymes conferring biotin and penicillin biosynthesis [4, 5]. In yeasts, peroxisomes are involved in the catabolism of many carbon and nitrogen sources, such as methanol, n-alkanes, purines, d-amino acids, methylamine, ethylamine, pipecolic acid, sarcosine, glycolate and spermidine [3, 6]. Involvement of peroxisomes in sugar catabolism has been described for some parasitic Kinetoplastida protists, where these organelles, also known as glycosomes, contain enzymes catalyzing key glycolytic reactions [7]. Regarding yeast and filamentous fungi, until recently it has been accepted that the enzymes of glucose catabolism (i.e., glycolysis and pentose phosphate pathway) are located in the cytosol [8]. However, recent studies on Cryptococcus neoformans and Ustilago maydis showed that some of the glycolytic enzymes exhibit dual localization in both cytosol and peroxisomes [9, 10]. Importantly, defects in peroxisomal localization of glycolytic proteins or deficient peroxisome biogenesis impaired growth of these organisms on glucose. Candida albicans and related species showed cytosolic and peroxisomal localization of enzymes from the oxidative branch of the pentose phosphate pathway, namely glucose-6-phosphate dehydrogenase and 6-phosphogluconate dehydrogenase [11]. Both cytosolic and peroxisomal isoforms of these proteins are encoded by single genes, suggesting that dual localization of the enzymes results from alternative splicing or ribosomal read-through of the stop codons [8, 10]. However, the methylotrophic yeast, Komagataella phaffii (Pichia pastoris), contains two sets of enzymes from the non-oxidative segment of the pentose phosphate pathway. These are the cytosolic and peroxisomal isoforms, encoded by different paralogs [12]. It is also known that peroxisomal enzymes are involved in the so-called xylulose monophosphate pathway for formaldehyde assimilation during growth on methanol. It has been suggested that this pathway for formaldehyde assimilation relies solely on the peroxisomal (and not cytosolic) enzymes of the non-oxidative branch of the pentose phosphate pathway (e.g., transketolase, transaldolase, ribulose phosphate epimerase, and ribose phosphate isomerase). Putative functions of these peroxisomal isoforms in the xylose metabolism of K. phaffii were not studied.
Here, we addressed the metabolism and ethanol fermentation of the second most abundant sugar in nature, xylose. Xylose is the major component of the hemicellulose found in grasses and hard wood trees. For this study, we used the methylotrophic yeast, Ogataea (Hansenula) polymorpha, which is capable of fermenting glucose, cellobiose, and xylose [13]; as well as converting glycerol to ethanol [14]. Moreover, this organism is the most thermotolerant yeast known to date with a maximal growth and fermenting temperature of 50 °C, making it suitable for the process of simultaneous saccharification and fermentation [15]. Recombinant O. polymorpha strains expressing amylolytic and xylanolytic enzymes grow on starch and xylan, respectively. They also ferment these polymers to ethanol [16]. Unfortunately, the efficiency of xylose alcoholic fermentation by wild-type O. polymorpha strains is very low [17]. However, the efficiency of xylose to ethanol fermentation was significantly improved by a combination of classical selection and novel approaches in metabolic engineering. Interestingly, although it is possible to efficiently express bacterial xylose isomerase in O. polymorpha and the recombinant enzyme shows high specific activity, the ethanol yield remained low [17, 18]. Instead, an increase in ethanol production from xylose was achieved upon overexpression of the engineered xylose reductase [19] or pyruvate decarboxylase [20]. In addition, O. polymorpha strains with substantially improved ethanol production from xylose were obtained by overexpression of the modified XYL1 gene and native XYL2 and XYL3 genes coding for enzymes used by the initial reactions of xylose metabolism [21]. Further increase in ethanol production from xylose was achieved by deletion of the CAT8 gene coding for a putative transcription factor [22]. The best available strains accumulated nearly 12.5 g ethanol/L in xylose medium at 45 °C, which is 20 times greater than the wild-type strain, and yet inferior to recombinant strains of Saccharomyces cerevisiae and Scheffersomyces (Pichia) stipitis (which are mesophilic microorganisms). Further improvement of the high-temperature ethanol fermentation could be achieved by identification of the bottlenecks likely to exist in the xylose conversion to ethanol in the thermotolerant yeast, O. polymorpha.
Xylose metabolism in yeast consists of three parts: conversion to xylulose-5-phosphate, reactions of pentose phosphate pathway, and the glycolysis reactions (Fig. 1) [23]. In this case, the presence of all three parts is strongly confirmed by both biochemical and genetic evidence. It is also assumed that all corresponding enzymes are in the cytosol. However, it has been known for many years that methylotrophic yeast contains peroxisomal transketolase, known also as dihydroxyacetone synthase [24]. This enzyme is involved in the assimilation of formaldehyde during methylotrophic growth and also catalyzes the classical transketolase reaction (Fig. 1) [25]. Most of the peroxisomal proteins are located in peroxisomes due to the Peroxisome Targeting Signal I (PTS1), which represents the evolutionarily conserved amino acid sequence S–K–L [3, 26]. Due to the PTS1 sequence, dihydroxyacetone synthase from O. polymorpha is also located in the peroxisomes of the heterologous system for the non-methylotrophic yeast, Saccharomyces cerevisiae [27]. The newly available complete sequence of O. polymorpha genome (http://genome.jgipsf.org/Hanpo2/Hanpo2.home.html; [28]) has allowed identification of genes presumably encoding peroxisomal transaldolase [29]; as well as ribulose phosphate epimerase (K. Dmytruk, A. Sibirny, unpublished). Peroxisomal transaldolase, designated here as Tal2, contains a classical PTS1 signal S–K–L. Peroxisomal localization of O. polymorpha Tal2 was not directly determined before; however, its ortholog (Tal1-2) was found to be localized in peroxisomes in a closely related methylotrophic species, K. phaffii [12]. Homology in protein sequences between Tal2 O. polymorpha and Tal1-2 K. phaffii is rather high (63% identities, 79% positives) and the Tal2 protein of O. polymorpha also contains PTS1 signal. These data suggest that Tal2 of O. polymorpha is most likely to be a peroxisomal protein. However, direct evidence for peroxisomal localization of Tal2 was absent before this work.
The metabolic pathway of xylose in O. polymorpha. X5P, xylulose 5-phosphate; R5, ribose 5-phosphate; RI5P, ribulose 5-phosphate; GAP, glyceraldehyde 3-phosphate; S7P, sedoheptulose 7-phosphate; Fr6P, fructose 6-phosphate; Er4P, erythrose 4-phosphate; FBP, fructose 1,6-bisphosphate; Genes: XYL1, xylose reductase; XYL2, xylitol dehydrogenase; XYL3, xylulokinase; RPE1, ribulose 5-phosphate epimerase; RKI1, ribose 5-phosphate isomerase; TKL1, transketolase; TAL1, translaldolase; DAS1, dihydroxyacetone synthase (peroxisomal transketolase); TAL2, peroxisomal transaldolase; PDC1, pyruvate decarboxylase; ADH1, alcohol dehydrogenase
Methylotrophic yeasts possess well-developed peroxisomes which could occupy up to 80% of cellular volume during growth on methanol [30]. We hypothesized that peroxisomal enzymes of the pentose phosphate pathway could be important not only for methanol metabolism [12], but also for xylose to ethanol fermentation (Fig. 1). We also decided to test the effect of pex mutations, which block peroxisome biogenesis on xylose growth and ethanol fermentation. We found that the corresponding knockouts in das1, tal2, pex3, or pex6, severely damaged xylose ethanol fermentation but did not affect growth on this sugar. Moreover, defects in expression of TKL1 (cytosolic transketolase) suppressed growth on both xylose and glucose, whereas knockout of TAL1 (cytosolic transaldolase) impaired only xylose growth. However, xylose fermentation was only partially suppressed in conditional TKL1 (pYNR1-TKL1) and knockout TAL1 (tal1Δ) mutants. In line with these observations, overexpression of the genes coding for cytosolic and peroxisomal transketolase and transaldolase (TKL1, TAL1, DAS1, TAL2) had an opposite effect and activated xylose alcoholic fermentation. Finally, simultaneous overexpression of DAS1 and TAL2 in the background of the recently isolated “best ethanol producer from xylose” [22] activated xylose alcoholic fermentation and enabled the construction of further improved ethanol producers from xylose at 45 °C.
Methods
Strains, media, and culture conditions
Ogataea polymorpha cells were grown on YPD (10 g/L yeast extract, 10 g/L peptone, 20 g/L glucose) or mineral medium (6.7 g/L YNB without amino acids, 20 g/L of glucose or xylose, or 10 g/L of methanol) at 37 °C. For the NCYC495 leu1-1 strain, leucine (40 mg/L) was added to the medium. For selection of yeast transformants on YPD 0.1 g/L of nourseothricin, 0.3-0.5 g/L of geneticin, 0.075-0.1 g/L of zeocin, or 0.35 g/L of hygromycin were added. Ethanol fermentation of O. polymorpha strains was tested as described previously [22]. Fermentation experiments were performed in at least triplicate to ensure the results were reproducible. The bars in the figures indicate the ranges of the standard deviation.
Strains pex3Δ and pex6Δ O. polymorpha were kindly provided by Prof. Ida van der Klei, Groningen University, the Netherlands. S. stipitis strains—parental ku80 [31] and pex3∆ mutants were grown on YNB medium supplemented with 40 mg/mL of histidine and 2 g/L glucose or 1 g/L of oleate at 30 °C. Ethanol fermentation of S. stipitis strains was tested (as mentioned above) for O. polymorpha strains under oxygen-limited conditions (100 rpm) at 30 °C.
The E. coli DH5α strain (Φ80dlacZΔM15, recA1, endA1, gyrA96, thi-1, hsdR17(r −K , m +K ), supE44, relA1, deoR, Δ(lacZYA-argF)U169) was used as a host for plasmid propagation. Strain DH5α was grown at 37 °C in LB medium as described previously [32]. Transformed E. coli cells were maintained on a medium containing 100 mg/L of ampicillin.
Molecular biology techniques
Standard cloning techniques were carried out as described [32]. Genomic DNA of O. polymorpha was isolated using the Wizard® Genomic DNA Purification Kit (Promega, Madison, WI, USA). Restriction endonucleases and DNA ligase (Fermentas, Vilnius, Lithuania) were used according to the manufacturer specifications. Plasmid isolation from E. coli was performed with the Wizard® Plus SV Minipreps DNA Purification System (Promega, Madison, WI, USA). DNA fragments were separated on a 0.8% agarose (Fisher Scientific, Fair Lawn, NJ, USA) gel. Isolation of fragments from the gel was carried out with a DNA Gel Extraction Kit (Millipore, Bedford, MA, USA). PCR amplification of the fragments of interest was done with Phusion® High-Fidelity DNA Polymerase (Thermo Scientific, USA) according to the manufacturer’s specifications. PCRs were performed in GeneAmp® PCR System 9700 thermocycler (Applied Biosystems, Foster City, CA, USA). Transformation of the yeasts O. polymorpha and S. stipitis was carried out as described previously [33].
Construction and analysis of das1Δ, tal2Δ, tal1Δ, pYNR1-TKL1 O. polymorpha mutants
Genomic DNA of O. polymorpha NCYC495 leu1-1 strain was used as a template for PCR amplification of 5′ and 3′ non-coding regions of DAS1 using primers OL207/OL208 and OL209/OL210 (Additional file 1). The resulting 5′ DAS1 (926 bp) and 3′ DAS1 (1257 bp) fragments were HindIII/EcoRI or EcoRI/XbaI digested and cloned into HindIII/XbaI-linearized vector pBluescript II KS(−). The resulting recombinant construct was named pLRDAS. Gene zeoR (1132 bp) conferring resistance to zeocin was amplified using vector pPICZB (Thermo Fisher Scientific) as a template and primers Ko64/Ko65. The obtained fragment was EcoRI digested and cloned into EcoRI-linearized plasmid pLRDAS. The constructed plasmid was designated as p∆DAS-Zeo.
The same approach was used for construction of the TAL2 deletion cassette. The 5′ (779 bp) and 3′ (1440 bp) non-coding regions of TAL2 were PCR amplified with primers OL211/OL212 and OL213/OL214. Amplified 5′ and 3′ non-coding regions were double digested with HindIII/EcoRI and EcoRI/BamHI and cloned into pBluescript II KS(−) digested with HindIII/BamHI. Selective marker gene conferring resistance to zeocin was amplified from pPICZB with Ko64/Ko65 and cloned between 5′ and 3′ non-coding regions of TAL2 as EcoRI digested fragment. The resulting plasmid was named p∆TAL-Zeo.
The constructed plasmids were transformed into O. polymorpha NCYC495 leu1-1 recipient strain using an standard electroporation method [33]. Transformants were selected on the solid YPD medium supplemented with 75 mg/L of zeocin after 4 days of incubation. The obtained transformants were examined by PCR using genomic DNA of recombinant strains as a template. Transformants with confirmed deletion of DAS1 and TAL2 were stabilized by altering cultivation in non-selective and selective media and once again examined by PCR. Fragments with predicted size were amplified using pairs of primers homologous to the sequence of selective marker and regions outside from the fragments used for recombination (Ko533/Ko534, Ko557/Ko559 for DAS1 and Ko535/Ko534, Ko557/Ko558 for TAL2) (Additional file 2).
The deletion cassette for isolation of tal1Δ mutant on the background of the wild-type strain was constructed as follows. Genomic DNA of O. polymorpha NCYC495 leu1-1 strain was used as template for isolation of 5′ and 3′ non-coding regions of TAL1 gene by PCR amplifications using primers OK74/OK75 and OK76/OK77. The obtained DNA fragments were fused by overlap PCR using primers OK74/OK77. The resulting fragment (1.8 kb) was BamHI/KpnI digested and cloned into the appropriate sites of pUC57 vector. The hphNT1 gene (1777 bp), conferring resistance to hygromycin, was amplified from plasmid pRS42H [34] as a template and primers Ko446 and Ko450. The resulting plasmid was designated as p∆TAL1-Hygr.
The constructed plasmid was transformed into O. polymorpha NCYC495 recipient strain using the electroporation method given above [33]. Transformants were selected on solid YPD medium supplemented with 0.35 g/L of hygromycin after 4 days of incubation. Obtained transformants were examined by PCR using genomic DNA of recombinant strains as a template. Transformants with confirmed deletion of TAL1 were stabilized by altering cultivation in non-selective and selective media and once again examined by PCR. Fragments with predicted size were amplified using pairs of primers homologous to the sequence of selective marker and regions outside from the fragments used for recombination (OK80/Ko450, Ko446/OK81). Additionally, primers OK99/OK100 for TAL1 ORF amplification were used (Additional file 3).
The conditional knockout mutant tkl1∆ was constructed by replacement of the endogenous promoter of TKL1 gene by regulated YNR1 promoter of nitrate reductase, repressed by ammonium sulfate as nitrogen source. Genomic DNA from O. polymorpha NCYC495 leu1-1 strain was used as a template for PCR amplification of 5′ non-coding regions; and part of the ORF of TKL1 gene using primers OK170/OK171 and OK174/OK175, respectively. The promoter of the YNR1 gene was amplified from genomic DNA from the O. polymorpha NCYC495 leu1-1 strain using primers OK172/OK173. The obtained DNA fragments were fused by overlap PCR using primers OK170 and OK175. The resulting fragment (3.6 kb) was KpnI/SphI digested and cloned into the corresponding sites of the pUC57 vector. Selective marker gene conferring resistance to hygromycin was amplified from plasmid pRS42H with primers Ko446 and Ko450 and cloned in XbaI-linearized plasmid pUC57-YNR1p_TKL1. The resulting plasmid was named pUC57-YNR1p_TKL1_ hphNT1.
The constructed plasmid was transformed into O. polymorpha NCYC495 recipient strain using the same electroporation method [33]. Transformants were selected on the solid YPD medium supplemented with 0.35 g/L of hygromycin after 4 days of incubation.
The correct replacement of TKL1 gene promoter was confirmed by PCR in obtained transformants using primers OK176/OK123 and OK172/OK102 (Additional file 4).
Construction and analysis of O. polymorpha strains with overexpression of DAS1, TAL2, TAL1, and TKL1 genes
The recombinant plasmids, pGLG61/DAS1 and pGLG61/TAL2, bearing the O. polymorpha genes DAS1 and TAL2, respectively, were constructed on the basis of the plasmid, pGLG61 [35].
Genomic DNA from O. polymorpha was used as a template for PCR amplifications of the DAS1 and TAL2 genes. Native promoters from these genes were substituted with a strong constitutive promoter, GAP1, from glyceraldehyde-3-phosphate dehydrogenase (GAP). First, the GAP1 promoter and ORF of the DAS1 gene with terminator sequence were amplified from O. polymorpha genomic DNA using the primers, Ko277/Ko278 and Ko279/Ko280. Then two fragments were fused by overlap PCR using primers, Ko277 and Ko280. The resulting fragment (2.9 kb) was digested with BamHI endonuclease and ligated with BamHI-linearized plasmid, pGLG61. The resulting recombinant construct was named pGLG61/DAS1 (Additional file 5A). At the next step, the GAP1 promoter and ORF of the TAL2 gene with terminator sequence were amplified from O. polymorpha genomic DNA using the primers, Ko405/Ko411 and Ko412/Ko414, respectively. Then two fragments were fused by overlap PCR using the primers, Ko405 and Ko414. The resulting fragment (1.8 kb) was digested with BamHI and BglII endonuclease and ligated with the BamHI/BglII-linearized plasmid, pGLG61. The resulting recombinant plasmid was named pGLG61/TAL2 (Additional file 5A). These plasmids were introduced into the genome of the O. polymorpha NCYC495 leu1-1 strain. Transformants were selected on solid YPD medium supplemented with 0.3–0.5 g/L of geneticin after 5 days of incubation. Selected transformants were stabilized by alternating cultivation in non-selective and selective media and examined by diagnostic PCR using the primers, Кo277/Ko278 or Кo279/Кo280, respectively.
For overexpression of the cytosolic transketolase and transaldolase recombinant plasmids, pTkZr and pTaZr, bearing the O. polymorpha genes (TKL1 and TAL1), respectively, were constructed. The strong constitutive GAP promoter and ORF of the TKL1 with terminator sequence were amplified by PCR from O. polymorpha chromosomal DNA using two pairs of primers, A58/A35 and Ko52/Ko53, respectively. The obtained PCR products were digested with SacI/NotI and then ligated with SacI/NotI-linearized vector pUC57, carrying the zeocin resistance gene as a selective marker (pUC57-Zr). The resulting plasmid was designated as pTkZr. For overexpression of the TAL1 gene, the DNA fragment bearing the GAP1 promoter was fused with the ORF of the TAL1 gene. This was accomplished by overlap PCR using two pairs of primers, K43/Ko77 and Ko76/Ko84. The PCR product was digested with BamHI and then ligated with BamHI-linearized vector, pUC57-Zr, resulting in the recombinant construct, pTaZr (Additional file 5B). The resulting plasmids were used for transformation of O. polymorpha NCYC495 leu1-1 strain. The transformants were selected on solid YPD medium supplemented with 0.1 g/L of zeocin after 3 days of incubation.
For simultaneous overexpression of the DAS1 and TAL2 genes, the plasmid, pUC57/DAS1/TAL2, was constructed. BamHI/PstI-restriction fragment containing GAPpr-TAL2 was isolated from the plasmid, pGLG61/TAL2, and cloned into the BamHI/PstI-linearized vector pUC57. The resulting recombinant construct was named pUC57/TAL2. The BamHI-restriction fragment containing GAPpr-DAS1 was isolated from the plasmid, pGLG61/DAS1, and cloned into the BamHI-linearized and dephosphorylated vector, pUC57/TAL2. The resulting recombinant construct was named pUC57/DAS1/TAL2. Gene natNT2, conferring resistance to nourseothricin, was amplified from the plasmid, pRS41N [33] by PCR using primers, OK42/OK43. The fragment obtained (1.3 kb) was NdeI-linearized and cloned into the appropriate site of pUC57/DAS1/TAL2. The resulting plasmid was named pUC57/DAS1/TAL2/NTC (Additional file 5C). Transformants were selected on solid YPD medium supplemented with 0.1 g/L of nourseothricin after 3 days of incubation. Selected transformants were stabilized by alternating cultivation in non-selective and selective media and examined by diagnostic PCR using the primers, Ko277/Ko278 and Ko279/Ko280, respectively.
Construction and analysis of pex3Δ S. stipitis mutants
Genomic DNA of S. stipitis ku80 strain was used as template PCR amplification of 5′ and 3′ non-coding regions of PEX3 gene using the primers, Ko770/Ko771 and Ko772/Ko773. The resulting 5′PEX3 (1682 bp) fragment was SacI/XbaI digested and cloned into SacI/XbaI-linearized vector pUC57. The resulting plasmid was named pUC57-5′PEX3. As the next step, 3′PEX3 (1499 bp) fragments were XbaI/BamHI digested and cloned into XbaI/BamHI-linearized vector pUC57-5′PEX3. The resulting plasmid was named pUC57-5′-3′PEX3. HIS3 gene (1399 bp) involved in histidine biosynthesis was amplified using vector p∆atg13Sc [36] as a template and primers KB5 and KB6. The obtained fragment was XbaI digested and subcloned into XbaI-linearized plasmid pUC57-5′-3′PEX3. As a result, the recombinant plasmid pUC57-5′-3′PEX3-HIS3 was constructed. This plasmid was PstI-linearized and transformed into S. stipitis ku80 his3-1 recipient strain using electroporation method [33]. Transformants were selected on solid YNB medium supplemented with 40 mg/L of histidine after 5 days of incubation at 30 °C. The obtained transformants were examined by PCR using genomic DNA of recombinant strains as a template. Transformants with confirmed deletion of PEX3 were stabilized by altering cultivation in non-selective and selective media and once again examined by PCR. Fragments with predicted size were amplified using pairs of primers homologous to the sequence of selective marker and regions outside from the fragments used for recombination (Ko774/KB9 and KB10/Ko775) (Additional file 6).
Fluorescence microscopy visualization of peroxisomal localization of Tal2 in O. polymorpha
For constitutive expression of peroxisomal SKL-tagged green fluorescent protein (GFP-SKL) in O. polymorpha, the DNA fragments harboring the GFP-SKL gene and the promoter ScTEF1 were PCR amplified with the primers, Ko799/Ko800, from the plasmid, p416TEF-GFP [37]. The terminator, ScCYC1, was amplified with the primers, Ko801/Ko802, from the genomic DNA of S. cerevisiae BY4742. The backbone plasmid containing KamMX4 selective marker was amplified with primers, Ko803/Ko804, from the plasmid, pCfB2055 [38]. Three PCR fragments were then Gibson assembled to generate the plasmid, pGFP-SLK. The obtained plasmid was digested with NotI and integrated into genome of O. polymorpha NCYC495 leu1-1 strain. Transformants were selected on the solid YPD medium supplemented with 0.3 g/L of geneticin after 4 days of incubation. One of the transformants was used as a recipient strain for localization studies of Tal2 protein. The DNA fragment harboring the gene coding for the red fluorescent protein (RFP) was amplified with the primers, Ko888/Ko889, from the plasmid, pDsRed2 (Clontech). The backbone plasmid containing TAL2 was amplified with the primers, Ko890/Ko891, from the plasmid, pGLG61/TAL2. Two PCR fragments were then Gibson assembled to generate the plasmid pGLG61/TAL2_RFP. This plasmid was introduced into genome of O. polymorpha wild-type strain carrying GFP-SKL. Transformants were selected on solid YNB medium after 5 days of incubation. Selected transformants were stabilized by alternating cultivation in non-selective and selective media and examined by diagnostic PCR using the primers, Ko892/Ko414. The resulting strains were grown at 37 °C in YNB medium with glucose, xylose, or methanol during 24 h; followed by microscopy analysis. Images were captured on a fluorescence microscope (Axio Imager A1; Carl Zeiss MicroImaging, Jena, Germany) coupled to a monochrome digital camera (Axio Cam MRm; Carl Zeiss MicroImaging) and processed using the AxioVision 4.5 (Carl Zeiss MicroImaging) and Adobe Photoshop CC software (Adobe Systems, Mountain View, CA).
Biochemical methods
The enzyme activity was measured directly after the preparation of cell-free extracts. Protein concentration was determined with Folin reagent [39]. The specific activities of total transketolase and transaldolase in cell extracts were determined spectrophotometrically as described before [25, 40].
All assay experiments were repeated at least twice.
Quantitative real-time PCR (qRT-PCR)
Expression of the XYL1, XYL2, XYL3, RPE1, TKL1, PDC1, ADH1, and CYC1 genes was analyzed by real-time PCR. The qRT-PCR was performed by 7500 Fast Real-Time PCR System (The Applied Biosystems, USA) with SG OneStep qRT-PCR kit (EURx Ltd., Gdansk, Poland) using gene-specific pairs of primers, RNA as a template, and ROX reference passive dye according to the manufacturer’s instructions as described previously [22]. The primers pairs used for qRT-PCR are listed in Additional file 1. Sequences of the tested genes were taken from O. polymorpha genome database (Ogataea polymorpha NCYC 495 leu1.1 v2.0-JGI Genome Portal. http://genome.jgipsf.org/Hanpo2/Hanpo2.home.html).
Analyses
The biomass was determined turbidimetrically with a Helios Gamma spectrophotometer (OD, 590 nm; cuvette, 10 mm) with gravimetric calibration. Concentrations of xylose and ethanol from fermentation in medium broth were analyzed by HPLC (PerkinElmer, Series 2000, USA) with an Aminex HPX-87H ion-exchange column (Bio-Rad, Hercules, USA). A mobile phase of 4 mM H2SO4 was used at a flow rate 0.6 mL/min and the column temperature was 30 °C. Alternatively, concentrations of ethanol in the medium were determined using alcohol oxidase/peroxidase-based enzymatic kit “Alcotest” [41]. Experiments were performed at least twice.
Results
Ogataea polymorpha is a methylotrophic yeast and thus it contains a xylulose monophosphate pathway for formaldehyde assimilation, i.e., its conversion to three carbon compound dihydroxyacetone [42]. Work in K. phaffii showed that the key (if not all) enzymes of this pathway are located in peroxisomes [12, 29]. However, the functions of peroxisomal transketolase (dihydroxyacetone synthase), the key enzyme in the xylulose monophosphate pathway for xylose growth and fermentation have not been studied. As was pointed above, genome of O. polymorpha also contains the transaldolase paralog gene (designated here as TAL2), which contains codons for peroxisome targeting signal PTS1 (amino acids SKL). However, localization of this protein was not determined earlier. To study localization of the Tal2 protein, the TAL2 gene was fused with the gene coding for RFP. The vector containing the TAL2-RFP fusion was introduced into the O. polymorpha wild-type strain, which expresses GFP containing the PTS1 signal. The GFP recipient strain we constructed possesses green fluorescent peroxisomes due to the targeting of GFP to this organelle, exactly as was described before [43] (not shown). Transformants of the GFP-expressed strain, which contained the TAL2-RFP fused gene, have been cultivated in the media with one of three carbon sources: glucose, xylose, and methanol. Cell fluorescence was also studied. Cells grown on each carbon source displayed both green and red fluorescence. Zones of green fluorescence corresponding to peroxisomes were the smallest in glucose-grown cells and the largest in methanol-grown cells, as expected. Most importantly, the red fluorescence of transaldolase Tal2 coincided perfectly with the green fluorescence of peroxisomes (Fig. 2). These data show that indeed transaldolase Tal2 containing PTS1 targeting signal is located only in peroxisomes, as expected.
Fluorescent microscopic observation of peroxisomal localization analysis of Tal2. Fluorescence microscopy of O. polymorpha cells of the wild-type strain, which expresses GFP- PTS1 for labeling of peroxisomes and RFP for labeling of Tal2, grown in the liquid YNB medium with glucose (2%), xylose (2%), or methanol (1%) for 24 h
The role of this peroxisomal transaldolase, Tal2; as well as the peroxisomal transketolase, Das1, in xylose metabolism and fermentation (and in this case of Tal2, also in methanol metabolism) was not studied. Furthermore, the roles of the cytosolic transketolase and transaldolase in xylose metabolism and fermentation in O. polymorpha have not been investigated as well. In this study, we have engineered knockout and overexpression strains for each corresponding gene (DAS1, TAL2, TKL1, TAL1) and studied their growth and fermentation on xylose and glucose. Mutants with knockout of genes coding for the peroxisomal transketolase, DAS1, and presumably the peroxisomal transaldolase, TAL2, did not differ from the wild-type strain regarding growth on glucose and xylose. Of note, mutant das1Δ failed to grow on methanol, whereas growth of tal2Δ mutant on methanol was normal (Fig. 3). However, the ability to ferment xylose was severely damaged in tal2Δ and das1Δ mutants (Fig. 4a, b). They also normally fermented glucose (Fig. 4c). The role of peroxisomal transketolase in methanol utilization has been known for many years [30]. Importantly, using O. polymorpha tal2Δ mutant, we did not observe the involvement of peroxisomal transaldolase in methanol metabolism (Fig. 3), unlike what was recently hypothesized for K. pastoris [12].
Ethanol production during xylose alcoholic fermentation of O. polymorpha strains a WT, tal2Δ, tal1Δ, tal1Δ/TAL2; b WT, das1Δ, pYNR1-TKL1, pYNR1-TKL1/DAS1; pYNR1-TKL1/DAS1(-PTS1). Data are shown as mean of three independent experiments. c Ethanol production during glucose alcoholic fermentation of O. polymorpha strains WT, das1Δ and tal2Δ. Data are shown as mean of two independent experiments
Subsequently, we decided to create deletion mutants in the genes coding the cytosolic transketolase and transaldolase enzymes. We found that the isolated tal1Δ mutant, in contrast to tal2Δ mutant, failed to grow on xylose, whereas growth on glucose was normal and growth on methanol was delayed (Fig. 3). Interestingly, despite complete inability to grow on xylose, tal1Δ mutant was still able to produce ethanol from this pentose (Fig. 4a). Next, we decided to test whether or not overexpression of the TAL2 gene coding for peroxisomal transaldolase (under control of strong constitutive promoter, GAP1, for the gene coding for glyceraldehyde-3-phosphate dehydrogenase) could rescue tal1Δ growth on xylose. Indeed, transformants showed a restored ability to grow on xylose (Fig. 3). Moreover, xylose fermentation of the tested transformant was the same as in the wild-type strain (Fig. 4a).
Our multiple attempts to obtain mutants with knockout of the TKL1 gene, encoding cytosolic transketolase were unsuccessful; even upon selection in the presence of aromatic and branched chain amino acids [44]. We speculated that tkl1Δ mutants of O. polymorpha could be lethal. Therefore, we decided to generate a conditional mutant expressing the TKL1 gene under control of strongly inducible promoter and substituted the native TKL1 promoter with that of O. polymorpha YNR1 promoter of nitrate reductase gene, known to be repressed by ammonium and strongly induced by nitrate [45]. The obtained transformants grew (although poorly) on the mineral medium (with ammonium sulfate) and glucose as carbon source. The addition of aromatic and branched amino acids did not affect the growth of isolated transformants in the medium with glucose and ammonium sulfate (not shown). We then confirmed the inducible TKL1 gene regulation under control of YNR1 promoter by qRT-PCR. As expected, it was induced by nitrate and repressed by ammonium ions (Fig. 5).
However, in the medium with ammonium sulfate and xylose, transformants failed to grow at all (Fig. 3). Growth of the transformants on xylose and glucose media with nitrate as nitrogen source was normal (not shown). Thus, cytosolic transketolase is compulsory for xylose metabolism in O. polymorpha. It is interesting to note that growth of pYNR1-TKL1 on methanol was unimpaired in contrast to that of the tal1Δ mutant, which showed growth defects on methanol (Fig. 3). Xylose fermentation of the pYNR1-TKL1 strain was suppressed, but not fully abolished as in the case of das1Δ mutants (Fig. 4b).
We then tried to rescue pYNR1-TKL1 strain’s growth on xylose by overexpression of DAS1. In this case, however, suppression was not complete as growth started after long lag-phase and was delayed (Fig. 3). We also constructed the shortened version of DAS1 gene lacking C-terminal PTS1 motif. Overexpression of this presumably cytosolic Das1 protein more efficiently restored growth of pYNR1-TKL1 mutant in the medium with xylose and ammonium sulfate (Fig. 3). Xylose fermentation of rescue strains pYNR1-TKL1/DAS1 and pYNR1-TKL1/DAS1(-PTS1) is shown in Fig. 4. Like growth, ethanol production was also better rescued by the peroxisomal Das1 than its cytosolic counterpart. Still, ethanol production by both rescued transformants was approximately twofold lower on the second day of fermentation as compared to that of the wild-type strain (Fig. 4). Altogether, we conclude that peroxisomal transketolase and peroxisomal transaldolase are compulsory for xylose alcoholic fermentation, but not for growth on this pentose, whereas their cytosolic counterparts are required for xylose utilization.
Next, we studied xylose growth and fermentation of the mutants defective in peroxisome biogenesis. We used mutants defective in the core membrane peroxisomal protein, Pex3, as well as the AAA-family ATPase, Pex6. The cells of pex3Δ and pex6Δ mutants O. polymorpha do not contain peroxisomes at all or contain only their remnants [3]. We found that growth of pex3Δ and pex6Δ mutants on xylose was normal, whereas xylose fermentation was totally abolished. However, ethanol production from glucose in pex3Δ mutants was close to that in the wild-type strain (Fig. 6). Thus, characteristics of xylose growth and fermentation of O. polymorpha pex3Δ and pex6Δ mutants were like those of das1Δ and tal2Δ mutants.
Ethanol production during a xylose or b glucose fermentation of O. polymorpha strains WT, pex3Δ and pex6Δ. Data are shown as mean of three independent experiments. c Growth of the O. polymorpha strains pex3Δ and pex6Δ on xylose as a carbon source as compared to the wild-type strain (WT). The data represent values of typical single cultivation
Inability of the mutants defective in peroxisome biogenesis to ferment xylose could be a consequence of mis-localization of peroxisomal transketolase and transaldolase into the cytosol. Alternatively, there could be an additional intrinsic requirement of peroxisome for xylose fermentation. To evaluate these possibilities, we decided to isolate peroxisome-deficient mutants in non-methylotrophic xylose-fermenting yeast, S. stipitis, whose genome does not contain genes of presumably peroxisomal transketolase and transaldolase. We created S. stipitis mutants with the PEX3 knockout and they were unable to grow on oleic acid as a sole carbon source (Fig. 7).
Crucially, we found that unlike the O. polymorpha pex3Δ, the mutant of S. stipitis did not differ from the wild-type strain in terms of growth and fermentation of glucose and xylose (Fig. 8). Thus, in the non-methylotrophic yeast, S. stipitis, peroxisomes are not required for xylose fermentation, in contrast to the methylotrophic yeast, O. polymorpha. Possibly, this difference stems from the involvement of peroxisomal transketolase and transaldolase in regulation of xylose fermentation in O. polymorpha. Indeed, in O. polymorpha pex3Δ or pex6Δ mutants, these enzymes are mis-localized to the cytosol, where they presumably cannot fulfil their functions. On the other hand, in S. stipitis, an organism lacking peroxisomal transketolase and transaldolase, xylose fermentation does not require any peroxisomal enzymes.
Based on the data for the requirements of the peroxisomal transketolase (Das1) and the peroxisomal transaldolase (Tal2), we hypothesized that overexpression of DAS1 and/or TAL2 would have beneficial effects on ethanol production from xylose. To test this, we overexpressed each of the mentioned genes separately or together under control of the strong constitutive promoter, GAP. Overexpression of these genes led to an increase in the total activities of the corresponding enzymes, cytosolic and peroxisomal transketolase and transaldolase (Table 1).
Transformants with overexpression of TAL2 doubled their ethanol production from xylose, whereas overexpression of DAS1 led to tripled ethanol production. Moreover, co-overexpression of DAS1 and TAL2 led to fourfold increase in ethanol production from xylose relative to that of the wild-type strain (Fig. 9a).
For comparison, we also overexpressed the genes, TKL1 and TAL1, coding for cytosolic transketolase and transaldolase, respectively. We found that overexpression of these genes also stimulated ethanol production from xylose during 3 days of fermentation (Fig. 9b).
One may assume that Das1 and Tal2 proteins, in addition to their catalytic reactions, also affect the expression of other genes. We tested expression of several genes involved with xylose metabolism and ethanol fermentation (XYL1, XYL2, XYL3, TKL1, TAL1, RPE1, CYC1, FBP1, PCK1, PDC1, ADH1) in the strains with knockout and overexpression conferred by the DAS1 and TAL2 genes. Interestingly, this comparison showed that deletion of DAS1 and TAL2 genes lowered the expression of the XYL1 gene coding for xylose reductase, whereas their overexpression, inversely, activated XYL1 expression (Table 2). This result suggests possible involvement of peroxisomal transketolase and transaldolase in the transcriptional regulation of the xylose reductase (i.e., the enzyme of the initial step of xylose metabolism).
We hypothesized that overexpression of DAS1 and TAL2 could be a useful approach for construction of advanced ethanol producers from xylose under elevated temperatures. To test this, we co-overexpressed the DAS1 and TAL2 genes in the background of the best previously constructed ethanol producer, BEP cat8Δ of O. polymorpha [22]. The resulting strain BEP cat8Δ/DAS1/TAL2 accumulated 29% more ethanol relative to the parental strain BEP cat8Δ during xylose fermentation producing 16.1 g/L of ethanol versus 12.5 g/L for BEP cat8Δ [22]. The BEP cat8Δ/DAS1/TAL2 strain accumulated only trace amounts of xylitol (up to 0.5 g/L) during xylose fermentation.
These transformants did not demonstrate a change in ethanol production in glucose medium (not shown). Transformants with co-overexpression of DAS1 and TAL2 were characterized by increased ethanol production from xylose; however, xylose consumption from the medium was not activated relative to the parental strain (Fig. 10). The resulting strain exhibited a one-third increase in ethanol yield in xylose medium (Table 3) relative to the parental strain.
Discussion
The role of peroxisomes in yeast and fungal glucose metabolism was recently established for relatively limited number of species [8,9,10,11]. However, nothing was known about the role of peroxisomes in the metabolism of the major pentose sugar, xylose. In this work, we have shown the importance of peroxisomal enzymes of PPP in xylose alcoholic fermentation in the native xylose-fermenting yeast, O. polymorpha. It was known for many years that this organism contains peroxisomal transketolase (dihydroxyacetone synthase, Das1) involved in methanol metabolism at the stage of formaldehyde assimilation [24]. Here, we found in the O. polymorpha genome database a gene designated (by us), as TAL2, which contains the PTS1 signal sequence and encodes the peroxisomal transaldolase (Tal2). This protein is located in peroxisomes under cultivation on glucose, xylose, or methanol as carbon sources (Fig. 2). It is interesting that both peroxisomal transketolase and transaldolase are not necessary for growth on xylose as a sole carbon and energy source, in contrast to their cytosolic counterparts, Tkl1 and Tal1, but are required for xylose to ethanol fermentation. Inversely, the knockout of genes coding for cytosolic transketolase, TKL1, and transaldolase, TAL1, totally abolished growth on xylose, while only partially suppressing the fermentation of this sugar. It should be stated that peroxisomal transaldolase is not involved in methanol metabolism in O. polymorpha (Fig. 3). Earlier, the role of peroxisomal transaldolase in methanol metabolism was suggested for K. phaffii [12]; however, such role was not shown directly.
We have also found that overexpression of Das1 and/or Tal2 enhanced ethanol production from xylose (like the effects of Tkl1 and Tal1 overexpression). Importantly, these manipulations specifically affected xylose fermentation, but not that of glucose. A crucial difference between growth and fermentation is that the latter demands limited oxygen supply. It could be that Das1 and Tal2 might be involved in responding to limited oxygen. Reactions catalyzed by transketolase and transaldolase do not involve any oxidoreductive changes; however, it is still possible that further peroxisomal metabolism decreases cell reductive state, which is favorable for xylose (but not glucose) alcoholic fermentation. Alternatively, this result could be explained by the potential involvement of the DAS1 and TAL2 genes in transcriptional regulation of XYL1, coding for the enzyme of the initial step of xylose metabolism and fermentation (Fig. 1; Table 2). Roles of enzymes in the regulation of gene expression in yeasts have been thoroughly demonstrated [46]. The specific mechanisms of Das1 and Tal2 involvements in regulation of XYL1 remain to be elucidated, however. It cannot be excluded that peroxisomes are required for xylose to ethanol fermentations due to the location of the Das1 and Tal2 enzymes in this organelle. Indeed, in S. stipitis, which does not contain peroxisomal transketolase and transaldolase enzymes, peroxisomes are not required for xylose fermentation.
The ability to increase ethanol production in O. polymorpha from xylose after overexpression of peroxisomal transketolase and presumably peroxisomal transaldolase was shown both for the wild-type strain and for earlier constructed advanced ethanol producer from xylose [22]. Co-overexpression of Das1 and Tal2 in the advanced ethanol producer led to the accumulation of 16.0–16.5 g ethanol/L at 45 °C in xylose medium. This titer of ethanol is 30–40 × higher relative to that accumulated by the wild-type strain and one-third higher than in previous best O. polymorpha strain [22]. It is interesting to compare our best strain isolated herein with xylose-fermenting strain isolated in another species of thermotolerant yeasts, Kluyveromyces marxianus [47]. Ethanol yield and the productivity of our best O. polymorpha strain with overexpressed DAS1 and TAL2 at 45 °C are like that described for K. marxianus at 42 °C; however, at 45 °C, K. marxianus showed a drop in the mentioned parameters. Moreover, our best strain of O. polymorpha did not accumulate xylitol during xylose fermentation, whereas K. marxianus accumulated large amounts of this by-product [47]. However, the main drawback of constructed O. polymorpha strain is incomplete xylose consumption under fermentation condition. To address this, we plan to activate xylose uptake and manipulate the genes of glycolysis and of oxidative and non-oxidative branches of pentose phosphate pathway. Indeed, we have found recently that simultaneous overexpression of pyruvate decarboxylase and alcohol dehydrogenase in the wild-type strain of O. polymorpha increased ethanol accumulation from glucose, xylose, and glycerol [14]. Besides, we can expect an increase in ethanol accumulation from xylose after additional overexpression of the genes, TKL1 and TAL1, coding for cytosolic transketolase and transaldolase, respectively.
Conclusions
Xylose to ethanol fermentation in the methylotrophic thermotolerant yeast, Ogataea polymorpha, depends on functional peroxisomal transketolase (Das1) and transaldolase (Tal2), whereas their cytosolic counterparts (Tkl1 and Tal1) are indispensable for growth on this pentose. Defects in peroxisome biogenesis in O. polymorpha (but not in the non-methylotrophic yeast S. stipitis) strongly compromise xylose fermentation. Glucose fermentation does not depend on peroxisomes or peroxisomal and cytosolic transketolases and transaldolases. Co-overexpression of peroxisomal transketolase and transaldolase in a previously isolated, advanced ethanol from xylose producer further increased ethanol accumulation up to 16.1 g/L at 45 °C.
References
van Roermund CW, Waterham HR, Ijlst L, Wanders RJ. Fatty acid metabolism in Saccharomyces cerevisiae. Cell Mol Life Sci. 2003;60:1838–51.
Michels PA, Moyersoen J, Krazy H, Galland N, Herman M, Hannaert V. Peroxisomes, glyoxysomes and glycosomes (review). Mol Membr Biol. 2005;22:133–45.
Sibirny AA. Yeast peroxisomes: structure, functions and biotechnological opportunities. FEMS Yeast Res. 2016;16:fow038.
Magliano P, Flipphi M, Sanglard D, Poirier Y. Characterization of the Aspergillus nidulans biotin biosynthetic gene cluster and use of the bioDA gene as a new transformation marker. Fungal Genet Biol. 2011;48:208–15.
Bartoszewska M, Opaliński Ł, Veenhuis M, van der Klei IJ. The significance of peroxisomes in secondary metabolite biosynthesis in filamentous fungi. Biotechnol Lett. 2011;33:1921–31.
Aksam EB, de Vries B, van der Klei IJ, Kiel JA. Preserving organelle vitality: peroxisomal quality control mechanisms in yeast. FEMS Yeast Res. 2009;9:808–20.
Moyersoen J, Choe J, Fan E, Hol WG, Michels PA. Biogenesis of peroxisomes and glycosomes:trypanosomatid glycosome assembly is a promising new drug target. FEMS Microbiol Rev. 2004;28:603–43.
Stehlik T, Sandrock B, Ast J, Freitag J. Fungal peroxisomes as biosynthetic organelles. Curr Opin Microbiol. 2014;22:8–14.
Idnurm A, Giles SS, Perfect JR, Heitman J. Peroxisome function regulates growth on glucose in the basidiomycete fungus Cryptococcus neoformans. Eukaryot Cell. 2007;6:60–72.
Freitag J, Ast J, Bo M. Cryptic peroxisomal targeting via alternative splicing and stop codon read-through in fungi. Nature. 2012;485:522–5.
Strijbis K, Visser WF, Distel B. Alternative splicing directs dual localization of Candida albicans 6-phosphogluconate dehydrogenase to cytosol and peroxisomes. FEMS Yeast Res. 2012;12:61–8.
Rußmayer H, Buchetics M, Gruber C, Valli M, Grillitsch K, Modarres G, et al. Systems-level organization of yeast methylotrophic lifestyle. BMC Biol. 2015;13:80.
Ryabova OB, Chmil OM, Sibirny AA. Xylose and cellobiose fermentation to ethanol by the thermotolerant methylotrophic yeast Hansenula polymorpha. FEMS Yeast Res. 2003;4:157–64.
Kata I, Semkiv MV, Ruchala J, Dmytruk KV, Sibirny AA. Overexpression of the genes PDC1 and ADH1 activates glycerol conversion to ethanol in the thermotolerant yeast Ogataea (Hansenula) polymorpha. Yeast. 2016;33:471–8.
Ishchuk OP, Voronovsky AY, Abbas CA, Sibirny AA. Construction of Hansenula polymorpha strains with improved thermotolerance. Biotechnol Bioeng. 2009;104:911–9.
Voronovsky AY, Rohulya OV, Abbas CA, Sibirny AA. Development of strains of the thermotolerant yeast Hansenula polymorpha capable of alcoholic fermentation of starch and xylan. Metab Eng. 2009;11:234–42.
Voronovsky AY, Ryabova OB, Verba OV, Ishchuk OP, Dmytruk KV, Sibirny AA. Expression of xylA genes encoding xylose isomerases from Escherichia coli and Streptomyces coelicolor in the methylotrophic yeast Hansenula polymorpha. FEMS Microbiol Lett. 2005;5:1055–62.
Dmytruk OV, Voronovsky AY, Abbas CA, Dmytruk KV, Ishchuk OP, Sibirny AA. Overexpression of bacterial xylose isomerase and yeast host xylulokinase improves xylose alcoholic fermentation in the thermotolerant yeast Hansenula polymorpha. FEMS Yeast Res. 2008;8:165–73.
Dmytruk OV, Dmytruk KV, Abbas CA, Voronovsky AY, Sibirny AA. Engineering of xylose reductase and overexpression of xylitol dehydrogenase and xylulokinase improves xylose alcoholic fermentation in the thermotolerant yeast Hansenula polymorpha. Microb Cell Fact. 2008;7:21.
Ishchuk OP, Voronovsky AY, Stasyk OV, Gayda GZ, Gonchar MV, Abbas CA, Sibirny AA. Overexpression of pyruvate decarboxylase in the yeast Hansenula polymorpha results in increased ethanol yield in high-temperature fermentation of xylose. FEMS Yeast Res. 2008;8:1164–74.
Kurylenko OO, Ruchala J, Hryniv OB, Abbas CA, Dmytruk KV, Sibirny AA. Metabolic engineering and classical selection of the methylotrophic thermotolerant yeast Hansenula polymorpha for improvement of high-temperature xylose alcoholic fermentation. Microb Cell Fact. 2014;13:122.
Ruchala J, Kurylenko OO, Soontorngun N, Dmytruk KV, Sibirny AA. Transcriptional activator Cat8 is involved in regulation of xylose alcoholic fermentation in the thermotolerant yeast Ogataea (Hansenula) polymorpha. Microb Cell Fact. 2017;16:36.
Jeffries T, Jin Y. Metabolic engineering for improved fermentation of pentoses by yeasts. Appl Microbiol Biotechnol. 2004;63:495–509.
Hansen H, Didion T, Thiemann A, Veenhuis M, Roggenkamp R. Targeting sequences of the two major peroxisomal proteins in the methylotrophic yeast Hansenula polymorpha. Mol Gen Genet. 1992;235:269–78.
Waites M, Quayle J. The interrelation between transketolase and dihydroxyacetone synthase activities in the methylotrophic yeast Candida boidinii. J Gen Microbiol. 1981;124:309–16.
Gould SJ, Keller GA, Hosken N, Wilkinson J, Subramani S. A conserved tripeptide sorts proteins to peroxisomes. J Cell Biol. 1989;108:1657–64.
Gödecke A, Veenhuis M, Roggenkamp R, Janowicz ZA, Hollenberg CP. Biosynthesis of the peroxisomal dihydroxyacetone synthase from Hansenula polymorpha in Saccharomyces cerevisiae induces growth but not proliferation of peroxisomes. Curr Genet. 1989;16:13–20.
Riley R, Haridas S, Wolfe KH, Lopes MR, Hittinger CT, Goker M, et al. Comparative genomics of biotechnologically important yeasts. Proc Natl Acad Sci USA. 2016;113(35):9882–7.
Kurylenko O, Ruchala J, Dmytruk K, Sibirny A. New targets for improvement of xylose alcoholic fermentation in the methylotrophic yeast Hansenula polymorpha. In: Sibirny A, Fedorovych D, Gonchar M, Grabek-Lejko D, editors. Living organisms and bioanalytical approaches for detoxification and monitoring of toxic compounds. Rzeszow: University of Rzeszow; 2015. p. 247–57.
van der Klei IJ, Yurimoto H, Sakai Y, Veenhuis M. The significance of peroxisomes in methanol metabolism in methylotrophic yeast. 2006;1763:1453–62.
Maassen N, Freese S, Schruff B, Passoth V, Klinner U. Nonhomologous end joining and homologous recombination DNA repair pathways in integration mutagenesis in the xylose-fermenting yeast Pichia stipitis. FEMS Yeast Res. 2008;8:735–43.
Sambrook J, Fritsch EF, Maniatis T. Molecular cloning: a laboratory manual. 3rd ed. New York: Cold Spring Harb. Lab; 2001.
Faber KN, Haima P, Harder W, Veenhuis M, Ab G. Highly-efficient electrotransformation of the yeast Hansenula polymorpha. Curr Genet. 1994;16:305–10.
Taxis C, Knop M. System of centromeric, episomal, and integrative vectors based on drug resistance markers for Saccharomyces cerevisiae. Biotechniques. 2006;40:73–8.
Sohn J, Choi E, Kang H, Rhee J, Agaphonov M. A dominant selection system designed for copy-number-controlled gene integration in Hansenula polymorpha DL-1. Appl Environ Microbiol. 1999;51:800–7.
Dmytruk K, Ruchala J, Grabek-Lejko D, Puchalski C, Bulbotka N, Sibirny A. Autophagy-related gene ATG13 is involved in control of xylose alcoholic fermentation in the thermotolerant methylotrophic yeast Ogataea polymorpha. FEMS Yeast Res. 2018;18(2):010.
Jensen ED, Ferreira R, Jakočiunas T, Arsovska D, Zhang J, Ding L, et al. Transcriptional reprogramming in yeast using dCas9 and combinatorial gRNA strategies. Microb Cell Fact. 2017;16(1):46.
Ferreira R, Teixeira PG, Gossing M, David F, Siewers V, Nielsen J. Metabolic engineering of Saccharomyces cerevisiae for overproduction of triacylglycerols. Metab Eng Commun. 2018;6:22–7.
Lowry O, Rosebrough NJ, Farr AL, Randall RJ. Protein measurement with the Folin phenol reagent. J Biol Chem. 1951;193:265–75.
Bergmeyer HU, Gawehn K. Methods of enzymatic analysis, vol. 2. London: Academic Press; 1974.
Gonchar M, Maidan M, Pavlishko H, Sibirny A. A new oxidase-peroxidase kit for ethanol assays in alcoholic beverages. Food Technol Biotechnol. 2001;39:37–42.
Veenhuis M, Van Dijken JP, Harder W. The significance of peroxisomes in the metabolism of one-carbon compounds in yeasts. In: Advances in microbial physiology. Cambridge: Academic Press; 1983.
Monosov EZ, Wenzel TJ, Luers GH, Heyman JA, Subramani S. Labeling of peroxisomes with green fluorescent protein in living P-pastoris cells. J Histochem Cytochem. 1996;44:581–9.
Sundström M, Lindqvist Y, Schneidert G, Hellman U, Ronne H. Yeast TKL1 gene encodes a transketolase that is required for efficient glycolysis and biosynthesis of aromatic amino acids. J Biol Chem. 1993;268:24346–52.
Avila J, Prez MD, Brito N, Gonz C, Siverio JM. Cloning and disruption of the YNR1 gene encoding the nitrate reductase apoenzyme of the yeast Hansenula polymorpha. FEBS Lett. 1995;366:137–42.
Santangelo GM. Glucose signaling in Saccharomyces cerevisiae. Microbiol Mol Biol Rev. 2006;70:253–82.
Zhang J, Zhang B, Wang D, Gao X, Sun L. Rapid ethanol production at elevated temperatures by engineered thermotolerant Kluyveromyces marxianus via the NADP(H)-preferring xylose reductase-xylitol dehydrogenase pathway. Metab Eng. 2015;31:140–52.
Authors’ contributions
OOK and JR carried out strains construction, evaluation of enzymes activity, qRT-PCR and fermentation experiments, and co-drafted the manuscript. RVV participated in strain construction and fermentation experiments. OVS commented and approved the manuscript. OVD participated in cloning and strain construction. KVD participated in design of cloning and strain construction, analyzed the date, and co-drafted the manuscript. AAS provided guidance and suggestions for experimental design, and wrote and edited the manuscript. All authors participated in finalizing the manuscript. All authors read and approved the final manuscript.
Acknowledgements
Authors are grateful to Ms. Olena Krasosvka (Institute of Cell Biology, NAS of Ukraine) for participation in some experiments. We thank Dr. Charles Abbas (University of Illinois, Urbana-Champaign, IL, USA) and Anastasia Sybirna (University of Cambridge, UK) for helpful discussion.
Competing interests
The authors declare that they have no competing interests.
Availability of data and materials
All data generated or analyzed during this study are included in this published article and its additional files.
Consent for publication
Not applicable.
Ethics approval and consent to participate
Not applicable.
Funding
This work was supported by grant of Polish National Scientific Center (NCN) Opus UMO-2016/21/B/NZ1/00280, grants of National Academy of Sciences of Ukraine (Grants 5-17, 6-17 and 35-18), and grant of Science and Technology Center in Ukraine (STCU) (Grant 6188).
Publisher’s Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Author information
Authors and Affiliations
Corresponding author
Additional files
Additional file 1.
Primers used in this study.
Additional file 2.
Scheme of DAS1 and TAL2 deletion cassettes (ZeoR – gene conferring resistance to zeocin) and PCR verification of the correct cassette integration into genome of the wild-type strain (das1∆ and tal2∆ – constructed deletion strains; WT – recipient strain NCYC495 leu 1-1).
Additional file 3.
Scheme of TAL1 deletion cassette (hphNT1 – gene conferring resistance to hygromycin) and PCR verification of the correct cassette integration into genome of the wild-type strain (tal1∆–constructed deletion strain; WT – recipient strain NCYC495 leu 1-1).
Additional file 4.
Scheme of TKL1 promoter replacement by YNR1 gene promoter (hphNT1 – gene conferring resistance to hygromycin) and PCR verification of the correct cassette integration into the genome of the wild-type strain (pYNR1-TKL1 – constructed strains with substituted gene promoter; WT – recipient strain NCYC495 leu 1-1).
Additional file 5.
Schemes of plasmids used in this study: pGLG61/DAS1, pGLG61/TAL2, pTkZr, pTaZr. (a) Expression cassettes HpGAPpr-DAS1 and HpGAPpr-TAL2 are shown as gray and white boxes, respectively. The geneticin resistance gene (APH), linked to the impaired constitutive gene promoter, encoding glyceraldehyde-3-phosphate dehydrogenase (HpGAPpr) and O. polymorpha LEU2 gene are shown as black and light-gray boxes, respectively. The telomeric region (TEL188) as an autonomously replicating sequence is designated with the hatched lines. Origin of replication (ORI) and ampicillin resistance gene (bla) are shown as arrows. (b) Expression cassettes HpGAPpr-TAL1 and HpGAPpr-TKL1 are shown as white and gray boxes, respectively. Zeocin resistance gene (Zr), is shown as a light-gray box. (c) Expression cassettes HpGAPpr-TAL2 and HpGAPpr-DAS1 are shown as gray and white boxes, respectively. Nourseothricin resistance gene (natNT2), is shown as a black box. Restriction sites: RI, EcoRI; Xb, XbaI; PI, PstI; BI, BamHI; KI, KpnI; BII, BglII; SmI, SmaI; Sc, SacI; Sl, SalI, Nd, NdeI.
Additional file 6.
Scheme of PEX3 deletion cassette (HIS3, gene involved in histidine biosynthesis, was used as selective marker) and PCR verification of the correct cassette integration into the genome of the wild-type strain (pex3∆ – constructed deletion strain; WT – recipient strain NCYC495 leu 1-1).
Rights and permissions
Open Access This article is distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution, and reproduction in any medium, provided you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made. The Creative Commons Public Domain Dedication waiver (http://creativecommons.org/publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated.
About this article
Cite this article
Kurylenko, O.O., Ruchala, J., Vasylyshyn, R.V. et al. Peroxisomes and peroxisomal transketolase and transaldolase enzymes are essential for xylose alcoholic fermentation by the methylotrophic thermotolerant yeast, Ogataea (Hansenula) polymorpha. Biotechnol Biofuels 11, 197 (2018). https://doi.org/10.1186/s13068-018-1203-z
Received:
Accepted:
Published:
DOI: https://doi.org/10.1186/s13068-018-1203-z