Abstract
The mechanical and tribological properties of amorphous carbon films have been studied in more detail in recent years because these films (a) can be deposited near room temperature, thus allowing film deposition on common engineering alloys (i.e., aluminum and steel) without altering their mechanical properties, and (b) are smooth and conform to surface roughness of the substrate, thus requiring no post deposition processing. In addition, amorphous carbon films exhibit low unlubricated sliding friction in contact with steel and ceramics which is comparable to that of steel against steel in a lubricated contact. The wear resistance of these films is also better than Ti‐based hard coatings. Further improvement in film tribological properties can be achieved by modifying film chemical composition. Because of these attractive features, amorphous carbon films have been evaluated in several applications including automotive, electronic and biomedical engineering. However, environmental factors such as oxygen and humidity have been found to influence tribological properties significantly. This paper reviews the current understanding of the tribological properties of both hydrogenated and non‐hydrogenated amorphous carbon films, the mechanisms responsible for low friction coefficient and identifies areas that require further research.
Similar content being viewed by others
References
M.A. Tamor, W.C. Vassell and K.R. Carduner, Appl. Phys. Lett. 58(6) (1991) 592.
J. Robertson, Surf. Coat. and Tech. 50 (1990) 185.
J.C. Angus, J.F. Stultz, P.J. Shiller, J.R. MacDonald, M.J. Mirtich and S. Domitz, Thin Solid Films 118 (1984) 311.
J. Franks, K. Enke and A. Richardt, Metals and Materials, Nov. (1990) 695.
X-M. He, W-Z. Li and H-D. Li, Diamond and Related Materials 3 (1994) 1319.
C. Weissmantel, K. Bewilogua, K. Breuer, D. Dietrich, U. Ebersbach, H.-J. Erler, B. Rau and G. Reisse, Thin Solid Films 96 (1982) 31.
E.G. Spencer, P.H. Schmidt, D.C. Jay and F.J. Sansalone, Appl. Phys. Lett. 29 (1976) 118.
J.F. Braza and T.S. Sudershan, Mat. Sci. & Tech. 8(7) (1992) 574.
A. Grill, Wear 168 (1993) 143.
K. Holmberg and A. Matthews, Coatings Tribology, Tribology Series 28 (Elsevier, Amsterdam, 1994) 197.
M.F. Doerner and W.D. Nix, J. Mater. Res. 1(4) (1986) 601.
J.B. Pethica, R. Hutchings and W.C. Oliver, Phil. Mag. A 48(4) (1983) 593.
D.L. Joslin and W.C. Oliver, J. Mater. Res. 5(1) (1990) 123.
X. Jiang, K. Reichelt and B. Stritzker, J. Appl. Phys. 66(12) (1989) 5805.
S.V. Hainsworth, T. Bartlet and T.F. Page, Thin Solid Films 236 (1993) 214.
M.V. Swain and J. Mencik, Thin Solid Films 253 (1994) 204.
A.K. Bhattacharya and W.D. Nix, Int. J. Solids Structures 24(12) (1988) 1287.
E.H.A. Dekempeneer, R. Jacobs, J. Smeets, J. Meneve, L. Eersels, B. Blanpain, J. Roos and D.J. Oostra, Thin Solid Films 217 (1992) 56.
J.W. Zou, K. Reichelt, K. Schmidt and B. Dischler, J. Appl. Phys. 65(10) (1989) 3914.
N. Savvides and T.J. Bell, J. Appl. Phys. 72(7) (1992) 2791.
J.C. Angus and F. Jansen, J. Vac. Sci. Technol. A (6) (1988) 1778.
M. Wang, K. Schmidt and K. Reichelt, J. Mater. Res. 7(3) (1992) 667.
M. Wang, K. Schmidt, K. Reichelt, H. Dimigen and H. Hubsch, Surf. Coat. Tech. 47 (1991) 691.
J.-P. Hirvonen, J. Koskinen, A. Antilla, R. Lappalainen, R.O. Toivanen, E. Arminen and M. Trkula, Wear 141 (1990) 45.
C. Weissmantel, Thin Films from Free Atoms and Particles, ed. K.J. Klabunde (Academic Press, New York, 1985) 153.
R. Lossy, D.L. Pappas, R.A. Roy and J.J. Cuomo, Appl. Phys. Lett. 61(2) (1992) 171.
E. Liu, B. Blanpain, E. Dekempeneer, F. Loffler, J.P. Celis and J.R. Roos, Diamond Films and Technology 4(1) (1994) 37.
J.B. Pethica, P. Koidl, J. Gobrecht and C. Schuler, J. Vac. Sci. Technol. A 3(6) (1985) 2391.
X. Jiang, P. Grunberg, K. Reichelt and B. Stritzker, Surf. Coat. Tech. 47 (1991) 687.
J. Koskinen, J. Appl. Phys. 63(6) (1985) 2094.
X. Jiang, J.W. Zou, K. Reichelt and P. Grunberg, J. Appl. Phys. 66(10) (1989) 4729.
A. Gangopadhyay, P.A. Willermet, W.C. Vassell and M.A. Tamor, Tribology International 30(1) (1997) 9.
A. Grill, V. Patel and B.S. Meyerson, J. Mater. Res. 5(11) (1990) 2531.
A. Gangopadhyay, W.C. Vassell, M.A. Tamor and P.A. Willermet, J. of Tribology 116 (1994) 454.
S.R.P. Silva, A. Kapoor and G.A.J Amaratunga, Surf. Coat. Tech. 73 (1995) 132.
A. Erdemir, M. Switala, R. Wei and P. Wilbur, Surf. Coat. Tech. 50 (1991) 17.
H. Ronkainen, J. Likonen and J. Koskinen, Surf. Coat. Tech. 54/55 (1992) 570.
C. Donnet, M. Belin, J.C. Auge, J.M. Martin, A. Grill and V. Patel, Surf. Coat. Tech. 68/69 (1994) 626.
T-A. Yeh, C-L. Lin, J.M. Sivertson, J.H. Judy and G-L. Chen, IEEE Trans. Magnetics 29(6) (1993) 3939.
V. Palsin, A. Erdemir, L. Yan and E.I. Meltis, Paper presented at the International Conference on Metallurgical Coatings and Thin Films, San Diego, April 1995.
I.I. Aksenov and V.E. Strel'nitskij, Surf. Coat. Tech. 47 (1991) 252.
K. Enke, Thin Solid Films 80 (1981) 227.
J.-P. Hirvonen, J. Koskinen, R. Lappalainen and A. Antilla, Materials Science Forum 52 & 53 (1989) 197.
J.-P. Hirvonen, R. Lappalainen, J. Koskinen, A. Antilla, T.R. Jervis and M. Trkula, J. Mater. Res. 5(11) (1990) 2524.
H. Ronkainen, J. Koskinen, A. Antilla, K. Holmberg and J.-P. Hirvonen, Diamond and Related Materials 1 (1992a) 639.
F.M. Kustas, M.S. Misra, D.F. Shepard and J.F. Froechtenigt, SPIE 1235 Diamond Optics III (1990) 117.
H. Ronkainen, Surf. Coat. Tech. 43/44 (1990) 888.
S.J. Bull, D.S. Rickerby and A. Jain, Surf. Coat. Tech. 41 (1990) 269.
T. Jamal, R. Nimmigada and R.P. Bunshah, Thin Solid Films 73 (1980) 245.
J. Koskinen J.-P. Hirvonen and A. Antilla, Appl. Phys. Lett. 47(9) (1985) 941.
J. Koskinen, A. Antilla and J.-P. Hirvonen, Surf. Coat. Tech. 47 (1991) 180.
K. Miyoshi, R.L.C. Wu and A. Garscadden, Surf. Coat. Tech. 54/55 (1992) 428.
R.L.C. Wu, K. Miyoshi, R. Vuppuladhadium and H.E. Jackson, Surf. Coat. Tech. 54/55 (1992) 576.
G.D. Lempert, Y. Lifshitz, S. Rotter, A.J. Armini and S. Bunker, Nucl. Inst. Methd. in Phys. Res. B80/81 (1993) 1502.
E.I. Meletis, A. Erdemir and G.R. Fenske, Surf. Coat. Tech. 73 (1995) 39.
K. Enke, H. Dimigem and H. Hubsch, Appl. Phys. Lett. 36(4) (1980) 291.
H. Dimigen, H. Hubsch and R. Memming, Appl. Phys. Lett. 5(16) (1987) 1056.
R. Memming, H.J. Tolle and P.E. Wierenga, Thin Solid Films 143 (1986) 31.
K. Enke, Materials Science Forum 52 & 53 (1989) 559.
Y. Kokaku and M. Kitoh, J. Vac. Sci. Tech. A7(3) (1989) 2311.
D.S. Kim, T.E. Fischer and B. Gallois, Surf. Coat. Tech. 49 (1991) 537.
R.H. Savage, J. Appl. Phys. 19(1) (1948) 1.
I.P. Heyward and I.L. Singer, SDIO/IST-ONR Diamond Technology Symposium, Crystal City, Virginia, 1989.
K. Miyoshi, J.J. Pouch and S.A. Alterovitz, Materials Science Forum 52 & 53 (1989) 645.
S. Miyake, S. Takahashi, I. Watanabe and H. Yoshihara, ASLE Trans. 30(1) (1987) 121.
I. Sugimoto and S. Miyake, Appl. Phys. Lett. 56(19) (1990) 1868.
I.I. Aksenov and V.E. Strelnitskij, Surf. Coat. Tech. 47 (1991) 252.
K. Miyoshi, in: Applications of Diamond Films and Related Materials: Third International Conference 1995, NIST special publication 885, eds. A. Feldman, W.A. Yarbrough, M. Yoshikawa and M. Murakawa (1995) p. 393.
H. Dimigen and H. Hubsch, US patent no. 4 525 (1985) 417.
C.P. Klages and R. Memming, Materials Science Forum 52 & 53 (1989) 609.
H. Dimigen, H. Hubsch and R. Memming, Appl. Phys. Lett. 50(16) (1987) 1056.
A.A. Voevodin, C. Rebholz and A. Matthews, Trib. Trans. 38(4) (1995) 829.
K. Oguri and T. Arai, J. Mater. Res. 5(11) (1990) 2567.
K. Oguri and T. Arai, Surf. Coat. Tech. 47 (1991) 710.
J. Meneve, R. Jacobs, L. Eersels, J. Smeets and E. Dekempeneer, Surf. Coat. Tech. 62 (1993) 577.
J. Meneve, E. Dekempeneer and J. Smeets, Diamond Films and Technology 4(1) (1994) 23.
K. Oguri and T. Arai, J. Mater. Res. 7(6) (1992) 1313.
T. Hioki, Y. Itoh, A. Itoh, S. Hibi and J. Kawamoto, Surf. Coat. Tech. 46 (1991) 233.
T. Hioki, S. Noda and A. Isogai, Hyomen Kogaku 12(4) (1991) 227.
C.G. Fountzoulas, T.Z. Kattamis, J.D. Demaree, W.E. Kosik, W. Franzen and J.K. Hirvonen, J. Vac. Sci. Technol. B 12(2) (1994) 977.
S. Miyake, T. Miyamoto and R. Kaneko, Wear 168 (1993) 155.
S. Miyake, R. Kaneko, Y. Kikuya and I. Sugimoto, J. of Tribology 113 (1991) 384.
T. Miyamoto, R. Kaneko and S. Miyake, J. Vac. Sci. Technol. B 9(2) (1991) 1336.
R. Wei, P.J. Wilber, A. Erdemir and F.M. Kustas, Surf. Coat. Tech. 51 (1992) 139.
X-M. He, W-Z. Li and H-D. Li, Mat. Res. Soc. Symp. Proc. 316 (1994) 605.
F.M. Kustas, M.S. Misra, R. Wei and P.J. Wilbur, Trib. Trans. 36(1) (1993) 113.
A. Gangopadhyay, P.A. Willermet, W.C. Vassell and M.A. Tamor, Tribology International 30(1) (1997) 19.
A. Erdemir, F.A. Nichols, X.Z. Pan, R. Wei and P.J. Wilbur, Diamond and Related Materials 3 (1993) 119.
R. Wei, P.J. Wilbur and F.M. Kustas, J. of Tribology 114 (1992) 298.
R. Wei, P.J. Wilbur, M. Liston and G. Lux, Wear 162–164 (1993) 558.
P. Koidl, Ch. Wild, B. Dischler, J. Wagner and M. Ramsteiner, Materials Science Forum 52 & 53 (1989) 41.
A.K. Gangopadhyay, W.C. Vassell, P.A. Willermet and M.A. Tamor, in: Applications of Diamond Films and Related Materials: Third International Conference 1995, eds. A. Feldman, Y. Tzeng, W.A. Yarbrough, M. Yoshikawa and M. Murakawa (1995) p. 703.
K. Iechika, Y. Kokaku, M. Ootake, K. Abe, H. Tani and H. Inaba, IEEE Transactions on Magnetics 30(6) (1994) 4134.
Y. Kokaku, H. Matsumoto, H. Inaba, S. Fujimaki, M. Kitoh and K. Abe, IEEE Transactions 29(6) (1993) 3942.
K.-R. Lee and K.Y. Eun, Thin Films: Stresses and Mechanical Properties V, MRS Proceedings 356, eds. S.P. Baker, C.A. Ross and P.H. Townsend (1995) p. 779.
H. Nakaue, T. Mitani, H. Kurokawa and T. Yonezawa, Thin Solid Films 212 (1992) 240.
Diamond Depositions: Science and Technology, October (1991) 6.
F.M. Kimock and B.J. Knapp, Surf. Coat. Tech. 56 (1993) 273.
S. Kim, W.J. Varhue and D.R. Durham, Trans. NAMRI/SME 18 (1990) 216.
A. Matthews and S.S. Eskildsen, Diamond and Related Materials 3 (1994) 902.
R.S. Butter and A.H. Lettington, in: Applications of Diamond Films and Related Materials: Third International Conference 1995, eds. A. Feldman, Y. Tzeng, W.A. Yarbrough, M. Yoshikawa and M. Murakawa (1995) p. 683.
D.M. Grant, I.R. McColl, M. Golozar and J.V. Wood, Diamond and Related Material 1 (1992) 727.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Gangopadhyay, A. Mechanical and tribological properties of amorphous carbon films. Tribology Letters 5, 25–39 (1998). https://doi.org/10.1023/A:1019152515982
Issue Date:
DOI: https://doi.org/10.1023/A:1019152515982