Abstract
Amide herbicides have been extensively used worldwide and have received substantial attention due to their adverse environmental effects. Here, a novel amidohydrolase gene was identified from a soil metagenomic library using diethyl terephthalate (DET) as a screening substrate. The recombinant enzyme, AmiH52, was heterologously expressed in Escherichia coli and later purified and characterized, with the highest activity occurring at 40 ℃ and pH 8.0. AmiH52 was demonstrated to have both esterase and amidohydrolase activities, which exhibited highly specific activity for p-nitrophenyl butyrate (2669 U/mg) and degrading activity against several amide herbicides. In particular, it displayed the strongest activity against propanil, with a high degradation rate of 84% at 8 h. A GC–MS analysis revealed that propanil was transformed into 3,4-dichloroaniline (3,4-DCA) during this degradation. The molecular interactions and binding stability were then analyzed by molecular docking and molecular dynamics simulation, which revealed that several key amino acid residues, including Tyr164, Trp66, Ala59, Val283, Arg58, His33, His191, and His226, are involved in the specific interactions with propanil. This study provides a function-driven screening method for amide herbicide hydrolase from the metagenomic libraries and a promising propanil-degrading enzyme (AmiH52) for potential applications in environmental remediation.
Similar content being viewed by others
Explore related subjects
Discover the latest articles, news and stories from top researchers in related subjects.Avoid common mistakes on your manuscript.
Introduction
With the continuous refinement and development of agriculture, the global consumption of pesticides has grown significantly from 1990 to 2020 (Statista, 2022). Among these various pesticides, amide herbicides have been used extensively to increase crop yield and farm labor efficiency (Ni et al. 2023; Qi et al. 2020), accounting for the second-largest proportion of herbicides used in agriculture (Wang et al. 2023). Moreover, in 2018 alone, global amide herbicide usage was more than 170,000 t (Ni et al. 2023). Due to this widespread use, mobility, and persistence, amide herbicides have been frequently detected in the soil environment. For example, a range of 0.03–709.37 mg/kg acetochlor was detected in the riparian soils and sediments of northeastern China, and its residual concentration was 54.76 mg/kg for maize land (Li et al. 2018). Furthermore, with the overdose and irrational use of toxic herbicides exceeding the maximum soil retention capacity, the residues diffuse to the surface waters and groundwater, posing a serious threat to food safety and public health (Tan et al. 2020). It is, therefore, necessary to take effective measures to reduce herbicide residue pollution.
Biodegradation has been recognized as the most effective intervention for removing amide herbicide residues in the environment (Huang et al. 2017). Research has suggested that the amide herbicides in the soil can be degraded through microbial catabolism, which is a more efficient degradation method than hydrolysis and photolysis (Sur and Sathiavelu 2022). As a result, many microorganisms have been identified and applied to remove herbicides from natural environments. Several bacterial strains, such as Paracoccus sp. strain M-1 (Jia et al. 2006), Sphingomonas sp. strain DC-6 (Chen et al. 2016), Ochrobactrum sp. strain PP-2 (Zhang et al. 2019), Paracoccus sp. strain FLN-7 (Zhang et al. 2012), and Comamonas strain SWP-3 (Zhang et al. 2020a), have been reported to have the ability to degrade propanil. Microbial strains such as Acinetobacter baumannii DT (Duc et al. 2021), Pseudomonas aeruginosa JD115 (Luo et al. 2015), and Bacillus altitudinis A16 (Kaur and Goyal 2020) have likewise been reported to effectively degrade chloroacetamide herbicides, such as acetochlor. The enzymes reported to contribute to amide herbicide degradation in these bacteria are mainly amidohydrolases or amidases. For instance, two amidohydrolases (PuhA and PuhB) responsible for linuron hydrolysis have been identified from Arthrobacter globiformis D47 (Turnbull et al. 2001) and Mycobacterium brisbanense JK1 (Khurana et al. 2009), respectively. A novel amidase PsaA identified from Bosea sp. was able to convert the herbicide propanil to its metabolite (Zhang et al. 2023). Another novel amidase PamH with broad substrate spectra was identified from Paracoccus sp. M-1 and could degrade a variety of organophosphorus insecticides and amide herbicides, such as phosphamidon, dichlorvos, propanil, acetochlor, and pretilachlor (Shen et al. 2012). Although there is an abundance of bacterial species present in soil, studies have suggested that more than 99% of these bacteria cannot be cultured using traditional laboratory techniques (Pham and Kim 2012). This means that the vast majority of microorganisms in the soil environment remain unexplored, owing to the barriers of bringing microorganisms to in vitro cultivation. To this end, metagenomics, which has emerged as a new field of research developed over the past decade, has proved itself a remarkable technique which is culture-independent, thereby representing a powerful tool for discovering novel biocatalysts from unculturable microorganisms (Schloss and Handelsman 2005). Several novel enzymes with a broad range of applications have been screened from soil metagenomic libraries, such as esterase, protease, cellulase, and amylase (Xing et al. 2012). However, to date, few studies have been published on amidohydrolases or amidases that degrade amide herbicides derived from metagenomic libraries, mainly because of the absence of effective screening methods.
In the current study, a novel amidohydrolase gene (AmiH52) was identified and cloned from a soil metagenomic library. The recombinant enzyme expressed in E. coil BL21 was further purified and biochemically characterized in terms of temperature and pH. The effect of various metal ions, organic solvents, and detergents on the activity of the enzyme AmiH52 was also addressed. Meanwhile, the degradation effect of AmiH52 on different amide herbicides was described in detail. Finally, molecular modeling and docking were performed to preliminarily explain the degradation mechanism of herbicides by AmiH52.
Materials and methods
Chemical reagents
Diethyl terephthalate (DET) and several amide herbicides, including acetochlor, propanil, diuron, carbosulfan, and diflubenzuron, were procured from Shanghai Macklin Biochemical Co., Ltd. A group of p-nitrophenyl esters with different acyl chain lengths (C2-C16) was purchased from Shanghai Yuanye Biological Technology Co., Ltd. Other chemicals and reagents, such as methanol, dimethyl sulfoxide (DMSO), and isopropyl β-D-1-thiogalactopyranoside (IPTG), were obtained from Nanjing Soda Biological Technology Co., Ltd.
Strains, plasmid, and culture conditions
E. coli competent cells (DH5α and BL21 (DE3)) were bought from Nanjing Vazyme Biotech Co., Ltd. Plasmids, including pET-28a and pUC118 vector, were obtained from Miaoling Biotechnology Co., Ltd. (Wuhan, China). Reaction enzymes (restriction endonucleases including Sau3AI, NcoI, HindIII, and T4 ligase) and DNA/protein markers were procured from Takara Bio (Kusatsu, Japan). All bacterial strains were grown in a commonly used Luria–Bertani (LB) broth at appropriate temperatures.
Construction of the metagenomic library
The soil samples were collected from a farmland site in Dalian, Liaoning, China (Latitude—38.5445 N, longitude—121.3609 E). The entire environmental DNA was extracted based on a standard protocol (Brady 2007). The DNA fragments (~ 40 kb) were recovered from the agarose gel after electrophoresis and purified using the electroelution method. The purified DNA fragments were then ligated to the pWEB plasmid, which was further packaged using lambda phage and transfected into E. coli EPI100 for building a metagenomic library using the commercial Cosmid Cloning Kit (purchased from Epicentre Biotechnologies).
Identification and isolation of positive clones
LB agar plate with 100 μg/mL ampicillin and 2.5 mM DET was used for function-driven screening of a soil metagenomic library (1.3 × 105 clones). After the library clones were incubated at 37 ℃ for 24 h, colonies that showed clear halos around them on the agar plate were identified as positive clones and were picked for the next analysis. To further identify the specific hydrolase gene, the plasmids of positive clones were extracted using commercial kits and then partially digested by Sau3AI (Takara, Japan). The resulting 1–5-kb DNA fragments were recovered, subcloned into the pUC118 vector, and transformed into E. coli DH5α. Similarly, the positive subclone was identified according to DET-degrading activity on the LB agar plate and sequenced at Tsingke Biotech Co., Ltd. (Nanjing, China).
Sequence analysis
Open reading frame (ORF) Finder searches were used for ORF identification at the NCBI online website. The amino acid sequence of a complete ORF was then subjected to the BlastP for homology searches. The phylogenetic tree of these aligned sequences was drawn using the MEGA-X software package based on the neighbor-joining method. The predicted molecular weight of a protein was determined by the ExPASy online tool (https://www.expasy.org/). The presence of signal peptide was predicted with the SignalP 5.0 server (https://services.healthtech.dtu.dk/services/SignalP-5.0/).
Cloning
A putative gene of AmiH52 was amplified by PCR using the following primers: amih52-F (5′-CATGCCATGGGCATGGGGCGAAGCGCGGAAG-3′) containing a NcoI recognition site shown in underlined, and amih52-R (5′-CCCAAGCTTAGTAAGGCCCAGCAACGCT-3′) containing a HindIII recognition site shown in underlined. Both the PCR product and pET-28a vector were digested with NcoI and HindIII. The digested DNA fragment was then ligated into a pET-28a using T4 ligase at 16 ℃ for 12 h. The physical map of the recombinant plasmid is shown in Fig. 1. The recombinant plasmid with a C-terminal six-histidine affinity tag was transformed into E. coli BL21 (DE3) competent cells for protein expression.
Protein expression and purification
Bacteria harboring recombinant plasmid were grown at 37 ℃ and 180 rpm. When the cell culture reached an OD600 of 0.6–0.8, IPTG (0.5 mM) was added into the medium to induce the protein expression at 16 ℃ for 24 h. The cultures were then harvested by centrifugation (10,000 g, 4 ℃, 10 min) and re-suspended in 20 mL phosphate buffer saline (PBS) buffer (100 mM, pH 8.0) and disrupted by an ultrasonic homogenizer (SCIENTZ-IID, Ningbo, Zhejiang, China) using an ice bath for 30 min. Next, the recombinant proteins in the crude lysates were purified by Ni–NTA affinity chromatography. Enzyme purity and molecular mass were determined using sodium dodecyl sulfate–polyacrylamide gel electrophoresis (SDS-PAGE). Each protein concentration was measured three times on the NanoDrop 2000c spectrophotometer (Thermo, USA).
Characterization of enzyme
A variety of p-nitrophenyl (pNP) esters having different acyl chain lengths (pNP acetate (C2), pNP butyrate (C4), pNP hexanoate (C6), pNP caprylate (C8), and pNP laurate (C12)) were chosen as substrates to investigate the substrate specificity of AmiH52. The reaction mixture consisted of 50 μL of p-nitrophenyl esters (10 mM), 50 μL of enzyme solution, and 400 μL of Tris–HCl buffer (100 mM, pH 8.0). The activity of the enzyme was determined based on the enzyme catalyzing the substrates to release p-nitrophenol, a chromogenic product whose absorbance can be measured at 405 nm. An international unit (U) for enzyme activity is defined as the amount of enzyme that produces 1 μmol of p-nitrophenol in 1 min.
The optimum temperature of AmiH52 was measured by mixing the appropriate amount of enzyme and substrate (1 mM pNP butyrate) in Tris–HCl buffer (100 mM, pH 8.0) at different temperatures (20–70 ℃). The thermostability of AmiH52 was investigated by pre-incubating the enzyme at 20–70 ℃ for 2 h. The residual activity was subsequently measured at its optimum temperature. To determine the optimum pH, AmiH52 was examined in different pH buffer solutions (pH 3.0 to 10.0) at 40 ℃ for 5 min. Subsequently, the stability of AmiH52 at these pH values was investigated by pre-incubating the enzyme with varied pH range buffers at 4 ℃ for 1 h. The effects of various chemical reagents on the AmiH52 activity were determined by adding various organic solvents (methanol, ethanol, isopropanol, n-butanol, acetone, DMSO, cyclohexane, and acetonitrile, at concentrations of 10% and 30%), metal ions (Na+, Mg2+, Ca2+, Mn2+, Al3+, Co2+, Fe3+, Cu2+, and Zn2+, each at 5 mM), and detergents (CTAB, Tween-80, Triton X-100, SDS, and EDTA, at 1% concentration) to the reaction solution at 40 ℃ for 5 min. The enzyme activities were determined according to the above procedure. In these enzymatic reaction solutions, the activity of the enzyme without any additive was used as a control and set at 100%.
Degradation of amide herbicides
The purified AmiH52 was prepared and stored at 4 ℃ for the degradation assay. The enzyme activity against amide herbicides was determined in 400 μL Tris–HCl buffer (100 mM and pH 8.0) supplemented with 10 μg/mL herbicide substrate (acetochlor, propanil, diuron, carbosulfan, and diflubenzuron) and 200 μL purified enzyme at 40 ℃ for 1 h, 2 h, and 8 h, respectively. A reaction solution without enzyme addition was used as the control group. Three replicates were set up for each group. After the reaction, the enzyme was inactivated by heating for 10 min in a boiling water bath. In each experimental group, 200 μL of supernatant was collected from each vial and passed through a sterile 0.22-μm filter membrane to obtain the final measurement samples, which were then placed in a 4 ℃ refrigerator for temporary storage.
Product analysis
To evaluate the degradation efficiency for each amide herbicide, an LC-20A high-performance liquid chromatography (HPLC) system (Shimadzu, Japan) coupled with a photodiode array detector and an Agilent ZORBAX SB-C18 column (4.6 × 150 mm, 5 µm) was employed to separate compounds in the reaction mixtures. The mobile phase was phase A (pure water) to phase B (acetonitrile) (20:80, v/v), and the flow rate was constant at 0.8 mL/min. The injection volume was 20 µL, and the column temperature was set to 25 ℃.
To further analyze the degradation products, gas chromatography-mass spectrometry (GC–MS) (Thermo Scientific TSQ 9000, USA) was harnessed to determine the individual substances within a sample. The enzyme reaction solutions in the tube were dried using nitrogen for 30 min. Subsequently, 200 μL of HPLC-grade acetonitrile was added to the tube, and the product was dissolved and dispersed in the acetonitrile by vortex shaking for a short time. The samples were passed through a 0.2-μm filter for the next GC–MS analysis. The GC–MS conditions were as follows: the column was an HP-5 column (0.25 μm × 0.25 mm × 30 m); a flow rate was set to 1 mL/min; the injection method was splitless injection GC; the injection port temperature and ion source temperature was 280 and 250 ℃, respectively. The ramp-up procedure of the GC column temperature chamber was as follows: hold at 60 ℃ for 3 min, increase to 200 ℃ at a rate of 15 ℃/min, then increase to 280 ℃ at a rate of 10 ℃/min, and hold at this temperature for 5 min.
Molecular docking
The small molecule’s three-dimensional (3D) structure was obtained from PubChem online database. The 3D structure of AmiH52 was predicted at I-TASSER online website (https://seq2fun.dcmb.med.umich.edu//I-TASSER/). Molecular docking was conducted using the AutoDock Vina program, and PyMoL software was harnessed for 3D visualization of protein complex and analysis of the results in protein structure: the interaction between AmiH52 and amide herbicide.
Molecular dynamics (MD) simulation
Gromacs 2022.3 software was used for molecular dynamics simulation. For small-molecule preprocessing, AmberTools22 was used to add the General AMBER Force Field (GAFF) to small molecules, while Gaussian 16W was used to hydrogenate small molecules and calculate RESP potential. Potential data will be added to the topology file of the molecular dynamics system. The simulation conditions were performed at a static temperature of 300 K and atmospheric pressure (1 bar). Amber99sb-ildn was employed as a force field, water molecules were used as the solvent (Tip3p water model), and the total charge of the simulation system was neutralized by adding an appropriate number of Na+ ions. The simulation system adopts the steepest descent method to minimize the energy and then carries out the isothermal isovolumic ensemble (NVT) equilibrium and isothermal isobaric ensemble (NPT) equilibrium for 100,000 steps, respectively, with the coupling constant of 0.1 ps and the duration of 100 ps. Finally, the free molecular dynamics simulation was carried out. The process consisted of 5,000,000 steps, the step length was 2 fs, and the total duration was 100 ns. After the simulation was completed, the built-in tool of the software was used to analyze the MD trajectory and calculate the root mean square variance (RMSD) of ligand, protein, and complex; root-mean-square fluctuation (RMSF) of AmiH52 residues; the number of hydrogen bonds; and solvent-accessible surface area (SASA) of proteins.
Results
A novel amidohydrolase
After the screening of the soil metagenomic library, a positive clone on the DET-containing agar plate was identified by the presence of a clear halo (Fig. 2a). Further, a sub-cloning library was constructed to obtain the specific hydrolase gene. Similarly, a positive sub-clone was identified and sequenced. The gene sequence of sub-clone SC52 was input into the ORF Finder, showing that there were 29 ORFs, of which ORF17, with a length of 984 bp and consisting of 328 amino acid residues, was the most likely functional motif. The encoding protein was named AmiH52. The amino acid sequence was then subjected to NCBI-BLASTp, and it was found that the homologous proteins of AmiH52 belonged to the amidohydrolase superfamily. It showed the highest similarity of 73.09% with the amidohydrolase (MBK9945108.1) from Kouleothrix sp. and 71.43% similarity with the amidohydrolase superfamily protein (WP_141612206.1) from Litorilinea aerophila. Furthermore, the evolutionary relationship between AmiH52 and its homologous amidohydrolases from varied hosts was analyzed (Fig. 2b). It revealed that AmiH52 was clustered into a clade with amidohydrolase DmhA (AGC74206) from Sphingomonas sp. DC-6 (Chen et al. 2016), histone-like hydrolase PrpH (AEO21835) from Sphingomonas sp. Y57 (Zhang et al. 2011), and α/β hydrolase Amq (YP_001210456) from Arthrobacter nitroguajacolicus Rü61a (Kolkenbrock et al. 2007). However, the similarities between AmiH52 and these functional hydrolases obtained from the NCBI/Swiss-Prot database were quite low (less than 15%) after performing the multiple sequence alignment by CLUSTALW. Therefore, based on sequence analysis and phylogenetic relationship, AmiH52 was judged as a novel amidohydrolase.
ExPASy program analysis revealed that the theoretical molecular mass of AmiH52 was 37.2 kDa, and the isoelectric point was 6.63. SignalP-5.0 analysis suggested that the signal peptide score of AmiH52 was extremely low, implying there is no signal peptide for the AmiH52 sequence. TMHMM-2.0 online server tool showed that there were no transmembrane helices, and the protein sequences of AmiH52 are all located inside the cell membrane; thus, the heterologously expressed protein in E. coli will be released using ultrasonication treatment.
Protein expression
The amide hydrolase AmiH52 was successfully overexpressed in E. coli BL21 (DE3). The protein purity was confirmed by using SDS-PAGE. Figure 3 shows that the protein band on the gel is single and clear, indicating that the recombinant protein is pure. Moreover, the recombinant enzyme has a molecular weight of approximately 37 kDa, which is in agreement with the predicted molecular weight of 37.2 kDa.
Characterization of AmiH52
Given that AmiH52 showed high hydrolytic activity against synthetic ester DET, p-nitrophenyl esters with various lengths of acyl chains were selected to determine the substrate specificity. The recombinant enzyme AmiH52 exhibited the highest hydrolysis activity toward pNP butyrate (C4) (Fig. 4), and the specific enzyme activity reached 186.83 U (2669 U/mg). The hydrolysis activity of pNP esters with side chain length of C2-C8 was generally high; however, the catalytic activity of pNP esters with long side chain (C12) decreased sharply, indicating that the substrate specificity of AmiH52 is broad, and the preference object is esters with short acyl chains rather than esters with long-chain fatty chains, a typical esterase activity.
Furthermore, the recombinant enzyme AmiH52 exhibited the maximum activity at 40 ℃ (Fig. 5a). In the range of 20–70 ℃, the relative enzyme activity was generally higher than 60%. Figure 5b shows that the activity of the enzyme displayed a downward trend with increasing temperature. In the water bath temperature ranging from 20 to 50 ℃, the residual activity of AmiH52 is above 50%, while it decreased sharply when the temperature rises from 50 ℃. For the impact of pH on enzyme activity, AmiH52 exhibited the maximum activity at pH 8.0 (Fig. 5c). The results of the pH stability experiment showed that the AmiH52 displayed relatively high stability in the pH range of 6–8. However, it has less than 10% enzyme activity when the pH is higher than 9.0 and lower than 5.0 (Fig. 5d).
Next, the influence of different metal ions, organic solvents, and detergents on the enzyme activity of AmiH52 was determined. For metal ions, Na+ could slightly enhance the hydrolysis ability of the recombinant enzyme and increase its enzyme activity by 20% (Fig. 6a) when compared to the control group. Mg2+ and Ca2+ had no obvious impact on the enzyme activity of AmiH52. Mn2+, Al3+, Co2+, Fe3+, Cu2+, and Zn2+ inhibited the enzyme activity more and more strongly, but the overall enzyme activity remained above 50%, indicating that AmiH52 had a high tolerance to different metal ions. The effect of different organic solvents on enzyme activity is shown in Fig. 6b. At a low concentration of 10%, ethanol, isopropanol, and acetone could significantly increase the catalytic activity of the AmiH52 by more than 20%. For methanol and acetonitrile, there is little effect on the enzymatic activity. The catalytic activity of the AmiH52 was slightly inhibited by n-butanol and cyclohexane, with the activity reduced by 20 to 40%. When the chemicals were supplied at a high concentration of 30%, no apparent effect of methanol, ethanol, and acetone on the activity of the enzyme was observed, while the other organic reagents significantly reduced the enzyme activity. Among them, n-butanol almost completely inhibited the enzyme activity of the AmiH52. For the effect of different detergents on AmiH52 (Fig. 6c), it was found that EDTA reduced the enzyme activity to 30%, while SDS and Triton X-100 reduced the activity to 60% and 80%, respectively. Tween-80 and CTAB had a weak inhibitory effect on AmiH52, and the relative activity of the enzyme remained above 90%.
Amide herbicide degradation
The degradation of five herbicides (acetochlor, propanil, diuron, carbosulfan, and diflubenzuron) by amidohydrolase AmiH52 with time was studied. As shown in Fig. 7a, the degradation rate of propanil was fast at the initial stage, reaching 60% at 2 h and the highest degradation rate of 84% at 8 h (Fig. 7b). The degradation rate of diuron reached 57% at 2 h and 69% at 8 h (Fig. 7b). Degradation reaction rate of acetochlor was slow at the initial stage of degradation, only 20% at 2 h, but reached 78% at 8 h (Fig. 7b). The degradation rate of carbosulfan and diflubenzuron at 8 h was below 30%.
Given that AmiH52 exhibited the highest degradation activity toward propanil, it was selected for GC–MS analysis. Figure 8 shows that two compounds, including propanil and its product, were identified at the retention time of 21.35 min and 15.45 min, respectively. Based on the mass spectra and library hit, it was found that AmiH52 is able to break the amide bond of propanil to produce 3,4-dichloroaniline (3,4-DCA).
Docking study
The molecular docking method was employed to understand the specific binding modes of propanil in contact with AmiH52. The propanil was docked into the active pocket site of AmiH52 (Fig. 9a). Several amino acid residues were involved in the interaction with propanil (Fig. 9b). In detail, Tyr164 is able to form a conventional hydrogen bond with the N–H of propanil, which is beneficial for the stabilization of the protein complex during the catalytic process. Trp66, Ala59, Val283, Arg58, His33, and His191 can form pi-alkyl/alkyl interactions with propanil. His226 is responsible for the formation of carbon-hydrogen bonds with the amide group of propanil. The novel AmiH52 represented an atypical amidohydrolase, with low sequence similarity to its close homologous protein Amq (YP_001210456.1) containing a typical catalytic triad of S155, E235, and H266. It was hypothesized that His226, as one of the catalytic triads of AmiH52, played an important role in the catalytic hydrolysis of propanil. The catalytic His226 first acted as a base to deprotonate the nucleophile (possibly serine or threonine) to attack the amide bond of propanil in the primary step, which will generate an enzyme intermediate. Then, His226 again acted as a base to deprotonate the water molecule so that it could break the carbonyl group of the intermediate complex to release the product 3,4-DCA. The free catalytic triads will be ready to attack the next substrate molecules.
MD simulation
The binding stability of propanil in complex with AmiH52 was further analyzed based on the 100-ns MD simulation (see the video in SI). Values of the root mean square deviation (RMSD) and root mean square fluctuation (RMSF) were calculated to determine the overall discrepancy of the protein molecule and the individual residue fluctuation during the MD simulation, respectively. The results showed that the RMSD values of the complex and protein increased rapidly during the first 20 ns of the simulation and then gradually leveled off (Fig. 10a). Overall, the RMSD values of all molecules varied within a small range, indicating that the binding between AmiH52 and propanil was stable. The RMSF values of the residues bound to propanil were generally small, while some residues such as D116, D168, P169, L170, R198, and E301 in the nonbound parts exhibited large RMSF values (Fig. 10b), indicating that the binding of propanil has a certain impact on the stability of AmiH52. Moreover, the hydrogen bond numbers between AmiH52 and propanil were calculated (Fig. 10c). The results showed that many hydrogen bonds (numbering from 0 to 3) were formed between protein and small molecules during the whole simulation process, suggesting hydrogen bonds are the key interactions between residues in the protein and some important groups located in the small molecules. Additionally, solvent-accessible surface area (SASA) was determined between proteins and propanil molecules (Fig. 10d). It showed that the SASA value of the protein was large before the protein was combined with the small molecule, but slightly decreased after the combination, indicating that the combination of small molecules was able to reduce the surface area of the protein.
Discussion
Amide herbicide is one of the most extensively used pesticides in the world. Owing to their low degradation rate, chemical stability, and highly water-soluble properties, however, residual amide herbicides gradually accumulate in the soil and water environment, posing a serious threat to the ecosystem (Han et al. 2022; Jolodar et al. 2021). Compared to the physical and chemical methods, biodegradation has been identified as a powerful, green, sustainable, and economical strategy to reduce amide herbicide pollution (Huang et al. 2017). In recent years, several microorganisms with herbicide-degrading capabilities have been identified and isolated from various environmental samples, especially from soil. However, those strains used for herbicide degradation, which were isolated based on traditional laboratory techniques, only account for less than 1% of microbes in the environmental samples. Metagenomics has already opened new avenues of research by providing access to far more microbial diversity in environmental contexts than traditional culturable manners (Handelsman 2004; Rashid and Stingl 2015). Function-driven screening is the preferred method because it is more straightforward, efficient, targeted, and more likely to enable the discovery of new genes with new functions when compared to sequence-based screening (Ngara and Zhang 2018). Selecting an appropriate substrate for function/activity screening is a major consideration. For example, tributyrin is frequently used for screening esterase (Nazarian and Arab 2022; Popovic et al. 2015), while carboxymethyl cellulose is often used for cellulase screening (Islam and Roy 2018). The corresponding clear halos or the color change on the substrate-containing plate has demonstrated that positive clones carry putative hydrolase genes. However, for amide herbicide screening, the positive clones cannot either form clear halos surrounding the colony or produce color change due to their highly water-soluble and structurally stable properties. Hence, the effective screening method for amide herbicide from metagenomic libraries has yet to be fully developed.
In the current study, diethyl terephthalate (DET) was used as a functional screening substrate for amide herbicide-degrading enzymes. DET is the most widely known synthetic ester compound due to its excellent material properties and has been used for the screening of polyethylene terephthalate (PET)–degrading strains (Liu et al. 2018). Interestingly, a novel amidohydrolase AmiH52 (the highest similarity of 73.09% with the amidohydrolase (MBK9945108.1) from Kouleothrix sp.) with strong ester hydrolysis and amide herbicide–degrading activities was identified. This ability is called enzyme promiscuity, playing a crucial role in ancestral strains for adaptation to evolutionary pressure or changing environments (Leveson-Gower et al. 2019). Many enzymes have been identified as promiscuous enzymes including carboxylesterases EstCE1 from a soil metagenome (Elend et al. 2006) and MsAcT from Mycobacterium smegmatis (Godehard et al. 2020), serine hydrolase (CalB) from Candida antarctica (Svedendahl et al. 2005), and C5 methyltransferase isolated from Haemophilus influenza (Cohen et al. 2002). The promiscuous AmiH52, presented in this study, is possibly the first example of amidohydrolase with high esterase activity (2669 U/mg for pNP ester C4). Moreover, it is suggested that we can use some certain ester compounds like DET to screen potential amidohydrolases from the metagenomic libraries.
High-level expression of recombinant proteins in E. coli often leads to the aggregation of the expressed protein and the formation of the inclusion body. Previous studies showed that heterologous expression of amidohydrolase LahB (Zhang et al. 2020b) and amidase Mah (Zhang et al. 2019) in E. coli BL21(DE3) has not been successful mainly because the inclusion bodies formed in the host. To this end, a number of strategies have been applied to increase protein solubility, such as lowing the induction temperature, reducing the inducer concentration and induction time, and promoter replacement (Gutierrez-Gonzalez et al. 2019; Muhlmann et al. 2017). In this study, the expression of recombinant enzyme AmiH 52 was induced by IPTG (0.5 mM) at 16 ℃ for 24 h and successfully overexpressed in E. coli BL21(DE3), thus providing a reference condition for amidohydrolase expression that can be used in future similar studies.
Among various amide herbicides, propanil is produced globally and is ranked among the top 20 pesticides used in agriculture in the USA (Roberts et al. 2009). Until now, a number of amidase/amidohydrolase which contribute to propanil degradation have been identified from a range of microorganisms. For instance, amidase/amidohydrolase AmpA and PamH were obtained from Paracoccus strain, and PrpH and DmhA were isolated from the Sphingomonas genus (Zhang et al. 2019). Most of these enzymes belong to amidases with extremely different substrate spectrums. For example, AmpA could efficiently hydrolyze propanil, dimethoate, chlorpropham, and omethoate, with a Km value of 29.5 µM for propanil (Zhang et al. 2012). PamH showed high activity against propanil, benzeneacetamid, propanamide, benzamide, pyrazinamide, and acetamide. Propenamide is the most suitable substrate for PamH (Shen et al. 2012). AmiH52 also exhibited a broad range of degrading activity against five amide herbicides, including acetochlor, propanil, diuron, carbosulfan, and diflubenzuron. It showed the strongest degradability toward propanil. The degradation rate of propanil reached 60% at 2 h and the highest degradation rate of 84% at 8 h. Furthermore, the degradation product of propanil by AmiH52 was determined as 3,4-dichloroaniline (3,4-DCA), which is consistent with previous studies (Herrera-Gonzalez et al. 2013; Zhang et al. 2011, 2019). In contrast, a mixed culture of four bacterial strains, which were isolated from the sediment slurry, transformed 90% of propanil within 10 days in liquid media (Oanh and Duc 2021). Another study reported that 81% of propanil was degraded after 100 days of incubation in an anaerobic soil environment (Pettigrew et al. 1985). Rafael et al. showed that an Enterobacter cloacae strain obtained from rice field soil was able to eliminate 100% of propanil in 28 days (Roehrs et al. 2012). Consequently, it is obvious that this study demonstrates the huge potential of biocatalyst AmiH52 identified from the metagenome and provides a strong and promising candidate for the remediation of a propanil-polluted environment.
Conclusion
In the present study, a novel amidohydrolase gene was identified and isolated from a soil metagenomic library, which was heterologously expressed in E. coli BL21(DE3). The recombinant enzyme AmiH52 exhibited the highest activity at 40 ℃ and pH 8.0. AmiH52 exhibited both esterase and amidohydrolase activities. It showed the highest hydrolysis activity toward pNP butyrate (C4) (2669 U/mg). Several amide herbicides can be degraded by AmiH52. In particular, it displayed the strongest activity against propanil, with the highest degradation rate of 84% at 8 h. GC–MS analysis suggested that propanil was transformed into 3,4-DCA. The molecular docking study revealed that several key amino acid residues, such as Tyr164, Trp66, Ala59, Val283, Arg58, His33, His191, and His226, are involved in the interactions with propanil. Our MD simulations have revealed that the binding between AmiH52 and propanil was stable. In summary, this study has provided a function-driven screening method for amide herbicide hydrolase from the metagenomic libraries and a promising propanil-degrading amidohydrolase AmiH52 for potential environmental applications.
Data availability
All the data is included in the manuscript. The raw data is available upon a reasonable request.
References
Brady SF (2007) Construction of soil environmental DNA cosmid libraries and screening for clones that produce biologically active small molecules. Nat Protoc 2:1297–1305
Chen Q, Chen K, Ni HY, Zhuang W, Wang HM, Zhu JC, He Q, He J (2016) A novel amidohydrolase (DmhA) from Sphingomonas sp that can hydrolyze the organophosphorus pesticide dimethoate to dimethoate carboxylic acid and methylamine. Biotech Lett 38:703–710
Cohen HM, Tawfik DS, Griffiths AD (2002) Promiscuous methylation of non-canonical DNA sites by HaeIII methyltransferase. Nucleic Acids Res 30:3880–3885
Duc HD, Truc HTT, Nhu NTH, Oanh NT, 2021. Degradation of butachlor and propanil by Pseudomonas sp. strain But2 and Acinetobacter baumannii strain DT (vol 367, fnaa151, 2020) Fems Microbiology Letters 368
Elend C, Schmeisser C, Leggewie C, Babiak P, Carballeira JD, Steele HL, Reymond JL, Jaeger KE, Streit WR (2006) Isolation and biochemical characterization of two novel metagenome-derived esterases. Appl Environ Microbiol 72:3637–3645
Godehard SP, Badenhorst CPS, Muller H, Bornscheuer UT (2020) Protein engineering for enhanced acyltransferase activity, substrate scope, and selectivity of the Mycobacterium smegmatis acyltransferase MsAcT. ACS Catal 10:7552–7562
Gutierrez-Gonzalez M, Farias C, Tello S, Perez-Etcheverry D, Romero A, Zuniga R, Ribeiro CH, Lorenzo-Ferreiro C, Molina MC 2019 Optimization of culture conditions for the expression of three different insoluble proteins in Escherichia coli Scientific Reports 9
Han LX, Liu T, Fang K, Li XX, You XW, Li YQ, Wang XG, Wang J 2022 Indigenous functional microbial communities for the preferential degradation of chloroacetamide herbicide S-enantiomers in soil J Hazard Mater 423
Handelsman J 2004 Metagenomics: application of genomics to uncultured microorganisms. Microbiol Mol Biol Rev 68 669
Herrera-Gonzalez VE, Ruiz-Ordaz N, Galindez-Mayer J, Juarez-Ramirez C, Santoyo-Tepole F, Montiel EM (2013) Biodegradation of the herbicide propanil, and its 3,4-dichloroaniline by-product in a continuously operated biofilm reactor. World J Microbiol Biotechnol 29:467–474
Huang X, He J, Yan X, Hong Q, Chen K, He Q, Zhang L, Liu XW, Chuang SC, Li SP, Jiang JD (2017) Microbial catabolism of chemical herbicides: microbial resources, metabolic pathways and catabolic genes. Pestic Biochem Physiol 143:272–297
Islam F, Roy N (2018) Screening, purification and characterization of cellulase from cellulase producing bacteria in molasses. BMC Res Notes 11:445
Jia KZ, Cui ZL, He J, Guo P, Li SP (2006) Isolation and characterization of a denitrifying monocrotophos-degrading Paracoccus sp M-1. FEMS Microbiol Lett 263:155–162
Jolodar NR, Karimi S, Bouteh E, Balist J, Prosser R 2021 Human health and ecological risk assessment of pesticides from rice production in the Babol Roud River in Northern Iran. Science of the Total Environment 772
Kaur R, Goyal D (2020) Biodegradation of Butachlor by Bacillus altitudinis and Identification of Metabolites. Curr Microbiol 77:2602–2612
Khurana JL, Jackson CJ, Scott C, Pandey G, Horne I, Russell RJ, Herlt A, Easton CJ, Oakeshott JG (2009) Characterization of the phenylurea hydrolases A and B: founding members of a novel amidohydrolase subgroup. Biochem J 418:431–441
Kolkenbrock S, Parschat K, Beermann B, Hinz HJ, Fetzner S (2007) N-acetylanthranilate amidase from Arthrobacter nitroguajacolicus Ru61a, an alpha/beta-hydrolase-fold protein active towards aryl-acylamides and -esters, and properties of its cysteine-deficient variant (vol 188, pg 8430, 2006). J Bacteriol 189:3933–3933
Leveson-Gower RB, Mayer C, Roelfes G (2019) The importance of catalytic promiscuity for enzyme design and evolution. Nat Rev Chem 3:687–705
Li Y, Liu XG, Wu XH, Dong FS, Xu J, Pan XL, Zheng YQ (2018) Effects of biochars on the fate of acetochlor in soil and on its uptake in maize seedling. Environ Pollut 241:710–719
Liu J, Xu G, Dong W, Xu N, Xin F, Ma J, Fang Y, Zhou J, Jiang M (2018) Biodegradation of diethyl terephthalate and polyethylene terephthalate by a novel identified degrader Delftia sp WL-3 and its proposed metabolic pathway. Lett Appl Microbiol 67:254–261
Luo W, Gu QY, Chen WT, Zhu XC, Duan ZB, Yu XB (2015) Biodegradation of Acetochlor by a Newly Isolated Pseudomonas Strain. Appl Biochem Biotechnol 176:636–644
Muhlmann M, Forsten E, Noack S, Buchs J, 2017 Optimizing recombinant protein expression via automated induction profiling in microtiter plates at different temperatures. Microbial Cell Factories 16
Nazarian Z, Arab SS (2022) Discovery of carboxylesterases via metagenomics: Putative enzymes that contribute to chemical kinetic resolution. Process Biochem 121:439–454
Ngara TR, Zhang HJ (2018) Recent Advances in Function-based Metagenomic Screening. Genom Proteom Bioinform 16:405–415
Ni N, Shi RY, Meng J, Guo XY, Shi ML, Zhang XH, Yao S, Nkoh JN, Wang FH, Song Y, Wang N, 2023 Comparative analysis of the sorption behaviors and mechanisms of amide herbicides on biodegradable and nondegradable microplastics derived from agricultural plastic products Environ Pollut 318
Oanh NT, Duc HD (2021) Anaerobic degradation of propanil in soil and sediment using mixed bacterial culture. Curr Microbiol 78:1499–1508
Pettigrew CA, Paynter MJB, Camper ND (1985) Anaerobic microbial degradation of the herbicide propanil. Soil Biol Biochem 17:815–818
Pham VHT, Kim J (2012) Cultivation of unculturable soil bacteria. Trends Biotechnol 30:475–484
Popovic A, Tchigvintsev A, Tran H, Chernikova TN, Golyshina OV, Yakimov MM, Golyshin PN, Yakunin AF 2015 Metagenomics as a tool for enzyme discovery: hydrolytic enzymes from marine-related metagenomes, in: Krogan, N.J., Babu, M. (Eds.), Prokaryotic Systems Biology pp. 1–20
Qi Y, Li JS, Guan X, Yan B, Fu G, He J, Du LS, Zhao CY, Zhang D 2020 Effects of herbicides on non-target plant species diversity and the community composition of fallow fields in northern China Sci Rep 10
Rashid M, Stingl U (2015) Contemporary molecular tools in microbial ecology and their application to advancing biotechnology. Biotechnol Adv 33:1755–1773
Roberts DM, Heilmair R, Buckley NA, Dawson AH, Fahim M, Eddleston M, Eyer P (2009) Clinical outcomes and kinetics of propanil following acute self-poisoning: a prospective case series. BMC Clin Pharmacol 9:3
Roehrs R, Roehrs M, Machado SLD, Zanella R 2012 Biodegradation of herbicide propanil and its subproduct 3,4-dichloroaniline in water (vol 40, pg 958, 2012) Clean-Soil Air Water 40
Schloss PD, Handelsman J, 2005. Metagenomics for studying unculturable microorganisms: cutting the Gordian knot Genome Biology 6
Shen WL, Chen HH, Jia KZ, Ni J, Yan X, Li SP (2012) Cloning and characterization of a novel amidase from Paracoccus sp M-1, showing aryl acylamidase and acyl transferase activities. Appl Microbiol Biotechnol 94:1007–1018
Sur S, Sathiavelu M (2022) A concise overview on pesticide detection and degradation strategies. Environmental Pollutants and Bioavailability 34:112–126
Svedendahl M, Hult K, Berglund P (2005) Fast carbon-carbon bond formation by a promiscuous lipase. J Am Chem Soc 127:17988–17989
Tan HD, Li QF, Zhang HJ, Wu CY, Zhao SQ, Deng X, Li Y, 2020 Pesticide residues in agricultural topsoil from the Hainan tropical riverside basin: determination, distribution, and relationships with planting patterns and surface water. Sci Total Environ 722
Turnbull GA, Ousley M, Walker A, Shaw E, Morgan JAW (2001) Degradation of substituted phenylurea herbicides by Arthrobacter globiformis strain D47 and characterization of a plasmid-associated hydrolase gene, puhA. Appl Environ Microbiol 67:2270–2275
Wang KX, Lv YZ, He M, Tian L, Nie F, Shao ZG, Wang ZS (2023) A quantitative structure-activity relationship approach to determine biotoxicity of amide herbicides for ecotoxicological risk assessment. Arch Environ Contam Toxicol 84:214–226
Xing MN, Zhang XZ, Huang H (2012) Application of metagenomic techniques in mining enzymes from microbial communities for biofuel synthesis. Biotechnol Adv 30:920–929
Zhang J, Sun JQ, Yuan QY, Li C, Yan X, Hong Q, Li SP (2011) Characterization of the propanil biodegradation pathway in Sphingomonas sp Y57 and cloning of the propanil hydrolase gene prpH. J Hazard Mater 196:412–419
Zhang J, Yin JG, Hang BJ, Cai S, He J, Zhou SG, Li SP (2012) Cloning of a novel arylamidase gene from Paracoccus sp strain FLN-7 that hydrolyzes amide pesticides. Appl Environ Microbiol 78:4848–4855
Zhang L, Hu Q, Hang P, Zhou XY, Jiang JD (2019) Characterization of an arylamidase from a newly isolated propanil-transforming strain of Ochrobactrum sp PP-2. Ecotoxicol Environ Saf 167:122–129
Zhang L, Hu Q, Liu B, Li F, Jiang JD (2020b) Characterization of a linuron-specific amidohydrolase from the newly isolated bacterium Sphingobium sp. strain SMB. J Agric Food Chem 68:4335–4345
Zhang L, Hang P, Zhou XY, Dai C, He ZY, Jiang JD 2020a. Mineralization of the herbicide swep by a two-strain consortium and characterization of a new amidase for hydrolyzing swep. Microbial Cell Factories 19
Zhang L, Yao G, Mao ZB, Song M, Zhao RQ, Zhang XC, Chen C, Zhang HJ, Liu Y, Wang GL, Li F, Wu XM 2023. Experimental and computational approaches to characterize a novel amidase that initiates the biodegradation of the herbicide propanil in Bosea sp. P5. Journal of Hazardous Materials 451.
Acknowledgements
We acknowledge Jack Dawson for proofreading.
Funding
This work was supported by a project funded by the Postgraduate Research & Practice Innovation Program of Jiangsu Province (KYCX21_0581), China.
Postgraduate Research & Practice Innovation Program of Jiangsu Province,KYCX21_0581,Shengwei sun
Author information
Authors and Affiliations
Contributions
Shengwei Sun: conceptualization, methodology, formal analysis, software, and writing, original draft. Wanqi Chen: methodology, software, and investigation. Kailin Peng and Xueyingzi Chen: conceptualization and investigation. Jinju Chen: conceptualization, writing, review, and editing.
Corresponding author
Ethics declarations
Ethics approval and consent to participate
Not applicable.
Consent for publication
All the authors have given consent for the publication of the data presented in this manuscript.
Conflict of interest
The authors declare no competing interests.
Additional information
Responsible Editor: Robert Duran
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Supplementary Information
Below is the link to the electronic supplementary material.
Supplementary file2 (MP4 2770 KB)
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Sun, S., Chen, W., Peng, K. et al. Characterization of a novel amidohydrolase with promiscuous esterase activity from a soil metagenomic library and its application in degradation of amide herbicides. Environ Sci Pollut Res 31, 20970–20982 (2024). https://doi.org/10.1007/s11356-024-32362-6
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11356-024-32362-6