Abstract
Glycerol, considered as a waste feedstock resulting from biodiesel production, has received much attention in recent years due to its properties, which offer to recover energy. The aim of this study was to investigate the use of a thermal water vapor plasma for waste (crude) glycerol conversion to synthesis gas, or syngas (H2 + CO). In parallel of crude glycerol, a pure glycerol (99.5%) was used as a reference material in order to compare the concentrations of the formed product gas. A direct current (DC) arc plasma torch stabilized by a mixture of argon/water vapor was utilized for the effective glycerol conversion to hydrogen-rich synthesis gas. It was found that after waste glycerol treatment, the main reaction products were gases with corresponding concentrations of H2 50.7%, CO 23.53%, CO2 11.45%, and CH4 3.82%, and traces of C2H2 and C2H6, which concentrations were below 0.5%. The comparable concentrations of the formed gas products were obtained after pure glycerol conversion—H2 46.4%, CO 26.25%, CO2 11.3%, and CH4 4.7%. The use of thermal water vapor plasma producing synthesis gas is an effective method to recover energy from both crude and pure glycerol. The performance of the glycerol conversion system was defined in terms of the produced gas yield, the carbon conversion efficiency, the cold gas efficiency, and the specific energy requirements.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Albarelli JQ, Santos DT, Holanda MR (2011) Energetic and economic evaluation of waste glycerol cogeneration in Brazil. Braz J Chem Eng 28:691–698. doi:10.1590/S0104-66322011000400014
Anitha M, Kamarudin SK, Kofli NT (2016) The potential of glycerol as a value-added commodity. Chem Eng J 295:119–130. doi:10.1016/j.cej.2016.03.012
Arechederra RL, Minter SD (2009) Complete oxidation of glycerol in an enzymatic biofuel cell. Fuel Cells 9:63–69. doi:10.1002/fuce.200800029
Bosmans A, Vanderreydt I, Geysen D, Helsen L (2013) The crucial role of waste-to-energy technologies in enhanced landfill mining: a technology review. J Clean Prod 55:10–23. doi:10.1016/j.jclepro.2012.05.032
Bueno AV, Oliveira MLM (2013) Glycerol steam reforming in a bench scale continuous flow heat recovery reactor. Int J Hydrogen Energ 38:13991–14001. doi:10.1016/j.ijhydene.2013.08.082
Du C, Li H, Zhang L, Wang J, Huang D, Xiao M, Cai J, Chen Y, Yan H, Xiong Y, Xiong Y (2012) Hydrogen production by steam-oxidative reforming of bio-ethanol assisted by Laval nozzle arc discharge. Int J Hydrogen Energ 37:8318–8329. doi:10.1016/j.ijhydene.2012.02.166
Du C, Huang D, Mo J, Ma D, Wang Q, Mo Z, Ma S (2014) Renewable hydrogen from ethanol by a miniaturized nonthermal arc plasma-catalytic reactor reforming system. Int J Hydrogen Energ 39:9057–9069. doi:10.1016/j.ijhydene.2014.04.041
EU Directive 2009/28/EC of The European Parliament and of The Council of 23 April 2009 on the promotion of the use of energy from renewable sources and amending and subsequently repealing Directives 2001/77/EC and 2003/30/EC, (2009, Official journal of the european union, L 140, 5 June, 16–62
European Biodiesel Board (EBB) (2016) The EU biodiesel industry, Statistics. http://www.ebb-eu.org/stats.php#. Accessed 31 May 2016
Freitas ACD, Guirardello R (2014) Comparison of several glycerol reforming methods for hydrogen and syngas production using Gibbs energy minimization. Int J hydrogen Energ 39:17969–17984. doi:10.1016/j.ijhydene.2014.03.130
Galo A, Pirovano C, Ferrini P, Marelli M, Psaro R, Santangelo S, Faggio G, Dal Santo V (2012) Influence of reaction parameters on the activity of ruthenium based catalysts for glycerol steam reforming. Appl Catal B-Environ 121–122:40–49. doi:10.1016/j.apcatb.2012.03.013
Grigaitienė V, Striūgas N, Snapkauskienė V, Zakarauskas K (2012) Improving syngas production from glycerol using plasma sprayed catalytic coatings. Catal Today 196:75–80. doi:10.1016/j.cattod.2012.02.034
Guo S, Guo L, Cao CH, Yin J, Lu Y, Zhang X (2012) Hydrogen production from glycerol by supercritical water gasification in a continuous flow tubular reactor. Int J hydrogen Energ 37:5559–5568. doi:10.1016/j.ijhydene.2011.12.135
Gutierrez Ortiz FJ, Campanario FJ, Aguilera PG, Ollero P (2015) Hydrogen production from supercritical water reforming of glycerol over Ni/Al2O3–SiO2 catalyst. Energy 84:634–642. doi:10.1016/j.energy.2015.03.046
Huang H, Tang L (2007) Treatment of organic waste using thermal plasma pyrolysis technology. Energ Convers Manage 48:1331–1337. doi:10.1016/j.enconman.2006.08.013
Huang ZY, Xu CH, Meng J, Zheng CF, Xiao HW, Chen J, Zhang YX (2014) Glycerol steam reforming to syngas over Ni-based catalysts on commercial Linde-type 5A zeolite modified by metal oxides. Journal of Environmental Chemical Engineering 2:598–604. doi:10.1016/j.jece.2013.10.015
Jung M, Hart JN, Boensch D, Scott J, Ng YH, Amal R (2016) Hydrogen evolution via glycerol photoreforming over Cu–Pt nanoalloys on TiO. Appl Catal A-Gen 518:221–230. doi:10.1016/j.apcata.2015.10.040
Kim Y, Ferreri VW, Rosocha LA, Anderson GK, Abbate A, Kim KT (2006) Effect of plasma chemistry on activated propane/air flames. IEEE Trans Plasma Sci 34:2532–2536. doi:10.1109/TPS.2006.886088
Kousi K, Chourdakis N, Matralis H, Kontarides D, Papadopoulou C, Verykios X (2016) Glycerol steam reforming over modified Ni-based catalysts. Appl Catal A-Gen 518:129–141. doi:10.1016/j.apcata.2015.11.047
Lin YC (2013) Catalytic valorization of glycerol to hydrogen and syngas. Int J hydrogen Energ 38:2678–2700. doi:10.1016/j.ijhydene.2012.12.079
Liu SK, Lin YC (2014) Generation of syngas through autothermal partial oxidation of glycerol over LaMnO3- and LaNiO3-coated monoliths. Catal Today 237:62–70. doi:10.1016/j.cattod.2013.12.028
Liu Y, Farrauto R, Lawal A (2013) Autothermal reforming of glycerol in a dual layer monolith catalyst. Chem Eng Sci 89:31–39. doi:10.1016/j.ces.2012.11.030
Sato ME, Duarte HA, Vignatti C, Padro CL, Apesteguia CR (2015) Steam reforming of glycerol: hydrogen production optimization. Int J hydrogen Energ 40:6097–6106. doi:10.1016/j.ijhydene.2015.03.043
Sekiguchi H, Mori Y (2003) Steam plasma reforming using microwave discharge. Thin Solid Films 435:44–48. doi:10.1016/S0040-6090(03)00379-1
Siew KW, Lee HC, Gimbum J, Chin SY, Khan MR, Taufiq-Yap YH, Cheng CK (2015) Syngas production from glycerol-dry(CO2) reforming over La-promoted Ni/Al2O3 catalyst. Renew Energ 74:441–447. doi:10.1016/j.renene.2014.08.048
Susanti RF, Dianningrum LW, Yum T, Kim Y, Lee YW, Kim J (2014) High-yield hydrogen production by supercritical water gasification of various feedstocks: alcohols, glucose, glycerol and long-chain alkanes. Chem Eng Res Des 92:1834–1844. doi:10.1016/j.cherd.2014.01.003
Tamošiūnas A, Valatkevičius P, Grigaitienė V, Valinčius V (2014) Production of synthesis gas from propane using thermal water vapor plasma. Int J hydrogen Energ 39:2078–2086. doi:10.1016/j.ijhydene.2013.11.134
Tamošiūnas A, Valatkevičius P, Valinčius V, Levinskas R (2016a) Biomass conversion to hydrogen-rich synthesis fuels using water steam plasma. CR Chim 19:433–440. doi:10.1016/j.crci.2015.12.002
Tamošiūnas A, Valatkevičius P, Grigaitienė V, Valinčius V, Striūgas N (2016b) A cleaner production of synthesis gas from glycerol using thermal water steam plasma. J Clean Prod 130:187–194. doi:10.1016/j.jclepro.2015.11.024
Valliyappan T, Bakshi NN, Dalai AK (2008) Pyrolysis of glycerol for the production of hydrogen or syn gas. Bioresource Technol 99:4476–4483. doi:10.1016/j.biortech.2007.08.069
Wang Y, Fan W, Liu Y, Zeng Z, Hao X, Chang M, Zhang Ch XY, Xiang H, Li Y (2008) Modeling of the Fischer–Tropsch synthesis in slurry bubble column reactors. Chem Eng Process 47:222–228. doi:10.1016/j.cep.2007.02.011
Yoon SJ, Yun YM, Seo MW, Kim YK, Ra HW, Lee JG (2013) Hydrogen and syngas production from glycerol through microwave plasma gasification. Int J Hydrogen Energ 38:14559–14567. doi:10.1016/j.ijhydene.2013.09.001
Zhu X, Hoang T, Lobban LL, Mallinson RG (2009) Plasma reforming of glycerol for synthesis gas production. Chem Commun:2908–2910. doi:10.1039/b823410h
Zhukov MF, Zasypkin IM (2007) Thermal plasma torches: design, characteristics, application. Cambridge International Science Publishing Ltd, Cambridge
Author information
Authors and Affiliations
Corresponding author
Additional information
Responsible editor: Philippe Garrigues
Rights and permissions
About this article
Cite this article
Tamošiūnas, A., Valatkevičius, P., Gimžauskaitė, D. et al. Energy recovery from waste glycerol by utilizing thermal water vapor plasma. Environ Sci Pollut Res 24, 10030–10040 (2017). https://doi.org/10.1007/s11356-016-8097-8
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11356-016-8097-8