Skip to main content
SpringerLink
Log in

Hydrogenation of CO2 on Nickel–Iron Nanoparticles Under Sunlight Irradiation

  • Original Paper
  • Published:
Topics in Catalysis Aims and scope Submit manuscript

Abstract

Nickel–iron oxide nanoparticles were prepared by a simple mixed oxalate precursor decomposition method and used as catalysts for the sunlight-promoted CO2 hydrogenation reaction. The composition of the NiyFe1−yOx materials was designed to cover the entire Ni/Fe ratio range (y = 1, 0.9, 0.75, 0.5, 0.25, 0.1, 0). Characterisation was undertaken by means of elemental analyses, X-ray diffraction and high resolution transmission electron microscopy. The pure nickel material (NiOx) contained crystalline NiO nanoparticles. Upon introducing lower proportions of iron in Ni9FeOx and Ni3FeOx, NiO was the only crystalline phase, along with increasing amounts of amorphous iron oxides. Higher iron contents resulted in the co-existence of NiO and γ-Fe2O3 domains at the nanoscale in NiFeOx, NiFe3Ox and NiFe9Ox, whereas the pure iron material (FeOx) was composed of α-Fe2O3 as the only crystalline phase and a significant fraction of amorphous iron oxides. The hydrogenation of carbon dioxide was tested on the materials under simulated sunlight irradiation, and the activities and selectivities investigated as initial CO2 conversion rates and product distributions, respectively. The introduction of iron was beneficial for the activation of CO2, due to the known ability of this metal for promoting the reverse water–gas shift (rWGS) reaction. On the other hand, it was proven that nickel and iron favoured hydrogenation and chain growth processes, respectively. Moreover, the lack of hydrogenation sites in the pure iron material results in the expected preferential generation of olefins. Results for the entire compositional range draw a clear trend towards the enhanced formation of short-chain alkanes at middle iron contents, most likely owing to the existence of junctions between nickel and iron oxides at the nanoscale, and the related interfaces providing rWGS, chain growth and hydrogenation sites in close vicinity. The resulting hydrocarbon products, presumably produced by the efficient combination of thermal and photonic effects, can be considered as solar fuel replacements for natural gas and liquefied petroleum gases.

Graphical Abstract

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4

Similar content being viewed by others

References

  1. Aresta M, Dibenedetto A, Angelini A (2014) Catalysis for the valorization of exhaust carbon: from CO2 to chemicals, materials, and fuels. Technological use of CO2. Chem Rev 114:1709–1742

    Article  CAS  Google Scholar 

  2. Centi G, Perathoner S (2009) Opportunities and prospects in the chemical recycling of carbon dioxide to fuels. Catal Today 148:191–205

    Article  CAS  Google Scholar 

  3. Porosoff MD, Yan B, Chen JG (2016) Catalytic reduction of CO2 by H2 for synthesis of CO, methanol and hydrocarbons: challenges and opportunities. Energy Environ Sci 9:62–73

    Article  CAS  Google Scholar 

  4. Dorner RW, Hardy DR, Williams FW, Willauer HD (2010) Heterogeneous catalytic CO2 conversion to value-added hydrocarbons. Energy Environ Sci 3:884–890

    Article  CAS  Google Scholar 

  5. Prieto G (2017) Carbon dioxide hydrogenation into higher hydrocarbons and oxygenates: thermodynamic and kinetic bounds and progress with heterogeneous and homogeneous catalysis. ChemSusChem 10:1056–1070

    Article  CAS  Google Scholar 

  6. Wang W, Wang S, Ma X, Gong J (2011) Recent advances in catalytic hydrogenation of carbon dioxide. Chem Soc Rev 40:3703–3727

    Article  CAS  Google Scholar 

  7. Centi G, Quadrelli EA, Perathoner S (2013) Catalysis for CO2 conversion: a key technology for rapid introduction of renewable energy in the value chain of chemical industries. Energy Environ Sci 6:1711–1731

    Article  CAS  Google Scholar 

  8. Balzani V, Credi A, Venturi M (2008) Photochemical conversion of solar energy. ChemSusChem 1:26–58

    Article  CAS  Google Scholar 

  9. Balzani V, Armaroli N (2010) Energy for a sustainable world: from the oil age to a sun-powered future. Wiley, Hoboken

    Google Scholar 

  10. Centi G, Perathoner S (2010) Towards solar fuels from water and CO2. ChemSusChem 3:195–208

    Article  CAS  Google Scholar 

  11. Cook TR, Dogutan DK, Reece SY, Surendranath Y, Teets TS, Nocera DG (2010) Solar energy supply and storage for the legacy and nonlegacy worlds. Chem Rev 110:6474–6502

    Article  CAS  Google Scholar 

  12. Izumi Y (2013) Recent advances in the photocatalytic conversion of carbon dioxide to fuels with water and/or hydrogen using solar energy and beyond. Coord Chem Rev 257:171–186

    Article  CAS  Google Scholar 

  13. Corma A, Garcia H (2013) Photocatalytic reduction of CO2 for fuel production: possibilities and challenges. J Catal 308:168–175

    Article  CAS  Google Scholar 

  14. Puga AV (2016) Light-promoted hydrogenation of carbon dioxide—an overview. Top Catal 59:1268–1278

    Article  CAS  Google Scholar 

  15. Sastre F, Puga AV, Liu L, Corma A, García H (2014) Complete photocatalytic reduction of CO2 to methane by H2 under solar light irradiation. J Am Chem Soc 136:6798–6801

    Article  CAS  Google Scholar 

  16. Meng X, Wang T, Liu L, Ouyang S, Li P, Hu H, Kako T, Iwai H, Tanaka A, Ye J (2014) Photothermal conversion of CO2 into CH4 with H2 over group VIII nanocatalysts: an alternative approach for solar fuel production. Angew Chem Int Ed 53:11478–11482

    Article  CAS  Google Scholar 

  17. Zhang H, Wang T, Wang J, Liu H, Dao TD, Li M, Liu G, Meng X, Chang K, Shi L, Nagao T, Ye J (2016) Surface-plasmon-enhanced photodriven CO2 reduction catalyzed by metal–organic-framework-derived iron nanoparticles encapsulated by ultrathin carbon layers. Adv Mater 28:3703–3710

    Article  CAS  Google Scholar 

  18. Liu L, Puga AV, Cored J, Concepción P, Pérez-Dieste V, García H, Corma A (2018) Sunlight-assisted hydrogenation of CO2 into ethanol and C 2+ hydrocarbons by sodium-promoted Co@C nanocomposites. Appl Catal B 235:186–196

    Article  CAS  Google Scholar 

  19. Li Z, Liu J, Zhao Y, Waterhouse GIN, Chen G, Shi R, Zhang X, Liu X, Wei Y, Wen X-D, Wu L-Z, Tung C-H, Zhang T (2018) Co-based catalysts derived from layered-double-hydroxide nanosheets for the photothermal production of light olefins. Adv Mater 31:1800527

    Article  Google Scholar 

  20. Chen G, Gao R, Zhao Y, Li Z, Waterhouse GIN, Shi R, Zhao J, Zhang M, Shang L, Sheng G, Zhang X, Wen X, Wu L-Z, Tung C-H, Zhang T (2017) Alumina-supported CoFe alloy catalysts derived from layered-double-hydroxide nanosheets for efficient photothermal CO2 hydrogenation to hydrocarbons. Adv Mater 30:1704663

    Article  Google Scholar 

  21. Zhao Y, Zhao B, Liu J, Chen G, Gao R, Yao S, Li M, Zhang Q, Gu L, Xie J, Wen X, Wu L-Z, Tung C-H, Ma D, Zhang T (2016) Oxide-modified nickel photocatalysts for the production of hydrocarbons in visible light. Angew Chem 128:4287–4291

    Article  Google Scholar 

  22. O’Brien PG, Sandhel A, Wood TE, Jelle AA, Hoch LB, Perovic DD, Mims CA, Ozin GA (2014) Photomethanation of gaseous CO2 over Ru/silicon nanowire catalysts with visible and near-infrared photons. Adv Sci 1:1400001

    Article  Google Scholar 

  23. Hoch LB, Wood TE, O’Brien PG, Liao K, Reyes LM, Mims CA, Ozin GA (2014) The rational design of a single-component photocatalyst for gas-phase CO2 reduction using both UV and visible light. Adv Sci 1:1400013

    Article  Google Scholar 

  24. Sun W, Qian C, He L, Ghuman KK, Wong APY, Jia J, Jelle AA, O/‘Brien PG, Reyes LM, Wood TE, Helmy AS, Mims CA, Singh CV, Ozin GA (2016) Heterogeneous reduction of carbon dioxide by hydride-terminated silicon nanocrystals. Nat Commun 7:12553

    Article  CAS  Google Scholar 

  25. Lo C-C, Hung C-H, Yuan C-S, Wu J-F (2007) Photoreduction of carbon dioxide with H2 and H2O over TiO2 and ZrO2 in a circulated photocatalytic reactor. Sol Energy Mater Sol Cells 91:1765–1774

    Article  CAS  Google Scholar 

  26. Cheng Y-H, Nguyen V-H, Chan H-Y, Wu JCS, Wang W-H (2015) Photo-enhanced hydrogenation of CO2 to mimic photosynthesis by CO co-feed in a novel twin reactor. Appl Energy 147:318–324

    Article  CAS  Google Scholar 

  27. Porosoff MD, Chen JG (2013) Trends in the catalytic reduction of CO2 by hydrogen over supported monometallic and bimetallic catalysts. J Catal 301:30–37

    Article  CAS  Google Scholar 

  28. Gao J, Liu Q, Gu F, Liu B, Zhong Z, Su F (2015) Recent advances in methanation catalysts for the production of synthetic natural gas. RSC Adv 5:22759–22776

    Article  CAS  Google Scholar 

  29. Khodakov AY, Chu W, Fongarland P (2007) Advances in the development of novel cobalt Fischer–Tropsch catalysts for synthesis of long-chain hydrocarbons and clean fuels. Chem Rev 107:1692–1744

    Article  CAS  Google Scholar 

  30. Abelló S, Montané D (2011) Exploring iron-based multifunctional catalysts for Fischer–Tropsch synthesis: a review. ChemSusChem 4:1538–1556

    Article  Google Scholar 

  31. de Smit E, Weckhuysen BM (2008) The renaissance of iron-based Fischer–Tropsch synthesis: on the multifaceted catalyst deactivation behaviour. Chem Soc Rev 37:2758–2781

    Article  Google Scholar 

  32. Riedel T, Claeys M, Schulz H, Schaub G, Nam SS, Jun KW, Choi MJ, Kishan G, Lee KW (1999) Comparative study of Fischer–Tropsch synthesis with H2/CO and H2/CO2 syngas using Fe- and Co-based catalysts. Appl Catal A 186:201–213

    Article  CAS  Google Scholar 

  33. Gnanamani MK, Jacobs G, Hamdeh HH, Shafer WD, Liu F, Hopps SD, Thomas GA, Davis BH (2016) Hydrogenation of carbon dioxide over Co–Fe bimetallic catalysts. ACS Catal 6:913–927

    Article  CAS  Google Scholar 

  34. Satthawong R, Koizumi N, Song C, Prasassarakich P (2015) Light olefin synthesis from CO2 hydrogenation over K-promoted Fe–Co bimetallic catalysts. Catal Today 251:34–40

    Article  CAS  Google Scholar 

  35. Li T, Wang H, Yang Y, Xiang H, Li Y (2014) Study on an iron–nickel bimetallic Fischer–Tropsch synthesis catalyst. Fuel Process Technol 118:117–124

    Article  CAS  Google Scholar 

  36. Xu Y, Schoonen MAA (2000) The absolute energy positions of conduction and valence bands of selected semiconducting minerals. Am Miner 85:543–556

    Article  CAS  Google Scholar 

  37. Wang W, Gong J (2011) Methanation of carbon dioxide: an overview. Front Chem Sci Eng 5:2–10

    Article  CAS  Google Scholar 

Download references

Acknowledgements

Financial support from the Spanish Government-MINECO [Ministerio de Economía, Industria y Competitividad, Gobierno de España (ES)] through “Severo Ochoa” (SEV 2016-0683) is acknowledged. AVP also thanks the Spanish Government (Agencia Estatal de Investigación) [Ministerio de Economía, Industria y Competitividad, Gobierno de España (ES)] and the European Union (European Regional Development Fund) for a grant for young researchers (CTQ2015-74138-JIN, AEI/FEDER/UE).

Author information

Authors and Affiliations

  1. Instituto de Tecnología Química (Universitat Politècnica de València – Consejo Superior de Investigaciones Científicas), Av. de los Naranjos s/n, 46022, Valencia, Spain

    Alberto V. Puga & Avelino Corma

Authors
  1. Alberto V. Puga
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Avelino Corma
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding authors

Correspondence to Alberto V. Puga or Avelino Corma.

Electronic supplementary material

Below is the link to the electronic supplementary material.

Supplementary material 1 (DOCX 12490 KB)

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Puga, A.V., Corma, A. Hydrogenation of CO2 on Nickel–Iron Nanoparticles Under Sunlight Irradiation. Top Catal 61, 1810–1819 (2018). https://doi.org/10.1007/s11244-018-1030-2

Download citation

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s11244-018-1030-2

Keywords

Search

Navigation