Skip to main content
SpringerLink
Log in

Extractability and phytotoxicity of heavy metals present in petrochemical industry sludge

  • Original Paper
  • Published:
Clean Technologies and Environmental Policy Aims and scope Submit manuscript

Abstract

Bioavailability of heavy metals present in industrial sludges and their subsequent phytotoxicity are crucial parameters to assess the associated health hazards and suitability for land application. The present study is an effort to determine the extractability of heavy metals present in different phases of the sludges, coming out of two different operations involved in petrochemical industry viz. spent caustic treatment (SCT) and waste water treatment (WWT) following the BCR sequential extraction procedure. The maximum amount of Cd and Cu was found associated with oxidizable phase, whereas Cr and Ni were best recovered in residual fractions of both the sludges. Maximum Pb was recovered in oxidizable and residual phase in the WWT and SCT sludges, respectively. The stabilization treatment undergone by sludges strongly influenced the heavy metal distribution and the phases to which they were associated. The total metal concentration in both the sludges did not exceed the limit set out by the European Legislation and was found as Cd = 0.449, Pb = 3.340, Ni = 6.530, Cr = 21.087, & Cu = 27.129 μg g−1 and Cd = 0.549, Pb = 5.664, Ni = 7.161, Cr = 27.096, & Cu = 35.479 μg g−1 in the SCT and WWT sludges, respectively. Phytotoxicity of the sludges was assessed against the germination index and the relative root and shoot growth. Sludge leachates did not adversely affect the seed germination and the early seedling growth of Mung (Phaseolus mungo) and Gram (Cicer arietinum), indicating that these metals were concentrated in the non-bioavailable fractions of sludges.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2

Similar content being viewed by others

References

  • Achi MM, Uzairu A, Gimba CE, Okunola OJ (2011) Chemical fractionation of heavy metals in soils around the vicinity of automobile mechanic workshops in Kaduna Metropolis, Nigeria. J Environ Chem Ecotoxicol 3(7):184–194

    CAS  Google Scholar 

  • Ahmed AB, Bouhadjera K (2010) Assessment of metals accumulated in Durum wheat (Triticum durum Desf.), pepper (Capsicum annuum) and agricultural soils. Afr J Agric Res 5(20):2795–2800

    Google Scholar 

  • Alloway WH (1968) Agronomic controls over the environmental cycling of trace elements. Adv Agron 20:235–275

    Google Scholar 

  • Alonso E, Callejon M, Jimenez JC, Ternero M (2002) Heavy metal extraction forms in sludge from waste water treatment plants. Chemosphere 47:765–775

    Article  Google Scholar 

  • American Public Health Association [APHA] (2005) Standard methods for the examination of water and wastewater, 21st edn. American Water Works Association, Washington, DC

    Google Scholar 

  • Bose S, Bhattacharyya AK (2008) Heavy metal accumulation in wheat plant grown in soil amended with industrial sludge. Chemosphere 70(7):1264–1272

    Article  CAS  Google Scholar 

  • Bose S, Chandrayan S, Rai V, Bhattacharyya AK, Ramanathan AL (2008) Translocation of metals in pea plants grown on various amendment of electroplating industrial sludge. Bioresour Technol 99(10):4467–4475

    Article  CAS  Google Scholar 

  • Bowen HJM (1979) Environmental chemistry of the elements. Academic Press, New York

    Google Scholar 

  • Corrochano BG, Azcárate A, Gonzalez MR (2011) Heavy metal chemical fractionation and immobilization in lightweight aggregates produced from mining and industrial waste. Int J Environ Sci Tech 8(4):667–676

    Article  CAS  Google Scholar 

  • Da Silva I, Abate G, Lichting J, Masini J (2002) Heavy metal distribution in recent sediments of Tiete-Pinheiros rever system in Sao Paulo state, Brazil. Appl Geochem 17:105–116

    Article  Google Scholar 

  • Fernandez A, Perez-Cid B, Fernandez E (2000) Comparison between sequential extraction procedure and single extraction for metal partitioning in sewage sludge samples. Analyst 125:1353–1357

    Article  Google Scholar 

  • Fuentes A, Llorens M, Saez J, Soler A, Aguilar MI, Ortuno JF, Meseguer VF (2003) Simple and sequential extraction of heavy metals from different sewage sludges. Chemosphere 54:1039–1047

    Article  Google Scholar 

  • Fuentes A, Llorens M, Saez J, Soler A, Aguilar MI, Ortuno JF, Meseguer VF (2004) Phytotoxicity of heavy metals speciation of stabilized sewage sludges. Hazard Mater 143:161–169

    Article  Google Scholar 

  • Fuentes A, Llorens M, Saez J, Soler A, Aguilar MI, Ortuno JF, Meseguer VF (2006) Ecotoxicity, phytotoxicity and extractability of heavy metals from different stabilized sewage sludges. Environ Pollut 143:355–360

    Article  CAS  Google Scholar 

  • Gaber SE, Rizk MS, Yehia MM (2011) Extraction of certain heavy metals from sewage sludge using different types of acids. Biokemistri 23(1):41–48

    Google Scholar 

  • González-Corrochano B, Alonso-Azcárate J, Rodas M, Barrenechea JF, Luque FJ (2011) Microstructure and mineralogy of lightweight aggregates manufactured from mining and industrial wastes. Constr Build Mater 25(8):3591–3602

    Article  Google Scholar 

  • Gothberg A, Greger M, Bengtsson BE (2002) Accumulation of heavy metals in water grown spinach (Ipomoea aquatica) cultivated in the Bangkok region, Thailand. Environ Toxicol Chem 21:19–34

    Google Scholar 

  • Hoekstra NJ, Bosker T, Lantinga EA (2002) Effects of cattle dung from farms with different feeding strategies on germination and initial root growth of cress (Lepidium sativum L.). Agric Ecosys Environ 93:189–196

    Article  Google Scholar 

  • Jamali MK, Tasneem GK, Arain MKJ, Afridi MB, Jalbani HIN, Memon AR, Ansari R, Shah A (2007) The feasibility of using an industrial sewage sludge produce in Pakistan as agricultural fertilizer used for cultivation of Sorghum bicolor L. Arch Agron Soil Sci 53(6):659–671

    Article  Google Scholar 

  • Jamali MK, Kazi TG, Arain MB, Afridi HI, Memon AR, Jalbani N, Shah A (2008) Use of sewage sludge after liming as fertilizer for maize growth. Pedosphere 18(2):203–213

    Article  CAS  Google Scholar 

  • Kabata-Pendias A, Pendias H (2001) Trace elements in soils and plants. CRC Press Inc., Boca Raton

    Google Scholar 

  • Kumar N, Bauddh K, Singh R, Anand K, Barman SC, Singh DP (2009a) Phytotoxicity of trace metals (Cu and Cd) to gram (Cicer aerientinum) and mung (Phasiolus mungo). J Ecophysiol Occup Health 9(2):59–65

    CAS  Google Scholar 

  • Kumar N, Kumar S, Bauddh K, Anand K, Dwivedi N, Singh DP (2009b) Phytotoxicity of industrial effluent to Raphanus sativus L. and Trigonella foenumgracum L. J Ecophysiol Occup Health 9:163–169

    CAS  Google Scholar 

  • Kumar N, Bauddh K, Barman SC, Singh DP (2012) Accumulation of metals in selected macrophytes grown in mixture of drain water and tannery effluent and their phytoremediation potential. J Environ Biol 33:323–327

    Google Scholar 

  • Li C, Xie F, Ma Y, Cai T, Li H, Huang Z, Yuan G (2010) Multiple heavy metals extraction and recovery from hazardous electroplating sludge waste via ultrasonically enhanced two-stage acid leaching. J Hazard Mater 178(1–3):823–833

    Article  CAS  Google Scholar 

  • Majid NM, Islam MM, Riasmi Y (2012) Heavy metal uptake and translocation by Jatropha curcas L. in sawdust sludge contaminated soils. Aust J Crop Sci 6(5):891–898

    CAS  Google Scholar 

  • Mohammed SS, Ayodele JT (2011) Comparison of extraction techniques for the determination of Ni, Cu, Zn and Pb in maize grown soils of Kaduna metropolis, Nigeria. Asian J Agric Sci 3(5):397–400

    Google Scholar 

  • Nair A, Juwarkar AA, Devotta S (2008) Study of speciation of metals in an industrial sludge and evaluation of metal chelators for their removal. J Hazard Mater 152(2):545–553

    Article  CAS  Google Scholar 

  • Odoh R, Agbaji EB, Kagbu JA, Thomas SA (2011) Heavy metal speciation in agricultural farmland in some selected local government areas of Benue state, Nigeria. Arch Appl Sci Res 3(3):560–573

    CAS  Google Scholar 

  • Pueyo M, Rauret G, Luck D, Yli-Halla M, Muntau H, Quevauvilla Ph, Lopez-Sanchez JF (2001) Certification of the extractable contents of Cd, Cr, Cu, Ni, Pb and Zn in a freshwater sediment following a collaboratively tested and optimized three step sequential extraction procedure. J Environ Monit 3–2:243–250

    Article  Google Scholar 

  • Sahu RK, Katiyar S, Yadav AK, Kumar N, Srivastava J (2008) Toxicity assessment of industrial effluent by bioassays. Clean Air Soil Water 36:517–520

    Article  CAS  Google Scholar 

  • Saruhan V, Gul I, Aydin I (2010) The effects of sewage sludge used as fertilizer on agronomic and chemical features of bird’s foot trefoil (Lotus corniculatus L.) and soil pollution. Sci Res Essays 5(17):2567–2573

    Google Scholar 

  • Scancar J, Milacic R, Strazar M, Burica O (2000) Total metal concentration and partitioning of Cd, Cr, Cu, Fe, Ni and Zn in sewage sludge. Sci Total Environ 250:9–19

    Article  CAS  Google Scholar 

  • Singh R, Singh DP, Kumar N, Bhargava SK, Barman SC (2010) Accumulation and translocation of heavy metals in soil and plants from fly ash contaminated area. J Environ Biol 31:421–430

    CAS  Google Scholar 

  • Sophia AC, Swaminathan K (2005) Assessment of the mechanical stability and chemical leachability of immobilized electroplating waste. Chemosphere 58(1):75–82

    Article  CAS  Google Scholar 

  • Tamunobereton-ari I, Omubo-Pepple VB, Tamunobereton-ari NA (2011) Speciation of heavy metals (Cu, Pb, Ni) pollutants and the vulnerability of groundwater resource in Okrika of Rivers state, Nigeria. Am J Sci Ind Res 2(1):69–77

    Google Scholar 

  • Tokalioglu S, Kartal S, Elci L (2000) Determination of heavy metals and thier speciation in lake sediments by flame atomic absorption spectrometry after a four stage sequential extraction procedure. Anal Chim Acta 413:33–40

    Article  CAS  Google Scholar 

  • U.S. Environmental Protection Agency [USEPA] (1992) Toxicity characteristic leaching procedure. Method 1311. USEPA, Washington, DC

    Google Scholar 

  • Walter I, Martinez F, Cala V (2005) Heavy metal speciation and phytotoxic effects of three representative sewage sludges for agricultural uses. Environ Pollut 139:507–514

    Article  Google Scholar 

  • Wong JWC, Li K, Fang M, Su DC (2001) Toxicity evaluation of sewage sludges in Hong Kong. Environ Int 27:373–380

    Article  CAS  Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Department of Environmental Science, Babasaheb Bhimrao Ambedkar University, Lucknow, India

    Narendra Kumar, Kuldeep Bauddh, Sanjeev Kumar, Neetu Dwivedi & D. P. Singh

  2. Environmental Monitoring Division, Indian Institute of Toxicology Research, Lucknow, India

    S. C. Barman

Authors
  1. Narendra Kumar
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Kuldeep Bauddh
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Sanjeev Kumar
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Neetu Dwivedi
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. D. P. Singh
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. S. C. Barman
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Narendra Kumar.

Rights and permissions

Reprints and permissions

About this article

Cite this article

Kumar, N., Bauddh, K., Kumar, S. et al. Extractability and phytotoxicity of heavy metals present in petrochemical industry sludge. Clean Techn Environ Policy 15, 1033–1039 (2013). https://doi.org/10.1007/s10098-012-0559-1

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s10098-012-0559-1

Keywords

Search

Navigation