Abstract
The objective of this research was to understand how carbon loading influences hydrogen (H2) synthesis and metabolic flow patterns in the thermophilic, cellulolytic bacterium, Clostridium thermocellum. C. thermocellum was cultivated in batch cultures with high (5 g L−1) and low (1 g L−1) initial concentrations of α-cellulose at 60°C. The growth rate of C. thermocellum was 22% lower (0.15 h−1) in cultures with low-cellulose concentration compared with cultures with high-cellulose concentrations. Although substrate depletion coincided with the end of log-growth in low-cellulose cultures, the prime reason for growth arrest in high-cellulose cultures was not identified. Ethanol, acetate, and formate were the major soluble end-products with concomitant release of H2 and CO2 under both conditions. Lactate appeared during the late log phase in high-carbon cultures when pH dropped below 6.4 and became the major end-product in stationary phase. During the exponential phase of cell growth, significantly higher yields for H2 and acetate (1.90 ± 0.14 and 1.11 ± 0.04 mol/mol glucose equivalent, respectively) were obtained from low-cellulose cultures compared to those from high-cellulose cultures. The maximum specific rate of H2 production, 6.41 ± 0.13 mmol H2/g dry cell/h, obtained during the exponential phase from low-carbon cultures was about 37% higher than that obtained from high-carbon cultures.
Similar content being viewed by others
References
Bothun GD, Knutson BL, Berberich JA, Strobel HJ, Nokes SE (2004) Metabolic selectivity and growth of Clostridium thermocellum in continuous culture under elevated hydrostatic pressure. Appl Microbiol Biotechnol 65:149–157
Bradford MM (1976) A rapid and sensitive method for the quantitation of microgram quantities of protein utilizing the principle of protein-dye binding. Anal Biochem 72:248–254
Desvaux ME, Guedon E, Petitdemange H (2000) Cellulose catabolism by Clostridium cellulolyticum growing in batch culture on defined medium. Appl Environ Microbiol 66:2461–2470
Felix CR, Ljungdahl LG (1993) The cellulosome: the exocellular organelle of Clostridium. Annu Rev Microbiol 47:791–819
Freier D, Mothershed CP, Wiegel J (1988) Characterization of Clostridium thermocellum JW20. Appl Environ Microbiol 54:204–211
Giallo J, Gaudin C, Belaich JP (1985) Metabolism and solubilization of cellulose by Clostridium cellulolyticum H10. Appl Environ Microbiol 49:1216–1221
Goel HC, Ramachandran KB (1983) Studies on adsorption of cellulose of lignocellulosics. J Ferment Technol 3:281–286
Guedon E, Desvaux M, Payot S, Petitdemange H (1999a) Growth inhibition of Clostridium cellulolyticum by an inefficiently regulated carbon flow. Microbiology 145:1831–1838
Guedon E, Payot S, Desvaux M, Petitdemange H (1999b) Carbon and electron flow in Clostridium cellulolyticum grown in chemostat culture on synthetic medium. J Bacteriol 181:3262–3269
Halliwell G, Philips TM, Halliwell N (1995) Microcrystalline forms of cellulose as substrates for strains of Clostridium thermocellum and cellulase formation. Process Biochem 30:243–250
Islam R, Cicek N, Sparling R, Levin D (2006) Effect of substrate loading on hydrogen production during anaerobic fermentation by Clostridium thermocellum 27405. Appl Microbiol Biotechnol 72:576–583
Johnson MJ, Peterson WH, Fred EB (1931) Oxidation and reduction relations between substrate and products in the acetonebutyl alcohol fermentation. J Biol Chem 91:569–591
Lamed R, Zeikus G (1980) Ethanol production by thermophilic bacteria: relationship between fermentation product yields and catabolic enzyme activities in Clostridium thermocellum and Thermoanerobium brockii. J Bacteriol 144:569–578
Lamed RJ, Lobos JH, Su TM (1988) Effects of stirring and hydrogen on fermentation products of Clostridium thermocellum. Appl Environ Microbiol 54:1216–1221
Lynd LR (1989) Ethanol production from lignocellulosic substrates using thermophilic bacteria: critical evaluation of potential and review. Adv Biochem Eng Biotechnol 38:1–52
Lynd LR, Grethlein HG (1987) Hydrolysis of dilute acid pretreated hardwood and purified microcyrstalline cellulose by cell-free broth from Clostridium thermocellum. Biotechnol Bioeng 29:92–100
Lynd LR, Grethlein HG, Wolkin RH (1989) Fermentation of cellulose substrates in batch and continuous culture by Clostridium thermocellum. Appl Environ Microbiol 55:3131–3139
Lynd LR, Weimer PJ, van Zyl WH, Pretorius IS (2002) Microbial cellulose utilization: fundamentals and biotechnology. Microbiol Mol Biol Rev 66:506–577
Ng TK, Zeikus JG (1982) Differential metabolism of cellobiose and glucose by Clostridium thermocellum and Clostridium thermohydrosulfuricum. J Bacteriol 150(3):1391–1399
Ng TK, Weimer PJ, Zeikus JG (1977) Cellulolytic and physiological properties of Clostridium thermocellum. Arch Microbiol 114:1–7
Ng TK, Ben-Bassat A, Zeikus JG (1981) Ethanol production by thermophilic bacteria: fermentation of cellulosic substrates by cocultures of Clostridium thermocellum and Clostridium thermohydrosulfuricum. Appl Environ Microbiol 41:1337–1343
Patni NJ, Alexander JK (1971a) Utilization of glucose by Clostridium thermocellum: presence of glucokinase and other glycolytic enzymes in cell extracts. J Bacteriol 105:220–225
Patni NJ, Alexander JK (1971b) Catabolism of fructose and mannitol by Clostridium thermocellum: presence of phosphoenolpyruvate:fructose phosphotransferase, fructose-1-phosphate kinase, phosphoenol-pyruvate:mannitol phosphotransferase, and mannitol-1-phosphate dehydrogenase in cell extracts. J Bacteriol 105:226–231
Pauss A, Andre G, Perrier M, Guiot SR JK (1990) Liquid-to-gas mass transfer in anaerobic processes: inevitable transfer limitations of methane and hydrogen in the biomethanation processes. Appl Environ Microbiol 56:1636–1644
Saddler JN, Chan MKH (1982) Optimization of Clostridium thermocellum growth on cellulose and pretreated wood substrates. Eur J Appl Microbiol Biotechnol 16:99–104
Schwarz WH (2001) The cellulosome and cellulose degradation by anaerobic bacteria. Appl Microbiol Biotechnol 56:634–649
Sparling R, Islam R, Cicek N, Carere C, Chow H, Levin D (2006) Formate synthesis by Clostridium thermocellum during anaerobic fermentation. Can J Microbiol 52:681–688
Stevenson DM, Weimer PJ (2005) Expression of 17 genes in Clostridium thermocellum ATCC 27405 during fermentation of cellulose or cellobiose in continuous culture. Appl Environ Microbiol 71:4672–4678
Strobel JH (1995) Growth of thermophilic bacterium Clostridium thermocellum in continuous culture. Curr Microbiol 31:210–214
Sudha Rani K, Swamy MV, Seenayya G (1997) Increased ethanol production by metabolic modulation of cellulose fermentation in Clostridium thermocellum. Biotechnol Lett 8:819–823
Wang DIC, Biocic I, Fang HY, Wang SD (1979) Direct microbiological conversion of cellulosic biomas to ethanol. Proc 3rd Annual Biomass Energy Systems Conf., Golden, Colorado. National Technical Information Service, U.S. Dept. of Commerce, pp 61–67
Wang DIC, Avgerinos GC, Biocic I, Wang SD, Fang HY, Young FE (1983) Ethanol from cellulosic biomass. Philos Trans R Soc Lond B 300:323–333
Weimer PJ, Zeikus G (1977) Fermentation of cellulose and cellobiose by Clostridium thermocellum in the absence and presence of Methanobacterium thermoautotrophicum. Appl Environ Microbiol 33:289–297
Yemm EW, Willis AJ (1954) The estimation of carbohydrates in plant extracts by anthrone. Biochem J 57:508–514
Zertuche L, Zall RR (1982) A study of producing ethanol from cellulose using Clostridium thermocellum. Biotechnol Bioeng 24:57–68
Zhang YHP, Lynd LR (2005) Cellulose utilization by Clostridium thermocellum: bioenergetics and hydrolysis product assimilation. Proc Natl Acad Sci U S A 102:7321–7325
Acknowledgements
This work was supported by funds provided by the Natural Sciences and Engineering Research Council of Canada (NSERC) through a strategic programs grant (STPGP 306944-04), the BIOCAP Canada Foundation, and by the Manitoba Conservation Sustainable Development and Innovation Fund, and the Manitoba Ministry of Agriculture, Food, and Rural Initiatives (MAFRI).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Islam, R., Cicek, N., Sparling, R. et al. Influence of initial cellulose concentration on the carbon flow distribution during batch fermentation by Clostridium thermocellum ATCC 27405. Appl Microbiol Biotechnol 82, 141–148 (2009). https://doi.org/10.1007/s00253-008-1763-0
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00253-008-1763-0