Abstract
Progress toward combining time-resolved experiments with periodic three-dimensional analysis of the evolved microstructural state has been made recently. In situ electron microscopy is used to observe in real time the development of irradiation defects and the influence of these defects on dislocation behavior. Three-dimensional characterization provides information on the true spatial distribution of defects and clarifies effects of the free surfaces in thin films. This quasi-four dimensional analysis approach has been applied to understand the formation of channels in irradiated alloys, the depth distribution of ion damage in an electron transparent foil, and the dislocation channel interactions with grain boundaries. The new insight obtained from these experiments is highlighted and contrasted with findings from simulations.
Similar content being viewed by others
References
G.R. Odette and G.E. Lucas: Embrittlement of nuclear reactor pressure vessels. JOM 53(7), 18 (2001).
A. Arsenlis, B.D. Wirth, and M. Rhee: Dislocation density-based constitutive model for the mechanical behaviour of irradiated Cu. Philos. Mag. 84(34), 3617 (2004).
K. Fukuya: Current understanding of radiation-induced degradation in light water reactor structural materials. J. Nucl. Sci. Technol. 50(3–4), 213 (2013).
M.J. Makin and F.J. Minter: The mechanical properties of irradiated niobium. Acta Metall. 7(6), 361 (1959).
A.W. McReynolds, W. Augustyniak, M. McKeown, and D.B. Rosenblatt: Neutron irradiation effects in Cu and Al at 80 K. Phys. Rev. 98(2), 418 (1955).
J.V. Sharp: Deformation of neutron-irradiated copper single crystals. Philos. Mag. 16, 77 (1967).
I. Charit and K.L. Murty: Structural materials issues for the next generation fission reactors. JOM 62(9), 67 (2010).
B.L. Eyre and A.F. Bartlett: An electron microscope study of neutron irradiation damage in alpha-iron. Philos. Mag. 12, 261 (1965).
G.S. Was and S.M. Bruemmer: Effects of irradiation on intergranular stress corrosion cracking. In Fundamentals of Radiation Damage: Proceedings of the International Summer School on the Fundamentals of Radiation Damage, Urbana, IL, August 1–12, 1993, Vol. 216, 1994; p. 326.
E.A. West, M.D. McMurtrey, J. Zhijie, and G.S. Was: Role of localized deformation in irradiation-assisted stress corrosion cracking initiation. Metall. Mater. Trans. A 43(1), 136 (2012).
E.R. Gilbert, B.A. Chin, and D.R. Duncan: Effect of irradiation on failure mode during creep. Metall. Trans. A 18A(1), 79 (1987).
I. Chant and K.L. Murty: Structural materials issues for the next generation fission reactors. JOM 62(9), 67 (2010).
M. Kirk, C. Santos, E. Eason, J. Wright, and G.R. Odette: Updated embrittlement trend curve for reactor pressure vessel steels. In Structural Mechanics in Reactor Technology, 2003.
A. Souidi, M. Hou, C.S. Becquart, L. Malerba, C. Domain, and R.E. Stoller: On the correlation between primary damage and long-term nanostructural evolution in iron under irradiation. J. Nucl. Mater. 419(1–3), 122 (2011).
R.E. Stoller, G.R. Odette, and B.D. Wirth: Primary damage formation in bcc iron. J. Nucl. Mater. 251, 49 (1997).
J. Kacher and I.M. Robertson: Quasi-four-dimensional analysis of dislocation interactions with grain boundaries in 304 stainless steel. Acta Mater. 60(19), 6657 (2012).
J. Kacher and I.M. Robertson: In situ and tomographic analysis of dislocation/grain boundary interactions in titanium. Philos. Mag. 94(8), 814 (2014).
J.P. Kacher, G.S. Liu, and I.M. Robertson: Visualization of grain boundary/dislocation interaction using tomographic reconstructions. Scr. Mater. 64, 677 (2011).
D. Xu, B.D. Wirth, M. Li, and M.A. Kirk: Combining in situ transmission electron microscopy irradiation experiments with cluster dynamics modeling to study nanoscale defect agglomeration in structural metals. Acta Mater. 60(10), 4286 (2012).
D. Bufford, S.H. Pratt, T.J. Boyle, and K. Hattar: In situ TEM ion irradiation and implantation effects on Au nanoparticle morphologies. Chem. Commun. 50(57), 7593 (2014).
J. Kacher, G.S. Liu, and I.M. Robertson: In situ and tomographic observations of defect free channel formation in ion irradiated stainless steels. Micron 43(11), 1099 (2012).
J.S. Barnard, J. Sharp, J.R. Tong, and P.A. Midgley: Weak-beam dark-field electron tomography of dislocations in GaN. J. Phys.: Conf. Ser. 26, 247 (2006).
J.S. Barnard, J. Sharp, J.R. Tong, and P.A. Midgley: Electron tomography of dislocations. Microsc. Microanal. 13, 150 (2007).
G.S. Liu, S.D. House, J. Kacher, M. Tanaka, K. Higashida, and I.M. Robertson: Electron tomography of dislocation structures. Mater. Charact. 87, 1 (2014).
M. Briceno, J. Fenske, M. Dadfarnia, P. Sofronis, and I.M. Robertson: Effects of ion irradiation-produced defects on the mobility of dislocations in 304 stainless steel. J. Nucl. Mater. 409, 18 (2011).
R.E. Smallman and K.H. Westmacott: Structure of quenched and irradiated metals. J. Appl. Phys. 30(5), 603 (1959).
D.J. Mazey, R.S. Barnes, and A. Howie: On interstitial dislocation loops in aluminium bombarded with alpha-particles. Philos. Mag. 7(83), 1861 (1962).
M.L. Jenkins: Characterisation of radiation-damage microstructures by TEM. J. Nucl. Mater. 216, 124 (1994).
K. Hattar, D.C. Bufford, and D.L. Buller: Concurrent in situ ion irradiation transmission electron microscope. Nucl. Instrum. Methods Phys. Res., Sect. B 338, 56 (2014).
M. Li, M.A. Kirk, P.M. Baldo, D. Xu, and B.D. Wirth: Study of defect evolution by TEM with in situ ion irradiation and coordinated modeling. Philos. Mag. 92(16), 2048 (2012).
C. Chisholm, K. Hattar, and A.M. Minor: In situ TEM concurrent and successive Au self-ion irradiation and He implantation. Mater. Trans. 55(3), 418 (2014).
S.L. Dudarev, K. Arakawa, X. Yi, Z. Yao, M.L. Jenkins, M.R. Gilbert, and P.M. Derlet: Spatial ordering of nano-dislocation loops in ion-irradiated materials. J. Nucl. Mater. 455, 16 (2014).
M. Hernandez-Mayoral, Z. Yao, M.L. Jenkins, and M.A. Kirk: Heavy-ion irradiations of Fe and Fe-Cr model alloys. Part 2: Damage evolution in thin-foils at higher doses. Philos. Mag. 88(21), 2881 (2008).
M.L. Jenkins, Z. Yao, M. Hernandez-Mayoral, and M.A. Kirk: Dynamic observations of heavy-ion damage in Fe and Fe-Cr alloys. J. Nucl. Mater. 389, 197 (2009).
Z. Yao, M. Hernandez-Mayoral, M.L. Jenkins, and M.A. Kirk: Heavy-ion irradiations of Fe and Fe-Cr model alloys. Part 1: Damage evolution in thin-foils at lower doses. Philos. Mag. 88(21), 2851 (2008).
M.L. Jenkins and M.A. Kirk: Characterization of Radiation Damage by Transmission Electron Microscopy (Institute of Physics Pub., CRC Press, Boca Raton, FL, 2001).
S. Ishino: A review of in situ observation of defect production with energetic heavy ions. J. Nucl. Mater. 251, 225 (1997).
C.W. Allen, L.L. Funk, and E.A. Ryan: New instrumentation in Argonne’s HVEM-Tandem Facility: Expanded capability for in situ ion beam studies. In Ion-Solid Interactions for Materials Modification and Processing, MRS Proc., 396, 1996; p. 641.
C.W. Allen: In situ ion- and electron-irradiation effects studies in transmission electron microscopes. Ultramicroscopy 56(1–3), 200 (1994).
J.A. Hinks: A review of transmission electron microscopes with in situ ion irradiation. Nucl. Instrum. Methods Phys. Res., Sect. B 267, 3652 (2009).
R.F. Egerton, P. Li, and M. Malac: Radiation damage in the TEM and SEM. Micron 35(6), 399 (2004).
M.A. Kirk, I.M. Robertson, W.E. King, E.A. Ryan, and A. Philippides: Hvem investigation of in-situ, self-ion damage in iron at 40 and K. MRS Proc. 41, 326–347 (1985).
M.R. Gilbert, Z. Yao, M.A. Kirk, M.L. Jenkins, and S.L. Dudarev: Vacancy defects in Fe: Comparison between simulation and experiment. J. Nucl. Mater. 386–388, 36 (2009).
E.A. Kenik and T.E. Mitchell: Orientation dependence of the threshold displacement energy in copper and vanadium. Philos. Mag. 32(4), 815 (1975).
T. Hayashi, K. Fukmuto, and H. Matsui: In situ observation of glide motions of SIA-type loops in vanadium and V–5Ti under HVEM irradiation. J. Nucl. Mater. 307–311(Part 2), 993 (2002).
A.V. Barashev, Y.N. Osetsky, and D.J. Bacon: Mechanism of one-dimensional glide of self-interstitial atom clusters in α-iron. Philos. Mag. A 80(11), 2709 (2000).
K. Arakawa, K. Ono, M. Isshiki, K. Mimura, M. Uchikoshi, and H. Mori: Observation of the one-dimensional diffusion of nanometer-sized dislocation loops. Science 318, 956 (2007).
B.L. Eyre and R. Bullough: On the formation of interstitial loops in metals. Philos. Mag. 12, 31 (1965).
J. Chen, N. Gao, P. Jung, and T. Sauvage: A new mechanism of loop formation and transformation in bcc iron without dislocation reaction. J. Nucl. Mater. 441(1–3), 216 (2013).
J. Marian, B. Wirth, and J. Perlado: Mechanism of formation and growth of <100> interstitial loops in ferritic materials. Phys. Rev. Lett. 88(25), 255507 (2002).
H. Xu, R.E. Stoller, Y.N. Osetsky, and D. Terentyev: Solving the puzzle of <110>interstitial loop formation in bcc iron. Phys. Rev. Lett. 110, 265503 (2013).
M.J. Aliaga, A. Prokhodtseva, R. Schaeublin, and M.J. Caturla: Molecular dynamics simulations of irradiation of α-Fe thin films with energetic Fe ions under channeling conditions. J. Nucl. Mater. 452(1–3), 453 (2014).
R.E. Stoller: The effect of free surfaces on cascade damage production in iron. J. Nucl. Mater. 307–311(2 Suppl.), 935 (2002).
R.E. Stoller and S.G. Guiriec: Secondary factors influencing cascade damage formation. In Proceedings of the 11th Conference on Fusion Research, December 7, 2003–December 12, 2003, Vol. 329–333; Elsevier, 2004; p. 1238.
X-M. Bai, A.F. Voter, R.G. Hoagland, M. Nastasi, and B.P. Uberuaga: Efficient annealing of radiation damage near grain boundaries via interstitial emission. Science 327, 1631 (2010).
B.N. Singh and A.J.E. Foreman: Calculated grain size-dependent vacancy supersaturation and its effect on void formation. Philos. Mag. 29(4), 847 (1974).
D. Chen, J. Wang, T. Chen, and L. Shao: Defect annihilation at grain boundaries in alpha-Fe. Sci. Rep. 3, 1450–1454, (2013).
C. Sun, K.Y. Yu, J.H. Lee, Y. Liu, H. Wang, L. Shao, S.A. Maloy, K.T. Hartwig, and X. Zhang: Enhanced radiation tolerance of ultrafine grained Fe-Cr-Ni alloy. J. Nucl. Mater. 420(1–3), 235 (2012).
K.Y. Yu, Y. Liu, C. Sun, H. Wang, L. Shao, E.G. Fu, and X. Zhang: Radiation damage in helium ion irradiated nanocrystalline Fe. J. Nucl. Mater. 425(1–3), 140 (2012).
O. El-Atwani, J.A. Hinks, G. Greaves, S. Gonderman, T. Qiu, M. Efe, and J.P. Allain: In-situ TEM observation of the response of ultrafine- and nanocrystalline-grained tungsten to extreme irradiation environments. Sci. Rep. 4, 4716–4722, (2014).
N. Li, K. Hattar, and A. Misra: In situ probing of the evolution of irradiation-induced defects in copper. J. Nucl. Mater. 439, 185 (2013).
J.W. Edington: Practical Electron Microscopy in Materials Science (N.V. Philips’ Gloeilampenfabrieken, Eindhoven, Netherlands, 1976).
B. Fultz and J. Howe: Transmission Electron Microscopy and Diffractometry of Materials (Springer, Berlin, Germany, 2008).
D. Xu, B.D. Wirth, M. Li, and M.A. Kirk: Recent work towards understanding defect evolution in thin molybdenum foils through in situ ion irradiation under TEM and coordinated cluster dynamics modeling. Curr. Opin. Solid State Mater. Sci. 16(3), 109 (2012).
B.D. Wirth, V.V. Bulatov, and T.D. De La Rubia: Atomistic simulation of dislocation-defect interactions in Cu. In Microstructural Processes in Irradiated Materials-2000, November 27, 2000–November 29, 2000, Vol. 650, MRS Proc., 2001; p. R3.27.1.
M. Victoria, N. Baluc, C. Bailat, Y. Dai, M.I. Luppo, R. Schaublin, and B.N. Singh: The microstructure and associated tensile properties of irradiated FCC and BCC metals. In International Workshop on Basic Aspects of Differences in Irradiation Effects between FCC, BCC and HCP Metals and Alloys, 15–20 Oct. 1998, Vol. 276; Elsevier, 2000; p. 114.
J. Silcox and P.B. Hirsch: Direct observations of defects in quenched gold. Philos. Mag. 4(37), 72 (1959).
T. Dlaz de la Rubia, H.M. Zhib, T.A. Khraishi, B.D. Wirth, M. Victoria, and M.J. Caturia: Multiscale modelling of plastic flow localization in irradiated materials. Nature 406(6798), 871 (2000).
T.A. Khraishi, H.M. Zbib, T.D. De La Rubia, and M. Victoria: Localized deformation and hardening in irradiated metals: Three-dimensional discrete dislocation dynamics simulations. Metall. Mater. Trans. B 33B(2), 285 (2002).
K. Farrell, T.S. Byun, and N. Hashimoto: Deformation mode maps for tensile deformation of neutron-irradiated structural alloys. J. Nucl. Mater. 335, 471 (2004).
S.J. Zinkle and Y. Matsukawa: Observation and analysis of defect cluster production and interactions with dislocations. In Proceedings of the 11th Conference on Fusion Research, December 7, 2003–December 12, 2003, Vol. 329–333; Elsevier, 2004; p. 88.
J.S. Robach, I.M. Robertson, B.D. Wirth, and A. Arsenlis: In-situ transmission electron microscopy observations and molecular dynamics simulations of dislocation-defect interactions in ion-irradiated copper. Philos. Mag. 83(8), 955 (2003).
R. Schaublin, Z. Yao, P. Spatig, and M. Victoria: Dislocation defect interaction in irradiated Cu. Mater. Sci. Eng., A. 400–401(1–2 Suppl.), 251 (2005).
I.M. Robertson, J.S. Robach, H.J. Lee, and B.D. Wirth: Dynamic observations and atomistic simulations of dislocation-defect interactions in rapidly quenched copper and gold. Acta Mater. 54(6), 1679 (2006).
A.S. Wadhwa and E.H.S. Dhaliwal: A Textbook of Engineering Material and Metallurgy (University Science Press, Laxmi Publications, New Delhi, India, 2008).
M. Briceño, J. Kacher, and I.M. Robertson: Dynamics of dislocation interactions with stacking-fault tetrahedra at high temperature. J. Nucl. Mater. 433(1–3), 390 (2013).
Y.N. Osetsky, Y. Matsukawa, R.E. Stoller, and S.J. Zinkle: On the features of dislocation-obstacle interaction in thin films: Large-scale atomistic simulation. Philos. Mag. Lett. 86(8), 511 (2006).
Y.N. Osetsky, R.E. Stoller, and Y. Matsukawa: Dislocation-stacking fault tetrahedron interaction: What can we learn from atomic-scale modelling. In Proceedings of the 11th Conference on Fusion Research, December 7, 2003–December 12, 2003, Vol. 329–333, Elsevier; 2004; p. 1228.
Y.N. Osetsky, R.E. Stoller, D. Rodney, and D.J. Bacon: Atomic-scale details of dislocation-stacking fault tetrahedra interaction. Mater. Sci. Eng., A. 400–401(1–2 Suppl.), 370 (2005).
B.D. Wirth, V.V. Bulatov, and T. De La Diaz Rubia: Dislocation-stacking fault tetrahedron interactions in Cu. J. Eng. Mater. Technol. 124(3), 329 (2002).
N.M. Ghoniem, S.H. Tong, J. Huang, B.N. Singh, and M. Wen: Mechanisms of dislocation-defect interactions in irradiated metals investigated by computer simulations. J. Nucl. Mater. 307–311(2 Suppl.), 843 (2002).
N.M. Ghoniem, S.H. Tong, B.N. Singh, and L.Z. Sun: On dislocation interaction with radiation-induced defect clusters and plastic flow localization in FCC metals. Philos. Mag. A 81(11), 2743 (2001).
M.D. McMurtrey, B. Cui, I.M. Robertson, D. Farkas, and G.S. Was: The role of dislocation channels in irradiation assisted stress corrosion cracking. Curr. Opin. Solid State Mater. Sci.(2014, submitted).
M.D. McMurtrey, G.S. Was, L. Patrick, and D. Farkas: Relationship between localized strain and irradiation assisted stress corrosion cracking in an austenitic alloy. Mater. Sci. Eng., A. 528(10–11), 3730 (2011).
T.C. Lee, I.M. Robertson, and H.K. Birnbaum: TEM in situ deformation study of the interaction of lattice dislocations with grain boundaries in metals. Philos. Mag. A 62(1), 131 (1990).
T.R. Bieler, P. Eisenlohr, F. Roters, D. Kumar, D.E. Mason, M.A. Crimp, and D. Raabe: The role of heterogeneous deformation on damage nucleation at grain boundaries in single phase metals. Int. J. Plast. 25, 1655 (2009).
T.C. Lee, I.M. Robertson, and H.K. Birnbaum: In situ transmission electron microscope deformation study of the slip transfer mechanisms in metals. Metall. Trans. A 21A(9), 2437 (1990).
L. Patriarca, W. Abuzaid, H. Sehitoglu, and H.J. Maier: Slip transmission in bcc FeCr polycrystal. Mater. Sci. Eng., A. 588, 308 (2013).
M.D. Sangid, T. Ezaz, H. Sehitoglu, and I.M. Robertson: Energy of slip transmission and nucleation at grain boundaries. Acta Mater. 59(1), 283 (2011).
B. Cui, J. Kacher, M. McMurtrey, G. Was, and I.M. Robertson: Influence of irradiation damage on slip transfer across grain boundaries. Acta Mater. 65, 150 (2014).
B. Cui, M.D. McMurtrey, G.S. Was, and I.M. Robertson: Micromechanistic origin of irradiation-assisted stress corrosion cracking. Philos. Mag. 94(36), 4197 (2014).
ACKNOWLEDGMENTS
This work was supported financially by the US Department of Energy under Award No. DE-FG02-08ER46525 (BC and IMR) and the US Department of Energy Office of Basic Energy Sciences under Award No. DEFG-02-07ER46443 (JK and IMR).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Kacher, J., Cui, B. & Robertson, I.M. In situ and tomographic characterization of damage and dislocation processes in irradiated metallic alloys by transmission electron microscopy. Journal of Materials Research 30, 1202–1213 (2015). https://doi.org/10.1557/jmr.2015.14
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1557/jmr.2015.14