Abstract
Efficient biodegradation of lignocellulosic biomass needs a battery of enzymes targeting cellulose, hemicellulose, and lignin. In this study, recombinant Trichoderma reesei ZJ-09 with Pycnoporus sanguineus laccase gene was used to degrade rice straw by in situ production of laccase, xylanase, and cellulases under solid-state fermentation (SSF). Effects of parameters on key enzymes (cellulase, xylanase, and laccase) in biodegradation during SSF were investigated. Under the optimized SSF conditions, the FPA, xylanase activity, and laccase activity reached 110.47 FPU/g, 5787.59 IU/g, and 24.45 IU/g, respectively, on day 12. The obtained recombinant T. reesei SSF system achieved efficient degradation of rice straw with the final mass loss up to 51.16% which was 1.4-fold higher than the host strain. Further, bioconversion of rice straw into a novel laccase-enriched koji for persistent organic pollutants bioremediation (LKPB) was conducted by the optimized SSF system. LKPB was found to degrade persistent organic pollutants (POPs) effectively without the addition of mediators. 4-h removal rates of three POPs mediated by LKPB (87.21% for 2,4,5-trichlorophenol, 92.45% for nonylphenol, and 90.73% for oxytetracycline) were comparable to those achieved by laccase-co-mediator system. The newly established recombinant T. reesei SSF system could be potential to effectively degrade lignocellulosic wastes as well as organic pollutants.
Graphical abstract
![](http://media.springernature.com/lw685/springer-static/image/art%3A10.1186%2Fs40643-022-00581-9/MediaObjects/40643_2022_581_Figa_HTML.png)
Similar content being viewed by others
Explore related subjects
Find the latest articles, discoveries, and news in related topics.Introduction
Lignocellulosic biomass is one of the world’s largest low-cost raw materials for energy production. It was reported that an annual total of 700 million tons of agricultural wastes were produced in China (Sun et al. 2018; Ma et al. 2020). These wastes were derived from various types of crops such as rice, wheat, corn, and sugarcane, accounting for over 20% of the world total production (Ma et al. 2020; Ren et al. 2019).
Open-field burning is a widely used straw disposal approach in developing countries with heavy agricultural industries, such as Philippines, India, etc. Straw burning yields little exportable energy, but produces a large amount of greenhouse gases, dust, and smog, which in turn cause extensive attention of air pollution and relevant public health (Gadde et al. 2009; Pouliot et al. 2017). As statistical data have shown, about 144 million tonnes of CO2 and 1.4 million tonnes of PM2.5 were emitted into the air annually caused by straw burning in China (Ren et al. 2019), which suggests that conventional straw treatment based on burning is confronting increasing challenges in consideration of its environmental sustainability.
As a traditional strategy, returning straw to fields has been applied for decades and is considered an economical strategy to minimize soil erosion and water losses by improving soil structure, soil fertility, soil organic matter, and microbial activity. According to previous studies, the crop yield represented an increase of 5–10% after returning straw to the field (Ren et al. 2019). However, the low degradation rate of straw has been considered a committed step in large-scale implementations considering the fact that straw contains a large proportion of poorly biodegradable lignocellulose polymers (i.e., cellulose, hemicellulose, and lignin).
Biodegradation is a well-known environmental-friendly method which has the benefit of uncomplicated equipment, low energy cost, inhibitors production or free of chemicals, and easy implementation compared to traditional chemical and physical pretreatment approaches. The current biological pretreatment method consists mainly of enzymatic saccharification and microbial degradation mediated by bacteria or fungi (Sánchez 2009). Previous research efforts have shown that there are multiple fungi that can degrade straw such as white-rot (i.e., Phanerochaete chrysosporium and Trametes versicolor), brown-rot (i.e., Postia placenta and Gloeophyllum trabeum) (Ray et al. 2010), and soft-rot fungi (i.e., Trichoderma reesei and Aspergillus niger) (Schilling et al. 2012; Shirkavand et al. 2016). For example, applying white-rot fungi Trametes versicolor can improve the hydrolysis of wheat straw with 91% sugar yield improvement compared to untreated straw. However, this method has two drawbacks. First, the whole process needs to take at least 15 days to complete. Second, although white-rot fungi pretreatment removes lignin efficiently, with high selectivity for lignin degradation over cellulose loss (Wan and Li 2012), they are generally poor in removing cellulose and hemicellulose (Ma et al. 2020). Therefore, some other researches focus on using bacteria for biodegradation, including Clostridium sp. (Lin et al. 2011), Cellulomonas sp. (Sharma et al. 2019), Bacillus sp. (Maas et al. 2008), Rhodococcusjostii sp., and Sphingobium sp. (Xu et al. 2018), various bacterial species have been developed for lignocellulosic materials degradation. Compared to fungi, bacteria can quickly decompose cellulose and hemicellulose while they have lower efficiency in degrading lignin (Ma et al. 2020). Therefore, strategies focusing on synergistically degrading all three major components of straw should be promising in future straw management.
Laccase (EC 1.10.3.2) is a part of the family of multicopper oxidases which catalyze the one-electron oxidation of multiple phenolic molecules to phenoxy radicals accompanied by the reduction of molecular oxygen to H2O (Su et al. 2018). Laccases are capable of directly oxidizing the phenolic subunits (accounting for 30% of lignin) with polymeric lignin as substrate (Hilgers et al. 2018). However, the non-phenolic units (accounting for 70% of lignin) possess redox potentials up to 1500 mV and thus cannot be directly oxidized via laccase-mediated reactions (Munk et al. 2015). Nevertheless, with the existence of mediators which are small aromatic molecules acting as “electron shuttles”, laccases can act on non-phenolic parts of lignin (Christopher et al. 2014). In laccase–mediator systems (LMS), the laccase first oxidizes the mediator, which subsequently attacks non-phenolic units. In this way, the substrate range of laccases can be largely extended (Hilgers et al. 2020; Munk et al. 2015).
Besides lignin degradation, the fact that laccases only require molecular oxygen for catalysis makes them suitable for bioremediation of xenobiotic compounds (Baldrian 2006). The capability of laccase to efficiently detoxify various persistent organic pollutants (POPs) has gained increasing attention in the area of bioremediation. The contaminants investigated include dyes (Liu S et al. 2020), polycyclic aromatic hydrocarbons (PAHs) (Zeng et al. 2021), endocrine disrupters (Bayramoglu et al. 2018), and pesticides (Sarker et al. 2021).
Pycnoporus sanguineus isolated from the tropical area could produce the laccase with good thermostability (Garcia et al. 2007). However, this laccase reveals low enzyme activity and stability under industrial conditions, thereby limiting its applications (Agrawal et al. 2018). Trichoderma reesei, encoding a series of cellulases and hemicellulases, is one of the most extensively studied cellulolytic microorganisms for biomass degradation. As the major industrial cellulase producer, the engineered T. reesei has been reported to achieve an extracellular protein titer up to 80.6 g/L under industrial fermentation conditions (Fonseca et al. 2020). Two main methods of T. reesei cellulase production are submerged fermentation and solid-state fermentation (SSF). SSF is widely used as it is easy to operate, has no need for skilled manpower, and is less capital intensive since it enables the usage of cheap lignocellulosic feedstock as substrates for enzyme production (Manan and Webb 2020).
In our previous work, the laccase gene from Pycnoporus sanguineus was cloned and integrated into the chromosomes of T. reesei ZU-02 and constructed the recombinant T. reesei ZJ-09 (Zhao et al. 2018). The principal goals of this study were: (1) to provide more efficient recommendations for agricultural crop residues management using recombinant T. reesei under suitable solid-state fermentation conditions; (2) to develop novel POPs biodegrading koji via SSF by the recombinant T. reesei. This research will provide useful information about improving the speed of agricultural wastes and POPs biodegradation.
Material and methods
Strain and chemicals
Trichoderma reesei ZJ-09 with Pycnoporus sanguineus laccase gene used for the present study was constructed in our previous study (Zhao et al. 2018). The parental strain Trichoderma reesei ZU-02 (originally derived from ATCC56764 via rounds of screening focused on high cellulase production) was used as a control for enzyme production, biodegradation of rice straw, and POPs degradation experiments. For inoculum preparation, 3–5 mL of sterile saline 0.9 wt. % was added into fully sporulated slants and then was gently pipetted up and down. After that, the obtained spore suspension was adjusted to 1 × 108 spores/mL using sterile saline.
POPs (2,4,5-trichlorophenol, nonylphenol, and oxytetracycline) were purchased from Sangon Biotech (Shanghai, China). Syringaldehyde, vanillin and 2,2-azino-bis (3-ethylbenzothiazoline-6-sulfonic acid) (ABTS) were obtained from Sigma-Aldrich (Saint-Louis, MO, USA). Methanol, oxalic acid, and acetonitrile were of HPLC grade and obtained from Sigma-Aldrich. All other chemicals used in this study were of analytical grade.
Raw material, pre-processing and composition analyses
Wheat straw (WS), corn straw (CS), rice straw (RS), and sugar cane bagasse (SCB) were picked up from the surrounding areas in Hangzhou, Zhejiang province, China. The samples were washed thoroughly with water and air-dried. After that, samples were milled to a particle size between 2—5 mm and stored in air-tight containers until used.
Milled samples were saturated with ammonium hydroxide (solid-to-water ratio of 1:10 (w/v)) for 24 h as described previously (Chen et al. 2009). After pretreatment, the samples were washed with water until the pH reached neutral and then air-dried.
Compositional analyses of agricultural residues (pretreated and untreated) were performed according to the National Renewable Energy Laboratory (NREL) protocol (Sluiter et al. 2004). In short, two-step acid hydrolysis with 72% H2SO4 was used to fractionate the biomass into forms that were more easily quantified. The acid-insoluble material was measured by gravimetric analysis. The acid-soluble lignin was determined by UV–Vis spectroscopy. The polymeric carbohydrates were hydrolyzed into the soluble monomeric forms, which were measured by HPLC (Waters) with an Aminex HPX-42A column (Bio-Rad, USA). Hemicellulose was measured as the sum of xylose, galactose, mannose, and arabinose. Cellulose was determined as the total amount of glucose.
Straw degradation under solid-state fermentation
Unless otherwise illustrated in the paper, solid-state fermentation by recombinant T. reesei was performed in 500 g capacity trays using rice straw as substrate with relative humidity maintained at 70%. 80 g of a total dry substrate and 20 g bran were mixed with 250 mL SSF nutrient solution. T. reesei spore suspension containing ~ 1 × 108 spores/mL was inoculated into the tray with the inoculum ratio of 10% (v/w). Fermentations were carried out at 30 ℃ for 10 days. The solid-state medium was sampled each day for determinations of enzyme activities and straw degradation rates.
SSF nutrient solution containing 2% (NH4)2SO4, 0.5% urea, 0.5% CaCl2, 0.5% KH2PO4, 0.25% MgSO4·7H2O, 0.05% CoCl2, 0.025% CuSO4. The pH was adjusted to 5.0 using 50 mM citrate buffer.
Enzyme preparation
Koji obtained from recombinant T. reesei ZJ-09 SSF for 10 days (LKPB) was taken directly for POPs degradation.
Enzyme extraction of LKPB was performed using 50 mM citrate buffer (pH 4.8) with a solid-to-liquid ratio of 1:5. The mixture was shaken for 60 min at 30 ℃, 200 rpm. After that, the mixture was centrifuged for 5 min at 4 ℃, 10,000 rpm. The supernatant was taken for enzyme assay.
Enzyme preparation from submerged fermentation was according to previously described (Xia et al. 2018). 1 mL of spore suspension was inoculated into 50 mL of the seed medium and grew for 48 h at 30 ℃, 180 rpm. Then 2.5 mL of the seed culture was transferred to 50 mL of the fermentation medium. Cultures were incubated at 28 ℃ up to 120 h. After that 48 h of cultivation, 2% (w/v) lactose was added to the medium every 24 h. The supernatant of the 120 h culture with laccase activity of 8.9 IU/mL was used as a control in the organic pollutants degradation experiment.
Organic pollutants degradation
50 mg/L of 2,4,5-trichlorophenol (TCP), nonylphenol (NP), and oxytetracycline (OTC) were incubated separately with 0.2 IU/mL laccase obtained by submerged fermentation or solid-state fermentation (shown in “Enzyme preparation” section) in the presence or absence of 0.3 mM individual mediator (syringaldehyde or vanillin or ABTS) or syringaldehyde/vanillin (Syr/Van) complex at the syringaldehyde to vanillin with a ratio of 4:6. Degradation reactions were performed at pH 4.0, 50 ℃ in a shaking water bath at 120 rpm for 4 h. A control test was performed on 50 mg/L individual pollutant with 0.2 IU/mL laccase obtained by submerged fermentation without mediators.
Residual pollutant concentrations were determined by HPLC system (shown in “HPLC analysis” section).
Analysis
Enzyme assays
Total cellulase activity (filter paper activity, FPA) was analyzed based on the Laboratory Analytical Procedure published by NREL (Adney and Baker 2008). One FPU was defined as the amount of enzyme that produced 1 μmol of reducing sugar per minute in glucose equivalents.
Laccase activity was measured as previously reported using ABTS as the substrate (Zhao et al. 2018). One unit of laccase activity (IU) was defined as the amount of enzyme that oxidized 1 μmol of ABTS per minute.
Suspension of D-xylan 1% (w/v) in 50 mM sodium acetate buffer (pH 5.0) was used as a substrate for xylanase activity assay. 0.5 mL of diluted enzyme solution was added and the mixture was incubated at 50 ℃ for 30 min. DNS solution was used to stop the reaction. One unit of xylanase activity (IU) is defined as the amount of enzyme releasing 1 μmol of reducing sugars per minute.
β-Glucosidase activity (BGA) (Xia et al. 2018), cellobiohydrolase activity (CBHA) (Fang and Xia 2015), and endoglucanase activity (CMCase) (Miller 1959) were assayed as previously reported. One unit (IU) of BGA and CMCase was defined as the amount of enzyme that released 1 µmol glucose equivalent per minute. One unit (U) of CBHA was defined as the amount of enzyme required for generating 1 mg of reducing sugars in 1 h.
For each enzyme assay, the mean value of three independent replicates equals the absolute enzyme activity (referred to as enzyme activity). For calculation of the relative enzyme activity in SSF optimization, enzyme activity from recombinant T. reesei ZJ-09 through solid-state fermentation using rice straw as substrate plus 30% bran content at 30 °C, initial pH 5.0, 70% water content with 10% (v/w) initial inoculum was set to 100%. The quotient of the absolute enzyme activity and the highest value equaled the relative enzyme activity. All results were given as the mean value ± standard deviation.
HPLC analysis
An HPLC (Agilent 1200, USA) system equipped with an Eclipse XDB-C18 column (150 mm × 4.6 mm × 5 μm) and a photodiode array detector (220 nm for TCP, 277 nm for NP, and 355 nm for OTC) was used.
Add 5 mL of methanol to 5 mL reaction system to completely dissolve the pollutants. After that, 1 mL of the sample was filtered through a 0.45-μm sterile membrane. For TCP and NP, the mobile phase was composed of methanol and water (85:15, v/v). For OTC, the mobile phase was composed of 0.01 M oxalic acid, acetonitrile, and methanol (72:14:14, v/v/v). The column was set at 30 ℃ and the injection volume was 20 μL. Flow rate was set at 1.0 mL/min for NP and TCP, and 0.8 mL/min for OTC:
where C0 (mg/mL) was the initial concentration of pollutant and C1 (mg/mL) was the residual concentration of pollutant.
Statistical analysis
All data in this paper are presented as the mean value ± standard deviation (SD). SPSS 20.0 (SPSS Inc., Chicago, IL, USA) was employed for statistical analysis. One-way ANOVA or t-test was used for significance of differences analysis. p < 0.05 was considered significant, p < 0.01 was considered extremely significant.
Results and discussion
Optimization of solid-state fermentation with recombinant T. reesei
Lignocellulolytic enzymes are essential to the complete decomposition of lignocellulosic biomass. Therefore, in this part, culture conditions for the yield of cellulase, laccase, and xylanase produced by recombinant T. reesei ZJ-09 during solid-state fermentation of lignocellulosic wastes were investigated using one-factor-at-a-time (OFAT) experiments.
Crop type
During SSF, solid substrate is critical to microbial growth and enzyme activity, since it not only supplies the culture nutrients, but also serves as an anchor for the microbial cells (Wong et al. 2017). In this study, enzyme production by T. reesei ZJ-09 under SSF was evaluated using several types of agricultural wastes (wheat straw (WS), rice straw (RS), corn straw (CS), and sugar cane bagasse (SCB)) as carbon sources.
Among these carbon sources, CS could induce the highest total cellulase activity (FPA) of 112.26 FPU/g, laccase activity of 20.50 IU/g, and xylanase activity of 5401.23 IU/g, respectively (Fig. 1). An explanation for this result is that CS had higher cellulose content compared to other lignocellulosic wastes (Additional file 1: Table S2) which led to the upregulation of genes associated with cellulase, hemicellulase, and laccase synthesis given that cellulose is a strong inducer for gene expression in Trichoderma reesei (Bischof et al. 2013). Besides CS, recombinant T. reesei also exhibited strong capability of cellulase, xylanase, and laccase production using RS and SCB as the substrate, indicating T. reesei ZJ-09 has great potential for degradation of various agricultural residues.
Rice straw, an economically feasible carbon source commonly used as the substrate for SSF, is the most abundant lignocellulosic biomass in southern China (Abraham et al. 2016). It is rich in several nutrients, which could explain its better performance as it can enhance cell growth as well as metabolism. Considering the nature of the substrate, cost, and availability, rice straw was chosen as the carbon source for further experiments.
Bran content
It has been reported that the addition of wheat bran into SSF medium could provide adequate essential nutrients as well as inducers for microbial growth and enzyme secretion (Farinas 2015). Meanwhile, bran was discovered to have suitable particle sizes, good porosity, and offer fungi the anchorage to grow on during SSF process (Sun et al. 2008). Besides, its texture was kept loose even in moist conditions, thus providing a large surface area by holding water (Kar et al. 2013).
In this study, the optimal bran content for enzyme production from recombinant T. reesei through solid-state fermentation using rice straw as substrate was investigated at 30 °C, initial pH 5.0, 70% water content with 10% (v/w) initial inoculum over a bran content from 0 to 40%. As presented in Fig. 2a, FPA, laccase activity, and xylanase activity increased with bran content, and 30% bran content led to the maximum enzyme activity. After that, further bran content increase brought slight decreases in enzyme activities.
Optimization of fermentation conditions, including the effect of bran content (a), temperature (b), water content (c), pH (d), and inoculum size (e) on enzyme production by T. reesei ZJ-09 under SSF. All samples are collected on day 10 to assay the FPA, xylanase activity, and laccase activity. Data were average values of triplicate samples and error bars indicate standard deviations
Wheat bran is a cheap carbon source rich in several nutrients including cellulose, hemicellulose, protein, and essential minerals. It can also increase the surface area of mixed substrates, which may provide optimum support for enzymes production and cell growth of T. reesei ZJ-09.
Temperature
Temperature is an important indicator during SSF, which can affect enzyme production efficiency. The effect of temperature on enzyme production during SSF was evaluated from 24 °C to 34 °C. As presented in Fig. 2b, enzyme activities did not exhibit huge differences during the measured temperature range. Three enzyme activities reached maximum values when the temperature was set to 30 °C. A slight decrease in laccase activity occurred at temperatures higher than 32 °C. Laccase activity exhibited a sharp decrease (accounting for only 68.15% of the maximal activity) when the temperature was up to 34 °C.
Water content
Sufficient moisture is crucial to microbial growth and metabolism. It is previously reported that initial water content had a major impact on the cellulases production. In this study, different moisture contents (50—80%) were evaluated for cultures of T. reesei ZJ-09 under SSF using rice straw as substrate. As presented in Fig. 2c, the ideal water content was observed between 60 and 75%. FPA, laccase activity, and xylanase activity maintained above 80% of the highest enzymatic activities when moisture content varied in this range, indicating recombinant T. reesei ZJ-09 could thrive on a comparatively wide range of water content. 70% was proven to be optimal for enzyme production. When moisture was maintained at 70%, FPA, laccase activity, and xylanase activity reached 124.49 IU/g, 24.60 IU/g, and 5763.34 IU/g, respectively (data not shown). Further increase in moisture level had a negative impact on enzyme production.
pH
The optimal pH for enzyme production by T. reesei ZJ-09 under SSF was studied over a pH range of 3.5–7.0. The FPA, laccase activity, and xylanase activity were measured on the 10th day of fermentation. Enzyme activities from the recombinant T. reesei did not vary considerably at pH varying from 4.5 to 7.0 (Fig. 2d). Notably, though the laccase activity decreased when pH was lower than 4.0, the recombinant T. reesei still presented laccase production capacity, suggesting comparatively wide pH adaptability of T. reesei ZJ-09. Taken together, the pH of SSF for T. reesei ZJ-09 was set at 7.0 (natural pH) to simplify pH adjustment process.
Inoculum size
The effect of inoculum size on T. reesei SSF was studied over the range of 5–15%. As shown in Fig. 2e, the increase in inoculum size within the range of 5% to 10% resulted in increased enzyme activities which could be due to enhanced growth rates achieved in the initial phase. There is a trade-off between strain growth and enzyme production, if increase the inoculum size, the fungal growth rate can be accelerated, but at the same time nutrient depletion can be also aggravated. Fungal growth will be affected via nutrient depletion, which would do harm to improving the yield of enzymes, thereby the suitable inoculum size was set to 10% in this study.
Enzyme production by recombinant T. reesei on rice straw
The changes of enzyme activity of cellulase, laccase, and xylanase during the SSF process are given in Fig. 3. Similar to the original strain, recombinant T. reesei ZJ-09 had strong cellulase and xylanase producing capability. FPAs of T. reesei ZJ-09 and the host strain T. reesei ZU-02 increased rapidly from day 2 to day 7, peaking at 110.47 FPU/g and 126.27 FPU/g, respectively, on day 12. Taking other components of cellulase complex into consideration, ZJ-09 exhibited slightly lower β-glucosidase activity, cellobiohydrolase activity, and endoglucanase activity (Additional file 1: Table S1). Significant increases in xylanase activities were found after 4 days of fermentation, reaching 5723.39 IU/g and 5225.21 IU/g, respectively, on day 10.
Notably, compared to the host strain, T. reesei transformant ZJ-09 could persistently secrete laccase from day 4 to day 10 with the activity of 24.45 IU/g on the 10th day of fermentation.
Taken together, recombinant T. reesei kept the abilities of efficient production of cellulase and xylanase from the original strain. Meanwhile, T. reesei ZJ-09 could use rice straw as a substrate to produce high activity laccase.
It was known that the complete degradation of lignocellulosic biomass needs a battery of enzymes targeting cellulose, hemicellulose, and lignin. Because of its complexity and rigid structure, lignin is hard to degrade. Despite the noted catalytic activity of laccases towards phenolic groups of lignin, laccase cannot oxidize lignin completely. Consequently, mediators, acting as electron carriers, are needed to assist laccase in depolymerizing lignin and are considered a crucial factor in efficient and complete lignocellulosic residues degradation. In this study, the early degradation of cellulose and hemicellulose catalyzed by the cellulase and xylanase from T. reesei ZJ-09 could release various phenolic compounds which could act as natural mediators for laccase. In this way, the formed laccase–mediator systems (LMS) could expand the oxidation ability of laccase, which made the recombinant T. reesei have greater potential to effectively degrade lignocellulosic wastes as well as organic pollutants.
Biodegradation of rice straw by T. reesei
Changes in the biomass compositions under SSF process are shown in Fig. 4. As it was expected, recombinant T. reesei ZJ-09 retained the strong cellulose and hemicellulose degradation ability of the original strain. The degrading ratio of cellulose and hemicellulose increased immediately after inoculation, reaching 21.41% and 23.64% on day 2, respectively, and then topped 59.12% and 52.61% on day 12, respectively.
Additionally, it is noteworthy that T. reesei ZJ-09 was able to degrade lignin effectively (Fig. 4a). Despite the lower removal rate during the initial phase of SSF, the lignin degradation ratio for T. reesei ZJ-09 had been growing with the laccase activity since day 4. The lignin degradation ratio was up to 38.05% on day 12. By comparison, the lignin degradation ratio of the original strain was undetectable.
The lower percentage of lignin makes cellulose and hemicellulose more available to the microorganism, which leads to higher biomass loss. As a result, the final mass loss of ZJ-09 was 1.4-fold higher to 51.16% compared to that of the original strain.
POPs degradation by recombinant T. reesei koji
Target organic contaminants (nonylphenol, 2,4,5-trichlorophenol, and oxytetracycline) selected in this study are the three most recalcitrant and prevalent in the environment, which pose significant health risks to humans. The laccase-mediated removal rates of the three contaminants are lower than 15% when no mediator is added.
As expected, the commonly used synthetic mediator ABTS could facilitate laccase-catalyzed degradation of inert chemicals. After reacting for 4 h, ABTS-mediated treatments achieved the removal rates of 94.28%, 52.01%, and 46.73% for nonylphenol (NP), 2,4,5-trichlorophenol (TCP), and oxytetracycline (OTC), respectively (Fig. 5). Regardless of the proven efficiency of the laccase/ABTS system, artificial mediators lead to additional costs, exhibit potential toxicity (Becker et al. 2016), and can cause laccase inactivation (Fillat et al. 2012). In comparison, natural mediators, considered as the true mediators for fungal laccases, are good alternatives to artificial ones given that they are more environmentally friendly and economically feasible.
Degradation of POPs by different laccase–mediator systems. Individual POP on 50 mg/L was treated with 0.2 IU/mL laccase at pH 4.0, 50 ℃ for 4 h in the presence or absence of 0.3 mM individual mediator or Syr/Van complex with a ratio of 4:6. Control was performed on 50 mg/L individual POP with 0.2 IU/mL laccase without mediators. Residual POP concentrations were determined by HPLC. Error bars represent the standard deviation of three independent repeats. *p < 0.05, **p < 0.01 compared with control
As shown in Fig. 5, the removal rates were 94.55%, 86.42%, and 62.98% for NP, TCP, and OTC, respectively, by syringaldehyde/laccase system. Interestingly, an improved removal rate was observed when syringaldehyde and vanillin were present in combination, indicating the coexistence of various mediators could bring a synergistic effect in laccase–mediator systems. This was probably due to that not only the primary radical species, but also the secondary species produced by the chain reactions among primary radicals could act on the recalcitrant chemicals, resulting in the enhancement of the oxidation efficiency.
A similar result was found by POPs degradation by koji from SSF by recombinant T. reesei ZJ-09 (LKPB). Degradation reactions using supernatant from submerged fermentation of T. reesei ZJ-09 (control group) were also run along with the test. When no mediator was added, the 4 h removal rates mediated by LKPB (92.45% for NP, 87.21% for TCP, and 90.73% for OTC) were comparable to those achieved by syringaldehyde/vanillin co-mediator system, while those of the control group were all lower than 15%.
Previous studies showed that the combination of laccase and mediators can efficiently transform phenolic xenobiotics into less toxic compounds (Su et al. 2018). For example, the degradation of OTC by laccase–mediator system (LMS) showed a reduction in toxicity (Mir-Tutusaus et al. 2014) and antimicrobial activity (Yang et al. 2017). As for TCP, the toxicity, persistence, and biodegradability depend on the number and position of chlorine substituents in the phenolic ring (Rubilar et al. 2008). Çabuk et al. revealed that TCP was dechlorinated by laccase (Çabuk et al. 2012) and Liu et al. demonstrated that laccase could achieve a good detoxification effect while degrading chlorophenols (Liu et al. 2021). Also, the acute toxicity test pointed out that the detected metabolites of NP were less toxic than the parent compound after laccase treatment (Mtibaà et al. 2020).
However, the application of laccase is limited because it is hard to react with pollutants with high redox potentials alone (Su et al. 2018). It was found that natural phenolic compounds derived from plants can generate active free radicals and then act on inert chemicals as mediators for laccase, thus expanding the substrate spectrum of laccase. In this study, the degradation of rice straw catalyzed by enzyme cocktails secreted by T. reesei ZJ-09 during SSF could release various phenolic compounds, which then formed laccase–mediator system and expanded the oxidation ability of laccase.
In this way, the recombinant T. reesei have greater potential to effectively degrade lignocellulosic wastes and organic pollutants simultaneously without addition of mediators. The future application of LKPB in wastewater and soil remediation is worth exploring.
Conclusions
Recombinant T. reesei ZJ-09 exhibited the ability of synchronous secretion of cellulase, xylanase, and laccase under SSF. Effects of key parameters on enzyme yield during the SSF process were investigated. Under the optimized SSF parameters, the FPA, xylanase activity and laccase activity reached 110.47 FPU/g, 5787.59 IU/g, and 24.45 IU/g, respectively, after 12 days of fermentation. When using rice straw as the carbon source, the resulting mass loss by recombinant T. reesei ZJ-09 was high up to 51.16%, which was significantly higher than that achieved by the original strain. The koji obtained from SSF of rice straw by recombinant T. reesei ZJ-09 effectively degraded recalcitrant organic pollutants (TCP, NP, and OTC) without the addition of mediators. The degradation rates were higher than those achieved by adding ABTS and vanillin as mediators and were comparable to those achieved by syringaldehyde and Syr/Van cocktail as mediators. The newly established recombinant T. reesei SSF system could be potential for economical and efficient lignocellulosic biomass conversion and bioremediation.
Availability of data and materials
All data supporting this article’s conclusion are available.
References
Abraham A, Mathew AK, Sindhu R, Pandey A, Binod P (2016) Potential of rice straw for bio-refining: an overview. Bioresour Technol 215:29–36. https://doi.org/10.1016/j.biortech.2016.04.011
Adney B, Baker J (2008) Measurement of cellulase activities. Technical report, NREL/TP-510-42628 laboratory analytical procedure.
Agrawal K, Chaturvedi V, Verma P (2018) Fungal laccase discovered but yet undiscovered. Bioresour Bioprocess 5:1–12. https://doi.org/10.1186/s40643-018-0190-z
Baldrian P (2006) Fungal laccases–occurrence and properties. FEMS Microbiol Rev 30:215–242. https://doi.org/10.1111/j.1574-4976.2005.00010.x
Bayramoglu G, Karagoz B, Arica MY (2018) Cyclic-carbonate functionalized polymer brushes on polymeric microspheres: immobilized laccase for degradation of endocrine disturbing compounds. J Ind Eng Chem 60:407–417. https://doi.org/10.1016/j.jiec.2017.11.028
Becker D, Della Giustina SV, Rodriguez-Mozaz S, Schoevaart R, Barceló D, de Cazes M, Belleville M-P, Sanchez-Marcano J, de Gunzburg J, Couillerot O (2016) Removal of antibiotics in wastewater by enzymatic treatment with fungal laccase–degradation of compounds does not always eliminate toxicity. Bioresour Technol 219:500–509. https://doi.org/10.1016/j.biortech.2016.08.004
Bischof R, Fourtis L, Limbeck A, Gamauf C, Seiboth B, Kubicek CP (2013) Comparative analysis of the Trichoderma reesei transcriptome during growth on the cellulase inducing substrates wheat straw and lactose. Biotechnol Biofuel 6:127. https://doi.org/10.1186/1754-6834-6-127
Çabuk A, Sidir YG, Aytar P, Gedikli S, Sidir İ (2012) Dechlorination of chlorinated compounds by Trametes versicolor ATCC 200801 crude laccase and quantitative structure-activity relationship of toxicity. J Environ Sci Heal A 47:1938–1947. https://doi.org/10.1080/03601234.2012.676517
Chen M, Zhao J, Xia L (2009) Comparison of four different chemical pretreatments of corn stover for enhancing enzymatic digestibility. Biomass Bioenerg 33:1381–1385. https://doi.org/10.1016/j.biombioe.2009.05.025
Christopher LP, Yao B, Ji Y (2014) Lignin biodegradation with laccase-mediator systems. Front Energy Res 2:12. https://doi.org/10.3389/fenrg.2014.00012
Fang H, Xia L (2015) Heterologous expression and production of Trichoderma reesei cellobiohydrolase II in Pichia pastoris and the application in the enzymatic hydrolysis of corn stover and rice straw. Biomass Bioenerg 78:99–109. https://doi.org/10.1016/j.biombioe.2015.04.014
Farinas CS (2015) Developments in solid-state fermentation for the production of biomass-degrading enzymes for the bioenergy sector. Renew Sust Energ Rev 52:179–188. https://doi.org/10.1016/j.rser.2015.07.092
Fillat U, Prieto A, Camarero S, Martínez ÁT, Martínez MJ (2012) Biodeinking of flexographic inks by fungal laccases using synthetic and natural mediators. Biochem Eng J 67:97–103. https://doi.org/10.1016/j.bej.2012.05.010
Fonseca LM, Parreiras LS, Murakami MT (2020) Rational engineering of the Trichoderma reesei RUT-C30 strain into an industrially relevant platform for cellulase production. Biotechnol Biofuel 13:1–15. https://doi.org/10.1186/s13068-020-01732-w
Gadde B, Bonnet S, Menke C, Garivait S (2009) Air pollutant emissions from rice straw open field burning in India, Thailand and the Philippines. Environ Pollut 157:1554–1558. https://doi.org/10.1016/j.envpol.2009.01.004
Garcia TA, Santiago MF, Ulhoa CJ (2007) Studies on the Pycnoporus sanguineus CCT-4518 laccase purified by hydrophobic interaction chromatography. Appl Microbiol Biotechnol 75:311–318. https://doi.org/10.1007/s00253-006-0817-4
Hilgers R, Vincken JP, Gruppen H, Kabel MA (2018) Laccase/Mediator systems: their reactivity toward phenolic lignin structures. ACS Sustain Chem Eng 6:2037–2046. https://doi.org/10.1021/acssuschemeng.7b03451
Hilgers R, van Erven G, Boerkamp V, Sulaeva I, Potthast A, Kabel MA, Vincken J-P (2020) Understanding laccase/HBT-catalyzed grass delignification at the molecular level. Green Chem 22:1735–1746. https://doi.org/10.1039/C9GC04341A
Kar S, Gauri SS, Das A, Jana A, Maity C, Mandal A, Mohapatra PKD, Pati BR, Mondal KC (2013) Process optimization of xylanase production using cheap solid substrate by Trichoderma reesei SAF3 and study on the alteration of behavioral properties of enzyme obtained from SSF and SmF. Bioprocess Biosyst Eng 36:57–68. https://doi.org/10.1007/s00449-012-0761-x
Lin Y, Wang J, Wang X, Sun X (2011) Optimization of butanol production from corn straw hydrolysate by Clostridium acetobutylicum using response surface method. Chin Sci Bull 56:1422–1428. https://doi.org/10.1007/s11434-010-4186-0
Liu S, Tsai S, Guo P, Lin C (2020) Inducing laccase activity in white rot fungi using copper ions and improving the efficiency of azo dye treatment with electricity generation using microbial fuel cells. Chemosphere 243:125304. https://doi.org/10.1016/j.chemosphere.2019.125304
Liu X, Deng W, Yang Y (2021) Characterization of a novel laccase LAC-Yang1 from white-rot fungus Pleurotus ostreatus strain Yang1 with a strong ability to degrade and detoxify chlorophenols. Molecules 26:473. https://doi.org/10.3390/molecules26020473
Ma Y, Shen Y, Liu Y (2020) State of the art of straw treatment technology: challenges and solutions forward. Bioresour Technol 313:123656. https://doi.org/10.1016/j.biortech.2020.123656
Maas RH, Bakker RR, Jansen ML, Visser D, De Jong E, Eggink G, Weusthuis RA (2008) Lactic acid production from lime-treated wheat straw by Bacillus coagulans: neutralization of acid by fed-batch addition of alkaline substrate. Appl Microbiol Biotechnol 78:751–758. https://doi.org/10.1007/s00253-008-1361-1
Manan MA, Webb C (2020) Newly designed multi-stacked circular tray solid-state bioreactor: analysis of a distributed parameter gas balance during solid-state fermentation with influence of variable initial moisture content arrangements. Bioresour Bioprocess 7:16. https://doi.org/10.1186/s40643-020-00307-9
Miller GL (1959) Use of Dinitrosalicylic acid reagent for determination of reducing Sugar. Anal Chem 31:426–428. https://doi.org/10.1021/ac60147a030
Mir-Tutusaus JA, Masís-Mora M, Corcellas C, Eljarrat E, Barceló D, Sarrà M, Caminal G, Vicent T, Rodríguez-Rodríguez CE (2014) Degradation of selected agrochemicals by the white rot fungus Trametes versicolor. Sci Total Environ 500–501:235–242. https://doi.org/10.1016/j.scitotenv.2014.08.116
Mtibaà R, Ezzanad A, Aranda E, Pozo C, Ghariani B, Moraga J, Nasri M, Manuel Cantoral J, Garrido C, Mechichi T (2020) Biodegradation and toxicity reduction of nonylphenol, 4-tert-octylphenol and 2,4-dichlorophenol by the ascomycetous fungus Thielavia sp HJ22: identification of fungal metabolites and proposal of a putative pathway. Sci Total Environ 708:135129. https://doi.org/10.1016/j.scitotenv.2019.135129
Munk L, Sitarz AK, Kalyani DC, Mikkelsen JD, Meyer AS (2015) Can laccases catalyze bond cleavage in lignin? Biotechnol Adv 33:13–24. https://doi.org/10.1016/j.biotechadv.2014.12.008
Pouliot G, Rao V, McCarty JL, Soja A (2017) Development of the crop residue and rangeland burning in the 2014 national emissions inventory using information from multiple sources. J Air Waste Manage 67:613–622. https://doi.org/10.1080/10962247.2016.1268982
Ray MJ, Leak DJ, Spanu PD, Murphy RJ (2010) Brown rot fungal early stage decay mechanism as a biological pretreatment for softwood biomass in biofuel production. Biomass Bioenergy 34:1257–1262. https://doi.org/10.1016/j.biombioe.2010.03.015
Ren J, Yu P, Xu X (2019) Straw utilization in China—status and recommendations. Sustainability 11:1762. https://doi.org/10.3390/su11061762
Rubilar O, Diez MC, Gianfreda L (2008) Transformation of chlorinated phenolic compounds by white rot fungi. Crit Rev Biotechnol 38:227–268. https://doi.org/10.1080/10643380701413351
Sánchez C (2009) Lignocellulosic residues: biodegradation and bioconversion by fungi. Biotechnol Adv 27:185–194. https://doi.org/10.1016/j.biotechadv.2008.11.001
Sarker A, Nandi R, Kim J-E, Islam T (2021) Remediation of chemical pesticides from contaminated sites through potential microorganisms and their functional enzymes: Prospects and challenges. Environ Technol Innov 23:101777. https://doi.org/10.1016/j.eti.2021.101777
Schilling JS, Ai J, Blanchette RA, Duncan SM, Filley TR, Tschirner UW (2012) Lignocellulose modifications by brown rot fungi and their effects, as pretreatments, on cellulolysis. Bioresour Technol 116:147–154. https://doi.org/10.1016/j.biortech.2012.04.018
Sharma HK, Xu C, Qin W (2019) Biological pretreatment of lignocellulosic biomass for biofuels and bioproducts: an overview. Waste Biomass Valoriz 10:235–251. https://doi.org/10.1007/s12649-017-0059-y
Shirkavand E, Baroutian S, Gapes DJ, Young BR (2016) Combination of fungal and physicochemical processes for lignocellulosic biomass pretreatment–a review. Renew Sust Energ Rev 54:217–234. https://doi.org/10.1016/j.rser.2015.10.003
Sluiter A, Hames B, Ruiz R, Scarlata C, Sluiter J, Templeton D, Crocker D (2004) Determination of structural carbohydrates and lignin in biomass. Lab Anal Proced 1617(1):1–16
Su J, Fu J, Wang Q, Silva C, Cavaco-Paulo A (2018) Laccase: a green catalyst for the biosynthesis of poly-phenols. Crit Rev Biotechnol 38:294–307. https://doi.org/10.1080/07388551.2017.1354353
Sun X, Liu Z, Qu Y, Li X (2008) The effects of wheat bran composition on the production of biomass-hydrolyzing enzymes by Penicillium decumbens. Appl Biochem Biotechnol 146:119–128. https://doi.org/10.1007/s12010-007-8049-3
Sun LN, Ma XY, Liu KB, Zheng XH, Zhang HL, Rong LG (2018) A review on research advances on microbial treatment and strengthening techniques of crop straw. J Shenyang Univ 30(03):188–195. https://doi.org/10.16103/j.cnki.21-1583/n.2018.03.004
Wan C, Li Y (2012) Fungal pretreatment of lignocellulosic biomass. Biotechnol Adv 30:1447–1457. https://doi.org/10.1016/j.biotechadv.2012.03.003
Wong JWC, Rajeshwar D, Tyagi A (2017) Current developments in biotechnology and bioengineering: solid waste management. Elsevier.
Xia Y, Yang L, Xia L (2018) Combined strategy of transcription factor manipulation and β-glucosidase gene overexpression in Trichoderma reesei and its application in lignocellulose bioconversion. J Ind Microbiol Biotechnol 45:803–811. https://doi.org/10.1007/s10295-018-2041-5
Xu W, Fu S, Yang Z, Lu J, Guo R (2018) Improved methane production from corn straw by microaerobic pretreatment with a pure bacteria system. Bioresour Technol 259:18–23. https://doi.org/10.1016/j.biortech.2018.02.046
Yang J, Lin Y, Yang X, Ng TB, Ye X, Lin J (2017) Degradation of tetracycline by immobilized laccase and the proposed transformation pathway. J Hazard Mater 322:525–531. https://doi.org/10.1016/j.jhazmat.2016.10.019
Zeng J, Li Y, Dai Y, Wu Y, Lin X (2021) Effects of polycyclic aromatic hydrocarbon structure on PAH mineralization and toxicity to soil microorganisms after oxidative bioremediation by laccase. Environ Pollut. https://doi.org/10.1016/j.envpol.2021.117581
Zhao J, Zeng S, Xia Y, Xia L (2018) Expression of a thermo tolerant laccase from Pycnoporus sanguineus in Trichoderma reesei and its application in the degradation of bisphenol A. J Biosci Bioeng 125:371–376. https://doi.org/10.1016/j.jbiosc.2017.11.010
Acknowledgements
This work was supported by the Zhejiang Provincial Natural Science Foundation of China (No. LQ22E090006).
Funding
This work was financially supported by the Zhejiang Provincial Natural Science Foundation of China (No. LQ22E090006).
Author information
Authors and Affiliations
Contributions
YX performed the experiments, analyzed the data, and wrote the manuscript. XDL revised the manuscript and supervised the project. All authors read and approved the final manuscript.
Corresponding author
Ethics declarations
Ethics approval and consent to participate
Not applicable.
Consent for publication
All authors approved the consent for publishing the manuscript to Bioresources and Bioprocessing.
Competing interests
The authors declare no competing interests.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Supplementary Information
Additional file 1: Table S1.
β-glucosidase activity (BGA), cellobiohydrolase activity (CBHA), and endoglucanase activity (CMCase) from T. reesei under optimized SSF conditions using rice straw as substrate on day 12. Table S2. Compositions of lignocellulosic wastes used in this study.
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Xia, Y., Lin, X. Efficient biodegradation of straw and persistent organic pollutants by a novel strategy using recombinant Trichoderma reesei. Bioresour. Bioprocess. 9, 91 (2022). https://doi.org/10.1186/s40643-022-00581-9
Received:
Accepted:
Published:
DOI: https://doi.org/10.1186/s40643-022-00581-9