Abstract
Yeasts are extremely useful, not only for fermentation but also for a wide spectrum of fuel and chemical productions. We analyzed the overall metabolic turnover and transcript dynamics in glycolysis and the TCA cycle, revealing the difference in adaptive pyruvate metabolic response between a Crabtree-negative species, Kluyveromyces marxianus, and a Crabtree-positive species, Saccharomyces cerevisiae, during aerobic growth. Pyruvate metabolism was inclined toward ethanol production under aerobic conditions in S. cerevisiae, while increased transcript abundances of the genes involved in ethanol metabolism and those encoding pyruvate dehydrogenase were seen in K. marxianus, indicating the augmentation of acetyl-CoA synthesis. Furthermore, different metabolic turnover in the TCA cycle was observed in the two species: malate and fumarate production in S. cerevisiae was higher than in K. marxianus, irrespective of aeration; however, fluxes of both the reductive and oxidative TCA cycles were enhanced in K. marxianus by aeration, implying both the cycles contribute to efficient electron flux without producing ethanol. Additionally, decreased hexokinase activity under aerobic conditions is expected to be important for maintenance of suitable carbon flux. These findings demonstrate differences in the key metabolic trait of yeasts employing respiration or fermentation, and provide important insight into the metabolic engineering of yeasts.
Similar content being viewed by others
Introduction
In the context of bio-refining, microbial fermentation of biomass has been shown to yield a wide spectrum of fuels and chemicals. The commonly used yeast Saccharomyces cerevisiae is useful in the field of metabolic engineering because the micro-organism is well-characterized in terms of physiology, biochemistry, and genetics, and an advanced genetic toolbox is available1,2,3. However, S. cerevisiae’s inherent high ethanol production ability under aerobic conditions (which defines the species as “Crabtree-positive4,5,6”) results in the low yield of other metabolites such as organic acids, diols, and diamines. Therefore, this property often represents a hurdle in the application of this yeast toward bio-refining7. In S. cerevisiae, NADH is oxidized in glucose-rich media by fermentation rather than by respiration, even in the presence of dissolved oxygen8. This tendency is attributed to a limited capacity of respiratory dissimilation of pyruvate4. Recently, a Crabtree-negative S. cerevisiae was developed through rational engineering of pyruvate metabolism9.
Kluyveromyces marxianus, a non-conventional thermo-tolerant yeast, is inherently Crabtree-negative, showing no ethanol production ability after a glucose pulse is provided to respiring cells10. In addition, K. marxianus is distinct among the yeast species in that it can assimilate a variety of sugars, not only glucose but also arabinose, cellobiose, lactose, and xylose. Thus, the species has the desirable properties of being able to produce commodity chemicals from a feedstock of lignocellulosic materials11,12,13. Several genetic tools for K. marxianus recently have been developed: heterologous gene expression is available by a plasmid-based system14 or by integrating into the genome by homologous recombination15; efficient non-homologous end-joining activity that joins DNA ends in a sequence-independent manner through transformation has been reported16; and the complete genome sequence of K. marxianus was revealed17. Hence, K. marxianus has attracted considerable attention as a host strain for the production of bio-based chemicals18,19. It is known that K. marxianus grows well, replicating faster under aerobic conditions without ethanol fermentation; however, K. marxianus’s overall metabolic turnover in glycolysis and the tricarboxylic acid (TCA) cycle and dynamics of the corresponding gene transcripts remain unclear.
A multi-omics analysis allows kinetic visualization of carbon metabolism and identification of the limiting steps in central metabolic pathways such as glycolysis and the TCA cycle, facilitating our understanding of cellular behaviors and molecular networks through different types of time-series data. In the present study, the transcript levels of the genes involved in glycolysis and the TCA cycle and the pool sizes of metabolites were investigated through global qPCR and metabolome analyses to unveil dynamic changes in transcript abundance and intracellular metabolites, respectively, by K. marxianus and S. cerevisiae growing with aeration. Furthermore, dynamic metabolic profiling, which directly measures the turnover of metabolic intermediates via in vivo 13C-labeling of metabolites20,21,22, successfully demonstrated the distinct metabolic responses of Crabtree-positive and –negative yeasts to aeration. Our results indicated that K. marxianus strictly controls central metabolism, including glycolysis and the TCA cycle, in response to aeration, discriminating between fermentation and respiration.
Materials and Methods
Aerobic and anaerobic cultivation of yeast
S. cerevisiae BY4741 (genotype: MATa his3Δ1 leu2Δ0 met15Δ0 ura3Δ0) and K. marxianus NBRC 177717 were pre-cultivated at 30 °C in YPD medium (20 g/L peptone, 10 g/L yeast extract, 20 g/L glucose) for 16 h under aerobic conditions. The grown cells were collected by centrifugation at 3000 × g for 10 min at 4 °C, washed with sterile distilled water, and then inoculated into a 100 mL of YPD broth containing 91 mL of YP base (10 g/L yeast extract and 20 g/L peptone) and 5.5 g/L glucose in a BJR-25NAIS-8M (ABLE Co., Tokyo, Japan) mini fermenter. Glucose (500 g/L) was continuously fed into 100 mL of the medium at 1 mL/h for 9 h of cultivation, yielding a final added amount of 5 g glucose to the culture. Aerobic cultivation was conducted at an aeration rate of 1.0-vvm at 30 °C. The dissolved oxygen concentration was maintained at a level of ≥2.25 ppm by controlling agitation speed. Anaerobic cultivation (fermentation) was performed under the same conditions but without agitation. For all cultures, the initial cell concentration was adjusted to 12.5 g of wet cells/L. Wet cell weight was determined by weighing a cell pellet harvested by centrifugation at 3,000 × g for 5 min. Dry cell weight (DCW) was determined by fitting the optical density at 600 nm (OD600; monitored using a UVmini-1240 spectrophotometer (Shimadzu, Kyoto, Japan)) to an equation based on a linear correlation between DCW and OD600.
For quantification of ethanol and glucose in the fermentation medium, the culture was centrifuged at 3,000 × g at 4 °C for 10 min, and the resulting supernatant was analyzed using an electrochemical biosensor system BF-7 (Oji Scientific Instruments, Hyogo, Japan) operated at 30 °C, with phosphate buffer (pH 7.0) at a flow rate of 1.0 mL/min. Acetate in the fermentation medium was monitored by a high-performance liquid chromatography (HPLC) system (Shimadzu) equipped with an Aminex HPX-87H column (7.8 × 300 mm; Bio-Rad, Hercules, CA) and a refractive index detector (RID-10A; Shimadzu). The HPLC system was operated at 50 °C using 5 mM H2SO4 as the mobile phase at a flow rate of 0.6 mL/min.
Pool size analysis of intracellular metabolites
Culture medium (5 mL) was mixed with 7 mL of methanol pre-cooled to −40 °C. The mixture was immediately placed back in the cryostat (−40 °C). After centrifugation at 5,000 × g for 5 min at −20 °C, the resulting pellet was suspended by addition of 10 μL of 17 μM camphorsulfonic acid as an internal standard for liquid chromatography–triple quadrupole mass spectrometry (LC-QqQ-MS) analysis; intracellular metabolites were prepared by the boiling ethanol extraction method as described previously1. The extract was dried in a vacuum environment using a CVE-3100 centrifugal evaporator (EYELE, Tokyo, Japan), dissolved in 50 μL of Milli-Q water, and applied to LC-QqQ-MS. The LC-QqQ-MS system (LC: Agilent 1200 series; MS, Agilent 6460 Agilent Technologies, Palo Alto, CA, USA) was controlled with a Mastro C18 column (Shimadzu GLC, Ltd.; 150 × 2.0 mm; particle size, 3 μm) as described previously23. The pool sizes of target metabolites were calculated based on the area of peaks identified by comparing the chromatographic characteristics of samples with those of authentic standards using MassHunter Quantitative Analysis ver. B04.00 software (Agilent Technologies). Each pool size was represented as µmol of metabolite/g-dry cell weight (µmol/g-DCW).
qPCR
Each culture of cells was grown for 4 h and total RNA was extracted using a Total RNA Isolation Mini Kit (Agilent Technologies). The concentration of total RNA was determined using a Nano Vue Plus spectrophotometer (Life Technologies, Carlsbad, CA). The quality was checked using an Agilent 2100 Bioanalyzer (Agilent Technologies). cDNA was generated from the extracted total RNA by reverse transcription using ReverTra Ace qPCR RT Mix and gDNA Remover (Toyobo, Osaka, Japan). Quantitative PCR experiments were carried out in triplicate using Thunderbird SYBR qPCR Mix (Toyobo) and an Mx3005P Real Time PCR system (Agilent Technologies). Specific primers for the amplification of the selected genes and ACT1 as a house-keeping internal-standard gene are listed in Supplementary Table 1. The fold-change of the transcript levels was calculated using the 2−∆∆CT method24.
13C-labeling metabolomics
13C-labeling was initiated by adding 1 mL of 500 g/L [U-13C] glucose to the 100 mL of YPD broth after 4 h of cultivation. Culture samples were collected at the indicated time points (10 sec, 30 sec, and 1, 2, 5, and 10 min) after the addition of [U-13C] glucose; each intracellular metabolite was prepared as described above (in “Pool size analysis of intracellular metabolites”). Extracted metabolites were analyzed using capillary electrophoresis-mass spectrometry (CE-MS) (CE, Agilent G7100; MS, Agilent G6224AA LC/MSD TOF; Agilent Technologies). Mass spectral peaks were identified by searching for mass shifts between the 12C- to 13C-mass spectra. The ratio of 13C to total carbon, defined as the 13C fraction, was calculated by relative isotopomer abundance of metabolites incorporating 13C atoms as described previously22. The relative isotopomer abundance (mi) for each metabolite incorporating i13C atoms was calculated as follows:
where Mi represents the isotopomer abundance for each metabolite incorporating i13C atoms. The 13C fraction of metabolites possessing n carbon atoms was calculated as follows:
Enzyme assays
After 4 h of cultivation, cells were harvested by centrifugation at 3,500 × g for 5 min at 4 °C, washed twice with sterile water, and suspended in 50 mM Tris-HCl buffer (pH 7.5). The suspended cells were mixed with glass beads (0.6-mm diameter) and disrupted using a Shake Master Neo (Bio Medical Science, Tokyo, Japan). The crude extract, collected after centrifugation at 12,000 × g at 4 °C for 30 min, was used for the enzyme assay.
Unless otherwise noted, enzyme activities were assayed by measuring the oxidation of NADH or the production of NADPH in the reaction mixtures using a U-3010 spectrophotometer (Hitachi, Tokyo, Japan). The composition of each reaction was as follows: for malate dehydrogenase (MDH), 45 mM KPO4 buffer (pH 7.4), 0.12 mM NADH, and 0.33 mM oxaloacetate25; for malic enzyme (MAE), 100 mM Tris-HCl (pH 7.5), 10 mM MgCl2, 0.4 mM NADP+, and 10 mM L-malate26; for pyruvate carboxylase (PYC), 100 mM Tris acetate (pH 8.5), 10 mM KHCO3, 10 mM magnesium acetate, 0.1 mM NADH, 2 mM pyruvate, and 1.5 U/ml malate dehydrogenase (Oriental Yeast Co., Ltd., Tokyo, Japan)27; and for hexokinase (HXK), 50 mM Tris-HCl (pH 7.5), 6.7 mM MgCl2, 1 mM ATP, 0.8 mM NADP+, 1 mM glucose, and 1 U/ml glucose-6-phosphate dehydrogenase28. Protein concentrations were determined by the Quick Start™ Bradford Protein Assay (Bio-Rad) with bovine serum albumin as the standard29. The activities are presented as the mean of at least three independent technical replicates. One unit of enzyme activity was defined as the amount of enzyme that produced 1 µmol of product per min.
Results
Time-course profiles of ethanol and acetate by S. cerevisiae and K. marxianus
S. cerevisiae and K. marxianus strains were cultivated (separately) at 30 °C in YP medium containing glucose under aerobic and anaerobic conditions to investigate the effect of aeration on ethanol and acetate production. The initial density of yeast cells was 12.5 g of wet cells/L (OD600 = 18). Glucose was continuously fed into the medium at a rate of 5 g/h through 9 h of cultivation, yielding a total addition of 50 g glucose in each 100-mL culture. Ethanol and acetate concentrations in the supernatant were determined by HPLC. The growth of S. cerevisiae reached the highest cell densities (OD600 = 46 and 54) after 10 h of cultivation under anaerobic and aerobic conditions, respectively (Fig. 1a). Under anaerobic conditions, ethanol concentrations increased during cultivation. The highest titer of ethanol was 26.4 g/L after 11 h of cultivation (Fig. 1a). The productivity of ethanol under aerobic conditions was lower than that under anaerobic conditions; the highest titer of ethanol was 22.1 g/L after 10 h of aerobic cultivation. In contrast, S. cerevisiae gradually accumulated a small amount of acetate (1.3 g/L) under aerobic conditions, while the acetate titer under anaerobic conditions peaked at less than 0.5 g/L. K. marxianus achieved the highest cell density (OD600 = 42) under anaerobic conditions after 10 h of cultivation, while the highest cell density (OD600 = 121, 10 h cultivation) under aerobic conditions was almost 3-fold that under anaerobic conditions (Fig. 1b). As in the case of S. cerevisiae grown under anaerobic conditions, ethanol production by K. marxianus increased during anaerobic cultivation, peaking at an ethanol titer of 22.1 g/L. However, the ethanol concentration in the K. marxianus culture increased gradually during the first 5 h of cultivation, with the titer peaking at 0.5 g/L under aerobic conditions, before subsequently decreasing to 0.3 g/L after 11 h of cultivation. Acetate productivity by K. marxianus increased after 4 and 6 h of cultivation under anaerobic conditions; the highest titer (7.0 g/L) was achieved after 10 h of cultivation (Fig. 1b). On the other hand, the acetate titer peaked at less than 0.5 g/L under aerobic conditions.
Growth characteristics and metabolite profiles of S. cerevisiae and K. marxianus. S. cerevisiae (a) and K. marxianus (b) were cultivated under aerobic (right) or anaerobic (left) conditions. Time-dependent glucose consumption and extracellular ethanol and acetate concentrations were monitored. The symbols used in the figure are as follows: ○, glucose; △, ethanol; ▢, acetate; and ◇, OD600nm. Values represent the mean (±SD) of three biological replicates.
Metabolome analysis
Intracellular metabolites were extracted from S. cerevisiae or K. marxianus cells growing aerobically or anaerobically after 4 h of cultivation. The pool sizes of hexoses (glucose-6-phosphate, G6P; fructose-6-phosphate, F6P; and fructose-1,6-bisphosphate, FBP), triose phosphates (dihydroxyacetone phosphate, DHAP; glyceraldehyde 3-phosphate, GAP; 3-phosphoglycerate, PGA; phosphoenolpyruvate, PEP), organic acids (citrate, isocitrate, 2-ketoglutarate, succinate, fumarate, malate, and oxaloacetate), pyruvate, and acetyl-CoA (AcCoA) in central metabolism were calculated by LC-QqQ-MS analysis based on the areas of the peaks (Fig. 2). In S. cerevisiae cells, the pool sizes of several metabolites under aerobic conditions were higher than those under anaerobic conditions. These metabolites with elevated pool sizes were as follows: F6P, 1.7-fold; PGA, 3.3-fold; PEP, 1.8-fold; AcCoA, 1.5-fold; isocitrate, 1.5-fold; and fumarate, 1.7-fold (on a log2 scale). The combined pool size of FBP, G6P, DHAP, and pyruvate in aerobic cultivation was more than one-half that in anaerobic cultivation. The pool sizes of the other metabolites, including G6P, GAP, citrate, 2-ketoglutarate, succinate, malate, and oxaloacetate, were comparable between aerobic and anaerobic cultivation. In K. marxianus cells, the changes in metabolite pool size from G6P to PGA between aerobic and anaerobic cultivation were similar to those in S. cerevisiae. However, unlike the case in S. cerevisiae, the pool sizes of several metabolites under anaerobic conditions were increased compared to those observed under aerobic conditions, including the following: PEP, 1.8-fold; isocitrate, 3.8-fold; 2-ketoglutarate, 1.3-fold; succinate, 2.1-fold; malate, 3.3-fold; and fumarate, 1.8-fold. Notably, in K. marxianus, the pool size of pyruvate in anaerobic cultivation was 4.5-fold higher than that in aerobic cultivation (Fig. 2).
Pool sizes of intracellular metabolites in S. cerevisiae and K. marxianus. Each strain was cultivated for 4 h under aerobic (blue) or anaerobic (orange) conditions. Values represent the mean (±SD) of three biological replicates. Changes in transcript abundance are shown, on a log2-fold scale, for the genes involved in the indicated pathways. y-axis, µmol/g-DCW.
Quantification of transcript abundance by qPCR
Total RNA was extracted from the cells after 4 h of cultivation under aerobic or anaerobic conditions. qPCR was conducted to analyze the mRNA expression levels of individual genes involved in glycolysis and the TCA cycle. Changes in transcript abundance under aerobic and anaerobic conditions are shown, on a log2-fold scale, for each gene (Table 1, Fig. 2). In S. cerevisiae, the levels of transcripts of genes involved in glycolysis (PGI1, phosphoglucose isomerase; PFK1, phosphofructokinase; FBA1, fructose 1,6-bisphosphate aldolase; PGK1, 3-phosphoglycerate kinase; CDC19, pyruvate kinase; ENO1, PEP hydratase) all were decreased under anaerobic conditions. In contrast, the expression level of HXK2, which encodes hexokinase, under aerobic conditions was quantitatively (0.55-fold) higher than that under anaerobic conditions. The transcript abundances of three alcohol dehydrogenase-encoding genes (ADH1, ADH2, and ADH4) under aerobic conditions were 0.59-fold, 1.85-fold and 0.79-fold lower than those under anaerobic conditions, respectively, whereas the ADH3 gene transcript was quantitatively increased (0.6-fold) under aerobic conditions. The PDA1 and LAT1 genes, both of which encode pyruvate dehydrogenase subunits, also exhibited decreased transcript levels under aerobic conditions. The transcript abundance of the MDH1 gene, which encodes mitochondrial malate dehydrogenase, under aerobic conditions was 0.6-fold lower than that obtained under anaerobic conditions. Interestingly, transcripts of MDH2, which encodes cytosolic MDH, accumulated to higher levels under aerobic conditions compared to those under anaerobic conditions. In the anaplerotic pathway, the mRNA expression level of the MAE1 gene, which encodes malic enzyme, under aerobic conditions was less than one-half that under anaerobic conditions, while transcripts of the S. cerevisiae PCK1 gene, which encodes PEP carboxykinase, accumulated to 5.42-fold higher levels under anaerobic conditions than under aerobic conditions.
As in the case of S. cerevisiae, the transcript abundances of the genes involved in glycolysis were lower under aerobic conditions than under anaerobic conditions in K. marxianus (Table 1). The decreased abundances of these genes were as follows: PGI1, 1.31-fold; PFK1, 1.77-fold; FBA1, 2.59-fold; PGK1, 2.08-fold; CDC19, 4.18-fold; and ENO1, 2.18-fold (on a log2 scale). Decreased transcript abundance under anaerobic conditions also was observed for the TDH1 gene, which encodes glyceraldehyde 3-phosphate. The HXK2 gene transcript under aerobic cultivation was 3.48-fold lower than that under anaerobic conditions. The mRNA expression levels of the genes involved in ethanol assimilation or production were increased under aerobic conditions, including the following genes: ADH2, 2.23-fold; ADH4, 1.68-fold; ALD2, 1.07-fold; ACS1, 4.19-fold; PDA1, 1.92-fold; LAT1, 1.72-fold; MDH1, 1.74-fold; and MDH3, 1.92-fold (on a log2 scale). In contrast to the gene expression profile in S. cerevisiae, under aerobic conditions the transcript of the K. marxianus MAE1 gene accumulated to a level approximately 5.40-fold higher than that under anaerobic fermentation, while the transcript of the K. marxianus PCK1 gene was decreased under aerobic conditions. Note that aeration caused more than 3-fold (on a log2 scale) increases in the transcript abundances of the CIT3, IDH1, and KGD1 genes, which encode citrate synthase, isocitrate dehydrogenase, and 2-ketoglutrate dehydrogenase, respectively.
13C-metabolic turnover analysis
In-vivo 13C-labeling was performed to analyze the turnover of metabolites in S. cerevisiae and K. marxianus. 13C was incorporated into metabolites in the yeast cells following the addition of [U-13C] glucose after 4 h of cultivation in YPD medium. The 13C fraction, defined as the ratio of 13C to the total carbon in each metabolite, was calculated from the mass isotopomer distributions. The 13C fraction of glycolysis metabolites (G6P, 3PGA, and PEP) reached a maximum of more than 90% after 10 sec of labeling in both yeast species (Fig. 3). On the other hand, the 13C incorporation of metabolites via the TCA cycle rose more slowly over time compared to those generated via glycolysis. The 13C fractions of TCA cycle metabolites were lower than those of their common precursor, PEP. Aeration promoted 13C incorporation into metabolites of the TCA cycle in both yeast species, implying the activation of metabolic turnover via the TCA cycle under aerobic conditions. The 13C fraction of fumarate under aerobic conditions was lower than that under anaerobic conditions in S. cerevisiae after 10 min of labeling. Furthermore, the 13C fraction of malate in S. cerevisiae reached a maximum of about 40% and 60% after 10 min of labeling under anaerobic and aerobic conditions, respectively. The 13C labeling of 2-ketoglutarate was about 1% and 3% in S. cerevisiae under anaerobic and aerobic conditions, respectively. In contrast to the cases in S. cerevisiae, the 13C fraction of malate was around 10% after 10 min of labeling in K. marxianus grown under anaerobic conditions; however, the corresponding value was 30% under aerobic conditions. The 13C labeling of 2-ketoglutarate was less than 1% after 10 min of labeling in K. marxianus grown under anaerobic conditions, but the corresponding value was approximately 10% after 10 min of labeling under aerobic conditions. These results suggested that (in contrast to S. cerevisiae), K. marxianus enhances metabolic turnover in the TCA cycle during aeration.
Time-course changes in 13C fractions of metabolites in S. cerevisiae and K. marxianus. [U-13C] Glucose was added to each S. cerevisiae (a) or K. marxianus (b) growth medium after 4 h cultivation under aerobic (blue) or anaerobic (orange) conditions. Values represent the mean (±SD) of three biological replicates. y-axis, 13C fraction (%) calculated by equations described in “13C-labeling metabolomics” in Methods.
Enzyme activity of HXK, MAE, and MDH
S. cerevisiae or K. marxianus cells were cultivated for 4 h under aerobic or anaerobic conditions, and cell extracts were obtained by shaking with glass beads. Given the observed difference in the 13C-enrichment pattern of malate in the two species, the activities of MDH and MAE, which are responsible for malate metabolism, were measured (Fig. 4). In S. cerevisiae, MDH and MAE activities were similar in the cells grown under aerobic and anaerobic conditions, while the activity of HXK, the first enzyme of glycolysis, was significantly elevated in cells grown under aerobic conditions compared to the activity in cells grown under anaerobic conditions. This observation was consistent with the earlier observation that the HXK2 and HXK3 transcript abundances were decreased under aerobic conditions. The MAE activity of K. marxianus cells under aerobic conditions was about 2.0–fold higher than that under anaerobic conditions, even though K. marxianus MAE1 transcript was significantly higher than (approximately 5.40-fold) that under anaerobic fermentation. Note that MDH activity was significantly enhanced in K. marxianus under aerobic conditions when compared to that under anaerobic condition. On the other hand, HXK activity in K. marxianus cells grown under aerobic conditions was decreased (0.8-fold) compared to that in cells grown under anaerobic conditions.
Enzyme activity of S. cerevisiae and K. marxianus cell extracts. The specific activities of hexokinase (HXK), malic enzyme (MAE), and malate dehydrogenase (MDH) were determined in crude extracts of S. cerevisiae and K. marxianus strains cultivated for 4 h under aerobic (blue) or anaerobic (orange) conditions. Values represent the mean (±SD) of three independent measurements.
Discussion
Here, we have determined the metabolic fluxes of glycolysis and the TCA cycle, as well as transcript abundances of the corresponding genes, in response to aeration in two yeast species, S. cerevisiae and K. marxianus. This evaluation is expected to facilitate a comprehensive comparison and understanding of metabolic flux changes in Crabtree-positive and –negative yeast strains. S. cerevisiae produces ethanol under aerobic conditions when glucose is in excess, generally referred to as the Crabtree effect. The fermentation data obtained in the present work showed that the titer of ethanol was comparable in S. cerevisiae cultures grown under aerobic and anaerobic conditions (Fig. 1). Among the transcripts of the four ADH paralogs, that of ADH3 accumulated to increased levels under aerobic conditions (Fig. 2). ADH3, which localizes within the mitochondrial fraction, is essential for aerobic growth and controls the intracellular NADH/NAD balance via the supply of NADH30. This result implies that ADH3 positively contributes to the metabolic regulatory system, facilitating the Crabtree effect. We hypothesize that the resulting NADH abundance in mitochondria contributes to the activation of pyruvate dehydrogenase kinase, thereby inactivating pyruvate dehydrogenase and favoring the reductive TCA cycle via the reduction by malate dehydrogenase, which converts oxaloacetate to malate30. In fact, 13C-metabolic turnover analysis yielded a 13C fraction of malate of 60% (the maximum observed value) under aerobic conditions (Fig. 4a). In addition, ethanol metabolism is expected to be suppressed under such conditions, given that the transcript abundances of ADH2 and ALD2, both of which are involved in acetate production, were decreased during aerobic growth. Furthermore, PDA1 and LAT1 transcript levels decreased under aerobic conditions; this observation may indicate the accumulation of pyruvate, leading to the high production of ethanol via the action of ADH3. Succinate is formed by the reductive TCA cycle during fermentation31. Our 13C-metabolic turnover analysis revealed that the 13C-labeling rate of fumarate under anaerobic conditions was lower than that under aerobic conditions (Fig. 3). The transcript abundances of S. cerevisiae MAE1, MDH1, and MDH3 were comparable between aerobic and anaerobic conditions, consistent with the observation that the 13C fraction of malate peaked at 40%, even under anaerobic conditions.
In contrast to S. cerevisiae, K. marxianus produces lower amounts of ethanol and acetate during aerobic growth in the presence of high concentrations of glucose32. The ethanol titer obtained during aerobic cultivation of K. marxianus peaked at 5 g/L before gradually decreasing after 5 h of cultivation; the acetate titer peaked at less than 0.2 g/L during anaerobic cultivation (Fig. 1). This pattern might be explained by the mRNA expression profile of this yeast; that is, the mRNA expression levels of K. marxianus ADH2, ALD2, and ACS1, which are responsible for ethanol assimilation to acetyl-CoA, were increased by aeration (Fig. 2). Aerobic growth also yielded increases in the transcript abundances of PDA1 and LAT1; these genes encode activities that contribute to the augmentation of acetyl-CoA synthesis, resulting in a substantial decrease in the pool size of pyruvate (Fig. 2). The increased pool sizes of isocitrate, succinate, fumarate, and malate in K. marxianus grown under anaerobic cultivation can be attributed to the retardation of metabolic flux via the TCA cycle (Fig. 2). On the other hand, the present 13C-labeling data indicated that aeration led to elevation of the 13C fraction of TCA cycle metabolites. Together, our 13C-metabolic turnover analysis, qPCR, and enzyme assay data revealed that the flux of malate synthesis was increased under aerobic conditions, mainly due to the increase of the expression level of MDH. Furthermore, the increased mRNA expression level of ADH3 was expected to enhance the mitochondrial supply of NADH. In addition, accumulation of the transcripts of the CIT1, IDH1, and KGD1 genes, which are involved in the TCA cycle, implied activation of the oxidative TCA cycle. This inference was supported by our 13C-labeling data, which revealed that the 13C fraction of 2-ketoglutarate was more than 2.7-fold higher during aerobic cultivation compared to anaerobic cultivation (Fig. 3).
A Crabtree-negative strain of S. cerevisiae with a faster growth rate recently was developed by modification of a pyruvate decarboxylase-deficient strain via engineering of pyruvate metabolism and adaptive laboratory evolution9. Glucose uptake was restricted in the engineered S. cerevisiae strain to avoid unrestricted glucose uptake, therefore, this modification limited the strain’s capacity for reoxidation of cytosolic NADH. Separate work has shown that abolishment of pyruvate kinase PYK1 activity results in decreased glycolytic flux, relieving the Crabtree effect33. Moreover, the multi-copy presence of hexose transporter-encoding genes has been shown to enhance ethanol production by fermentation under aerobic conditions34. In the present study, we showed that glucose uptake is restricted in K. marxianus under aerobic conditions, correlating with decreases in hexokinase at the level of both mRNA expression and enzymatic activity (Figs 3 and 4). This finding indicates that controlling glucose uptake is a common strategy to retain efficient carbon and electron flux in the cell, enabling the maintenance of high growth rate. We conclude that K. marxianus growing under aerobic conditions augments acetyl-CoA biosynthesis from pyruvate and employs the oxidative TCA cycle; in combination with a decrease in the glucose uptake rate, these effects lead to strong suppression of ethanol and acetate production. The data presented here are expected to serve as a promising platform for the rational design of K. marxianus strains appropriate for the production of bio-based chemicals, as part of a metabolic engineering strategy.
References
Hasunuma, T. et al. Metabolic pathway engineering based on metabolomics confers acetic and formic acid tolerance to a recombinant xylose-fermenting strain of Saccharomyces cerevisiae. Microb. Cell Fact. 10, 2 (2011).
Alexander, W. G. A history of genome editing in Saccharomyces cerevisiae. Yeast. 35, 355–360 (2018).
Turner, T. L. et al. Engineering and Evolution of Saccharomyces cerevisiae to Produce Biofuels and Chemicals. Adv. Biochem. Eng. Biotechnol. 162, 175–215 (2018).
Pronk, J. T., Yde Steensma, H. & Van Dijken, J. P. Pyruvate metabolism in Saccharomyces cerevisiae. Yeast. 12, 1607–1533 (1996).
Klein, C. J., Olsson, L. & Nielsen, J. Glucose control in Saccharomyces cerevisiae: the role of Mig1 in metabolic functions. Microbiology. 144, 13–24 (1998).
Zaman, S. et al. Glucose regulates transcription in yeast through a network of signaling pathways. Mol. Syst. Biol. 5, 245 (2009).
Nielsen, J., Larsson, C., van Maris, A. & Pronk, J. Metabolic engineering of yeast for production of fuels and chemicals. Curr. Opin. Biotechnol. 31, 851–861 (2013).
Merico, A., Sulo, P., Piskur, J. & Compagno, C. Fermentative lifestyle in yeasts belonging to the Saccharomyces complex. FEBS J. 274, 976–989 (2007).
Dai, Z. et al. Global rewiring of cellular metabolism renders Saccharomyces cerevisiae Crabtree negative. Nat. Commun. 9, 3059, https://doi.org/10.1038/s41467-018-05409-9 (2018).
Fonseca, G. G., Heinzle, E., Wittmann, C. & Gombert, A. K. The yeast Kluyveromyces marxianus and its biotechnological potential. Appl. Microbiol. Biotechnol. 79, 339–354 (2008).
Nonklang, S. et al. High-temperature ethanol fermentation and transformation with linear DNA in the thermotolerant yeast Kluyveromyces marxianus DMKU3-1042. Appl. Environ. Microbiol. 74, 7514–7521 (2008).
Rodrussamee, N. et al. Growth and ethanol fermentation ability on hexose and pentose sugars and glucose effect under various conditions in thermotolerant yeast Kluyveromyces marxianus. Appl. Microbiol. Biotechnol. 90, 1573–1586 (2011).
Hasunuma, T. & Kondo, A. Consolidated bioprocessing and simultaneous saccharification and ermentation of lignocellulose to ethanol with thermotolerant yeast strains. Process Biochem. 47, 1287–1294 (2012).
Yanase, S. et al. Direct ethanol production from cellulosic materials at high temperature using the thermotolerant yeast Kluyveromyces marxianus displaing cellulolytic enzymes. Appl. Microbiol. Biotechnol. 88, 381–388 (2010).
Abdel-Banat, B. M. et al. Random and targeted gene integrations through the control of non-homologous end joining in the yeast Kluyveromyces marxianus. Yeast. 27, 29–39 (2010).
Yarimizu, T., Nakamura, M., Hoshida, H. & Akada, R. Synthetic signal sequences that enable efficient secretory protein production in the yeast Kluyveromyces marxianus. Microb. Cell Fact. 14, 20 (2015).
Inokuma, K. et al. Complete Genome Sequence of Kluyveromyces marxianus NBRC1777, a nonconventional Thermotolerant Yeast. Genome Announc. 3, https://doi.org/10.1128/genomeA.00389-15 (2015).
Morrissey, J. P., Etschmann, M. M., Schrader, J. & de Billerbeck, G. M. Cell factory applications of the yeast Kluyveromyces marxianus for the biotechnological production of natural flavour and fragrance molecules. Yeast 32, 3–16 (2015).
Zhang, J. et al. Improving xylitol production at elevated temperature with engineered Kluyveromyces marxianus through over-expressing transporters. Bioresour. Technol. 175, 642–645 (2014).
Hasunuma, T. et al. Metabolic turnover analysis by a combination of in vivo 13C-labeling from 13CO2 and metabolic profiling with CE-MS/MS reveals rate-limiting steps of the C3 photosynthetic pathway in Nicotiana tabacum leaves. J. Exp. Bot. 61, 1041–1051 (2010).
Hasunuma, T. et al. Dynamic metabolic profiling of cyanobacterial glycogen biosynthesis under conditions of nitrate depletion. J. Exp. Bot. 64, 2943–2954 (2013).
Hasunuma, T. et al. Temperature enhanced succinate production concurrent with increased central metabolism turnover in the cyanobacterium Synechocystis sp. PCC 6803. Metab. Eng. 48, 109–120 (2018).
Kato, H. et al. Widely targeted metabolic profiling analysis of yeast central metabolites. J. Biosci. Bioeng. 113, 665–673 (2012).
Arikawa, E. et al. Cross-platform comparison of SYBR Green real-time PCR with TaqMan PCR, microarrays and other gene expression measurement technologies evaluated in the MicroArray Quality Control (MAQC) study. BMC Genomics. 9, 328 (2008).
Steffan, J. S. & McAlister-Henn, L. Isolation and characterization of yeast gene encoding the MDH3 isozyme of malate dehydrogenase. J. Biol. Chem. 267, 24708–24715 (1992).
Boles, E., De Jong-Gubbels, P. & Pronk, J. T. Identification and characterization of MAE1, the Saccharomyces cerevisiae structural gene encoding mitochondrial malic enzyme. J. Bacteriol. 180, 2875–2882 (1998).
Menéndez, J., Delgado, J. & Gancedo, C. Isolation of the Pichia pastoris PYC1 gene encoding pyruvate carboxylase and identification of a suppressor of the pyc phenotype. Yeast. 14, 647–654 (1998).
Karp, H., Jäviste, A., Kriegel, T. M. & Alamäe, T. Cloning and biochemical characterization of hexokinase from the methylotrophic yeast Hansenula polymorpha. Curr. Genet. 44, 268–276 (2004).
Bradford, M. M. A rapid and sensitive method for the quantitation of microgram quantities of protein utilizing the principle of protein-dye binding. Anal. Biochem. 72, 248–254 (1976).
Bakker, B. M. et al. Stoichiometry and compartmentation of NADH metabolism in Saccharomyces cerevisiae. FEMS Microbiol. Rev. 25, 15–37 (2001).
Camarasa, C., Grivet, J. P. & Dequin, S. Investigation by 13C-NMR and tricarboxylic acid (TCA) deletion mutant analysis of pathways for succinate formation in Saccharomyces cerevisiae during anaerobic fermentation. Microbiology. 149, 2669–78 (2003).
van Dijken, J. P., Weusthuis, R. A. & Pronk, J. T. Kinetics of growth and sugar consumption in yeasts. Antonie Van Leeuwenhoek. 63, 343–52 (1993).
Yu, T. et al. Reprogramming Yeast Metabolism from Alcoholic Fermentation to Lipogenesis. Cell. 174, 1549–1558 (2018).
Lin, Z. & Li, W. H. Expansion of hexose transporter genes was associated with the evolution of aerobic fermentation in yeasts. Mol. Biol. Evol. 28, 131–141 (2011).
Acknowledgements
The authors thank Ms. Yoshimi Hori and Ms. Mami Matsuda for technical assistance. This work was partly supported by a Special Coordination Fund for Promoting Science and Technology, Creation of Innovative Centers for Advanced Interdisciplinary Research Areas (Innovative BioProduction Kobe) from the Ministry of Education, Culture, Sports, Science and Technology (MEXT) and by “Smart Cell Project” commissioned by New Energy and Industrial Technology Development Organization (NEDO) Materials Technology and Nanotechnology Department.
Author information
Authors and Affiliations
Contributions
Y.S. and T.H. designed the experiment. Y.S., R.H. and T.H. analyzed the data and wrote the manuscript. A.K. supervised the manuscript. All authors approved the final version of the manuscript.
Corresponding authors
Ethics declarations
Competing Interests
The authors declare no competing interests.
Additional information
Publisher’s note: Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Supplementary information
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons license, and indicate if changes were made. The images or other third party material in this article are included in the article’s Creative Commons license, unless indicated otherwise in a credit line to the material. If material is not included in the article’s Creative Commons license and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this license, visit http://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Sakihama, Y., Hidese, R., Hasunuma, T. et al. Increased flux in acetyl-CoA synthetic pathway and TCA cycle of Kluyveromyces marxianus under respiratory conditions. Sci Rep 9, 5319 (2019). https://doi.org/10.1038/s41598-019-41863-1
Received:
Accepted:
Published:
DOI: https://doi.org/10.1038/s41598-019-41863-1
- Springer Nature Limited
This article is cited by
-
Transcriptomic profiling of an evolved Yarrowia lipolytica strain: tackling hexanoic acid fermentation to increase lipid production from short-chain fatty acids
Microbial Cell Factories (2024)
-
An adaptive biomolecular condensation response is conserved across environmentally divergent species
Nature Communications (2024)
-
Rice bran extract as an alternative nutritional supplement for Kluyveromyces marxianus
Biomass Conversion and Biorefinery (2024)
-
Comparative Analysis of Three Types of Whey as Substrate for Fermentation by Kluyveromyces marxianus and its Influence on Isoamyl Acetate Synthesis
Waste and Biomass Valorization (2024)
-
Genome engineering of Kluyveromyces marxianus for high D-( −)-lactic acid production under low pH conditions
Applied Microbiology and Biotechnology (2023)