Abstract
The activity and product selectivity of Na2WO4-MnO2-CeO2/TiO2 (MNTiCe) catalysts promoted by Sr and Mg in the oxidative coupling of methane (OCM) reaction was studied. The OCM reaction holds significance due to its potential for methane utilization, production of valuable chemicals, and environmental benefits. The Sr and Mg promoters are added simultaneously or after the impregnation of Ce to the catalyst. The catalyst activity results showed that the simultaneous addition of Sr and Mg promoters along with Ce provides more C2 selectivity for the catalyst. These results show that the C2 selectivity of the MNTiCe catalyst in the OCM reaction is improved by simultaneous Sr and Mg addition, in which the optimum loading of Sr is 0.75 wt% and the optimum loading of Mg is 0.25 wt%. According to the XPS results, the catalytic surface of catalyst loading with 0.75 wt% of Sr has a higher concentration of O2− species and increases the ability of the catalyst in the OCM reaction. The surface areas of all catalysts are lower than 10 m2/g which is suitable for OCM reaction and increased by the addition of Sr and Mg. According to the TPR results the catalyst reduction in simultaneously Sr and Mg loading catalysts are higher than in unpromoted catalyst.
Similar content being viewed by others
References
H. Cruchade, I.C. Medeiros-Costa, N. Nesterenko, J.-P. Gilson, L. Pinard, A. Beuque et al., Catalytic routes for direct methane conversion to hydrocarbons and hydrogen: current state and opportunities. ACS Catal. 12, 14533–14558 (2022)
A. Nakhaei Pour, M.R. Housaindokht, S.F. Tayyari, J. Zarkesh, Deactivation studies of nano-structured iron catalyst in Fischer-Tropsch synthesis. J. Nat. Gas Chem. 19, 333–340 (2010)
Z. Zhu, W. Guo, Y. Zhang, C. Pan, J. Xu, Y. Zhu et al., Research progress on methane conversion coupling photocatalysis and thermocatalysis. Carbon Energy 3, 519–540 (2021)
X. Li, C. Wang, J. Tang, Methane transformation by photocatalysis. Nat. Rev. Mater. 7, 617–632 (2022)
Z. Mohammadkhani, S. Abedi, A. Morsali, A.R. Abbasi, M.E. Ebrahimzadeh, F. Babaei et al., Effects of pore size and surface area on CH4 and CO2 capture in mesostructured MIL-101. J. Iran. Chem. Soc. 16, 137–142 (2019)
Z. Bonakchi, A. Nakhaei Pour, S. Soheili, Molecular simulation of methane on various g-C3N4 isomers: collision, adsorption, desorption, and diffusion studies. J. Iran. Chem. Soc. 19, 3649–3657 (2022)
A. Nakhaei Pour, J. Karimi, S. Taghipoor, M. Gholizadeh, M. Hashemian, Fischer–Tropsch synthesis over CNT-supported cobalt catalyst: effect of magnetic field. J. Iran. Chem. Soc. 14, 1477–1488 (2017)
A. Nakhaei Pour, M.R. Housaindokht, S.M. Kamali Shahri, Fischer–Tropsch synthesis over cobalt/CNTs catalysts: functionalized support and catalyst preparation effect on activity and kinetic parameters. Ind. Eng. Chem. Res. 57, 13639–13649 (2018)
A. Nakhaei Pour, E. Hosaini, A. Tavasoli, A. Behroozsarand, F. Dolati, Intrinsic kinetics of Fischer–Tropsch synthesis over Co/CNTs catalyst: effects of metallic cobalt particle size. J. Nat. Gas Sci. Eng. 21, 772–778 (2014)
A. Nakhaei Pour, M.R. Housaindokht, Study of activity, products selectivity and physico-chemical properties of bifunctional Fe/HZSM-5 Fischer–Tropsch catalyst: effect of catalyst shaping. J. Nat. Gas Sci. Eng. 14, 29–33 (2013)
M. Abdollahi, H. Atashi, F.F. Tabrizi, M. Mansouri, Fischer–Tropsch study over impregnated silica-supported cobalt–iron nanocatalyst. J. Iran. Chem. Soc. 14, 245–256 (2017)
N. Davoodian, A. Nakhaei Pour, M. Izadyar, A. Mohammadi, M. Vahidi, Fischer–Tropsch synthesis over a novel cobalt catalyst supported on UiO-66. J. Iran. Chem. Soc. 18, 1043–1050 (2021)
M. Behrooz, M.H. Peyrovi, P.A. Nakhaei, Direct partial oxidation (dpo) of methane to higher hydrocarbons by modified H-ZSM5 catalyst. React. Kinet. Catal. Lett. 73, 127–133 (2001)
A. Nakhaei Pour, M. Mousavi, Combined reforming of methane by carbon dioxide and water: particle size effect of Ni–Mg nanoparticles. Int. J. Hydrog. Energy 40, 12985–12992 (2015)
M. Mousavi, A. Nakhaei Pour, Performance and structural features of LaNi0.5Co0.5O3 perovskite oxides for the dry reforming of methane: influence of the preparation method. New J. Chem. 43, 10763–10773 (2019)
S.M.K. Shahri, P.A. Nakhaei, Ce-promoted Mn/Na2WO4/SiO2 catalyst for oxidative coupling of methane at atmospheric pressure. J. Nat. Gas Chem. 19, 47–53 (2010)
Y. Gao, Y. Wei, W. Sun, G. Zhao, Y. Liu, Y. Lu, Insight into deactivation of the carbon-/sintering-resistant Ni@ Silicalite-1 for catalytic partial oxidation of methane to syngas. Fuel 320, 123892 (2022)
H. Yang, R. Yu, Y. Fang, J. Yao, Y. Gan, J. Chen et al., Singly dispersed Ir1Ti3 bimetallic site for partial oxidation of methane at high temperature. Appl. Surf. Sci. 599, 153863 (2022)
M. Pourali, J.A. Esfahani, H. Jahangir, A. Farzaneh, K.C. Kim, Ammonia decomposition in a porous catalytic reactor to enable hydrogen storage: numerical simulation, machine learning, and response surface methodology. J. Energy Storage 55, 105804 (2022)
S. Carlotto, The catalytic performance of pure, doped, and reduced-doped SrTiO3 perovskite surfaces for oxidative coupling of methane. Appl. Surf. Sci. 602, 154376 (2022)
H. Wang, R. Schmack, S. Sokolov, E.V. Kondratenko, A. Mazheika, R. Kraehnert, Oxide-supported carbonates reveal a unique descriptor for catalytic performance in the oxidative coupling of methane (OCM). ACS Catal. 12, 9325–9338 (2022)
S. Damasceno, F.J. Trindade, F.C. Fonseca, D.Z. de Florio, A.S. Ferlauto, Oxidative coupling of methane in chemical looping design. Fuel Process. Technol. 231, 107255 (2022)
R.S. Pal, S. Rana, S.K. Sharma, R. Khatun, D. Khurana, T.S. Khan et al., Enhancement of oxygen vacancy sites of La2−xMxCe2O7−δ (M= Ca, Ba, Sr) catalyst for the low temperature oxidative coupling of methane: a combined DFT and experimental study. Chem. Eng. J. 458, 141379 (2023)
S. Sourav, Y. Wang, D. Kiani, J. Baltrusaitis, R.R. Fushimi, I.E. Wachs, New mechanistic and reaction pathway insights for oxidative coupling of methane (OCM) over supported Na2WO4/SiO2 catalysts. Angew. Chem. Int. Ed. 60, 21502–21511 (2021)
Y. Chen, X. Mu, X. Luo, K. Shi, G. Yang, T. Wu, Catalytic conversion of methane at low temperatures: a critical review. Energ. Technol. 8, 1900750 (2020)
L. Hu, D. Pinto, A. Urakawa, Catalytic oxidative coupling of methane: heterogeneous or homogeneous reaction? ACS Sustain. Chem. Eng. (2023). https://doi.org/10.1021/acssuschemeng.3c02088
B.L. Farrell, S. Linic, Oxidative coupling of methane over mixed oxide catalysts designed for solid oxide membrane reactors. Catal. Sci. Technol. 6, 4370–4376 (2016)
S. Pak, P. Qiu, J.H. Lunsford, Elementary reactions in the oxidative coupling of methane over Mn/Na2WO4/SiO2 and Mn/Na2WO4/MgO catalysts. J. Catal. 179, 222–230 (1998)
S. Arndt, T. Otremba, U. Simon, M. Yildiz, H. Schubert, R. Schomäcker, Mn–Na2WO4/SiO2 as catalyst for the oxidative coupling of methane. What is really known? Appl. Catal. A Gen. 425, 53–61 (2012)
S. Arndt, G. Laugel, S. Levchenko, R. Horn, M. Baerns, M. Scheffler et al., A critical assessment of Li/MgO-based catalysts for the oxidative coupling of methane. Catal. Rev. 53, 424–514 (2011)
T.W. Elkins, H.E. Hagelin-Weaver, Characterization of Mn–Na2WO4/SiO2 and Mn–Na2WO4/MgO catalysts for the oxidative coupling of methane. Appl. Catal. A: Gen. 497, 96–106 (2015)
V. Jodaian, M. Mirzaei, Ce–promoted Na2WO4/TiO2 catalysts for the oxidative coupling of methane. Inorg. Chem. Commun. 100, 97–100 (2019)
P. Wang, G. Zhao, Y. Liu, Y. Lu, TiO2-doped Mn2O3-Na2WO4/SiO2 catalyst for oxidative coupling of methane: solution combustion synthesis and MnTiO3-dependent low-temperature activity improvement. Appl. Catal. A: Gen. 544, 77–83 (2017)
P. Kidamorn, W. Tiyatha, T. Chukeaw, C. Niamnuy, M. Chareonpanich, H. Sohn et al., Synthesis of value-added chemicals via oxidative coupling of methanes over Na2WO4–TiO2–MnOx/SiO2 catalysts with alkali or alkali earth oxide additives. ACS Omega 5, 13612–13620 (2020)
G.J. Kim, J.T. Ausenbaugh, H.T. Hwang, Effect of TiO2 on the performance of Mn/Na2WO4 catalysts in oxidative coupling of methane. Ind. Eng. Chem. Res. 60, 3914–3921 (2021)
B.M. Sollier, M. Bonne, N. Khenoussi, L. Michelin, E.E. Miró, L.E. Gómez et al., Synthesis and characterization of electrospun nanofibers of Sr-La-Ce oxides as catalysts for the oxidative coupling of methane. Ind. Eng. Chem. Res. 59, 11419–11430 (2020)
V.J. Ferreira, P. Tavares, J.L. Figueiredo, J.L. Faria, Effect of Mg, Ca, and Sr on CeO2 based catalysts for the oxidative coupling of methane: investigation on the oxygen species responsible for catalytic performance. Ind. Eng. Chem. Res. 51, 10535–10541 (2012)
F. Cheng, J. Yang, L. Yan, J. Zhao, H. Zhao, H. Song et al., Effect of calcination temperature on the characteristics and performance of solid acid WO3/TiO2-supported lithium–manganese catalysts for the oxidative coupling of methane. Eur. J. Inorg. Chem. 2019, 1236–1242 (2019)
W. Tiyatha, T. Chukeaw, S. Sringam, T. Witoon, M. Chareonpanich, G. Rupprechter et al., Oxidative coupling of methane—comparisons of MnTiO3–Na2WO4 and MnOx–TiO2–Na2WO4 catalysts on different silica supports. Sci. Rep. 12, 2595 (2022)
S. Ganeshan, P. Ramasundari, A. Elangovan, G. Arivazhagan, R. Vijayalakshmi, Synthesis and characterization of MnO2 nanoparticles: study of structural and optical properties. Int. J. Sci. Res. Phys. Appl. Sci. 5, 5–8 (2017)
F. Soleimani, M. Salehi, A. Gholizadeh, Comparing catalytic activity of MgMnO3 and SrMnO3 nanocatalyst for synthesis of polyhydroquinoline and new derivatives via Hantzsch reaction. Iran. J. Sci. Technol. Trans. A Sci. 44(4), 1011–1023 (2020)
B. Yan, L. Lin, J. Wu, F. Lei, Photoluminescence of rare earth phosphors Na0.5Gd0.5WO 4: RE3+ and Na0.5Gd0.5(Mo0.75W0.25)O4: RE3+ (RE= Eu, Sm, Dy). J. Fluoresc. 21, 203–211 (2011)
F. Esteban-Betegón, C. Zaldo, C. Cascales, Hydrothermal Yb3+-doped NaGd(WO4)2 nano-and micrometer-sized crystals with preserved photoluminescence properties. Chem. Mater. 22, 2315–2324 (2010)
G. Rajakumar, A.A. Rahuman, S.M. Roopan, V.G. Khanna, G. Elango, C. Kamaraj et al., Fungus-mediated biosynthesis and characterization of TiO2 nanoparticles and their activity against pathogenic bacteria. Spectrochim. Acta Part A Mol. Biomol. Spectrosc. 91, 23–29 (2012)
M. Zhao, S. Ke, H. Wu, W. Xia, H. Wan, Flower-like Sr-La2O3 microspheres with hierarchically porous structures for oxidative coupling of methane. Ind. Eng. Chem. Res. 58, 22847–22856 (2019)
D.D. Petrolini, F.F. Marcos, A.F. Lucrédio, V.R. Mastelaro, J.M. Assaf, E.M. Assaf, Exploiting oxidative coupling of methane performed over La2(Ce1–xMgx)2O7−δ catalysts with disordered defective cubic fluorite structure. Catal. Sci. Technol. 11, 4471–4481 (2021)
Y. Gambo, A. Jalil, S. Triwahyono, A. Abdulrasheed, Recent advances and future prospect in catalysts for oxidative coupling of methane to ethylene: a review. J. Ind. Eng. Chem. 59, 218–229 (2018)
P. Wang, G. Zhao, Y. Wang, Y. Lu, MnTiO3-driven low-temperature oxidative coupling of methane over TiO2-doped Mn2O3-Na2WO4/SiO2 catalyst. Sci. Adv. 3, e1603180 (2017)
S. Gu, H.-S. Oh, J.-W. Choi, D.J. Suh, J. Jae, J. Choi et al., Effects of metal or metal oxide additives on oxidative coupling of methane using Na2WO4/SiO2 catalysts: reducibility of metal additives to manipulate the catalytic activity. Appl. Catal. A Gen. 562, 114–119 (2018)
J. Wu, S. Li, J. Niu, X. Fang, Mechanistic study of oxidative coupling of methane over Mn2O3 Na2WO4SiO2 catalyst. Appl. Catal. A Gen. 124, 9–18 (1995)
Z-c. Jiang, H. Gong, S-b. Li. Methane activation over Mn2O3-Na2WO4/SiO2 catalyst and oxygen spillover. in Studies in Surface Science and Catalysis: Elsevier pp. 481–490 (1997)
Acknowledgements
The authors of this work appreciate the financial support of the Ferdowsi University of Mashhad Research Council, Mashhad, Iran (Grant No. 3/57039) and (OCM project No.23346).
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflicts of interest
There are no conflicts of interest to declare.
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Moradkhani, F., Nakhaei Pour, A. & Salimi, A. Mn-Na2WO4-Ce/TiO2 catalyst promoted with Mg and Sr in the oxidative coupling of methane. J IRAN CHEM SOC 20, 2757–2766 (2023). https://doi.org/10.1007/s13738-023-02873-z
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s13738-023-02873-z