Abstract
The feasibility of converting biomass into bio-oil and the effect of an alkaline treatment during biomass liquefaction was studied. Sweet sorghum bagasse (SSB) was treated with NaOH concentrations of 0.5, 1.0, 3.0 and 6.0 M. The experiments were conducted in a temperature range of 260–320 °C in N2. The results showed that the alkaline treatment affected the product distribution of SSB liquefaction. The highest yield of bio-oil (53.2 wt%) and phenols extracted (≈ 40.0 wt%) were obtained at 320 °C and NaOH aqueous solution of 3.0 M. The ATR-FTIR results indicated the presence of carboxyl, ketone, ester and aromatic ring structures in the bio-oils. The absorption intensities of all the bio-oils at 1100 cm−1 (primary alcohols) substantially decreased with an increase in temperature and NaOH concentration. At given reaction temperature, the use of 3.0 and 6.0 M NaOH resulted in the extraction of more identifiable phenol derivatives than were obtained with the lower concentrations of NaOH. These results suggest that a temperature of 320 °C and a NaOH concentration of 3.0 M yields the best results among the temperatures and concentrations tested, and also that alkaline treatment is feasible for liquefaction and extraction of phenols from the bio-oil.
Graphic Abstract
Similar content being viewed by others
References
Czernik, S., Bridgewater, A.V.: Overview of applications of biomass fast pyrolysis oil. Energy Fuels 18, 590–598 (2004)
Mohan, D., Pittman, C.U., Steele, P.H.: Pyrolysis of wood/biomass for bio-oil: a critical review. Energy Fuels 20, 848–889 (2006)
Bridgwater, A.V.: Review of fast pyrolysis of biomass and product upgrading. Biomass Bioenergy 38, 68–94 (2012)
Kim, T.H.: Pretreatment of lignocellulosic biomass. In: Yang, S.T., El-Enhasy, H.A., Thingchul, N., Martin, Y. (eds.) Bioprocessing Technologies in Integrated Biorefinery for Production of Biofuels. Biochemicals, and Biopolymers from Biomass, pp. 91–109. Wiley, New York (2013)
Amen-Chen, C., Pakdel, H., Roy, C.: Production of monomeric phenol by thermodynamical conversion of biomass: a review. Biores. Technol. 79, 227–299 (2001)
Chornet, E., Overend, R.P.: Fundamentals of Thermochemical Biomass Conversion. Elsevier, New York (1985)
Demirbas, A.: Current technologies for the thermos-conversion of biomass into fuels and chemicals. Energy Sources 26, 715–730 (2004)
Akhtar, J., Amin, N.A.S.: A review on process conditions for optimum bio-oil yield in hydrothermal liquefaction o biomass. Renew. Sustain. Energy Rev. 15, 1615–1624 (2011)
Yan, X., Ma, J., Wang, W., Zhao, Y., Zhou, J.: The effect of different catalysts and process parameters on the chemical content of bio-oils from hydrothermal liquefaction of sugarcane bagasse. BioResources 13, 997–1018 (2018)
Gollakota, A.R.K., Kishore, N.: A review on hydrothermal liquefaction of biomass. Renew. Sustain. Energy Rev. 81, 1378–1392 (2018)
Liu, Z., Zhang, F.-S.: Effects of various solvents on the liquefaction of biomass to produce fuels and chemicals feedstocks. Energy Convers. Manag. 49, 3498–3504 (2008)
Yip, J., Chen, M., Szeto, Y.S., Yan, S.: Comparative study of liquefaction process and liquefied products from bamboo using different organic solvents. Biores. Technol. 100, 6674–6678 (2009)
Karagoz, S., Bhaskar, T., Muto, A., Sakata, Y., Oshiki, T., Kishimoto, T.: Low-temperature catalytic hydrothermal treatment of wood biomass: analysis of liquid products. Chem. Eng. J. 108, 127–137 (2005)
Karagoz, S., Bhaskar, T., Muto, A., Sakata, Y., Uddin, M.A.: Low-temperature hydro-thermal treatment of biomass: effect of reaction parameters on products and boiling point distributions. Energy Fuels 18, 234–241 (2004)
Karagoz, S., Bhaskar, T., Muto, A., Sakata, Y.: Catalytic hydrothermal treatment of pine wood biomass: effect of RbOH and CsOH on product distribution. J. Chem. Technol. Biotechnol. 80, 1097–1102 (2005)
Kumar, S. (2010): Hydrothermal treatment for biofuels: lignocellulosic biomass to bioethanol, biocrude, and biochar, Ph.D. Dissertation, Auburn University, Auburn, AL
Ju, Y.-H., Huynh, L.-H., Kasim, N.S., Guo, T.-J., Wang, J.-H., Fazary, A.E.: Analysis of soluble and insoluble fractions of alkali and subcritical water treated sugarcane bagasse. Carbohyd. Polym. 83, 591–599 (2011)
Singh, S.P., Chouhan, A.P.: Experimental studies on enhancement of bio-oil production using agro waste materials pre-treated with alkaline solutions. Afr. J. Basic Appl. Sci. 6, 19–24 (2014)
Li, Z., Cao, J., Huang, K., Hong, Y., Li, C., Zhou, X., Xie, N., Lai, F., Shen, F., Chen, C.: Alkaline pretreatment and the synergic effect of water and tetralin enhances the liquefaction efficiency of bagasse. Biores. Technol. 177, 159–168 (2015)
Li, X., Ye, J., Chen, J., Yu, J., Ding, M., Hong, J.: Dissolution of wheat straw with aqueous NaOH/urea solution. Fibers Polym. 16, 2368–2374 (2015)
Janker-Obermeier, I., Sieber, V., Faulstich, M., Schieder, D.: Solubilization of hemicellulose and lignin from wheat straw through microwave-assisted alkali treatment. Ind. Crop. Prod. 39, 198–203 (2012)
Wang, Y.: Cellulose fiber dissolution in sodium hydroxide solution at low temperature: Dissolution kinetics and solubility improvement. Thesis, PhD in the Department of Chemical and Biomolecular Engineering, Georgia Institute of Technology (2008)
Kim, J.S., Lee, Y.Y., Kim, T.H.: A review on alkaline pretreatment technology for bioconversion of lignocellulosic biomass. Biores. Technol. 199, 42–48 (2016)
Fan, L.T., Lee, Y.H., Gharpuray, M.M.: The nature of lignocellulosics and their pretreatments for enzymatic hydrolysis. Adv. Biochem. Eng. 23, 157–187 (1982)
Isogai, A., Atalla, R.H.: Dissolution of cellulose in aqueous NaOH solutions. Cellulose 5, 309–319 (1998)
Sorghum Production. https://www.arc.agric.za/arc-gci/Fact%20Sheets%20Library/Sorghum%20Production.pdf. Accessed 14 Oct 2019.
Wright, M., Lima, I., Bigner, R.: Stability and use of sweet sorghum bagasse. Sugar Tech 19, 451–457 (2017)
Kiebler, M.W. (1945) The action of solvents on coal. In: Lowry H.H. (ed) Chemistry of Coal Utilization, Chap. 19. Wiley, New York
Berkowitz, N.: The Chemistry of Coal, Chap. 6. Elsevier, Amsterdam (1985)
Griffith, J.M., Clifford, C.E.B., Rudnick, L.R., Schobert, H.H.: Solvent extraction of bituminous coals using light cycle oil: characterization of diaromatic products in liquids. Energy Fuels 23, 4553–4561 (2009)
British Stainless Steel Association. Selection of stainless steels for handling sodium hydroxide. https://www.bssa.org.uk/topics.php?article=34. Accessed 14 Oct 2019
Qu, Y., Wei, X., Zhong, C.: Experimental study on the direct liquefaction of Cunninghamia lanceolata in water. Energy 28, 597–606 (2003)
Boocock, D.G.B., Sherman, K.M.: Further aspects of powdered poplar wood liquefaction by aqueous pyrolysis. Can. J. Chem. Eng. 63, 627–633 (2009)
Speight, J.G.: Handbook of petroleum product analysis, 2nd edn. Wiley, Hoboken (2015)
Mafu, L.D., Neomagus, H.W.J.P., Everson, R.C., Carrier, M., Strydom, C.A., Bunt, J.R.: Structural and chemical modifications of typical South African biomasses during torrefaction. Bioresour. Technol. 202, 192–197 (2016)
Patel, R.N., Bandyopadhyay, S., Ganesh, A.: Extraction of cardinal and phenol from bio-oils obtained through vacuum pyrolysis of biomass using supercritical fluid extraction. Energy 36, 1535–1542 (2011)
Li, J., Wang, C., Yang, Z.: Production and separation of phenols from biomass-derived bio-petroleum. J. Anal. Appl. Pyrol. 89, 218–224 (2010)
Protić, M., Miltojević, A., Raos, M., Đorđević, A., Golubović, T., Vukadinović, A.: Thermogravimetric analysis of biomass and sub-bituminous coal. VIII International Conference Industrial Engineering and Environmental Protection: (IIZS 2018) October 11–12th. Zrenjanin, Serbia (2018)
Varma, A.K., Mondal, P.: Physical characterization and pyrolysis kinetic study of sugarcane bafasse using thermogravimetric analysis. J. Energy Resour. Technol. 138, 52205 (2016)
Mantilla, S.V., Manrique, A.M., Gauther-Maradei, P.: Methodology for extraction of phenolic compounds of bio-oil from agricultural biomass wastes. Waste Biomass Valoriz. 6, 371–383 (2015)
Drummond, A.R.F., Drummond, I.W.: Pyrolysis of sugarcane bagasse in a wire mesh reactor. Ind. Eng. Chem. Res. 35, 1263–1268 (1996)
Bridgwater, A.V.: Principles and practice of biomass fast pyrolysis process for liquids. J. Anal. Appl. Pyrol. 51, 3–22 (1999)
Karagoz, S., Bhaskar, T., Muto, A., Sakata, Y.: Hydrothermal upgrading of biomass: effect of K2CO3 concentration and biomass/water ratio on products distribution. Bioresour. Technol. 97, 90–98 (2006)
Zhou, D., Zhang, L., Zhang, S., Fu, H., Chen, J.: Hydrothermal liquefaction of Macroalgae Enteromorpha prolifera to bio-oil. Energy Fuels 24, 4054–4061 (2010)
Pidtasang, B., Udomsap, P., Sukkasi, S., Chollacoop, N., Pattiya, A.: Influence of alcohol addition on properties of bio-oil produced from fast pyrolysis of eucalyptus bark in a free-fall reactor. J. Ind. Eng. Chem. 19, 1851–1857 (2013)
Lai, Y.Z.: Chemical degradation. In: Hon, D.N.S., Shiraishi, N., (eds.) Wood and Cellulosic Chemistry, Chap. 10. Marcel Dekker Inc, New York (1991)
Lai, Y.Z., Ontto, D.E.: Effects of alkalinity on endwise depolymerization of hydrocellulose. J. Appl. Polym. Sci. 23, 3219–3225 (1979)
Lai, Y.Z.: Kinetic evidence of anionic intermediates in the base-catalyzed cleavage of glycosidic bonds in the methyl D-glucopyranosides. Carbohydr. Res. 24, 57–65 (1972)
Lai, Y.Z., Ontto, D.E.: Kinetics of base-catalyzed degradation of phenyl d-gluco-pyranosides. Carbohydr. Res. 75, 51–59 (1979)
Wang, Y., Wang, H., Lin, H., Zheng, Y., Zhao, J., Pelletier, A., Li, K.: Effects of solvents and catalysts in liquefaction of pinewood sawdust for the production of bio-oils. Biomass Bioenergy 59, 158–167 (2013)
Fan, S.P., Zakaria, S., Chia, C.H., Jamaluddin, F., Nabihah, S., Liew, T.K., Pua, F.L.: Comparative studies of products obtained from solvolysis liquefaction of oil palm empty fruit bunch fibres using different solvents. Bioresour. Technol. 102, 3521–3526 (2011)
Agrawalla, A., Kumar, S., Singh, R.K.: Pyrolysis of groundnut de-oiled cake and characterization of the liquid product. Bioresour. Technol. 102, 10711–10716 (2011)
Bagewadi, Z.K., Mulla, L.S., Ninnekar, H.Z.: Purification and characterisation of endo β-1,4-D-glucanase from Trichoderma harzianum strain HZN11 and its application in production of bioethanol from sweet sorghum bagasse. 3 Biotech 6, 101 (2016)
Singh, R., Balagurumurthy, B., Prakash, A., Bhaskar, T.: Catalytic hydrothermal liquefaction of water hyacinth. Bioresour. Technol. 178, 157–165 (2015)
Yu, Y., Lou, X., Wu, H.: Some recent advances in hydrolysis of biomass in hot-compressed water and its comparisons with other hydrolysis methods. Energy Fuels 22, 46–60 (2008)
Amen-Chen, C., Pakdel, H., Roy, C.: Separation of phenols from Eucalyptus wood tar. Biomass Bioenergy 13, 25–37 (1997)
Won, K.W., Prausnitz, J.M.: Distribution of phenolic solutes between water and polar organic solvents. J. Chem. Thermodyn. 7, 661–670 (1975)
Lo, T.C., Baird, M.H., Hanson, C.: Handbook of solvent extraction, Chap. 18.5, 21, 23. Wiley, New York (1983)
Zilnik, L.F., Jazbinsek, A.: Recovery of renewable phenolic fraction from pyrolysis oil. Sep. Purif. Technol. 86, 157–170 (2012)
Newbury, D.E., Ritchie, N.W.M.: Is scanning electron microscopy/energy dispersive X-ray spectrometry (SEM/EDS) quantitative? Scanning 35, 141–168 (2013)
Munir, S., Daood, S.S., Nimmo, W., Cunliffe, A.M., Gibbs, B.M.: Thermal analysis and devolatilisation kinetics of cotton stalk, sugarcane bagasse and shea meal under nitrogen and air atmospheres. Biores. Technol. 100, 1413–1418 (2009)
Cunha, J.A., Pereira, M.M., Valente, L.M.M., de Piscina, P.R., Homs, N., Santos, M.R.L.: Waste biomass to liquids: low temperature conversion of sugarcane bagasse to bio-oil. The effect of combined hydrolysis treatments. Biomass Bioenergy 35, 2106–2116 (2011)
Acknowledgements
The authors thank Dr. Roelf Venter for GC–MS analysis, and Dr. Nemera Shargie from the Agricultural Research Council, Grain Crops Institute, for the supply of sweet sorghum bagasse. The work presented in this paper is based on research financially supported by the South African Research Chairs Initiative of the Department of Science and Technology and National Research Foundation of South Africa (Coal Research Chair Grant No. 86880, UID115228, Grant No. TP1208137225). Any opinion, finding, conclusion, or recommendation expressed in this material is that of the authors(s), and the NRF does not accept any liability in this regard.
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
The authors declare no conflict of interest.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Sehume, T.Z., Strydom, C.A., Bunt, J.R. et al. Bio-oil Production from Sweet Sorghum Bagasse Via Liquefaction Using Alkaline Solutions and Identification of Phenolic Products. Waste Biomass Valor 11, 3593–3607 (2020). https://doi.org/10.1007/s12649-019-00893-6
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12649-019-00893-6