Abstract
The microstructures and textures of four rectangular extruded Mg alloys, Mg–3Gd, Mg–3Nd, Mg–1Gd–1Nd and Mg–1.5Gd–1.5Nd (all in wt%) were investigated by using optical microscopy (OM), X-ray diffraction (XRD) and electron backscatter diffraction (EBSD). The results demonstrate that the extruded alloys all reveal fully recrystallized microstructure and weak non-basal texture. For textures of the four extruded alloys, it is shown that the basal planes of majority grains tilt away from the sheet plane normal toward the extrusion direction. Compared with two binary alloys, the ternary alloys possess weaker texture strengths. Through orientation distribution function analysis, two types of rare earth textures, {01\(\bar{1}\)3} <0\(\bar{2}\)23> and {\(\bar{1}\)2\(\bar{1}\)5} <1\(\bar{2}\)13>, were found in the extruded alloys. Texture component {\(\bar{1}\)2\(\bar{1}\)5} <1\(\bar{2}\)13> is relatively weak, but it plays a critical role in the low texture intensities of two ternary alloys. A pairing effect of Gd and Nd elements has an influence on the texture modification. Additionally, there is a difference in the sensitivities of experimental parameters between the microstructure and texture.
Similar content being viewed by others
References
Yang Y, Zhang K, Li XG, Li YJ, Ma ML, Shi GL, Yuan JW. Microstructure and phase transformation of as-cast and annealed Mg–4Zn–1Y alloy containing quasi-crystal phase. Rare Met. 2015;34(4):239.
Zeng ZR, Zhu YM, Xu SW, Bian MZ, Davies CHJ, Birbilis N, Nie JF. Texture evolution during static recrystallization of cold-rolled magnesium alloys. Acta Mater. 2016;105(1):479.
Stanford N, Barnett MR. The origin of “rare earth” texture development in extruded Mg-based alloys and its effect on tensile ductility. Mater Sci Eng, A. 2008;496(1):399.
Stanford N, Barnett MR. Effect of composition on the texture and deformation behaviour of wrought Mg alloys. Scr Mater. 2008;58(3):179.
Stanford N. Micro-alloying Mg with Y, Ce, Gd and La for texture modification—a comparative study. Mater Sci Eng, A. 2010;527(10–11):2669.
Lentz M, Nissen J, Fahrenson C, Vogel SC, Reimers W. Macro- and microtexture evolution of an extruded Mg–Mn–Ce alloy during annealing. Mater Sci Eng, A. 2016;655(1):17.
Jung IH, Sanjari M, Kim J, Yue S. Role of RE in the deformation and recrystallization of Mg alloy and a new alloy design concept for Mg–RE alloys. Scr Mater. 2015;102(1):1.
Al-Samman T, Li X. Sheet texture modification in magnesium-based alloys by selective rare earth alloying. Mater Sci Eng, A. 2011;528(10–11):3809.
Hantzsche K, Bohlen J, Wendt J, Kainer KU, Yi SB, Letzig D. Effect of rare earth additions on microstructure and texture development of magnesium alloy sheets. Scr Mater. 2010;63(7):725.
Mackenzie LWF, Pekguleryuz MO. The recrystallization and texture of magnesium–zinc–cerium alloys. Scr Mater. 2008;59(6):665.
Ball EA, Prangnell PB. Tensile-compressive yield asymmetries in high strength wrought magnesium alloys. Scr Metall Mater. 1994;31(2):111.
Mackenzie LWF, Davis B, Humphreys FJ, Lorimer GW. The deformation, recrystallization and texture of three magnesium alloy extrusions. Mater Sci Technol. 2007;23(23):1173.
Laser T, Hartig C, Nürnberg MR, Letzig D, Bormann R. The influence of calcium and cerium mischmetal on the microstructural evolution of Mg–3Al–1Zn during extrusion and resulting mechanical properties. Acta Mater. 2008;56(12):2791.
Bohlen J, Nurnberg MR, Senn JW, Letzig D, Agnew SR. The texture and anisotropy of magnesium–zinc–rare earth alloy sheets. Acta Mater. 2007;55(6):2101.
Basu I, Al-Samman T, Gottstein G. Shear band-related recrystallization and grain growth in two rolled magnesium-rare earth alloys. Mater Sci Eng, A. 2013;579(9):50.
Basu I, Al-Samman T. Triggering rare earth texture modification in magnesium alloys by addition of zinc and zirconium. Acta Mater. 2014;67(2):116.
Sanjari M, Farzadfar A, Kabir ASH, Utsunomiya H, Jung IH, Petrov R, Kestens L, Yue S. Promotion of texture weakening in magnesium by alloying and thermomechanical processing: (I) alloying. J Mater Sci. 2014;49(3):1408.
Stanford N, Callaghan MD, Jong BD. The effect of rare earth elements on the behaviour of magnesium-based alloys: part 1—hot deformation behavior. Mater Sci Eng, A. 2013;565(1):459.
Pan SW, Xin YC, Huang GJ, Li Q, Guo FL, Liu Q. Tailoring the texture and mechanical anisotropy of a Mg–2Zn–2Gd plate by varying the rolling path. Mater Sci Eng, A. 2016;653(1):93.
Xu DK, Li CQ, Wang BJ, Han EH. Effect of icosahedral phase on the crystallographic texture and mechanical anisotropy of duplex structured Mg–Li alloys. Mater Des. 2015;88(1):88.
Ma Q, Li B, Whittington WR, Oppedal AL, Wang PT, Horstemeyer MF. Texture evolution during dynamic recrystallization in a magnesium alloy at 450°C. Acta Mater. 2014;67(1):102.
Sarker D, Chen DL. Texture transformation in an extruded magnesium alloy under pressure. Mater Sci Eng, A. 2013;582(1):63.
Yi SB, Brokmeier HG, Letzig D. Microstructural evolution during the annealing of an extruded AZ31 magnesium alloy. J Alloys Compd. 2010;506(1):364.
Yi SB, Zaefferer S, Brokmeier HG. Mechanical behaviour and microstructural evolution of magnesium alloy AZ31 in tension at different temperatures. Mater Sci Eng, A. 2006;424(1–2):275.
Stanford N, Atwell D, Beer A, Davies C, Barnett MR. Effect of microalloying with rare-earth elements on the texture of extruded magnesium-based alloys. Scr Mater. 2008;59(7):772.
Huppmann M, Gall S, Muller S, Reimers W. Changes of the texture and the mechanical properties of the extruded Mg alloy ME21 as a function of the process parameters. Mater Sci Eng, A. 2010;528(1):342.
Stanford N. The effect of rare earth elements on the behaviour of magnesium-based alloys: part 2—recrystallisation and texture development. Mater Sci Eng, A. 2013;565(5):469.
Bohlen J, Yi S, Letzig D, Kainer KU. Effect of rare earth elements on the microstructure and texture development in magnesium–manganese alloys during extrusion. Mater Sci Eng, A. 2010;527(26):7092.
Cottam R, Robson J, Lorimer G, Davis B. Dynamic recrystallization of Mg and Mg–Y alloys: crystallographic texture development. Mater Sci Eng, A. 2008;485(1–2):375.
Hadorn JP, Hantzsche K, Yi SB, Bohlen J, Letzig D, Wollmershauser JA, Agnew SR. Role of solute in the texture modification during hot deformation of Mg-rare earth alloys. Metall Mater Trans A. 2012;43(4):1347.
Hadorn JP, Hantzsche K, Yi SB, Bohlen J, Letzig D, Agnew SR. Effects of solute and second-phase particles on the texture of Nd-containing Mg alloys. Metall Mater Trans A. 2012;43(4):1363.
Mayama T, Noda M, Chiba R, Kuroda M. Crystal plasticity analysis of texture development in magnesium alloy during extrusion. Int J Plast. 2011;27(12):1916.
Hirsch J, Al-Samman T. Superior light metals by texture engineering: optimized aluminum and magnesium alloys for automotive applications. Acta Mater. 2013;61(3):818.
Bozzolo N, Dewobroto N, Grosdidier T, Wagner F. Texture evolution during grain growth in recrystallized commercially pure titanium. Mater Sci Eng A. 2005;397(1–2):346.
Molodov DA, Bozzolo N. Observations on the effect of a magnetic field on the annealing texture and microstructure evolution in zirconium. Acta Mater. 2010;58(10):3568.
Ma Q, Li B, Marin EB, Horstemeyer SJ. Twinning-induced dynamic recrystallization in a magnesium alloy extruded at 450°C. Scr Mater. 2011;65(9):823.
Stanford N, Sha G, Xia JH, Ringer SP, Barnett MR. Solute segregation and texture modification in an extruded magnesium alloy containing gadolinium. Scr Mater. 2011;65(10):919.
Acknowledgments
This study was financially supported by the Natural Science Foundation of Jiangsu Province for Youths (No. BK20130519) and Foundation of Jiangsu University (No. 12JDG094).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Hou, XL., Zhai, YX., Zhang, P. et al. Rare earth texture analysis of rectangular extruded Mg alloys and a comparison of different alloying adding ways. Rare Met. 35, 850–857 (2016). https://doi.org/10.1007/s12598-016-0796-2
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12598-016-0796-2