Abstract
A new method based on sulfide utilizing autotrophic denitrification was adopted to remove nitrate from wastewater and to reuse spent sulfidic caustic containing high sulfide and alkalinity levels. The experiments were performed using a bench-scale upflow anoxic hybrid growth reactor (UAHGR) and an upflow anoxic suspended growth reactor (UASGR) to characterize the stoichiometric relationship between sulfur and nitrate in the process as well as the performance of the reactors. The level of nitrate removal from the UAHGR and UASGR were maintained at over 90% at a nitrate loading rate ranging from 0.15∼0.40 kgNO3 −/m3·d and no significant nitrite accumulation was observed in either reactor. Although the influent pH values were higher than the optimum range of autotrophic denitrification at 8.7∼10.1, the effluent pH was stable at 7.2∼7.9 due to the production of hydrogen ions during operation. The stoichiometric ratio of sulfate production to nitrate removal was 1.5∼2.1 mgSO4 2−/mgNO3 − in both reactors. A comparison of the reactor performance revealed that the chemical parameters of the UAHGR operation corresponded to a plug flow like type reactor while the chemical parameters of the UASGR operation corresponded to a completely stirred tank reactor like type reactor. UAHGR did not require sludge recycling due to the packed media while UASGR required 300∼700% sludge recycling. Therefore, spent sulfidic caustic could be used in the sulfur utilizing autotrophic denitrification processes as substrate and alkalinity sources.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Van Loosdrecht, M. C. M. and M. S. M. Jetten (1998) Microbiological conversions in nitrogen removal. Water Sci. Technol. 38: 1–7.
Lee, J. H., H. U. Nam, and T. J. Park (1999) Removal of nitrogen and phosphorus using a new biofilm process-INRS (Innovative Nutrient Removal System). Kor. J. Chem. Eng. 16: 303–307.
Kim, I. S. and J. H. Son (2000) Impact of COD/N/S ratio on denitrification by the mixed cultures of sulfate re ducing bacteria and sulfur denitrifying bacteria. Water Sci. Technol. 42: 69–76.
Koenig, A. and L. H. Liu (1996) Autotrophic denitrification of landfill leachate using elemental sulphur. Water Sci. Technol. 34: 469–476.
Koenig, A. and L. H. Liu (2002) Use of limestone for pH control in autotrophic denitrification: continuous flow experiments in pilot-scale packed bed reactors. J. Biotechnol. 99: 161–171.
Whitmire, S. L. and S. K. Hamilton (2005) Rapid removal of nitrate and sulfate in freshwater wetland sediments. J. Environ. Qual. 34: 2062–2071.
Flere, J. M. and T. C. Zhang (1999) Nitrate removal with sulfur-limestone autotrophic denitrification processes. J. Environ. Eng. 125: 721–729.
Kim, E. W. and J. H. Bae (2000) Alkalinity requirements and the possibility of simultaneous heterotrophic denitrification during sulfur-utilizing autotrophic denitrification. Water Sci. Technol. 42: 233–238.
Koenig, A. and L. H. Liu (2001) Kinetic model of auto trophic denitrification in sulphur packed-bed reactors. Water Res. 35: 1969–1978.
Claus, G. and H. J. Kutzner (1985) Phisiology and kinetics of autotrophic denitrification by Thiobacillus denitrificans. Appl. Microbiol. Biotechnol. 22: 283–288.
Zhang, T. C. and D. G. Lampe (1999) Sulfur:limestone autotrophic denitrification processes for treatment of nitrate-contaminated water: batch experiments. Water Res. 33: 599–608.
Wang, H. and J. Qu (2003) Combined bioelectrochemical and sulfur autotrophic denitrification for drinking water treatment. Water Res. 37: 3767–3775.
Byun, I.-G., J.-H. Ko, Y.-R. Jung, T.-H. Lee, C.-W. Kim, and T.-J. Park (2005) The feasibility of using spent sulfidic caustic as alternative sulfur and alkalinity sources in autotrophic denitrification. Kor. J. Chem. Eng. 22: 910–916.
Sipma, J., A. Svitelskaya, B. van der Mark, L. W. Hulshoff Pol, G. Lettinga, C. J. N. Buisman, and A. J. H. Janssen (2004) Potentials of biological oxidation processes for the treatment of spent sulfidic caustics containing thiols. Water Res. 38: 4331–4340.
Lim, S. J., Y. H. Ahn, E. Y. Kim, and H. N. Chang (2006) Nitrate removal in a packed bed reactor using volatile fatty acids from anaerobic acidogenesis of food wastes. Biotechnol. Bioprocess Eng. 11: 538–543.
Tran, H.-T., Y.-J. Park, M.-K. Cho, D.-J. Kim, and D.-H. Ahn (2006) Anaerobic ammonium oxidation process in an upflow anaerobic sludge blanket reactor with granular sludge selected from an anaerobic digestor. Biotechnol. Bioprocess Eng. 11: 199–204.
Batchelor, B. and A. W. Lawrence (1978) Autotrophic denitrification using elemental sulfur. J. WPCF August: 1986–2001.
Koenig, A., T. Zhang, L. H. Liu, and H. H. P. Fang (2005) Microbial community and biochemistry process in autosulfurotrophic denitrifying biofilm. Chemosphere 58: 1041–1047.
Olaniran, A. O., S. Naidoo, M. G. Masango, and B. Pillay (2007) Aerobic biodegradation of 1,2-dichloroethane and 1,3-dichloropropene by bacteria isolated from a pulp mill wastewater effluent in South Africa. Biotechnol. Bioprocess Eng. 12: 276–281.
Kim, I. S., S. Y. Kim, M. S. Kim, W. S. Park, and H. J. Jung (2004) Novel nitrogen control process dominated by autotrophic denitrifying bacteria for the treatment of municipal and industrial wastewaters. J. Kor. Soc. Water Qual. 1: 67–73.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Byun, I., Park, J. & Park, T. A new method of autotrophic denitrification with spent sulfidic caustic as substrate and alkalinity source. Biotechnol Bioproc E 13, 89–95 (2008). https://doi.org/10.1007/s12257-007-0180-z
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s12257-007-0180-z