Abstract
This study compared effects of three different valent iron (Fe0, Fe(II) and Fe(III)) on enhanced anaerobic sludge digestion, focusing on the changes of oxidation reduction potential (ORP), dissolved organic nitrogen (DON), and microbial community. Under the same iron dose in range of 0–160 mg/L after an incubation period of 30 days (d), the maximum methane production rate of sludge samples dosed with respective Fe0, Fe(II) and Fe(III) at the same concentration showed indiscernible differences at each iron dose, regardless of the different iron valence. Moreover, their behavior in changes of ORP, DON and microbial community was different: (1) the addition of Fe0 made the ORP of sludge more negative, and the addition of Fe(II) and Fe(III) made the ORP of sludge less negative. However, whether being more or less negative, the changes of ORP may show unobservable effects on methane yield when it ranged from −278.71 to −379.80 mV; (2) the degradation of dissolved organic nitrogen, particularly proteins, was less efficient in sludge samples dosed with Fe0 compared with those dosed with Fe(II) and Fe(III) after an incubation period of 30 d. At the same dose of 160 mg/L iron, more cysteine was noted in sludge samples dosed with Fe(II) (30.74 mg/L) and Fe(III) (27.92 mg/L) compared with that dosed with Fe0 (21.75 mg/L); (3) Fe0 particularly promoted the enrichment of Geobacter, and it was 6 times higher than those in sludge samples dosed with Fe(II) and Fe(III) at the same dose of 160 mg/L iron.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Buchfink B, Xie C, Huson D H (2015). Fast and sensitive protein alignment using DIAMOND. Nature Methods, 12(1): 59–60
Cai W, Liu J, Zhang X, Ng W J, Liu Y (2016). Generation of dissolved organic matter and byproducts from activated sludge during contact with sodium hypochlorite and its implications to on-line chemical cleaning in MBR. Water Research, 104(1): 44–52
Chan W, Wang J (2018). Formation of synthetic sludge as a representative tool for thermochemical conversion modelling and performance analysis of sewage sludge based on a TG-FT. Journal of Analytical and Applied Pyrolysis, 133(1): 97–106
Chen S, Dong B, Dai X, Wang H, Li N, Yang D (2019). Effects of thermal hydrolysis on the metabolism of amino acids in sewage sludge in anaerobic digestion. Waste Management, 88(1): 309–318
Chen W, Westerhoff P, Leenheer J A, Booksh K (2003). Fluorescence excitation-emission matrix regional integration to quantify spectra for dissolved organic matter. Environmental Science & Technology, 37(24): 5701–5710
Fei X, Zekkos D, Raskin L (2015). Archaeal community structure in leachate and solid waste is correlated to methane generation and volume reduction during biodegradation of municipal solid waste. Waste Management, 36(1): 184–190
Feng Y, Zhang Y, Quan X, Chen S (2014). Enhanced anaerobic digestion of waste activated sludge digestion by the addition of zero valent iron. Water Research, 52(1): 242–250
Gonzalez A, Hendriks A T W M, van Lier J B, de Kreuk M (2018). Pretreatments to enhance the biodegradability of waste activated sludge: Elucidating the rate limiting step. Biotechnology Advances, 36(5): 1434–1469
Hao X, Wei J, van Loosdrecht M C M, Cao D (2017). Analysing the mechanisms of sludge digestion enhanced by iron. Water Research, 117(1): 58–67
Huson D H, Mitra S, Ruscheweyh H J, Weber N, Schuster S C (2011). Integrative analysis of environmental sequences using MEGAN4. Genome Research, 21(9): 1552–1560
Kanehisa M, Goto S, Sato Y, Kawashima M, Furumichi M, Tanabe M (2014). Data, information, knowledge and principle: back to metabolism in KEGG. Nucleic Acids Research, 42(D1): D199–D205
Li A, Chu Y, Wang X, Ren L, Yu J, Liu X, Yan J, Zhang L, Wu S, Li S (2013). A pyrosequencing-based metagenomic study of methane-producing microbial community in solid-state biogas reactor. Biotechnology for Biofuels, 6(1): 3–17
Li Y, Achinas S, Zhao J, Geurkink B, Krooneman J, Euverink G J W (2020). Co-digestion of cow and sheep manure: Performance evaluation and relative microbial activity. Renewable Energy, 153(1): 553–563
Liang J, Zhang S, Huang J, Ye M, Yang X, Huang S, Sun S (2020). Mechanism of zero valent iron and anaerobic mesophilic digestion combined with hydrogen peroxide pretreatment to enhance sludge dewaterability: Relationship between soluble EPS and rheological behavior. Chemosphere, 247(1): 125859
Liu Y, Zhang Y, Quan X, Li Y, Zhao Z, Meng X, Chen S (2012). Optimization of anaerobic acidogenesis by adding Fe0 powder to enhance anaerobic wastewater treatment. Chemical Engineering Journal, 192(1): 179–185
Lu D, Liu X, Apul O, Zhang L, Ryan D, Zhang X (2019). Optimization of biomethane production from anaerobic co-digestion of microalgae and septic tank sludge. Biomass and Bioenergy, 127(1): 105266
Lu D, Xiao K, Chen Y, Soh Y N A, Zhou Y (2018). Transformation of dissolved organic matters produced from alkaline-ultrasonic sludge pretreatment in anaerobic digestion: From macro to micro. Water Research, 142(1): 138–146
Nazari L, Yuan Z, Santoro D, Sarathy S, Ho D, Batstone D, Xu C C, Ray M B (2017). Low-temperature thermal pre-treatment of municipal wastewater sludge: Process optimization and effects on solubilization and anaerobic degradation. Water Research, 113(1): 111–123
Nguyen D D, Chang S, Jeong S Y, Jeung J, Kim S, Guo W, Ngo H H (2016). Dry thermophilic semi-continuous anaerobic digestion of food waste: performance evaluation, modified Gompertz model analysis, and energy balance. Energy Conversion and Management, 128(1): 203–210
Paepatung N, Songkasiri W, Yasui H, Phalakornkule C (2020). Enhancing methanogenesis in fed-batch anaerobic digestion of high-strength sulfate-rich wastewater using zero valent scrap iron. Journal of Environmental Chemical Engineering, 8(6): 104508
Ping Q, Zheng M, Dai X, Li Y (2020). Metagenomic characterization of the enhanced performance of anaerobic fermentation of waste activated sludge with CaO2 addition at ambient temperature: Fatty acid biosynthesis metabolic pathway and CAZymes. Water Research, 170(1): 115309
Qin Y, Chen L, Wang T, Ren J, Cao Y, Zhou S (2019). Impacts of ferric chloride, ferrous chloride and solid retention time on the methane-producing and physicochemical characterization in high-solids sludge anaerobic digestion. Renewable Energy, 139(1): 1290–1298
Rotaru A E, Shrestha P M, Liu F, Markovaite B, Chen S, Nevin K P, Lovley D R (2014). Direct interspecies electron transfer between Geobacter metallireducens and Methanosarcina barkeri. Applied and Environmental Microbiology, 80(15): 4599–4605
Shan J, Zhao X, Sheng R, Xia Y, Ti C, Quan X, Wang S, Wei W, Yan X (2016). Dissimilatory nitrate reduction processes in typical chinese paddy soils: rates, relative contributions, and influencing factors. Environmental Science & Technology, 50(18): 9972–9980
Walsh A M, Crispie F, Claesson M J, Cotter P D (2017). Translating omics to food microbiology. Annual Review of Food Science and Technology, 8(1): 113–134
Wang R, Lv N, Li C, Cai G, Pan X, Li Y, Zhu G (2021). Novel strategy for enhancing acetic and formic acids generation in acidogenesis of anaerobic digestion via targeted adjusting environmental niches. Water Research, 193(1): 116896
Wei J, Hao X, Van Loosdrecht M C M, Li J (2018). Feasibility analysis of anaerobic digestion of excess sludge enhanced by iron: A review. Renewable & Sustainable Energy Reviews, 89(1): 16–26
Xiao K, Abbt-Braun G, Horn H (2020). Changes in the characteristics of dissolved organic matter during sludge treatment: A critical review. Water Research, 187(1): 116441
Xiao K, Chen Y, Jiang X, Yang Q, Seow W Y, Zhu W, Zhou Y (2017). Variations in physical, chemical and biological properties in relation to sludge dewaterability under Fe (II) — Oxone conditioning. Water Research, 109(1): 13–23
Xiao K, Yu Z, Pei K, Sun M, Zhu Y, Liang S, Hou H, Liu B, Hu J, Yang J (2022). Anaerobic digestion of sludge by different pretreatments: Changes of amino acids and microbial community. Frontiers of Environmental Science & Engineering, 16(2): 23
Yang Y, Yang F, Huang W, Huang W, Li F, Lei Z, Zhang Z (2018). Enhanced anaerobic digestion of ammonia-rich swine manure by zero-valent iron: With special focus on the enhancement effect on hydrogenotrophic methanogenesis activity. Bioresource Technology, 270(1): 172–179
Yu B, Zhang D, Shan A, Lou Z, Yuan H, Huang X, Yuan W, Dai X, Zhu N (2015). Methane-rich biogas production from waste-activated sludge with the addition of ferric chloride under a thermophilic anaerobic digestion system. Royal Society of Chemistry Advances, 5(48): 38538–38546
Zeng W, Li B, Wang X, Bai X, Peng Y (2016). Influence of nitrite accumulation on “Candidatus Accumulibacter” population structure and enhanced biological phosphorus removal from municipal wastewater. Chemosphere, 144(1): 1018–1025
Zhang J, Qu Y, Qi Q, Zhang P, Zhang Y, Tong Y W, He Y (2020a). The bio-chemical cycle of iron and the function induced by ZVI addition in anaerobic digestion: A review. Water Research, 186(1): 116405
Zhang Y, Frankenberger W T Jr (2007). Supplementing Bacillus sp. RS1 with Dechloromonas sp. HZ for enhancing selenate reduction in agricultural drainage water. Science of the Total Environment, 372(2–3): 397–405
Zhang Z, Guo L, Wang Y, Zhao Y, She Z, Gao M, Guo Y (2020b). Application of iron oxide (Fe3O4) nanoparticles during the two-stage anaerobic digestion with waste sludge: impact on the biogas production and the substrate metabolism. Renewable Energy, 146(1): 2724–2735
Zhou L, Gao Y, Yu K, Zhou H, De Costa Y G, Yi S, Zhuang W Q (2020). Microbial community in in-situ waste sludge anaerobic digestion with alkalization for enhancement of nutrient recovery and energy generation. Bioresource Technology, 295(1): 122277
Zhu L, Gao K, Jin J, Lin H, Xu X (2014). Analysis of ZVI corrosion products and their functions in the combined ZVI and anaerobic sludge system. Environmental Science and Pollution Research International, 21(22): 12747–12756
Acknowledgements
This study was funded by the National Natural Science Foundation of China (Grant Nos. 52170133, U1901216 and 51708239), the Natural Science Foundation of Hubei Province (No. 2020CFA042), and Applied Basic Research Program of Wuhan (No. 2020020601012277), and Program for HUST Academic Frontier Youth Team. Additionally, we would also like to thank the Analytical and Testing Center of Huazhong University of Science and Technology and the Core Facilities of Life Sciences of Huazhong University of Science and Technology for providing experimental measurements.
Author information
Authors and Affiliations
Corresponding author
Additional information
Highlights
• ORP value from −278.71 to −379.80 mV showed indiscernible effects on methane yield.
• Fe(II) and Fe(III) promoted more degradation of proteins and amino acids than Fe0.
• The highest enrichment of Geobacter was noted in samples added with Fe0.
• Cysteine was accumulated during iron enhanced anaerobic sludge digestion.
• Both iron content and valence were important for methane production.
Supporting information
11783_2021_1514_MOESM1_ESM.pdf
Comparison of different valent iron on enhanced anaerobic sludge digestion: Focusing on oxidation reduction potential, dissolved organic nitrogen and microbial community
Rights and permissions
About this article
Cite this article
Yu, Z., Xiao, K., Zhu, Y. et al. Comparison of different valent iron on anaerobic sludge digestion: Focusing on oxidation reduction potential, dissolved organic nitrogen and microbial community. Front. Environ. Sci. Eng. 16, 80 (2022). https://doi.org/10.1007/s11783-021-1514-3
Received:
Revised:
Accepted:
Published:
DOI: https://doi.org/10.1007/s11783-021-1514-3