Skip to main content
SpringerLink
Log in

Al,Fe,Ni-pillared bentonite in the catalytic wet peroxide oxidation of the textile dye Acid Yellow 99

  • Published:
Reaction Kinetics, Mechanisms and Catalysis Aims and scope Submit manuscript

Abstract

The main goal of this work was to prove that nickel containing Al,Fe pillared bentonites have enhanced catalytic properties. The chosen test system was the catalytic wet peroxide oxidation (CWPO) the Acid Yellow 99 dye (AY99) with the initial concentration of 50 mg dm−3, the amount of H2O2 that exceeded the stoichiometric one, 60 °C, magnetic stirrer, atmospheric pressure. Bentonite was successfully pillared with AlFe and AlFeNi polyoxo cations. The chemical composition of the synthesized samples was: SiO2 56.5, Al2O3 31.3, Fe2O3 9.2; SiO2 56.4, Al2O3 31.9, Fe2O3 8.9 and NiO 0.1; SiO2 61.1, Al2O3 31.3, Fe2O3 4.8 and NiO < 0.01 for AlFe10-PILC, AlFe10Ni5-PILC and AlFe5Ni5-PILC, respectively. The values of textural property parameters decreased in the following order AlFe10-PILC > AlFe10Ni5-PILC > AlFe5Ni5-PILC. Almost complete decolorization was achieved using all synthesized catalysts and followed first order kinetics. AlFe10Ni5-PILC induced the highest decolorization rate. Somewhat higher decolorization rate in the presence of AlFe10Ni5-PILC in comparison with AlFe5Ni5-PILC can probably be ascribed to one of the following properties or their combined effect: higher Fe content and more developed porous structure. Adsorption of AY99 on AlFe5Ni5-PILC and its degradation by H2O2 (without catalyst) were investigated in order for their influence on the decolorization of AY99, in comparison with that of CWPO using AlFe10Ni5-PILC, to be estimated. The adsorption was the least efficient, followed by degradation using H2O2 (without catalyst). CWPO was more efficient when compared to adsorption and degradation by H2O2 together. CWPO using Al,Fe,Ni-PILC can be regarded as promising method for degradation of azo dyes.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6

Similar content being viewed by others

References

  1. Naskar A, Majumder R (2017) Understanding the adsorption behaviour of Acid Yellow 99 on Aspergillus niger biomass. J Mol Liq 242:892–899

    Article  CAS  Google Scholar 

  2. Haji S, Khalaf M, Shukrallah M, Abdullah J, Ahmed S (2014) A kinetic comparative study of azo dye decolorization by catalytic wet peroxide oxidation using Fe–Y zeolite/H2O2 and photooxidation using UV/H2O2. Reac Kinet Mech Cat 114:795–815

    Article  Google Scholar 

  3. Antonopoulou M, Evgenidou E, Lambropoulou D, Konstantinou I (2014) A review on advanced oxidation processes for the removal of taste and odor compounds from aqueous media. Water Res 53:215–234

    Article  CAS  Google Scholar 

  4. Dewil R, Mantzavinos D, Poulios I, Rodrigo MA (2017) New perspectives for advanced oxidation processes. J Environ Manage 195:93–99

    Article  CAS  Google Scholar 

  5. Garrido-Ramírez EG, Theng BK, Mora ML (2010) Clays and oxide minerals as catalysts and nanocatalysts in Fenton-like reactions—a review. Appl Clay Sci 47:182–192

    Article  Google Scholar 

  6. Herney-Ramírez J, Madeira LM (2010) In: Gil A, Korili SA, Trujillano R, Vicence MA (eds) Pillared clays and related catalysts. Springer, New York

    Google Scholar 

  7. Tabaï A, Bechiri O, Abbessi M (2017) Study of the degradation of a toxic dye by the catalytic system (H1.5Fe1.5P2W12Mo6O61, 22H2O)/H2O2. Euro-Mediterr J Environ Integr 2:1–8

    Article  Google Scholar 

  8. Elwakeel KZ, El-Bindary AA, El-Sonbati AZ, Hawas AR (2016) Adsorption of toxic acidic dye from aqueous solution onto diethylenetriamine functionalized magnetic glycidyl methacrylate-N, N′-methylenebisacrylamide. RSC Adv 6:3350–3361

    Article  CAS  Google Scholar 

  9. Khan MMR, Ray M, Guha AK (2011) Mechanistic studies on the binding of Acid Yellow 99 on coir pith. Bioresour Technol 102:2394–2399

    Article  CAS  Google Scholar 

  10. El-Bindary AA, Hussien MA, Diab MA, Eessa AM (2014) Adsorption of Acid Yellow 99 by polyacrylonitrile/activated carbon composite: kinetics, thermodynamics and isotherm studies. J Mol Liq 197:236–242

    Article  CAS  Google Scholar 

  11. Ozcan S, Ozcan A (2008) Adsorption of Acid Yellow 99 onto DEDMA-sepiolite from aqueous solutions. Int J Environ Pollut 34:308–324

    Article  CAS  Google Scholar 

  12. Pitchaimuthu S, Subramanian R, Nagarathinam K, Ponnusamy V (2014) Enhanced photocatalytic activity of titanium dioxide by b-cyclodextrin in decoloration of Acid Yellow 99 dye. Desalin Water Treat 52:3392–3402

    Article  CAS  Google Scholar 

  13. Bahloul L, Ismail F, Samar ME, Meradi H (2014) Removal of AY99 from an aqueous solution using an emulsified liquid membrane. Application of Plackett-Burman design. Energy Proced 50:1008–1016

    Article  CAS  Google Scholar 

  14. Park C-H, Lee Y-R, Kim T-H, Lee B-H, Lee J-W, Kim S-Y (2004) Decolorization of three acid dyes by enzymes from fungal strains. J Microbiol Biotechnol 14:1190–1195

    CAS  Google Scholar 

  15. Zhang J, Hu F-T, Liu Q-Q, Zhao X, Liu S-Q (2011) Application of heterogenous catalyst of tris(1,10)-phenanthroline iron(II) loaded on zeolite for the photo-Fenton degradation of methylene blue. Reac Kinet Mech Cat 103:299–310

    Article  CAS  Google Scholar 

  16. Bouasla C, Ismail F, Samar MEH (2012) Effects of operator parameters, anions and cations on the degradation of AY99 in an aqueous solution using Fenton’s reagent. Optimization and kinetics study. Int J Ind Chem 3(15):1–11

    Google Scholar 

  17. Bokare AD, Choi W (2014) Review of iron-free Fenton-like systems for activating H2O2 in advanced oxidation processes. J Hazard Mater 275:121–135

    Article  CAS  Google Scholar 

  18. Banković P, Milutinović-Nikolić A, Mojović Z, Jović-Jovičić N, Perović M, Spasojević V, Jovanović D (2013) Synthesis and characterization of bentonites rich in beidellite with incorporated Al or Al–Fe oxide pillars. Micropor Mesopor Mater 165:247–256

    Article  Google Scholar 

  19. Bergaya F, Lagaly G (2013) Handbook of clay science, developments in clay science. Elsevier, Amsterdam

    Google Scholar 

  20. Sheldon RA, Arends IWCE, Lempers HEB (1998) Liquid phase oxidation at metal ions and complexes in constrained environments. Catal Today 41:387–407

    Article  CAS  Google Scholar 

  21. Centi G, Perathoner S (2008) Catalysis by layered materials: a review. Micropor Mesopor Mater 107:3–15

    Article  CAS  Google Scholar 

  22. Zhou S, Zhang C, Hu X, Wang Y, Xu R, Xia C, Zhang H, Song Z (2014) Catalytic wet peroxide oxidation of 4-chlorophenol over Al-Fe-, Al-Cu-, and Al-Fe-Cu-pillared clays: sensitivity, kinetics and mechanism. Appl Clay Sci 95:275–283

    Article  CAS  Google Scholar 

  23. Herney-Ramirez J, Vicente MA, Madeira LM (2010) Heterogeneous photo-Fenton oxidation with pillared clay-based catalysts for wastewater treatment: A review. Appl Catal B 98:10–26

    Article  CAS  Google Scholar 

  24. Gil A, Korili SA, Trujillano R, Vicente MA (2011) A review on characterization of pillared clays by specific techniques. Appl Clay Sci 53:97–105

    Article  CAS  Google Scholar 

  25. Timofeeva MN, Khankhasaeva ST, Talsi EP, Panchenko VN, Golovin AV, Dashinamzhilova ET, Tsybulya SV (2009) The effect of Fe/Cu ratio in the synthesis of mixed Fe, Cu, Al-clays used as catalysts in phenol peroxide oxidation. Appl Catal B 90:618–627

    Article  CAS  Google Scholar 

  26. Gao H, Zhao BX, Luo JC, Wu D, Ye W, Wang Q, Zhang XL (2014) Fe–Ni–Al pillared montmorillonite as a heterogeneous catalyst for the catalytic wet peroxide oxidation degradation of orange acid II: preparation condition and properties study. Micropor Mesopor Mater 196:208–215

    Article  CAS  Google Scholar 

  27. Mudrinić T, Mojović Z, Milutinović-Nikolić A, Banković P, Dojčinović B, Vukelić N, Jovanović D (2014) Beneficial effect of Ni in pillared bentonite based electrodes on the electrochemical oxidation of phenol. Electrochim Acta 144:92–99

    Article  Google Scholar 

  28. Jović-Jovičić N, Milutinović-Nikolić A, Žunić M, Mojović Z, Banković P, Gržetić I, Jovanović D (2013) Synergic adsorption Pb2+ and reactive dye—RB5 on two series orgamonodified bentonites. J Contam Hydrol 150:1–11

    Article  Google Scholar 

  29. Gregg SH, Sing KS (1967) Adsorption, surface area and porosity. Academic Press, New York

    Google Scholar 

  30. Rouquerol F, Rouquerol J, Sing K (1999) Adsorption by powders and porous polids. Academic Press, London

    Google Scholar 

  31. Webb PA, Orr C (1997) Analytical methods in fine particle technology. Micrometrics Instrument Corporation, Norcross

    Google Scholar 

  32. Banković P, Milutinović-Nikolić A, Mojović Z, Jović-Jovičić N, Žunić M, Dondur V, Jovanović D (2012) Al, Fe-pillared clays in catalytic decolorization of aqueous tartrazine solutions. Appl Clay Sci 58:73–78

    Article  Google Scholar 

  33. Banković P, Mojović Z, Milutinović-Nikolić A, Jović-Jovičić N, Marinović S, Jovanović D (2010) Mixed pillared bentonite for electrooxidation of phenol. Appl Clay Sci 49:84–89

    Article  Google Scholar 

  34. Mojović Z, Banković P, Milutinović-Nikolić A, Nedić B, Jovanović D (2010) Co-aluminosilicate based electrodes. Appl Clay Sci 48:179–184

    Article  Google Scholar 

  35. Lente G (2015) Deterministic kinetics in chemistry and systems biology. The dynamics of complex reaction networks. Springer, New York

    Google Scholar 

  36. Özen AS, Aviyente V, Tezcanli-Güyer G, Ince NH (2005) Experimental and modeling approach to decolorization of azo dyes by ultrasound: degradation of the hydrazone tautomer. J Phys Chem A 109:3506–3516

    Article  Google Scholar 

  37. Ju Y, Yang S, Ding Y, Sun C, Zhang A, Wang L (2008) Microwave-assisted rapid photocatalytic degradation of malachite green in TiO2 suspensions: mechanism and pathways. J Phys Chem A 112:11172–11177

    Article  CAS  Google Scholar 

  38. Lucas MS, Amaral C, Sampaio A, Peres JA, Dias AA (2006) Biodegradation of the diazo dye Reactive Black 5 by a wild isolate of Candida oleophila. Enzyme Microb Tech 39:51–55

    Article  CAS  Google Scholar 

  39. Gürses A, Açıkyıldız M, Güneş K, Gürses MS (2016) Dyes and pigments: their structure and properties. In: Dyes and Pigments. Springer, Cham

  40. Silverstein RMC, Bassler GC, Morrill TC (1991) Spectrophotometric identification of organic compounds. Wiley, New York

    Google Scholar 

  41. John Daniel (ed) (2010) IARC monographs on the evaluation of carcinogenic risks to humans, some aromatic amines, organic dyes, and related exposures, vol 99. Lyon, France, pp 55–67 https://monographs.iarc.fr/ENG/Monographs/vol99/mono99.pdf

Download references

Acknowledgement

This work was supported by the Ministry of Education, Science and Technological Development of the Republic of Serbia (Project III 45001).

Author information

Authors and Affiliations

  1. University of Belgrade - Institute of Chemistry, Technology and Metallurgy, Center for Catalysis and Chemical Engineering, Njegoševa 12, Belgrade, Serbia

    Tihana M. Mudrinić, Marija J. Ajduković, Nataša P. Jović-Jovičić, Sanja R. Marinović, Zorica D. Mojović, Aleksandra D. Milutinović-Nikolić & Predrag T. Banković

Authors
  1. Tihana M. Mudrinić
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Marija J. Ajduković
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Nataša P. Jović-Jovičić
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Sanja R. Marinović
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. Zorica D. Mojović
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. Aleksandra D. Milutinović-Nikolić
    View author publications

    You can also search for this author in PubMed Google Scholar

  7. Predrag T. Banković
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Tihana M. Mudrinić.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Mudrinić, T.M., Ajduković, M.J., Jović-Jovičić, N.P. et al. Al,Fe,Ni-pillared bentonite in the catalytic wet peroxide oxidation of the textile dye Acid Yellow 99. Reac Kinet Mech Cat 124, 75–88 (2018). https://doi.org/10.1007/s11144-018-1386-0

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s11144-018-1386-0

Keywords

Search

Navigation