Abstract
In this work, the impact of nonstoichiometric substitution of Fe3+ cations by Ni2+ ones on the structural and magnetic properties of Co0.5Ni0.5+xFe2−xO4 nanoferrites (0.0 ≤ x ≤ 0.4) synthesized by citric autocombustion method has been investigated. The single cubic phase for samples sintered at 600 °C was verified by XRD patterns and FTIR spectra. The crystallite size and microstrain were deduced using Williamson-Hall method, with the former ranging from 55 to 89 nm, in agreement with the TEM microimaging. Hysteresis loops traced via VSM prevailed a regular reduction of the saturation magnetization with Ni2+ substitution. A cation distribution has been suggested for each sample based on the experimental data of XRD, FTIR, and VSM. The suggested cation distribution successfully explained the recorded data of lattice parameter, crystallite size, IR frequencies, magnetization and coercivity. Besides the experimental data, the cation distribution supports the compensation of the nonstoichiometric substitution by the appearance of higher valance states of Fe, Ni, and Co cations.
Similar content being viewed by others
References
Z. Zhou, Y. Sun, J. Shen, J. Wei, Yu. Chao, B. Kong, W. Liu, H. Yang, S. Yang, W. Wang, Iron/iron oxide core/shell nanoparticles for magnetic targeting MRI and near-infrared photothermal therapy. Biomaterials 35, 7470–7478 (2014). https://doi.org/10.1016/j.biomaterials.2014.04.063
R. Srivastava, B.C. Yadav, Ferrite materials: introduction, synthesis techniques, and applications as sensors. Int. J. Green Nanotechnol. Biomed. 4, 141–154 (2012). https://doi.org/10.1080/19430892.2012.676918
M. Amiri, K. Eskandari, M. Salavati-Niasari, Magnetically retrievable ferrite nanoparticles in the catalysis application. Adv. Colloid Interface Sci. 271, 101982 (2019). https://doi.org/10.1016/j.cis.2019.07.003
J.H. Hankiewicz, J.A. Stoll, J. Stroud, J. Davidson, K.L. Livesey, K. Tvrdy, A. Roshko, S.E. Russek, K. Stupic, P. Bilski, R.E. Camley, Z.J. Celinski, Nano-sized ferrite particles for magnetic resonance imaging thermometry. J. Magn. Magn. Mater. 469, 550–557 (2019). https://doi.org/10.1016/j.jmmm.2018.09.037
Z.A. Gilani, M.S. Shifa, M.A. Khan, M.N. Anjum, M.N. Usmani, R. Ali, M.F. Warsi, New LiCo0.5PrxFe2−xO4 nanoferrites: prepared via low cost technique for high density storage application. Ceram. Int. 44, 1881–1885 (2018). https://doi.org/10.1016/j.ceramint.2017.10.126
V. Kashyap, S. Kurungot, Zirconium-substituted cobalt ferrite nanoparticle supported N-doped reduced graphene oxide as an efficient bifunctional electrocatalyst for rechargeable Zn-air battery. ACS Catal. 8, 3715–3726 (2018). https://doi.org/10.1021/acscatal.7b03823
A. Nigam, S.J. Pawar, Structural, magnetic, and antimicrobial properties of zinc doped magnesium ferrite for drug delivery applications. Ceram. Int. 46, 4058–4064 (2020). https://doi.org/10.1016/j.ceramint.2019.10.243
E. Petrova, D. Kotsikau, V. Pankov, A. Fahmi, Influence of synthesis methods on structural and magnetic characteristics of Mg–Zn-ferrite nanopowders. J. Magn. Magn. Mater. 473, 85–91 (2019). https://doi.org/10.1016/j.jmmm.2018.09.128
D.R. Mane, S. Patil, D.D. Birajdar, A.B. Kadam, S.E. Shirsath, R.H. Kadam, Sol-gel synthesis of Cr3+ substituted Li0.5Fe2.5O4: cation distribution, structural and magnetic properties. Mater. Chem. Phys. 126, 755–760 (2011). https://doi.org/10.1016/j.matchemphys.2010.12.048
S.T. Alone, S.E. Shirsath, R.H. Kadam, K.M. Jadhav, Chemical synthesis, structural and magnetic properties of nano-structured Co-Zn-Fe-Cr ferrite. J. Alloys Compd. 509, 5055–5060 (2011). https://doi.org/10.1016/j.jallcom.2011.02.006
M. Li, X. Liu, T. Xu, Y. Nie, H. Li, C. Zhang, Synthesis and characterization of nanosized MnZn ferrites via a modified hydrothermal method. J. Magn. Magn. Mater. 439, 228–235 (2017). https://doi.org/10.1016/j.jmmm.2017.04.015
Y. Köseoǧlu, A. Baykal, F. Gözüak, H. Kavas, Structural and magnetic properties of CoxZn1-xFe2O4 nanocrystals synthesized by microwave method. Polyhedron 28, 2887–2892 (2009). https://doi.org/10.1016/j.poly.2009.06.061
A.M. Wahba, M.B. Mohamed, Correlating cation distribution with the structural and magnetic properties of Co0.5Zn0.5AlxFe2–xO4 nanoferrites. Appl. Phys. A 126, 1–11 (2020). https://doi.org/10.1007/s00339-020-03692-2
M.H. Mahmoud, A.M. Elshahawy, S.A. Makhlouf, H.H. Hamdeh, Synthesis of highly ordered 30 nm NiFe2O4 particles by the microwave-combustion method. J. Magn. Magn. Mater. 369, 55–61 (2014). https://doi.org/10.1016/j.jmmm.2014.06.011
M.C. Dimri, H. Khanduri, P. Agarwal, J. Pahapill, R. Stern, Structural, magnetic, microwave permittivity and permeability studies of barium monoferrite (BaFe2O4). J. Magn. Magn. Mater. 486, 165278 (2019). https://doi.org/10.1016/j.jmmm.2019.165278
P. Tiwari, R. Verma, S.N. Kane, T. Tatarchuk, F. Mazaleyrat, Effect of Zn addition on structural, magnetic properties and anti-structural modeling of magnesium-nickel nano ferrites. Mater. Chem. Phys. 23, 78–86 (2019). https://doi.org/10.1016/j.matchemphys.2019.02.030
K.K. Bamzai, G. Kour, B. Kaur, S.D. Kulkarni, Effect of cation distribution on structural and magnetic properties of Dy substituted magnesium ferrite. J. Magn. Magn. Mater. 327, 159–166 (2013). https://doi.org/10.1016/j.jmmm.2012.09.013
M.A. Yousuf, S. Jabeen, M.N. Shahi, M.A. Khan, I. Shakir, M.F. Warsi, Magnetic and electrical properties of yttrium substituted manganese ferrite nanoparticles prepared via micro-emulsion route. Results Phys. 16, 102973 (2020). https://doi.org/10.1016/j.rinp.2020.102973
V. Tukaram, S.S. Shinde, R.B. Borade, A.B. Kadam, Study of cation distribution, structural and electrical properties of Al – Zn substituted Ni – Co ferrite. Phys. B 577, 411783 (2020). https://doi.org/10.1016/j.physb.2019.411783
F.H. Starsich, G.A. Sotiriou, M.C. Wurnig, C. Eberhardt, A.M. Hirt, A. Boss, S.E. Pratsinis, Pratsinis, silica-coated nonstoichiometric nano Zn-ferrites for magnetic resonance imaging and hyperthermia treatment. Adv. Healthc. Mater. 5, 2698–2706 (2016). https://doi.org/10.1002/adhm.201600725
H. Yun, J. Kim, T. Paik, L. Meng, P.S. Jo, J.M. Kikkawa, C.R. Kagan, M.G. Allen, C.B. Murray, Alternate current magnetic property characterization of nonstoichiometric zinc ferrite nanocrystals for inductor fabrication via a solution based process. J. Appl. Phys. 119, 113901 (2016). https://doi.org/10.1063/1.4942865
A. Sutka, G. Mezinskis, A. Lusis, D. Jakovlevs, Chemical Influence of iron non-stoichiometry on spinel zinc ferrite gas sensing properties. Sens. Actuators B 171, 204–209 (2012). https://doi.org/10.1016/j.snb.2012.03.012
E.E. Ateia, A.T. Mohamed, Nonstoichiometry and phase stability of Al and Cr substituted Mg ferrite nanoparticles synthesized by citrate method. J. Magn. Magn. Mater. 426, 217–224 (2017). https://doi.org/10.1016/j.jmmm.2016.11.053
R.S. Yadav, I. Kuřitka, J. Vilcakova, J. Havlica, J. Masilko, L. Kalina, J. Tkacz, V. Enev, M. Hajdúchová, Structural, magnetic, dielectric, and electrical properties of NiFe2O4 spinel ferrite nanoparticles prepared by honey-mediated sol-gel combustion. J. Phys. Chem. Solids 107, 150–161 (2017). https://doi.org/10.1016/j.jpcs.2017.04.004
Ru. Li Sun, Z.W. Zhang, Ju. Lin, E. Cao, Y. Zhang, Structural, dielectric and magnetic properties of NiFe2O4 prepared via sol–gel auto-combustion method. J. Magn. Magn. Mater. 421, 65–70 (2017). https://doi.org/10.1016/j.jmmm.2016.08.003
S. Moosavi, S. Zakaria, C.H. Chia, S. Gan, N.A. Azahari, H. Kaco, Hydrothermal synthesis, magnetic properties and characterization of CoFe2O4 nanocrystals. Ceram. Int. 43, 7889–7894 (2017). https://doi.org/10.1016/j.ceramint.2017.03.110
G.P.D. Peddis, N. Yaacoub, M. Ferretti, A. Martinelli, D.F.A. Musinu, C. Cannas, G. Navarra, J.M. Greneche, Cationic distribution and spin canting in CoFe2O4 nanoparticles. J. Phys. Condens. Matter. 23, 1–8 (2011). https://doi.org/10.1088/0953-8984/23/42/426004
A.M. Wahba, M. Bakr Mohamed, Structural and magnetic characterization and cation distribution of nanocrystalline CoxFe3-xO4 ferrites. J. Magn. Magn. Mater. 378, 246–252 (2015). https://doi.org/10.1016/j.jmmm.2014.10.164
V.K. Chakradhary, M.J. Akhtar, Absorption properties of CNF mixed cobalt nickel ferrite nanocomposite for radar and stealth applications. J. Magn. Magn. Mater. 525, 167592 (2021). https://doi.org/10.1016/j.jmmm.2020.167592
A. Lassoued, J.F. Li, Magnetic and photocatalytic properties of Ni–Co ferrites. Solid State Sci. 104, 106199 (2020). https://doi.org/10.1016/j.solidstatesciences.2020.106199
M. Hashim, S. Kumar, S.E. Shirsath, R.K. Kotnala, J. Shah, R. Kumar, Synthesis and characterizations of Ni2+ substituted cobalt ferrite nanoparticles. Mater. Chem. Phys. 139, 364–374 (2013). https://doi.org/10.1016/j.matchemphys.2012.09.019
Q. Chang, H. Liang, B. Shi, X. Li, Y. Zhang, L. Zhang, Wu. Hongjing, Ethylenediamine-assisted hydrothermal synthesis of NiCo2O4 absorber with controlled morphology and excellent absorbing performance. J. Colloid Interface Sci. 588, 336–345 (2021). https://doi.org/10.1016/j.jcis.2020.12.099
P.A. Shaikh, R.C. Kambale, A.V. Rao, Y.D. Kolekar, Structural, magnetic and electrical properties of Co-Ni-Mn ferrites synthesized by co-precipitation method. J. Alloys Compd. 492, 590–596 (2010). https://doi.org/10.1016/j.jallcom.2009.11.189
A.K. Zak, W.H.A. Majid, M.E. Abrishami, R. Youse, X-ray analysis of ZnO nanoparticles by Williamson e Hall and size e strain plot methods. Solid State Sci. 13, 251–256 (2011). https://doi.org/10.1016/j.solidstatesciences.2010.11.024
M. George, A. Mary John, S.S. Nair, P.A. Joy, M.R. Anantharaman, Finite size effects on the structural and magnetic properties of sol-gel synthesized NiFe2O4 powders. J. Magn. Magn. Mater. 302, 190–195 (2006). https://doi.org/10.1016/j.jmmm.2005.08.029
V.K. Chakradhary, A. Ansari, M.J. Akhtar, Design, synthesis, and testing of high coercivity cobalt doped nickel ferrite nanoparticles for magnetic applications. J. Magn. Magn. Mater. 469, 674–680 (2019). https://doi.org/10.1016/j.jmmm.2018.09.021
B. Ali, S.M. Tasirin, P. Aminayi, Z. Yaakob, N.T. Ali, W. Noori, Non-supported nickel-based coral sponge-like porous magnetic alloys for catalytic production of syngas and carbon bio-nanofilaments via a biogas decomposition approach. Nanomaterials 8, 1053 (2018). https://doi.org/10.3390/NANO8121053
J.M. Yang, W.J. Tsuo, F.S. Yen, Preparation of ultrafine nickel ferrite powders using mixed Ni and Fe tartrates. J. Solid State Chem. 145, 50–57 (1999). https://doi.org/10.1006/jssc.1999.8215
X. Wu, W. Chen, W. Wu, J. Wu, Q. Wang, Improvement of the magnetic moment of NiZn ferrites induced by substitution of Nd3+ ions for Fe3+ ions. J. Magn. Magn. Mater. 453, 246–253 (2018). https://doi.org/10.1016/j.jmmm.2018.01.057
M. Mozaffari, J. Amighian, E. Darsheshdar, Magnetic and structural studies of nickel-substituted cobalt ferrite nanoparticles, synthesized by the sol-gel method. J. Magn. Magn. Mater. 350, 19–22 (2014). https://doi.org/10.1016/j.jmmm.2013.08.008
A. Kuwabara, C.A.J. Fisher, Y.H. Ikuhara, H. Moriwake, H. Oki, Y. Ikuhara, The influence of charge ordering on the phase stability of spinel LiNi2O4. RSC Adv. 2, 12940–12948 (2012). https://doi.org/10.1039/c2ra21043f
C. Sujatha, K. Venugopal Reddy, K. Sowri Babu, A. Ramachandra Reddy, K.H. Rao, Effect of sintering temperature on electromagnetic properties of NiCuZn ferrite. Ceram. Int. 39, 3077–3086 (2013). https://doi.org/10.1016/j.ceramint.2012.09.087
B. Gillot, P. Tailhades, Temperature dependence of oxidation behavior and coercivity evolution in fine-grained spinel ferrites. J. Magn. Magn. Mater. 208, 181–187 (2000). https://doi.org/10.1016/S0304-8853(99)00591-0
J.S. Ghodake, R.C. Kambale, S.V. Salvi, S.R. Sawant, S.S. Suryavanshi, Electric properties of Co substituted Ni-Zn ferrites. J. Alloys Compd. 486, 830–834 (2009). https://doi.org/10.1016/j.jallcom.2009.07.075
I.H. Gul, E. Pervaiz, Comparative study of NiFe2-xAlxO4 ferrite nanoparticles synthesized by chemical co-precipitation and sol-gel combustion techniques. Mater. Res. Bull. 47, 1353–1361 (2012). https://doi.org/10.1016/j.materresbull.2012.03.005
H. Parmar, R.V. Upadhyay, S. Rayaprol, V. Siruguri, Structural and magnetic properties of nickel–zinc ferrite nanocrystalline magnetic particles prepared by microwave combustion method. Indian J. Phys. 88, 1257–1264 (2014). https://doi.org/10.1007/s12648-014-0576-5
H. Zhang, A. Chang, C. Peng, Preparation and characterization of Fe3+-doped Ni 0.9Co0.8Mn1.3−xFexO4 (0 ≤ x ≤ 0.7) negative temperature coefficient ceramic materials. Microelectron. Eng. 88, 2934–2940 (2011). https://doi.org/10.1016/j.mee.2011.04.023
K.S. Rao, G.S. Choudary, K.H. Rao, C. Sujatha, Structural and magnetic properties of ultrafine CoFe2O4 nanoparticles. Proced. Mater. Sci. 10, 19–27 (2015). https://doi.org/10.1016/j.mspro.2015.06.019
H. Du, X. Yao, L. Zhang, Structure, IR spectra and dielectric properties of Bi2O3-ZnO-SnO2-Nb2O5 quarternary pyrochlore. Ceram. Int. 28, 231–234 (2002). https://doi.org/10.1016/S0272-8842(01)00084-0
R. Tiwari, M. De, H.S. Tewari, S.K. Ghoshal, Structural and magnetic properties of tailored NiFe2O4 nanostructures synthesized using auto-combustion method. Results Phys. 16, 1–8 (2020). https://doi.org/10.1016/j.rinp.2019.102916
B.P. Barbero, J.A. Gamboa, L.E. Cadús, Synthesis and characterisation of La1-xCaxFeO3 perovskite-type oxide catalysts for total oxidation of volatile organic compounds. Appl. Catal. B 65, 21–30 (2006). https://doi.org/10.1016/j.apcatb.2005.11.018
A. Gholizadeh, The effects of A/B-site substitution on structural, redox and catalytic properties of lanthanum ferrite nanoparticles. J. Mater. Res. Technol. 8, 457–466 (2019). https://doi.org/10.1016/j.jmrt.2017.12.006
Z.K. Heiba, M.B. Mohamed, A.M. Wahba, M.I. Almalowi, Effect of vanadium doping on structural and magnetic properties of defective nano-nickel ferrite. Appl. Phys. A 124, 1–9 (2018). https://doi.org/10.1007/s00339-018-1721-3
Z. Tan, T. Saito, F. Denis Romero, M. Amano Patino, M. Goto, W.T. Chen, Y.C. Chuang, H.S. Sheu, Y. Shimakawa, Hexagonal Perovskite Ba4Fe3NiO12 containing tetravalent Fe and Ni ions. Inorg. Chem. 57, 10410–10415 (2018). https://doi.org/10.1021/acs.inorgchem.8b01618
C.D. Patel, P.N. Dhruv, S.S. Meena, C. Singh, S. Kavita, M. Ellouze, R.B. Jotania, Influence of Co4+−Ca2+ substitution on structural, microstructure, magnetic, electrical and impedance characteristics of M-type barium–strontium hexagonal ferrites. Ceram. Int. 46, 24816–24830 (2020). https://doi.org/10.1016/j.ceramint.2020.05.326
K.M. Batoo, F.A. Mir, M.S. Abd El-sadek, M. Shahabuddin, N. Ahmed, Extraordinary high dielectric constant, electrical and magnetic properties of ferrite nanoparticles at room temperature. J. Nanopart. Res. 15, 1–9 (2013). https://doi.org/10.1007/s11051-013-2067-6
I. Bhat, S. Husain, W. Khan, S.I. Patil, Effect of Zn doping on structural, magnetic and dielectric properties of LaFeO3 synthesized through sol–gel auto-combustion process. Mater. Res. Bull. 48, 4506–4512 (2013). https://doi.org/10.1016/j.materresbull.2013.07.028
L. Kumar, M. Kar, Influence of Al3+ ion concentration on the crystal structure and magnetic anisotropy of nanocrystalline spinel cobalt ferrite. J. Magn. Magn. Mater. 323, 2042–2048 (2011). https://doi.org/10.1016/j.jmmm.2011.03.010
C.N. Chinnasamy, M. Senoue, B. Jeyadevan, O. Perales-Perez, K. Shinoda, K. Tohji, Synthesis of size-controlled cobalt ferrite particles with high coercivity and squareness ratio. J. Colloid Interface Sci. 263, 80–83 (2003). https://doi.org/10.1016/S0021-9797(03)00258-3
G.F. Dionne, Electron spins in ionic molecular structures, in Magnetic interactions and spin transport. (Springer, Boston, 2003), pp. 1–130
S. Debnath, R. Das, Cobalt doping on nickel ferrite nanocrystals enhances the micro-structural and magnetic properties: Shows a correlation between them. J. Alloys Compd. 852, 156884 (2021). https://doi.org/10.1016/j.jallcom.2020.156884
Author information
Authors and Affiliations
Corresponding author
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Wahba, A.M., Moharam, B.E.M. & Mahmoud, A.F. The impact of cation distribution on the structural and magnetic properties of nonstoichiometric Co0.5Ni0.5+xFe2−xO4 nanoferrites. J Mater Sci: Mater Electron 32, 14194–14206 (2021). https://doi.org/10.1007/s10854-021-05978-4
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10854-021-05978-4