Abstract
A stable neural interface between neural electrodes and surrounding tissues is a critical point to achieve long-term signal recording stability, and flexible polymer-based neural microelectrodes are attracting growing interests due to their mechanical properties compatible to surrounding tissues and potential to minimize post-implantation injury. As a fundamental study to have an insight into the flexible polymer-based microelectrode–tissue interface in vivo, the neural microelectrode interface was investigated in vitro in neural cell culture medium. Flexible polyimide-based gold electrodes used for recording neural signals were micro fabricated and packaged to model the in vitro neural microelectrode–cell medium interface. The surface of gold recording sites of the neural microelectrode was observed using scanning electron microscopy (SEM), and island-like structure with the size of 537.4 ± 357.2 nm was visualized. To better understand biological processes that affect neural signal recording, the microelectrodes were immersed in neural cell culture medium for 9 days, and electrochemical impedance spectroscopy (EIS) measurement was carried out at each time point. Nyquist and Bode plots resulting from the EIS measurement were analyzed by fitting the experimental data with equivalent circuit models. On the basis of equivalent circuit models, physical processes occurring at the interface were described. Moreover, the mechanism for the impedance variation of recording sites in cell culture medium was discussed.
Similar content being viewed by others
References
Adhikari R, Dao B, Hodgkin J, Mardel J (2011) Synthesis, structures and membrane properties of siloxane-imide co-polymers produced by aqueous polymerization. Eur Polym J 47(6):1328–1337
Baek DH, Moon JH, Choi YY, Lee M, Choi JH, Pak JJ, Lee SH (2011) A dry release of polyimide electrodes using Kapton film and application to EEG signal measurements. Microsyst Technol 17(1):7–14
Burgos-Asperilla L, García-Alonso MC, Escudero ML, Alonso C (2010) Study of the interaction of inorganic and organic compounds of cell culture medium with a Ti surface. Acta Biomater 6(2):652–661
Chan HY, Aslam DM, Wiler JA, Casey B (2009) A novel diamond microprobe for neuro-chemical and -electrical recording in neural prosthesis. J Microelectromech S 18(3):511–521
Chapin JK, Moxon KA, Markowitz RS, Nicolelis MAL (1999) Real-time control of a robot arm using simultaneously recorded neurons in the motor cortex. Nat Neurosci 2(7):664–670
Chen YY, Lai HY, Lin SH, Cho CW, Chao WH, Liao CH, Lin SY (2009) Design and fabrication of a polyimide-based microelectrode array: application in neural recording and repeatable electrolytic lesion in rat brain. J Neurosci Meth 182(1):6–16
Chien TM, Hung WH (2014) Observation of strong plasmonic heating in Au-Fe2O3 nanocomposite. Mater Express 1(1):015009
Collinger JL, Wodlinger BD, John E, Wang W, Tyler-Kabara EC, Weber DJ, Schwartz AB (2013) High-performance neuroprosthetic control by an individual with tetraplegia. Lancet 381(9866):557–564
Demir H, Atikler U, Balköse D, Tıhmınlıoğlu F (2006) The effect of fiber surface treatments on the tensile and water sorption properties of polypropylene–luffa fiber composites. Compos Part A Appl S 37(3):447–456
Deng M, Yang X, Silke M, Qiu W, Xu M, Borghs G, Chen H (2011) Electrochemical deposition of polypyrrole/graphene oxide composite on microelectrodes towards tuning the electrochemical properties of neural probes. Sens Actuators B 158(1):176–184
Duan YY, Clark GM, Cowan RSC (2004) A study of intra-cochlear electrodes and tissue interface by electrochemical impedance methods in vivo. Biomaterials 25(17):3813–3828
El-Said WA, Lee JH, Oh BK, Choi JW (2011) Electrochemical sensor to detect neurotransmitter using gold nano-island coated ITO electrode. J Nanosci Nanotechnol 11(7):6539–6543
Franks W, Schenker I, Schmutz P, Hierlemann A (2005) Impedance characterization and modeling of electrodes for biomedical applications. IEEE Trans Biomed Eng 52(7):1295–1302
Gilletti A, Muthuswamy J (2006) Brain micromotion around implants in the rodent somatosensory cortex. J Neural Eng 3(3):189
Jung N, Kim D, Yim C, Park JY, Chang BY, Jeon S (2014) Quartz resonator for simultaneous measurement of changes in mass and electrical impedance during protein adsorption. J Electrochem Soc 161(2):B3107–B3110
Mercanzini A, Colin P, Bensadoun JC, Bertsch A, Renaud P (2009) In vivo electrical impedance spectroscopy of tissue reaction to microelectrode arrays. IEEE Trans Biomed Eng 56(7):1909–1918
Minnikanti S, Diao G, Pancrazio JJ, Xie X, Rieth L, Solzbacher F, Peixoto N (2014) Lifetime assessment of atomic-layer-deposited Al2O3–Parylene C bilayer coating for neural interfaces using accelerated age testing and electrochemical characterization. Acta Biomater 10(2):960–967
Moulton SE, Barisci JN, Bath A, Stella R, Wallace GG (2003) Investigation of protein adsorption and electrochemical behavior at a gold electrode. J Colloid Interf Sci 261(2):312–319
Mtsuko D, Avnon A, Lievonen J, Ahlskog M, Menon R (2008) Electrochemical deposition of polypyrrole nanolayers on discontinuous ultrathin gold films. Nanotechnology 19(12):125304
Paik SJ, Park Y, Cho DD (2003) Roughened polysilicon for low impedance microelectrodes in neural probes. J Micromech Microeng 13(3):373
Quan X, Fischer LM, Boisen A, Tenje M (2011) Development of nanoporous gold electrodes for electrochemical applications. Microelectron Eng 88(8):2379–2382
Rousche PJ, Normann RA (1998) Chronic recording capability of the utah intracortical electrode array in cat sensory cortex. J Neurosci Meth 82(1):1–15
Rui Y, Liu J, Wang Y, Yang C (2011) Parylene-based implantable Pt-black coated flexible 3-D hemispherical microelectrode arrays for improved neural interfaces. Microsyst Technol 17(3):437–442
Selvakumaran J, Keddie J, Ewins D, Hughes MP (2008) Protein adsorption on materials for recording sites on implantable microelectrodes. J Mater Sci Mater Med 19(1):143–151
Seymour JP, Langhals NB, Anderson DJ, Kipke DR (2011) Novel multi-sided, microelectrode arrays for implantable neural applications. Biomed Microdevices 13(3):441–451
Shanechi MM, Hu RC, Williams ZM (2014) A cortical–spinal prosthesis for targeted limb movement in paralysed primate avatars. Nat Commun 5:3237
Sillay KA, Rutecki P, Cicora K, Worrell G, Drazkowski J, Shih JJ, Sharan AD, Morrel MJ, Williams J, Wingeier B (2013) Long-term measurement of impedance in chronically implanted depth and subdural electrodes during responsive neurostimulation in humans. Brain Stimul 6(5):718–726
Sun T, Park WT, Cheng MY, An JZ, Xue RF, Tan KL, Je M (2012) Implantable polyimide cable for multichannel high-data-rate neural recording microsystems. IEEE Trans Biomed Eng 59(2):390–399
Tsang WM, Stone AL, Aldworth ZN, Hildebrand JG, Daniel TL, Akinwande AI, Voldman J (2010) Flexible split-ring electrode for insect flight biasing using multisite neural stimulation. IEEE Trans Biomed Eng 57(7):1757–1764
Tsang WM, Stone AL, Otten D, Aldworth ZN, Daniel TL, Hildebrand JG, Levine RB, Voldman J (2012) Insect-machine interface: a carbon nanotube-enhanced flexible neural probe. J Neurosci Meth 204(2):355–365
Wang LP, Wang W, Di L, Lu YN, Wang JY (2010) Protein adsorption under electrical stimulation of neural probe coated with polyaniline. J Colloid Interf Sci 80(1):72–78
Williams JC, Hippensteel JA, Dilgen J, Shain W, Kipke DR (2007) Complex impedance spectroscopy for monitoring tissue responses to inserted neural implants. J Neural Eng 4(4):410–423
Acknowledgments
The authors gratefully acknowledge staffs in the Bioelectronics Lab, Institute of Microelectronics for their generous help and valuable suggestions. This work was supported by the Science and Engineering Research Council of Agency for Science, Technology and Research (A*STAR) under Grant 1021710159, and also by Basic Science Research Program through the National Research Foundation of Korea (NRF) funded by the Ministry of Science, ICT and Future Planning (NRF-2013R1A1A1012616).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Sun, T., Tsang, W.M., Park, WT. et al. Modeling in vitro neural electrode interface in neural cell culture medium. Microsyst Technol 21, 1739–1747 (2015). https://doi.org/10.1007/s00542-014-2292-7
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s00542-014-2292-7