Abstract
This study reports the thermogravimetric analysis and microstructure characteristic of alkali-activated metakaolin cement pastes using Na2SiO3-to-NaOH ratio of 1.5. Metakaolin was used at 70, 80, 90, 95 and 100% by total mass of binder, and Portland cement (ASTM Type I) was used at 0–30% by total mass. Alkali/binder ratio of 1.5 and water curing at 23 °C was used. Thermogravimetric analysis and scanning electron micrographs showed that at 70% metakaolin the major phase found is calcium silicate hydrate (C–S–H) which is normally found in normal water-based cement paste mixes with a slight shoulder peak of N–A–S–H. At higher metakaolin content (80% and higher), sodium aluminium silicate hydrate (N–A–S–H) phase was detected as found in geopolymer, and this is the case in 100% metakaolin mix where essentially only N–A–S–H was found. The compressive strength results were found in the region of 43–48 MPa with higher strength found at higher metakaolin content. Therefore, the results of alkali-activated metakaolin cement paste mixes showed interesting change in the major phase of C–S–H to N–A–S–H depending on amount of Portland cement and metakaolin.
Similar content being viewed by others
References
Statista, Cement production globally and in the U.S. from 2010 to 2017 (in million metric tons); 2018. https://www.statista.com/statistics/219343/cement-production-worldwide/. Accessed 1 Nov 2018.
Belmokhtar N, El Ayadi H, Ammari M, Brigui J, Ben Allal L. Effect of structural and textural properties of a ceramic industrial sludge and kaolin on the hardened geopolymer properties. Appl Clay Sci. 2018;146:1–9.
Bich CH, Ambroise J, Pera J. Influence of degree of dehidroxylation on the pozzolanic activity of metakaolin. Appl Clay Sci. 2009;194:200–44.
Khan MI, Khan HU, Azizli K, Sufian S, Man Z, Siyal AA, Muhammad N, Rehman MF. The pyrolysis kinetics of the conversion of Malaysian kaolin to metakaolin. Appl Clay Sci. 2017;146:152–61.
Murat M. Hydration reaction and hardening of calcined clays and related minerals. I. Preliminary Investigation on metakaolinite. Cem Concr Res. 1983;13:259–66.
Ambroise J, Murat M, Pera J. Hydration reaction and hardening of calcined clays and related minerals. IV. Experimental conditions for strength improvement on metakaolin minicylinders. Cem Concr Res. 1985;15:83–8.
Palou M, Kuzielová E, Žemlička M, Novotný R, Másilko J. The effect of metakaolin upon the formation of ettringite in metakaolin–lime–gypsum ternary systems. J Therm Anal Calorim. 2018;133:77–86.
Malhotra VM, Mehta PK. Pozzolanic and cementitious materials. Ottawa: Gordon and Breach Publisher; 1996.
Amer AA, El-Hoseny S. Properties and performance of metakaolin pozzolanic cement pastes. J Therm Anal Calorim. 2017;129(1):33–44.
Badogiannis E, Kakali G, Tsivilis S. Metakaolin as supplementary cementitious material: optimization of kaolin to metakaolin conversion. J Therm Anal Calorim. 2005;81(2):457–62.
Love CA, Richardson IG, Brough AR. Composition and structure of C–S–H in white Portland cement-20% metakaolin pastes hydrated at 25 °C. Cem Concr Res. 2007;37(2):109–17.
Boháč M, Palou M, Novotný R, Másilko J, Šoukal F, Opravil T. Influence of temperature on early hydration of portland cement–metakaolin–slag system. J Therm Anal Calorim. 2017;127(1):309–18.
Xu MX, He Y, Liu ZH, Tong ZF, Cui XM. Preparation of geopolymer inorganic membrane and purification of pulp paper making green liquor. Appl Clay Sci. 2019;168:269–75.
Pacheco-Torgal F, Moura D, Ding Y, Jalali S. Composition, strength and workability of alkali-activated metakaolin based mortars. Constr Build Mater. 2011;25(9):3732–45.
Wang J, Xl Wu, Wang JX, Liu CZ, Lai YM, Hong ZK, Zheng JP. Hydrothermal synthesis and characterization of alkali-activated slag–fly ash–metakaolin cementitious materials. Microporous Mesoporous Mater. 2012;155:186–91.
Rashad AM. Alkali-activated metakaolin: a short guide for civil engineer—an overview. Constr Build Mater. 2013;41:751–65.
Kong DLY, Sanjayan JG, Sagoe-Crentsil K. Comparative performance of geopolymers made with metakaolin and fly ash after exposure to elevated temperatures. Cem Concr Res. 2007;37(12):1583–9.
Palomo A, Grutzeck MW, Blanco MT. Alkali-activated fly ashes: a cement for the future. Cem Concr Res. 1999;29(8):1323–9.
Duxson P, Fernández-Jiménez A, Provis JL, Lukey GC, Palomo A, Van Deventer JSJ. Geopolymer technology: the current state of the art. J Mater Sci. 2007;42(9):2917–33.
Davidovits, J. Synthesis of new high temperature geo-polymers for reinforced plastics/composites. In: SPE PACTEC’79. Society of Plastic Engineers, Brookfield Center, USA; 1979.
Davidovits J. Geopolymers—inorganic polymeric new materials. J Therm Anal Calorim. 1991;37(8):1633–56.
Chindaprasirt P, Jaturapitakkul C, Chalee W, Rattanasak U. Comparative study on the characteristics of fly ash and bottom ash geopolymers. Waste Manag. 2009;29(2):539–43.
Chindaprasirt P, Chareerat T, Sirivivatnanon V. Workability and strength of coarse high calcium fly ash geopolymer. Cem Concr Compos. 2007;29(3):224–9.
Škvára F, Kopecký L, Šmilauer V, Bittnar Z. Material and structural characterization of alkali activated low-calcium brown coal fly ash. J Hazard Mater. 2009;168(2–3):711–20.
Wianglor S, Sinthupinyo S, Piyaworapaiboon M, Chaipanich A. Effect of alkali-activated metakaolin cement on compressive strength of mortars. Appl Clay Sci. 2017;141:272–9.
Pelisser F, Guerrino EL, Menger M, Michel MD. Micromechanical characterization of metakaolin-based geopolymers. Const Build Mater. 2013;49:547–53.
Sathonsaowaphak A, Chindaprasirt P, Pimaraksa K. Workability and strength of lignite bottom ash geopolymer mortar. J Hazard Mater. 2009;168:44–50.
Pangdaeng S, Phoo-ngernkham T, Sata V, Chindaprasirt P. Influence of curing conditions on properties of high calcium fly ash geopolymer containing portland cement as additive. Mater Des. 2014;53:269–74.
García-Lodeiro I, Fernández-Jiménez A, Palomo A. Variation in hybrid cements over time. Alkaline activation of fly ash-portland cement blends. Cem Concr Res. 2013;52:112–22.
Kuzielová E, Žemlička M, Novotný R, Palou M. Simultaneous effect of silica fume, metakaolin and ground granulated blast-furnace slag on the hydration of multicomponent cementitious binders. J Therm Anal Calorim. 2019;136:1527–37.
Acknowledgements
The authors would like to thank the Thailand Research Fund (TRF) for the Research Scholar Award given to Associate Professor Dr. Arnon Chaipanich. The authors are also grateful for Master Research Grant, Research and Researcher for Industry (RRI), given to Miss Kornnika Wianglor under support from the Thailand Research Fund (TRF) and the Research and Innovation Center, SCG Cement Co., Ltd. This research work was also partially supported by Chiang Mai University.
Author information
Authors and Affiliations
Corresponding author
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Chaipanich, A., Wianglor, K., Piyaworapaiboon, M. et al. Thermogravimetric analysis and microstructure of alkali-activated metakaolin cement pastes. J Therm Anal Calorim 138, 1965–1970 (2019). https://doi.org/10.1007/s10973-019-08592-z
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s10973-019-08592-z