Skip to main content
SpringerLink
Log in

Electrolytic Deposition of Hard Chromium Coatings from Electrolyte Based on Deep Eutectic Solvent

  • Applied Electrochemistry and Metal Corrosion Protection
  • Published:
Russian Journal of Applied Chemistry Aims and scope Submit manuscript

Abstract

Deposition of chromium coatings from an electrolyte based on a deep eutectic solvent (new type of ionic fluids) was studied. The electrolyte used to deposit the coatings contained choline chloride, chromium(III) chloride, and addition of water. It was found that introduction of a certain amount of water makes it possible to raise the electrical conductivity and reduce the viscosity of the electrolyte to values acceptable for its practical application. The manner in which the electrolysis conditions affect the current efficiency for chromium deposition was determined. It was shown that uniform hard chromium coatings with good adhesion to the substrate can be deposited.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  1. Solodkova, L.N. and Kudryavtsev, V.N., Elektroliticheskoe khromirovanie (Electrolytic Chromium Plating), Moscow: Globus, 2007.

    Google Scholar 

  2. Zeng, Z., Liang, A., and Zhang, J., Recent Pat. Mater. Sci., 2009, vol. 2, pp. 50–57.

    Article  CAS  Google Scholar 

  3. Safonova, O.V., Vykhodtseva, L.N., Polyakov, N.A., Swarbrick, J.C., Sikora, M., Glatzel, P., and Safonov, V.A., Electrochim. Acta, 2010, vol. 56, pp. 145–153.

    Article  CAS  Google Scholar 

  4. Danilov, F.I., Protsenko, V.S., Butyrina, T.E., Krasinskii, V.A., Baskevich, A.S., Kwon, S.C., and Lee, J.Y., Prot. Met. Phys. Chem. Surf., 2011, vol. 47, pp. 598–605.

    Article  CAS  Google Scholar 

  5. Danilov, F.I., Protsenko, V.S., Gordiienko, V.O., Baskevich, A.S., and Artemchuk, V.V., Prot. Met. Phys. Chem. Surf., 2012, vol. 48, pp. 328–333.

    Article  CAS  Google Scholar 

  6. Danilov, F.I., Protsenko, V.S., Gordiienko, V.O., Baskevich, A.S., and Artemchuk, V.V., Prot. Met. Phys. Chem. Surf., 2013, vol. 49, pp. 299–303.

    Article  CAS  Google Scholar 

  7. Protsenko, V.S. and Danilov, F.I., Clean Technol. Environ. Policy, 2014, vol. 16, pp. 1201–1206.

    Article  CAS  Google Scholar 

  8. Surviliené, S., Nivinskiené, O., Cešuniené, A., and Selskis, A., J. Appl. Electrochem., 2006, vol. 36, pp. 649–654.

    Article  CAS  Google Scholar 

  9. Protsenko, V. and Danilov, F., Electrochim. Acta, 2009, vol. 54, pp. 5666–5672.

    Article  CAS  Google Scholar 

  10. Protsenko, V.S., Kityk, A.A., and Danilov, F.I., Surf. Eng. Appl. Electrochem., 2014, vol. 50, pp. 384–389.

    Article  Google Scholar 

  11. Abbott, A.P., Al-Barzinjy, A.A., Abbott, P.D., Frisch, G., Harris, R.C., Hartley, J., and Ryder, K.S., Phys. Chem. Chem. Phys., 2014, vol. 16, pp. 9047–9055.

    Article  CAS  PubMed  Google Scholar 

  12. Ferreira, E.S.C., Pereira, C.M., and Silva, A.F., J. Electroanal. Chem., 2013, vol. 707, pp. 52–58.

    Article  CAS  Google Scholar 

  13. McCalman, D.C., Sun, L., Zhang, Y., Brennecke, J.F., Maginn, E.J., and Schneider, W.F., J. Phys. Chem. B, 2015, vol. 119, pp. 6018–6023.

    Article  CAS  PubMed  Google Scholar 

  14. Sun, L. and Brennecke, J.F., Ind. Eng. Chem. Res., 2015, vol. 54, pp. 4879–4890.

    Article  CAS  Google Scholar 

  15. Zhang, J., Gu, C., Tong, Y., Gou, J., Wang, X., and Tu, J., RSC Adv., 2015, vol. 5, pp. 71268–71277.

    Article  CAS  Google Scholar 

  16. Bobrova, L.S., Danilov, F.I., and Protsenko, V.S., J. Mol. Liq., 2016, vol. 223, pp. 48–53.

    Article  CAS  Google Scholar 

  17. Abbott, A.P., Ryder, K.S., and König, U., Trans. Inst. Met. Finish., 2008, vol. 86, pp. 196–204.

    Article  CAS  Google Scholar 

  18. Smith, E.L., Abbott, A.P., and Ryder, K.S., Chem. Rev., 2014, vol. 114, pp. 11060–11082.

    Article  CAS  PubMed  Google Scholar 

  19. Abbott, A.P., Capper, G., Davies, D.L., Rasheed, R.K., and Tambyrajah, V., Chem. Commun., 2003, pp. 70–71.

    Google Scholar 

  20. Lavrukhina, A.K. and Yukina, L.V., Analiticheskaya khimiya khroma (Analytical Chemistry of Chromium), Moscow: Nauka, 1979.

    Google Scholar 

  21. Danilov, F.I., Protsenko, V.S., and Gordiienko V.O., Russ. J. Electrochem., 2013, vol. 49, pp. 475–482.

    Article  CAS  Google Scholar 

  22. Protsenko, V.S., Bobrova, L.S., and Danilov, F.I., Ionics, 2017, vol. 23, pp. 637–643.

    Article  CAS  Google Scholar 

  23. Protsenko, V.S., Kityk, A.A., Shaiderov, D.A., and Danilov, F.I., J. Mol. Liq., 2015, vol. 212, pp. 716–722.

    Article  CAS  Google Scholar 

  24. Protsenko, V.S., Bobrova, L.S., Burmistrov, K.S., and Danilov, F.I., Voprosy Khimii i Khimicheskoi Tekhnologii, 2017, no. 1, pp. 27–35.

    Google Scholar 

  25. Kwon, S.C., Kim, M., Park, S.U., Kim, D.Y., Kim, D., Nam, K.S., and Choi, Y., Surf. Coat. Technol., 2004, vol. 183, pp. 151–156.

    Article  CAS  Google Scholar 

  26. Vykhodtseva, L.N., Lubnin, E.N., Polukarov, Yu.M., and Safonov, V.A., Russ. J. Electrochem., 2005, vol. 41, pp. 919–924.

    Article  CAS  Google Scholar 

  27. Edigaryan, A.A., Safonof, V.A., Lubnin, E.N., Vykhodtseva, L.N., Chusova, G.E., and Polukarov, Yu.M., Electrochim. Acta, 2002, vol. 47, pp. 2775–2786.

    Article  CAS  Google Scholar 

  28. Protsenko, V.S., Gordiienko, V.O., and Danilov, F.I., Electrochem. Commun., 2012, vol. 17, pp. 85–87.

    Article  CAS  Google Scholar 

  29. Protsenko, V.S., Gordiienko, V.O., Danilov, F.I., and Kwon, S.C., Met. Finish., 2011, vol. 109, pp. 33–37.

    Article  CAS  Google Scholar 

  30. Protsenko, V., Gordiienko, V., Butyrina, T., Vasil’eva, E., and Danilov, F., Turk. J. Chem., 2014, vol. 38, pp. 50–55.

    Article  CAS  Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Ukrainian State University of Chemical Technology, Dnipro, Ukraine

    V. S. Protsenko, L. S. Bobrova, D. E. Golubtsov, S. A. Korniy & F. I. Danilov

  2. Karpenko Physicomechanical Institute, National Academy of Sciences of Ukraine, Lviv, Ukraine

    S. A. Korniy

Authors
  1. V. S. Protsenko
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. L. S. Bobrova
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. D. E. Golubtsov
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. S. A. Korniy
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. F. I. Danilov
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to V. S. Protsenko.

Additional information

Original Russian Text © V.S. Protsenko, L.S. Bobrova, D.E. Golubtsov, S.A. Korniy, F.I. Danilov, 2018, published in Zhurnal Prikladnoi Khimii, 2018, Vol. 91, No. 7, pp. 968−974.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Protsenko, V.S., Bobrova, L.S., Golubtsov, D.E. et al. Electrolytic Deposition of Hard Chromium Coatings from Electrolyte Based on Deep Eutectic Solvent. Russ J Appl Chem 91, 1106–1111 (2018). https://doi.org/10.1134/S1070427218070066

Download citation

  • Received:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1134/S1070427218070066

Keywords

Search

Navigation