Abstract
Thin film piezoelectric materials offer a number of advantages in microelectromechanical systems (MEMS), due to the large motions that can be generated, often with low hysteresis, the high available energy densities, as well as high sensitivity sensors with wide dynamic ranges, and low power requirements. This paper reviews the literature in this field, with an emphasis on the factors that impact the magnitude of the available piezoelectric response. For non-ferroelectric piezoelectrics such as ZnO and AlN, the importance of film orientation is discussed. The high available electrical resistivity in AlN, its compatibility with CMOS processing, and its high frequency constant make it especially attractive in resonator applications. The higher piezoelectric response available in ferroelectric films enables lower voltage operation of actuators, as well as high sensitivity sensors. Among ferroelectric films, the majority of the MEMS sensors and actuators developed have utilized lead zirconate titanate (PZT) films as the transducer. Randomly oriented PZT films show piezoelectric e 31,f coefficients of about −7 C/m2 at the morphotropic phase boundary. In PZT films, orientation, composition, grain size, defect chemistry, and mechanical boundary conditions all impact the observed piezoelectric coefficients. The highest achievable piezoelectric responses can be observed in {001} oriented rhombohedrally-distorted perovskites. For a variety of such films, e 31,f coefficients of −12 to −27 C/m2 have been reported.
Similar content being viewed by others
References
F.D. Bannon, J.R. Clark, and C.T.C. Nguyen, IEEE J. Sol. State Circuits, 35(4), 512 (2000).
L.W. Lin, R.T. Howe, and A.P. Pisano, J. MEMS, 7(3), 286 (1998).
L. Pescini, H. Lorenz, and R.H. Blick, Appl. Phys. Lett. 82(3), 352 (2003).
M.A. Abdelmoneum, M.U. Demirci, and C.T.-C. Nguyen, The Sixteenth Annual International Conference on Micro Electro Mechanical Systems, 2003. MEMS-03 Kyoto. IEEE, 698 (2003).
Y. Ito, K. Kushida, K. Sugawara, and H. Takeuchi, IEEETUFFC, 42, 316 (1995).
M.A. Dubois and P. Muralt, Appl. Phys. Lett., 74, 3032 (1999).
S.H. Kim, J.H. Kim, H.D. Park, and G.W. Yoon, J. Vac. Sci. Tech.B, 19, 1164 (2001).
M. Umeda, K. Nakamura, and S. Ueha, Jpn. J. Appl. Phys. Part 1, 36(5B), 3146 (1997).
G.W. Taylor, J.R. Burns, S.M. Kammann, W.B. Powers, and T.R. Welsh, IEEE J. Ocean. Eng., 26(2), 539 (2001).
G.K. Ottman, H.F. Hofmann, and G.A. Lesieutre, IEEE Trans. Power Electron., 18(2), 696 (2003).
P. Glynne-Jones, S.P. Beeby, and N.M. White, IEE Proc. Sci. Meas. Tech. 148(2) 68 (2001).
J.J. Bernstein, S.L. Finberg, K. Houston, L.C. Niles, H.D. Chen, L.E. Cross, K.K. Li, and K. Udayakumar, IEEE Trans. UFFC, 44, 960 (1997).
Y. Nemirovsky, A. Nemirovsky, P. Muralt, and N. Setter, Sen. and Act., A56, 239 (1996).
P. Muralt, M. Kohli, T. Maeder, A. Kolkin, K. Brooks, N. Setter, and R. Luthier, Sen. and Act., A48, 157 (1995).
P. Muralt, IEEE Trans. UFFC, 47(4), 903 (2000).
D.L. Polla and L.F. Francis, MRS Bulletin, 21(7), 59 (1996).
L.-P.Wang, K. Deng, L. Zou, R. Wolf, R.J. Davis, and S. Trolier-McKinstry, IEEE Electron Device Lett., 23, 182 (2002).
J.F. Nye, Physical Properties of Crystals: Their Representation by Tensors and Matrices(Clarendon Press, Oxford, 1979).
T. Ikeda, Fundamentals of Piezoelectricity(Oxford University Press, New York, 1996).
R.M. White and V.W. Voltmer, Appl. Phys. Lett., 17, 314 (1965).
K. Tsubouchi and N. Mikoshiba, IEEE Trans. Son. Ultrasonics, 32, 634 (1985).
H. Nakahata, H. Kitabayashi, T. Uemura, A. Hachigo, K. Higaki, S. Fujii, Y. Seki, K. Yoshida, and S. Shikata, Jpn. J. Appl. Phys. Pt 1, 372918 Sp. Iss. SI (1998).
G.F. Iriarte, J. Appl. Phys., 93, 9604 (2003).
I. Cerven, T. Lacko, I. Novotny, V. Tvarozek, and M. Harvanka, J. Cryst. Growth, 131(3/4), 546 (1993).
J.G. Smits and W.S. Choi, IEEE TUFFC, 38(3), 256 (1991).
Q. Meng, M. Mehregany, and K. Deng, J. Micromech. Microeng., 3, 18 (1993).
Ph. Luginbuhl, G.-A. Racine, Ph. Lerch, B. Romanowicz, K.G. Brooks, N.F. de Rooij, Ph. Renaud, and N. Setter, Int. Conf. Solid-State Sens. Act., Proc., 1, 413 (1995).
T. Fabula, H. Wagner, B. Schmidt, and S. Buttgenbach, Sens. Act. A, 42(1-3), 375 (1994).
F.S. Hickernell, Proc. IEEE, 64, 631 (1976).
A. Rodriguez-Navarro, W. Otano-Rivera, J.M. Garcia-Ruiz, and R. Messier, J. Mater. Res., 12, 1850 (1997).
M.A. Dubois and P. Muralt, Appl. Phys. Lett., 74(20), 3032 (1999).
F.J. Hickernell, R.X. Yue, and F.S. Hickernell, IEEE Trans. UFFC, 44, 615 (1997).
H.P. Loebl, C. Metzmacher, R.F. Milsom, P. Lok, F. van Straten, and A. Tuinhout, J. Electroceramics, forthcoming issue.
M.-A. Dubois and P. Muralt, J. Appl. Phys., 89, 6389 (2001).
A. Barker, S. Crowther, and D. Rees, Sensors & Actuators, 58, 229 (1997).
A.L. Kholkin, C. Wutchrich, D.V. Taylor, and N. Setter, Rev. Sci. Instrum., 67(5), 1935 (1996).
J.F. Shepard, Jr., P.J. Moses, and S. Trolier-McKinstry, Sens. Actuators A, 71, 133 (1998).
M.A. Dubois and P. Muralt, Sens. Act. A, 77(20), 106 (1999).
F.J. von Preissig, H. Zeng, and E.S. Kim, Smart Mater. Struct., 7, 396 (1998).
J.G. Gualtieri, J.A. Kosinski, and A. Ballato, Trans. UFFC, 41, 53 (1994).
G. Carlotti, G. Socino, A. Petri, and E. Verona, Proc. 1987 IEEE Ultrason. Symp.(Oct. 1987), p. 295.
K. Tsubouchi, K. Sugai, and N. Mikoshiba, IEEE Ultrason. Symp., Oct. 1981, p. 375.
N. Ledermann, P. Muralt, J. Baborowski, S. Gentil, K. Mukati, M. Cantoni, A. Seifert, and N. Setter, Sens. Act. A, 105, 162 (2003).
D. Peroulis, S.P. Pacheco, K. Sarabandi, and L.P.B. Katehi, IEEE Trans. Microwav. Theory Tech., 51(10), 259 (2003).
F. Xu, S. Trolier-McKinstry, W. Ren, and B. Xu, J. Appl. Phys., 89(2), 1336 (2001).
K. Saito, T. Kurosawa, T. Akai, T. Oikawa, and H. Funakubo, J. Appl. Phys., 93(1), 545 (2003).
X.H. Du, J.H. Zheng, U. Belegundu, and K. Uchino, Appl. Phys. Lett., 72(19), 2421 (1998).
S.-E. Park and T.R. Shrout, IEEE Trans. UFFC, 44, 1140 (1997).
B. Noheda, D.E. Cox, G. Shirane, R. Guo, B. Jones, and L.E. Cross, Phys. Rev. B, 63(1), 014103 (2001).
H.D. Chen, K.R. Udayakumar, C.J. Gaskey, and L.E. Cross, Appl. Phys. Lett., 67(23), 3411 (1995).
A. Seifert, N. Ledermann, S. Hiboux, J. Baborowski, P. Muralt, and N. Setter, Integr. Ferro., 35(1-4), 1889 (2001).
F. Xu, R.A. Wolf, T. Yoshimura, and S. Trolier-McKinstry, Proc. 11th Int. Symp. Electrets, 386 (2002).
R.A.Wolf and S. Trolier McKinstry, J. Appl. Phys., 95(3), 1397 (2004).
T. Haccart, C. Soyer, E. Cattan, and D. Remiens, Ferroelectrics, 254(1-4), 185 (2001).
I. Kanno, H. Kotera, K. Wasa, T. Matsunaga, T. Kamada, and R. Takayama, J. Appl. Phys., 93(7), 4091 (2003).
D.-J. Kim, J.-P. Maria, A.I. Kingon, and S.K. Streiffer, J. Appl. Phys., 93, 5568 (2003).
R.E. Eitel, C.A. Randall, T.R. Shrout, P.W. Rehrig, W. Hackenberger, and S.E. Park, Jpn. J. Appl. Phys. Part 1, 40(10), 5999 (2001).
T.R. Shrout, Private Communication (2002).
K. Kakimoto, H. Kakemoto, S. Fujita, and Y. Masuda, J. Am. Ceram. Soc., 85(4), 1019 (2002).
B.A. Tuttle, T.J. Garino, J.A. Voight, T.J. Headley, D. Dimos, and M.O. Eatough, Science and Technology of Electroceramic Thin Films, edited by O. Auciello and R. Waser, Kluwer Academic Publishers, The Netherlands, 117 (1995).
A.L. Kholkin, M.L. Calzada, P. Ramos, J. Mendiola, and N. Setter, Appl. Phys. Lett., 69, 3602 (1996).
P. Muralt, J. Micromech. Microeng., 10, 136 (2000).
K.G. Brooks, I.A. Reaney, R. Klissurska, Y. Huang, L. Bursill, and N. Setter, J. Mater. Res., 9, 2540 (1994).
S.-Y. Chen and I.-W. Chen, J. Amer. Cer. Soc., 77, 2337 (1994).
R.W. Whatmore, Q. Zhang, Z. Huang, and R.A. Dorey, Materials Science in Semiconductor Processing, 5, 65 (2003).
J.H. Park, F. Xu, and S. Trolier-McKinstry, J. Appl. Phys., 89(1), 568 (2001).
D.M. Kim, S.D. Bu, C.B. Eom, S. K. Streiffer, W. Tian, X.Q. Pan, T. Yoshimura, S. Trolier-McKinstry, D.G. Schlom, V. Nagurajan, A. Stanishev-Sky, J. Ouyang, R. Ramash, W. Tian, and X.Q. Pan, unpublished.
T. Yoshimura and S. Trolier-McKinstry, Integr. Ferroelectr., 50, 33 (2002).
A.J. Bell, J. Appl. Phys., 89(7), 3907 (2001).
Q.Q. Zhang, Q.F. Zhou, and S. Trolier-McKinstry, Appl. Phys. Lett., 80(18), 3370 (2002).
Q.F. Zhou, Q.Q. Zhang, and S. Trolier-McKinstry, J. Appl. Phys., 94(5) 3397 (2003).
Z. Zhang, J.-H. Park, and S. Trolier-McKinstry, MRS. Proc. 596 Ferroelectric Thin Films VIII, edited by R.W. Schwartz, P.C. McIntyre, Y. Miyasaka, S.R. Summerfelt, and D. Wouters, Materials Research Society, Warrendale, PA, 73, (2000).
J.P. Maria, Ph.D. Thesis, The Pennsylvania State University (1998).
J.F. Shepard Jr., S. Trolier-McKinstry, M. Hendrickson, and R. Zeto, MRS Proc. 459: Materials for Smart Systems II, 47 (1997).
N. Kim, Ph. D. Thesis, The Pennsylvania State University (1994).
F. Jona and G. Shirane, Ferroelectric Crystals(Pergamon Press, New York, 1962).
T.M. Shaw, S. Trolier-McKinstry, and P.C. McIntyre, Ann. Rev. Mater. Sci., 30, 263 (2000).
T. Yoshimura and S. Trolier-McKinstry, J. Appl. Phys., 92(7), 3979 (2002).
J. Nino, T. Yoshimura, and S. Trolier-McKinstry, J. Mat. Res.(2003), submitted.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Trolier-McKinstry, S., Muralt, P. Thin Film Piezoelectrics for MEMS. Journal of Electroceramics 12, 7–17 (2004). https://doi.org/10.1023/B:JECR.0000033998.72845.51
Issue Date:
DOI: https://doi.org/10.1023/B:JECR.0000033998.72845.51