Abstract
Microstructure evolution of a low-carbon steel with the initial microstructure of ferrite matrix plus cementite particles during hot compression deformation was investigated at the strain rates of 0.001 s−1, 0.01 s−1, and 1 s−1 at 973 K (700 °C) by means of field-emission scanning electron microscope, electron backscattered diffraction, and transmission electron microscopy. The results indicated that dynamic recrystallization (DRX) of ferrite took place at all of three strain rates, which can be classified as discontinuous DRX at 0.001 s−1, 0.01 s−1, and as continuous DRX at 1 s−1. The formation of the nuclei of DRX of ferrite was mainly ascribed to the occurrence of particle-stimulated nucleation (PSN), accompanied with the lattice rotation and the formation of new high-angle boundaries. The occurrence of PSN was dependent on the development of a subgrain in the regions with high density of dislocations around cementite particles, without the need for the formation of the deformation zone.
Similar content being viewed by others
References
G. Glover and C.M. Sellars: Metall. Trans., 1973, vol. 4, pp. 765–75.
J. Baczynski and J.J. Jonas: Metall. Mater. Trans. A, 1998, vol. 29A, pp.447–62.
N. Tsuji, Y. Matsubara, and Y. Saito: Scripta Mater., 1997, vol. 37, pp. 477–84.
F. Gao, Y.A. Xu, B. Song, and K. Xia: Metall. Mater. Trans. A, 2000, vol. 31A, no. 1, pp. 21–27.
H. Yagi, N. Tsuji, and Y. Saito: Tetsu-To-Hagané, 2000, vol. 86, pp. 349–56.
R.Z. Wang and T.C. Lei: Scripta Metall. Mater., 1994, vol. 31, pp. 1193–96.
S.V.S.N Murty, S. Torizuka, K. Nagai, T. Kitai, and Y. Kogo: Scripta Mater., 2005, vol. 52, pp. 713–18.
S.V.S.N. Murty, S. Torizuka, K. Nagai, T. Kitai, and Y. Kogo: Scripta Mater., 2005, vol. 53, pp.763–68.
Y.Z. Bao, Y. Adachi, Y. Toomine, P.G. Xu, T. Suzuki, and Y. Tomota: Scripta Mater., 2005, vol. 53, pp. 1471–76.
L.F. Li, W.Y. Yang, and Z.Q Sun: Metall. Mater. Trans. A, 2006, vol. 37A, pp. 609–19.
B. Eghbali, A. Abdollah-Zadeh, and P.D. Hodgson: Mater. Sci. Eng. A, 2007, vol. 462A, pp. 259–63.
A. Abdollah-Zadeh and B. Eghbali: Mater. Sci. Eng. A, 2007, vol. 457, pp. 219–25.
Z.Q Sun, L.F. Li, and W.Y. Yang: Mater. Sci. Forum, 2007, vols. 558–559, pp. 617–22.
N. Hansen: Memoires Sci. Rev. Metall., 1975, vol. 72, pp. 189–203.
F.J. Humphreys: Acta Metall., 1977, vol. 25, pp. 1323–44.
F.J. Humphreys: Acta Metall., 1979, vol. 27, pp. 1801–14.
J.R. Porter and F.J. Humphreys: Metall. Sci., 1979, vol. 13, pp. 83–88.
H.J. McQueen, E. Evangelista, J. Bowles, and G. Crawford: Metall. Sci., 1984, vol. 18, pp. 395–402.
F.R. Castro-Fernandez and C.M. Sellars: Mater. Sci. Tech., 1988, vol. 4, pp. 621–27.
D.T. Gawne and G.T. Higgins: J. Mater. Sci., 1971, vol. 6, pp. 403–12.
T. De Cock, C. Capdevila, F.G. Caballero, and C. Garca de Andres: Mater. Sci. Eng. A, 2009, vol. 519A, pp. 9–18.
F.J. Humphreys and M. Hatherly: Recrystallization and Related Annealing Phenomena, 2nd ed., Elsevier, New York, NY, 2004.
M.F. Ashby: Philos. Mag., 1970, vol. 21, pp. 399–424.
Acknowledgments
The financial support of The National Natural Science Foundation of China (No. 50701004) is gratefully acknowledged.
Author information
Authors and Affiliations
Corresponding author
Additional information
Manuscript submitted December 13, 2010.
Rights and permissions
About this article
Cite this article
Li, L., Yang, W. & Sun, Z. Dynamic Recrystallization of Ferrite with Particle-Stimulated Nucleation in a Low-Carbon Steel. Metall Mater Trans A 44, 2060–2069 (2013). https://doi.org/10.1007/s11661-012-1572-z
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11661-012-1572-z