Abstract
Nano brazing of Pt-Ag nanoparticles with nano Ag filler metal is reported in this letter, which presents an effective way to join nanoobjects by femtosecond laser irradiation. The nano brazed interface between Pt-Ag and Ag showed good lattice matching along (111)Ag//(111)Ag-Pt. Lattice mismatch can hardly be observed at the interface between the filler metal and Pt-Ag nanoparticle, which is important for the joint strength and normally does not occur during joining. The very low mismatch also suggested that melting and solidification occurred during nano brazing by femtosecond laser. The role of Brownian motion on the nano joining process is also discussed in this paper.
Article PDF
Similar content being viewed by others
Avoid common mistakes on your manuscript.
References
S. Guo, “The creation of nanojunctions”, Nanoscale 2(12), 2521–2529 (2010). http://dx.doi.org/10.1039/C0NR00352B
Y. Zhou and A. Hu, “From microjoining to nanojoining”, Open Surf. Sci. J. 3, 32–41 (2008).
C. Chen, Y. Lu, E. S. Kong, Y. Zhang and S. T. Lee, “Nanowelded carbon-nanotube-based solar microcells”, Small 4(9), 1313–1318 (2008). http://dx.doi.org/10.1002/smll.200701309
K. Nanda, A. Maisels, F. Kruis, H. Fissan and S. Stappert, “Higher surface energy of free nanoparticles”, Phys. Rev. Lett. 91(10), 106102–106105 (2003). http://dx.doi.org/10.1103/PhysRevLett.91.106102
S. J. Kim and D. J. Jang, “Laser-induced nanowelding of gold nanoparticles”, Appl. Phys. Lett. 86(3), 033112.1–033112.3 (2005). http://dx.doi.org/10.1063/1.1856139
H. Tohmyoh, T. Imaizumi, H. Hayashi and M. Saka,“Welding of Pt nanowires by Jouleheating”, Scr. Mater. 57(10), 953–956 (2007). http://dx.doi.org/10.1016/j.scriptamat.2007.07.018
K. Asaka, M. Karita and Y. Saito, “Joining of multiwall carbon nanotubes for the end-contact configuration by applying electric current”, Mater. Lett. 65(12), 1832–1834 (2011). http://dx.doi.org/10.1016/j.matlet.2011.03.081
Q. Yang, S. Bai, G. Wang and J. Bai, “Local recon struction and controllable nanospot welding of multiwalled carbon nanotubes under mild electron beamirradiation”, Mater. Lett. 60(20), 2433–3437. http://dx.doi.org/10.1016/j.matlet.2006.01.071
E. Ide, S. Angata, A. Hirose and K. F. Kobayashi, “Metal-metal bonding process using Ag metalloorganic nanoparticles”, Acta. Mater. 53(8), 2385–2393 (2005). http://dx.doi.org/10.1016/j.actamat.2005.01.047
S. Besner and M. Meunier, “Femtosecond laser synthesis of AuAg nanoalloys: photoinduced oxidation and ions release”, J. Phys. Chem. C 114(23), 10403–10409 (2010). http://dx.doi.org/10.1021/jp102461u
V. Amendola and M. Meneghetti, “Laser ablation synthesis in solution and size manipulation of noble metal nanoparticles”, Phys. Chem. Chem. Phys. 11(20), 3805–3821 (2009). http://dx.doi.org/10.1039/b900654k
A. V. Kabashin and M. Meunier, “Synthesis of colloidal nanoparticles during femtosecond laser ablation of gold in water”, J. Appl. Phys. 94(12), 7941–7943 (2003). http://dx.doi.org/10.1063/1.1626793
J. Zhang, J. Worley, S. Denommee, C. Kingston, Z. J. Jakubek, Y. Deslandes, M. Post, B. Simard, N. Braidy and G. A. Botton, “Synthesis of metal alloy nanoparticles in solution by laser irradiation of a metal powder suspension”, J. Phys. Chem. B 107(29), 6920–6923 (2003). http://dx.doi.org/10.1021/jp027269k
K. Torigoe, Y. Nakajima and K. Esumi, “Preparation and characterization of colloidal silverplatinumalloys”, J. Phys. Chem. 97(31), 8304–8309 (1993). http://dx.doi.org/10.1021/j100133a029
A. Hu, J. Y. Guo, H. Alarifi, G. Patane, Y. Zhou, G. Compagnini and C. X. Xu, “Low temperature sintering of Ag nanoparticles for flexible electronicspackaging”, Appl. Phys. Lett. 97, 153117–153119 (2010). http://dx.doi.org/+10.1063/1.3502604
R. Prasher, P. Bhattacharya and P. E. Phelan, “Thermal conductivity of nanoscale colloidal solutions (nanofluids)”, Phys. Rev. Lett. 94(2), 25901–25904 (2005). http://dx.doi.org/10.1103/PhysRevLett.94.025901
S. P. Jang and S. U. S. Choi, “Effects of various parameters on nanofluid thermal conductivity”, J. Heat Transfer 129(5), 617–623 (2006). http://dx.doi.org/10.1115/1.2712475
L. Liu, L. Xiao, J. Feng, L. Li, S. Esmaeili and Y. Zhou, “Bonding of immiscible Mg and Fe by coated nanoscale Fe2Al5 transition layer”, Scr. Mater. 65(11), 982–985 (2011). http://dx.doi.org/10.1016/j.scriptamat.2011.08.026
A. Hu, Y. Zhou and W. W. Duley, “Femtosecond laser-induced nanowelding: fundamentals and applications”, Open Surf. Sci. J. 3, 42–45 (2011).
W. Hu, S. Xiao, J. Yang and Z. Zhang, “Melting evolution and diffusion behavior of vanadiumnanoparticles”, Eur. Phy. J. B 45(4), 547–554 (2005). http://dx.doi.org/10.1140/epjb/e2005-00210-8
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made.
The images or other third party material in this article are included in the article’s Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article’s Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder.
To view a copy of this licence, visit https://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Liu, L., Huang, H., Hu, A. et al. Nano Brazing of Pt-Ag Nanoparticles under Femtosecond Laser Irradiation. Nano-Micro Lett. 5, 88–92 (2013). https://doi.org/10.1007/BF03353734
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/BF03353734