Skip to main content
SpringerLink
Log in

A Study of cryostructuring of polymer systems. 41. Complex and composite poly(vinyl alcohol) cryogels containing soluble and insoluble forms of chitosan, respectively

  • Published:
Colloid Journal Aims and scope Submit manuscript

Abstract

Complex macroporous poly(vinyl alcohol) (PVA) cryogels have been obtained by cryogenic treatment (freezing at–20°C for 12 h followed by defrosting at a rate of 0.03°C/min) of PVA–chitosan hydrochloride mixed solutions. The subsequent alkaline treatment of the cryogels has resulted in the transformation of the water-soluble salt form of chitosan into its insoluble basic form, which coagulates inside the bulk of the continuous phase of PVA cryogel into small particles with sizes of 2–5 µm. In the resulting composite cryogels, these particles play the role of an “active” filler, which increases the rigidity and heat endurance of the gel material. It has been shown that the sorption capacity of such chitosan particles entrapped into the bulk of composite cryogels with respect of bivalent copper ions is noticeably higher than the sorption capacity of ground chitosan particles incorporated as a discrete filler into the continuous phase PVA cryogels. The study of the properties of PVA–chitosan hydrochloride mixed solutions revealed that these polymers are, to a large extent, compatible with one another in a common solvent at a low ionic strength. Therefore, liquidliquid phase separation of these systems due to the thermodynamic incompatibility of macromolecules of different natures is observed only upon increasing the ionic strength by adding a low-molecular-mass salt (NaCl, 0.15 mol/L) to the solution.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Similar content being viewed by others

References

  1. Lozinskii, V.I., Usp. Khim., 1998, vol. 67, p. 641.

    Google Scholar 

  2. Hassan, C.M. and Peppas, N.A., Adv. Polym. Sci., 2000, vol. 153, p. 37.

    Article  CAS  Google Scholar 

  3. Lozinsky, V.I., Adv. Polym. Sci., 2014, vol. 263, p. 1.

    Article  CAS  Google Scholar 

  4. Yokoyama, F., Masada, I., Shimamura, K., Ikawa, T., and Monobe, K., Colloid Polym. Sci., 1986, vol. 264, p. 595.

    Article  CAS  Google Scholar 

  5. Hassan, C.M. and Peppas, N.A., Macromolecules, 2000, vol. 33, p. 2472.

    Article  CAS  Google Scholar 

  6. Ricciardi, R., Gaillet, C., Ducouret, G., Lafuma, F., and Laupretre, F., Polymer, 2003, vol. 44, p. 3375.

    Article  CAS  Google Scholar 

  7. Rosa, C.D., Auriemma, F., and Girolamo, R.D., Adv. Polym. Sci., 2014, vol. 263, p. 159.

    Article  Google Scholar 

  8. Lozinsky, V.I., Vainerman, E.S., Domotenko, L.V., Mamtsis, A.M., Titova, E.F., Belavtseva, E.M., and Rogozhin, S.V., Colloid Polym. Sci., 1986, vol. 264, p. 19.

    Article  CAS  Google Scholar 

  9. Willcox, P.J., Howie, D.W., Schmidt-Rohr, K., Hoagland, D.A., Gido, S.P., Pudjijanto, S., Kleiner, L.W., and Venkatraman, S., J. Polym. Sci., Part B: Polym. Phys., 1999, vol. 37, p. 3438.

    Article  CAS  Google Scholar 

  10. Gutiérrez, M.C., Aranaz, I., Ferrer, M.L., and Del Monto, F., in Macroporous Polymers: Production, Properties and Biological/Biomedical Applications, Mattiasson, B., Kumar, A., and Galaev, I., Eds., Boca Raton: CRC, 2010, p. 83.

  11. Gun’ko, V.M., Savina, I.N., and Mikhalovsky, S.V., Adv. Colloid Interface Sci., 2013, vols. 187–188, p. 1.

    Article  Google Scholar 

  12. Lozinsky, V.I. and Okay, O., Adv. Polym. Sci., 2014, vol. 263, p. 49.

    Article  CAS  Google Scholar 

  13. Lozinskii, V.I., Vainerman, E.S., Domotenko, L.V., Blyumenfel’d, A.L., Rogov, V.V., Barkovskaya, E.N., Fedin, E.I., and Rogozhin, S.V., Kolloidn. Zh., 1989, vol. 51, p. 685.

    CAS  Google Scholar 

  14. Lozinsky, V.I., Damshkaln, L.G., Kurochkin, I.N., and Kurochkin, I.I., Colloid J., 2007, vol. 69, p. 747.

    Article  CAS  Google Scholar 

  15. Lozinsky, V.I., Damshkaln, L.G., Kurochkin, I.N., and Kurochkin, I.I., Colloid J., 2008, vol. 70, p. 189.

    Article  CAS  Google Scholar 

  16. Lozinsky, V.I., Damshkaln, L.G., Kurochkin, I.N., and Kurochkin, I.I., Colloid J., 2012, vol. 74, p. 319.

    Article  CAS  Google Scholar 

  17. Nambu, M., Kobunshi Ronbunshu, 1990, vol. 47, p. 695.

    Article  CAS  Google Scholar 

  18. Surry, K.J.M., Austin, H.J.B., Fenster, A., and Peters, T.M., Phys. Med. Biol., 2004, vol. 49, p. 5529.

    Article  CAS  Google Scholar 

  19. Hoskins, P.R., Ultrasound Med. Biol., 2008, vol. 34, p. 693.

    Article  Google Scholar 

  20. Baker, M.I., Walsh, S.P., Schwartz, Z., and Boyan, B.D., J. Biomed. Mater. Res. Appl., 2012, vol. 100, p. 1451.

    Article  Google Scholar 

  21. Wan, W., Bannerman, A.D., Yang, L., and Mak, H., Adv. Polym. Sci., 2014, vol. 263, p. 283.

    Article  CAS  Google Scholar 

  22. Lozinskii, V.I., Vakula, A.S., and Zubov, A.L., Biotekhnologiya, 1992, no. 4, p. 5.

    Google Scholar 

  23. Varfolomeev, S.D., Rainina, E.I., and Lozinsky, V.I., Pure Appl. Chem., 1992, vol. 64, p. 1193.

    CAS  Google Scholar 

  24. Lozinsky, V.I. and Plieva, F.M., Enzyme Microb. Technol., 1998, vol. 23, p. 227.

    Article  CAS  Google Scholar 

  25. Bacheva, A.V., Plieva, F.M., Lysogorskaya, E.N., Filippova, I.Yu., and Lozinsky, V.I., Bioorg. Med. Chem. Lett., 2001, vol. 11, p. 1005.

    Article  CAS  Google Scholar 

  26. Lozinskii, V.I., Izv. Ross. Akad. Nauk, Ser. Khim., 2008, p. 996.

    Google Scholar 

  27. Mattiasson, B., Adv. Polym. Sci., 2014, vol. 263, p. 245.

    Article  CAS  Google Scholar 

  28. Zuikova, L.P., Izyumova, E.I., and Korneva, G.G., Rybn. Khoz., 1977, no. 1, p. 70.

    Google Scholar 

  29. Bulatnikova, L.I., Plisko, E.V., and Belyatskaya, O.I., Plast. Massy, 1983, no. 7, p. 52.

    Google Scholar 

  30. Altunina, L.K., Kuvshinov, V.A., and Dolgikh, S.N., NATO Sci. Ser. IV: Earth Environ. Sci., 2006, vol. 65, p. 103.

    Google Scholar 

  31. Vasiliev, N.K., Ivanov, A.A., Sokurov, V.V., Shatalina, I.N., and Vasilyev, K.N., Cold Reg. Sci. Technol., 2012, vol. 70, p. 94.

    Article  Google Scholar 

  32. Altunina, L.K., Fufaeva, M.S., Filatov, D.A., Svarovskaya, L.I., Rozhdestvenskii, E.A., and GanErdene, T., Pochvovedenie, 2014, p. 563.

    Google Scholar 

  33. Watase, M., Nippon Kagaku Kaishi, 1983, p. 1254.

    Google Scholar 

  34. Rogozhin, S.V., Lozinskii, V.I., Vainerman, E.S., Domotenko, L.V., Mamtsis, A.M., Ivanova, S.A., Shtil’man, M.I., and Korshak, V.V., Dokl. Akad. Nauk SSSR, 1984, vol. 278, p. 129.

    CAS  Google Scholar 

  35. Watase, M. and Nishinari, K., Makromol. Chem., 1988, vol. 189, p. 871.

    Article  CAS  Google Scholar 

  36. Urushizaki, F., Yamaguchi, H., Nakamura, K., Namajiri, S., Sugibayashi, K., and Moromoto, Y., Int. J. Pharm., 1990, vol. 58, p. 135.

    Article  CAS  Google Scholar 

  37. Lozinsky, V.I., Zubov, A.L., and Titova, E.F., Enzyme Microb. Technol., 1996, vol. 18, p. 561.

    Article  CAS  Google Scholar 

  38. Lozinsky, V.I., Domotenko, L.V., Zubov, A.L., and Simenel, I.A., J. Appl. Polym. Sci., 1996, vol. 61, p. 1991.

    Article  CAS  Google Scholar 

  39. Lozinsky, V.I., Damshkaln, L.G., Kurochkin, I.N., and Kurochkin, I.I., Eur. Polym. J., 2014, vol. 53, p. 189.

    Article  CAS  Google Scholar 

  40. Lozinsky, V.I., Solodova, E.V., Zubov, A.L., and Simenel, I.A., J. Appl. Polym. Sci., 1995, vol. 58, p. 171.

    Article  CAS  Google Scholar 

  41. Yamaura, K., Mitsuishi, M., Fukuda, M., Tanigami, T., Hoei, Y., and Matsuzawa, S., J. Appl. Polym. Sci., 1995, vol. 56, p. 653.

    Article  CAS  Google Scholar 

  42. Tolstoguzov, V.B., Iskusstvennye produkty pitaniya (Artificial Food Products), Moscow: Nauka, 1978.

    Google Scholar 

  43. Lozinsky, V.I., Zubov, A.L., Kulakova, V.K., Titova, E.F., and Rogozhin, S.V., J. Appl. Polym. Sci., 1992, vol. 44, p. 1423.

    Article  Google Scholar 

  44. Siritienthong, T., Ratanavaraporn, J., and Aramvit, P., Int. J. Pharm., 2012, vol. 439, p. 175.

    Article  CAS  Google Scholar 

  45. Gonzalez, J.S., Ludueña, L.N., Ponce, A., and Alvarez, V.A., Mater. Sci. Eng. C, 2014, vol. 34, p. 54.

    Article  CAS  Google Scholar 

  46. Podorozhko, E.A., Lunev, I.A., Ryabev, A.N., Kil’deeva, N.R., and Lozinsky, V.I., Colloid J., 2015, vol. 77, p. 186.

    Article  CAS  Google Scholar 

  47. Suzuki, M. and Hirasa, O., Adv. Polym. Sci., 1993, vol. 110, p. 241.

    Article  CAS  Google Scholar 

  48. Cascone, M.G., Barbani, N., Maltini, S., and Lazzeri, L., Polym. Int., 2001, vol. 50, p. 1241.

    Article  CAS  Google Scholar 

  49. Minton, J.A., Iravani, A., and Yousefi, A.-M., Med. Phys., 2012, vol. 39, p. 6796.

    Article  CAS  Google Scholar 

  50. Abdel-Mohsen, A.M., Aly, A.S., Hrdina, R., Montaser, A.S., and Hebedish, A., J. Polym. Environ., 2011, vol. 19, p. 1005.

    Article  CAS  Google Scholar 

  51. Lozinsky, V.I., Damshkaln, L.G., Ezernitskaya, M.G., Glotova, Y.K., and Antonov, Y.A., Soft Matter, 2012, vol. 8, p. 8493.

    Article  CAS  Google Scholar 

  52. Kulikov, S., Tikhonov, V., Blagodatskikh, I., Bezrodnykh, E., Lopatin, S., Khairullin, R., Philippova, Y., and Abramchuk, S., Carbohydr. Res., 2012, vol. 87, p. 545.

    Article  CAS  Google Scholar 

  53. Lopatin, S.A., Derbeneva, M.S., Kulikov, S.N., Varlamov, V.P., and Shpigun, O.A., J. Anal. Chem., 2009, vol. 64, p. 648.

    Article  CAS  Google Scholar 

  54. Hirai, A., Odani, H., and Nakajima, A., Polym. Bull. (Berlin), 1991, vol. 26, p. 87.

    Article  CAS  Google Scholar 

  55. Koningsveld, R. and Staverman, A.J., J. Polym. Sci. B, 1968, vol. 6, p. 305.

    CAS  Google Scholar 

  56. Polyakov, V.I., Grinberg, V.Ya., and Tolstoguzov, V.B., Polym. Bull. (Berlin), 1980, vol. 2, p. 757.

    Article  CAS  Google Scholar 

  57. Albertsson, P.-A., Partition of Cell Particles and Macromolecules, New York: Wiley, 1971.

    Google Scholar 

  58. Antonov, Yu.A., Lozinskaya, N.V., Grinberg, V.Ya., and Tolstoguzov, V.B., Colloid Polym. Sci., 1979, vol. 257, p. 1159.

    Article  CAS  Google Scholar 

  59. Tikhonov, V.E., in Khitozan (Chitosan), Skryabin, K.G., Mikhailov, S.N., and Varlamov, V.P., Eds., Moscow: Tsentr “Bioinzheneriya”, Ross. Akad. Nauk, 2013, p. 49.

  60. Antonov, Yu.A., Pletenko, M.G., and Tolstoguzov, V.B., Vysokomol. Soedin., Ser. A, 1987, vol. 29, p. 2482.

    CAS  Google Scholar 

  61. Simonet, F., Garnier, C., and Doublier, J.-L., Carbohydr. Res., 2002, vol. 47, p. 313.

    Article  CAS  Google Scholar 

  62. Antonov, Y.A., Grinberg, V.Y., and Tolstoguzov, V.B., Starch—Stärke, 1975, vol. 27, p. 424.

    Article  CAS  Google Scholar 

  63. Antonov, Y.A., Grinberg, V.Y., and Tolstoguzov, V.B., Carbohydr. Res., 1982, vol. 2, p. 81.

    Article  CAS  Google Scholar 

  64. Lozinsky, V.I., Sakhno, N.G., Damshkaln, L.G., Bakeeva, I.V., Zubov, V.P., Kurochkin, I.N., and Kurochkin, I.I., Colloid J., 2011, vol. 73, p. 234.

    Article  CAS  Google Scholar 

  65. Sergeev, G.B. and Batyuk, V.A., Usp. Khim., 1976, vol. 45, p. 793.

    CAS  Google Scholar 

  66. Voelkel, J., Pol. J. Chem., 1981, vol. 55, p. 455.

    Google Scholar 

  67. Dai, L.X., Ukai, K., Shaheen, S.M., and Yamaura, K., Polym. Int., 2002, vol. 51, p. 715.

    Article  CAS  Google Scholar 

  68. Marcus, Y., Chem. Rev., 2009, vol. 109, p. 1346.

    Article  CAS  Google Scholar 

  69. Damshkaln, L.G., Simenel, I.A., and Lozinsky, V.I., J. Appl. Polym. Sci., 1999, vol. 74, p. 1978.

    Article  CAS  Google Scholar 

  70. Muzzarelli, R.A.A. and Muzzarelli, C., Adv. Polym. Sci., 2005, vol. 186, p. 151.

    Article  CAS  Google Scholar 

  71. Mathews, D.T., Birney, Y.A., Cahill, P.A., and McGuinness, G.B., J. Appl. Polym. Sci., 2008, vol. 109, p. 1129.

    Article  CAS  Google Scholar 

  72. Lipatov, Yu.S., Fizicheskaya khimiya napolnennykh polimerov (Physical Chemistry of Filled Polymers), Moscow: Khimiya, 1977.

    Google Scholar 

  73. Kamin'ski, W. and Modrzejewska, Z., Sep. Sci. Technol., 1997, vol. 32, p. 2659.

    Article  Google Scholar 

  74. Salmon, S. and Hudson, S.M., J. Macromol. Sci. Part C: Polym. Rev., 1997, vol. 37, p. 199.

    Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Nesmeyanov Institute of Organoelement Compounds, Russian Academy of Sciences, ul. Vavilova 28, Moscow, 119991, Russia

    E. A. Podorozhko, V. E. Tikhonov & V. I. Lozinsky

  2. Moscow State University of Design and Technology, ul. Sadovnicheskaya 33/1, Moscow, 117997, Russia

    G. R. Ul’yabaeva & N. R. Kil’deeva

  3. Emanuel Institute of Biochemical Physics, Russian Academy of Sciences, ul. Kosygina 4, Moscow, 119991, Russia

    Yu. A. Antonov & I. L. Zhuravleva

Authors
  1. E. A. Podorozhko
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. G. R. Ul’yabaeva
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. N. R. Kil’deeva
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. V. E. Tikhonov
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. Yu. A. Antonov
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. I. L. Zhuravleva
    View author publications

    You can also search for this author in PubMed Google Scholar

  7. V. I. Lozinsky
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to V. I. Lozinsky.

Additional information

Original Russian Text © E.A. Podorozhko, G.R. Ul’yabaeva, N.R. Kil’deeva, V.E. Tikhonov, Yu.A. Antonov, I.L. Zhuravleva, V.I. Lozinsky, 2016, published in Kolloidnyi Zhurnal, 2016, Vol. 78, No. 1, pp. 75–87.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Podorozhko, E.A., Ul’yabaeva, G.R., Kil’deeva, N.R. et al. A Study of cryostructuring of polymer systems. 41. Complex and composite poly(vinyl alcohol) cryogels containing soluble and insoluble forms of chitosan, respectively. Colloid J 78, 90–101 (2016). https://doi.org/10.1134/S1061933X16010130

Download citation

  • Received:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1134/S1061933X16010130

Keywords

Search

Navigation