Skip to main content
SpringerLink
Log in

Desorption experiments and modeling of micropollutants on activated carbon in water phase: application to transient concentrations mitigation

  • Original Paper
  • Published:
International Journal of Environmental Science and Technology Aims and scope Submit manuscript

Abstract

Experimental studies and numerical modeling were conducted to assess the feasibility of a granular activated carbon column to buffer load variations of contaminants before wastewater treatment devices. Studies of cycles of adsorption, and more especially desorption, of methyldiethanolamine (MDEA) and 2,4-dimethylphenol (2,4-DMP) have been carried out on granular activated carbon (GAC). Dynamic variations of contaminants concentrations were run at several conditions of duration (peaks). GAC fixed-bed exhibited a stable adsorption/desorption capacity after undergoing two conditioning cycles. The study of pollution peaks revealed that attenuation is largely dependent on the targeted pollutant: 2.4 ± 0.5 % attenuation/cm of bed for MDEA and 6.0 ± 1.2 % attenuation/cm of bed for 2,4-DMP. Mass balances calculated from both injected and recovered pollutant during peaks were respected. Finally, a coupling of the linear driving force model and isotherms models was used to fit experimental data for both adsorption breakthrough curves and desorption curves. The model was used to predict adsorption and desorption behaviors of following cycles. Good agreement with experimental values was obtained.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5

Similar content being viewed by others

References

  • Aboussaoud W, Manero M-H, Pic J-S, Debellefontaine H (2014) Combined ozonation using alumino-silica materials for the removal of 2,4-dimethylphenol from water. Ozone Sci Eng 36:221–228

    Article  CAS  Google Scholar 

  • Alinsafi A, da Motta M, Le Bonté S et al (2006) Effect of variability on the treatment of textile dyeing wastewater by activated sludge. Dyes Pigments 69:31–39

    Article  CAS  Google Scholar 

  • Argaman Y, Raize O Jr, Eckenfelder W, O’Reilly AJ (2000) Applicability of batch test data for industrial wastewater continuous flow process design. Water Environ Res 72:348–352

    Article  CAS  Google Scholar 

  • Berčič G, Pintar A, Levec J (1996) Desorption of phenol from activated carbon by hot water regeneration. Desorption isotherms. Ind Eng Chem Res 35:4619–4625

    Article  Google Scholar 

  • Brosillon S, Manero MH, Foussard JN (2001) Mass transfer in VOC adsorption on zeolite: experimental and theoretical breakthrough curves. Environ Sci Technol 35:3571–3575

    Article  CAS  Google Scholar 

  • Cai Z, Sorial GA (2009) Treatment of dynamic VOC mixture in a trickling-bed air biofilter integrated with cyclic adsorption/desorption beds. Chem Eng J 151:105–112

    Article  CAS  Google Scholar 

  • Chakma A, Meisen A (1989) Activated carbon adsorption of diethanolamine, methyl diethanolamine and their degradation products. Carbon 27:573–584

    Article  CAS  Google Scholar 

  • Choi KJ, Kim SG, Kim CW, Kim SH (2005) Effects of activated carbon types and service life on removal of endocrine disrupting chemicals: amitrol, nonylphenol, and bisphenol-A. Chemosphere 58:1535–1545

    Article  CAS  Google Scholar 

  • Cox HHJ, Deshusses MA (2002) Effect of starvation on the performance and re-acclimation of biotrickling filters for air pollution control. Environ Sci Technol 36:3069–3073. doi:10.1021/es015693d

    Article  CAS  Google Scholar 

  • Crittenden B, Thomas WJ (1998) Adsorption technology & design. Butterworth-Heinemann, Boston

    Google Scholar 

  • Crittenden JC, Wong BWC, Thacker WE et al (1980) Mathematical model of sequential loading in fixed-bed adsorbers. J Water Pollut Control Fed 52:2780–2795

    Google Scholar 

  • De Jonge RJ, Breure AM, van Andel JG (1996) Reversibility of adsorption of aromatic compounds onto powdered activated carbon (PAC). Water Res 30:883–892

    Article  Google Scholar 

  • Delgado JMPQ (2007) Longitudinal and transverse dispersion in porous media. Chem Eng Res Des 85:1245–1252

    Article  CAS  Google Scholar 

  • Fitch MW, England E, Zhang B (2002) 1-Butanol removal from a contaminated airstream under continuous and diurnal loading conditions. J Air Waste Manag Assoc 52:1288–1297

    Article  CAS  Google Scholar 

  • Freundlich H (1906) Über die Adsorption in Lösungen. Wilhelm Engelmann, Leipzig

  • Glueckauf E (1955) Theory of chromatography. Part 10—Formulæ for diffusion into spheres and their application to chromatography. Trans Faraday Soc 51:1540–1551

    Article  CAS  Google Scholar 

  • Hand DW, Crittenden JC, Hokanson DR, Bulloch JL (1997) Predicting the performance of fixed-bed granular activated carbon adsorbers. Water Sci Technol 35:235–241

    Article  CAS  Google Scholar 

  • Hu Z, Srinivasan MP, Ni Y (2000) Adsorption and desorption of phenols and dyes on microporous and mesoporous activated carbons Adsorption science and technology. World Scientific, Singapore, pp 274–278

    Google Scholar 

  • Iranpour R, Cox HHJ, Deshusses MA, Schroeder ED (2005) Literature review of air pollution control biofilters and biotrickling filters for odor and volatile organic compound removal. Environ Prog 24:254–267. doi:10.1002/ep.10077

    Article  CAS  Google Scholar 

  • Johnson MD, Weber WJ (2001) Rapid prediction of long-term rates of contaminant desorption from soils and sediments. Environ Sci Technol 35:427–433. doi:10.1021/es001392c

    Article  CAS  Google Scholar 

  • Kim S, Kim Y-K (2004) Apparent desorption kinetics of phenol in organic solvents from spent activated carbon saturated with phenol. Chem Eng J 98:237–243

    Article  CAS  Google Scholar 

  • Kim D, Cai Z, Sorial GA (2005) Evaluation of trickle-bed air biofilter performance under periodic stressed operating conditions as a function of styrene loading. J Air Waste Manag Assoc 55:200–209

    Article  CAS  Google Scholar 

  • Kim D, Cai Z, Sorial GA et al (2007) Integrated treatment scheme of a biofilter preceded by a two-bed cyclic adsorption unit treating dynamic toluene loading. Chem Eng J 130:45–52

    Article  CAS  Google Scholar 

  • Langmuir I (1916) The constitution and fundamental properties of solids and liquids. Part I. Solids. J Am Chem Soc 38:2221–2295

    Article  CAS  Google Scholar 

  • Leglize P, Saada A, Berthelin J, Leyval C (2006) Evaluation of matrices for the sorption and biodegradation of phenanthrene. Water Res 40:2397–2404

    Article  CAS  Google Scholar 

  • Lesage N (2005) Etude d’un procédé hybride Adsorption / Bioréacteur à membranes pour le traitement des effluents industriels. PhD Thesis

  • Li C, Moe WM (2005) Activated carbon load equalization of discontinuously generated acetone and toluene mixtures treated by biofiltration. Environ Sci Technol 39:2349–2356

    Article  CAS  Google Scholar 

  • Mason CA, Ward G, Abu-Salah K et al (2000) Biodegradation of BTEX by bacteria on powdered activated carbon. Bioprocess Eng 23:331–336

    Article  CAS  Google Scholar 

  • Merle T (2009) Couplage des procédés d’adsorption et d’ozonation pour l’élimination de molécules bio-récalcitrantes. PhD thesis, University of Toulouse

  • Moe WM, Li C (2005) A design methodology for activated carbon load equalization systems applied to biofilters treating intermittent toluene loading. Chem Eng J 113:175–185

    Article  CAS  Google Scholar 

  • Muhammad Khan MA, Choong TSY et al (2011) Desorption of β-carotene from mesoporous carbon coated monolith: isotherm, kinetics and regeneration studies. Chem Eng J 173:474–479

    Article  CAS  Google Scholar 

  • Nabatilan MM, Moe WM (2010) Effects of water vapor on activated carbon load equalization of gas phase toluene. Water Res 44:3924–3934. doi:10.1016/j.watres.2010.04.028

    Article  CAS  Google Scholar 

  • Ottengraf SPP (1986) Exhaust gas purification. In: Rehm HJ, Reed G (eds) VCH Verlagsgesellschaf, vol 8. Weinheim, Germany, p 426

  • Ozkaya B (2006) Adsorption and desorption of phenol on activated carbon and a comparison of isotherm models. J Hazard Mater 129:158–163. doi:10.1016/j.jhazmat.2005.08.025

    Article  Google Scholar 

  • Perry RH, Chilton CH (1973) Chemical engineers’ handbook, 5th edn. McGraw-Hill, New York

    Google Scholar 

  • Ruthven DM (1984) Principles of adsorption and adsorption processes. Wiley, New York

    Google Scholar 

  • Sing KSW (1985) Reporting physisorption data for gas/solid systems with special reference to the determination of surface area and porosity (Recommendations 1984)

  • Snoeyink VL, Weber WJ, Mark HB (1969) Sorption of phenol and nitrophenol by active carbon. Environ Sci Technol 3:918–926

    Article  CAS  Google Scholar 

  • Tanthapanichakoon W, Ariyadejwanich P, Japthong P et al (2005) Adsorption–desorption characteristics of phenol and reactive dyes from aqueous solution on mesoporous activated carbon prepared from waste tires. Water Res 39:1347–1353. doi:10.1016/j.watres.2004.12.044

    Article  CAS  Google Scholar 

  • Tchobanoglous G, Burton FL, Stensel HD (2002) Wastewater engineering: treatment and reuse, 4th edn. McGraw-Hill Science/Engineering/Math, Boston

    Google Scholar 

  • Tien C (1995) Adsorption calculations and modeling. Butterworth-Heinemann, Boston

    Google Scholar 

  • Wakao N, Funazkri T (1978) Effect of fluid dispersion coefficients on particle-to-fluid mass transfer coefficients in packed beds: Correlation of sherwood numbers. Chem Eng Sci 33:1375–1384

    Article  CAS  Google Scholar 

  • Wani AH, Branion RMR, Lau AK (1998) Effects of periods of starvation and fluctuating hydrogen sulfide concentration on biofilter dynamics and performance. J Hazard Mater 60:287–303

    Article  CAS  Google Scholar 

  • Weber FJ, Hartmans S (1995) Use of activated carbon as a buffer in biofiltration of waste gases with fluctuating concentrations of toluene. Appl Microbiol Biotechnol 43:365–369

    Article  CAS  Google Scholar 

Download references

Acknowledgments

The authors gratefully acknowledge the financial support for the research by French National Agency for Research and Technology and Total Group (CIFRE 2011/0925). The authors thank Dr. Nicolas Lesage for his support and helpful advices.

Author information

Authors and Affiliations

  1. Laboratoire de Génie Chimique, INPT, UPS, Université de Toulouse, 4, Allée Emile Monso, 31030, Toulouse, France

    S. Bourneuf, R. Richard & M. H. Manero

  2. Laboratoire de Génie Chimique, CNRS, 31030, Toulouse, France

    S. Bourneuf, C. Albasi, R. Richard & M. H. Manero

  3. TOTAL, PERL - Pôle d’Etudes et de Recherche de Lacq, RN 117, BP 47, 64170, Lacq, France

    S. Bourneuf & M. Jacob

  4. Laboratoire de Thermique Energétique & Procédés, ENSGTI, Université Pau et Pays de l’Adour, Rue Jules Ferry, BP 7511, 64075, Pau Cedex, France

    S. Sochard

Authors
  1. S. Bourneuf
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. M. Jacob
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. C. Albasi
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. S. Sochard
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. R. Richard
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. M. H. Manero
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to S. Bourneuf.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Bourneuf, S., Jacob, M., Albasi, C. et al. Desorption experiments and modeling of micropollutants on activated carbon in water phase: application to transient concentrations mitigation. Int. J. Environ. Sci. Technol. 13, 1–10 (2016). https://doi.org/10.1007/s13762-015-0834-x

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s13762-015-0834-x

Keywords

Search

Navigation