Skip to main content
SpringerLink
Log in

Microgravity Bubbly-to-Slug Flow Regime Transition Theory and Modeling

  • Original Article
  • Published:
Microgravity Science and Technology Aims and scope Submit manuscript

Abstract

In the published microgravity bubbly-slug data sets, the average critical void fraction for the bubbly-to-slug transition is observed to cluster around \(\sim \)0.20 and \(\sim \)0.45. The origin of what causes there to be two data subsets remains an open question. The \(\sim \)0.20 and \(\sim \)0.45 critical void fractions were reported by one researcher to occur during 1-g and \(\mu \)-g intervals on a reduced gravity aircraft, respectively. This suggests that the experiments belonging to the \(\sim \)0.20 data subset may have encountered undue buoyancy effects or perturbations which may have caused the bubbly-to-slug flow regime transitions to occur at prematurely low void fractions. Should this assertion hold, the ∼0.20 data subset can be treated separately from the ∼0.45 data subset, which provides a much clearer picture of the bubbly-to-slug flow regime transition. A new theory has been developed which explains the mechanics of the \(\sim \)0.45 data subset, for which corresponding physical and dimensionless models have been derived. The new theory and models are validated by their clear fit to the entirety of the published ∼0.45 data subset, however, they do not offer a firm explanation of the mechanics of the \(\sim \)0.20 data subset. This provides further indication that these two data subsets are indeed different. Further investigation into the differences between experiments and the manner in which they were conducted may explain the existence of these two data subsets.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9
Fig. 10
Fig. 11
Fig. 12
Fig. 13
Fig. 14
Fig. 15

Similar content being viewed by others

References

  • Balasubramaniam, R., Rame, E., Kizito, J., Kassemi, M.: Two phase flow modeling summary of flow regimes and pressure drop correlations in reduced and partial gravity, NASA/CR-2006-214085 (2006)

  • Bousman, W.S.: Studies of Two-Phase Gas-Liquid Flow in Microgravity, Ph.D. dissertation, University of Houston, USA (1994)

  • Bousman, W.S., Dukler, A.E.: Studies of gas-liquid flow in microgravity: void fractions, pressure drop and flow patterns. ASME, AMD-Vol, 174/FED-Vol. 175 (1993)

  • Choi, B., Fujii, T., Asano, H., Sugimoto, K.: A study of flow characteristics in air-water two-phase flow under microgravity (results of flight experiments). JSME Int. J. Ser. B 46(2), 262–269 (2003)

    Article  Google Scholar 

  • Colin, C.: Ecoulements Diphasiques à bulles et à poches en micropesanteur. Thèse, Institut National Polytechnique de Toulouse, France (1990)

  • Colin, C., Fabre, J.: Gas-liquid pipe flow under microgravity conditions: influence of tube diameter on flow patterns and pressure drops. Adv. Space Res. 16, 137–142 (1995)

    Article  Google Scholar 

  • Colin, C., Fabre, J., Dukler, A.E.: Gas-liquid flow at microgravity conditions—I. Dispersed bubble and slug flow. Int. J. Multiphase Flow 17, 533–544 (1991)

    Article  MATH  Google Scholar 

  • Colin, C., Kamp, A., Fabre, J.: Influence of gravity on void distribution in two-phase gas-liquid flow in a pipe. Adv. Space Res. 13(7), 141–145 (1993)

    Article  Google Scholar 

  • Colin, C., Fabre, J., McQuillen, J.: Bubble and slug flow at microgravity conditions: state of knowledge and open questions. Chem. Eng. Comm. 141–142, 155–173 (1996)

    Article  Google Scholar 

  • Colin, C., Riou, X., Fabre, J.: Bubble coalesence in gas-liquid flow at microgravity conditions. Microgravity Sci. Technol. 20, 243–246 (2008)

    Article  Google Scholar 

  • Crowley, C.J., Chen, W.B.: Scaling of Multiphase Flow Regimes and Interfacial Behavior at Microgravity. Creare Report TM-2086 (2001)

  • Dukler, A.E., Fabre, J.A., McQuillen, J.B., Vernon, R.: Gas-liquid flow at microgravity conditions: flow patterns and their transitions. Int. J. Multiphas. Flow 14, 389–400 (1988)

    Article  Google Scholar 

  • Elkow, K.J.: Void Fraction Measurements and Analysis at Normal Gravity and Microgravity Conditions. M.Sc. thesis, University of Saskatchewan, Canada (1995)

  • Heppner, N.B., King, C.N., Littles, J.W.: Zero-G experiments in two-phase fluid flow regimes, ASME 75-ENAs-24 (1975)

  • Huckerby, C.S., Rezkallah, K.S.: Flow pattern observations in two-phase gas-liquid flow in a straight tube under normal and microgravity conditions. Proc. 1992 AIChE Heat Transfer Conference, San Diego, 88, 139–147 (1992)

  • Janicot, A.J.P.: Experimental and theoretical studies of gas-liquid two-phase flow at reduced gravity conditions. M.Sc. thesis, University of Houston, USA (1988)

  • Jayawardena, S.S., Balakotaiah, V., Witte, L.C.: Flow pattern transition maps for microgravity two-phase flows. AIChE J. 43, 1637–1640 (1997)

    Article  Google Scholar 

  • Kamp, A., Colin, C., Fabre, J.: Bubbly flow in a pile: influence of gravity upon void and velocity distributions. In Proc. of the 3rd World Conference on Experimental Heat Transfer, Fluid Dynamics, and Thermodynamics, Honolulu, USA, 1418–1424 (1993)

  • Kamp, A.M., Chesters, A.K., Colin, C., Fabre, J.: Bubble coalescence in turbulent flows: a mechanistic model for turbulence-induced coalescence applied to microgravity bubbly pipe flow. Int. J. Multiphas. Flow 27, 1363–1396 (2001)

    Article  MATH  Google Scholar 

  • Kurwitz, C., Best, F.: A statistical comparison of various fluids for a drift flux model in reduced gravity two phase slug flow. AIP Conf. Proc. 746, 38 (2005)

    Article  Google Scholar 

  • Lin, C.S., Moulton, R.W., Putnam, G.L.: Mass transfer between solid wall and fluid streams. Ind. Eng. Chem. 45, 636–640 (1953)

    Article  Google Scholar 

  • Lowe, D.C.: A study on flow regime identification in microgravity gas-liquid flows using a capacitance sensor. M.Sc. thesis. University of Saskatchewan, Canada (1997)

  • Reinarts, T.R.: Adiabatic Two-Phase Flow Regime Data and Modeling for Zero and Reduced (Horizontal Flow) Acceleration Fields. Ph.D. dissertation, Texas A&M University, USA (1993)

  • Rite, R.W.: Heat transfer in gas-liquid flows through a vertical, circular tube under microgravity conditions. Ph.D. Thesis, University of Saskatchewan (1995)

  • Takamasa, T., Iguchi, T., Hazuku, T., Hibiki, T., Ishii, M.: Interfacial area transport of bubbly flow under microgravity conditions. Int. J. Multiphas. Flow 29, 291–304 (2003)

    Article  MATH  Google Scholar 

  • Wallis, G.B.: One-dimensional two-phase flow. McGraw-Hill, New York (1969)

    Google Scholar 

  • Zhao, L., Rezkallah, K.S.: Gas-liquid flow patterns at microgravity conditions. Int. J. Multiphas. Flow 19, 751–763 (1993)

    Article  MATH  Google Scholar 

  • Zhao, J.F., Xie, J.C., Lin, H., Hu, W.R., Ivanov, A.V., Belyaev, A.Y.: Experimental studies on two-phase flow patterns aboard the Mir space station. Int. J. Multiphas. Flow 27, 1931–1944 (2001a)

    Article  MATH  Google Scholar 

  • Zhao, J.F., Xie, J.C., Lin, H., Hu, W.R.: Experimental study on two-phase gas-liquid flow patterns at normal and reduced gravity conditions. Sci. China E 44(5), 553–560 (2001b)

    Article  MATH  Google Scholar 

  • Zhao, J.F., Lin, H., Xie, J.C., Hu, W.R.: Pressure drop of bubbly two-phase flow in a square channel at reduced gravity. Adv. Space Res. 29(4), 681–686 (2002)

    Article  Google Scholar 

  • Zuber, N., Findlay, J.A.: Average volumetric concentration in two phase flow systems. J. Heat Transf. 87(4), 453–468 (1965)

    Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Department of Nuclear Engineering, Texas A&M University, College Station, TX, 77843, USA

    Adam M. Shephard, Cable Kurwitz & Frederick R. Best

  2. Space Engineering Research Center, Texas A&M University, 3380 University Drive East, Suite 102, College Station, TX, 77845, USA

    Cable Kurwitz

Authors
  1. Adam M. Shephard
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Cable Kurwitz
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Frederick R. Best
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Adam M. Shephard.

Rights and permissions

Reprints and permissions

About this article

Cite this article

Shephard, A.M., Kurwitz, C. & Best, F.R. Microgravity Bubbly-to-Slug Flow Regime Transition Theory and Modeling. Microgravity Sci. Technol. 25, 161–177 (2013). https://doi.org/10.1007/s12217-013-9344-y

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s12217-013-9344-y

Keywords

Search

Navigation