Skip to main content
SpringerLink
Log in

PbS Thin Films Prepared by Chemical Bath Deposition: Effects of Concentration on the Morphology, Structure and Optical Properties

  • Review Paper
  • Published:
Iranian Journal of Science and Technology, Transactions A: Science Aims and scope Submit manuscript

Abstract

Lead sulfide thin films were prepared at 25 °C temperature using chemical bath deposition (CBD) on both Si (100) and glass substrates. XRD analysis of the PbS film shows that the prepared films have a polycrystalline structure with (200) preferential orientation. The grains become smaller with increasing the deposition concentration. X-ray photoelectron spectroscopy (XPS) demonstrated the presence of lead sulfide as PbS. The composition of the prepared films is investigated by energy-dispersive X-ray spectroscopy technique, and it was found that the films are stoichiometric and have low oxygen contamination. Raman and XPS spectra confirm that the CBD method is a decent one to acquire stoichiometric PbS film with nanostructures. Atomic force microscopy was applied to investigate the change in the films morphology with the concentration. The effect of the concentration, on both optical transmittance in the UV–NIR region and the structure of the film, was studied. The results revealed that the optical band gap increased slightly when the concentration increased together with the grain size evolution.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1
Fig. 2
Fig. 3
Fig. 4
Fig. 5
Fig. 6
Fig. 7
Fig. 8
Fig. 9

Similar content being viewed by others

References

  • Abbas MM, Shehab AA-M, Al-Samuraee AK, Hassan NA (2011) Effect of deposition time on the optical characteristics of chemically deposited nanostructure PbS thin films. Energy Procedia 6:241–250

    Article  Google Scholar 

  • Abdallah B, Al-Khawaja S (2015) Optical and electrical characterization of (002) preferentially oriented n-ZnO/p-Si heterostructure. Acta Phys Pol 128:283–288

    Article  Google Scholar 

  • Abdallah B, Kakhia M, Shaker SA (2016) Deposition of Na2WO4 films by ultrasonic spray pyrolysis: effect of thickness on the crystallographic and sensing properties. Compos Interfaces 23:663–674

    Article  Google Scholar 

  • Abdallah B, Jazmatia AK, Refaai R (2017) Oxygen effect on structural and optical properties of ZnO thin films deposited by RF magnetron sputtering. Mater Res Innov 20:1–6

    Google Scholar 

  • Abdallah B, Jazmati AK, Kakhia M (2018a) Physical, optical and sensing properties of sprayed zinc doped tin oxide films. Optik 158:1113–1122

    Article  Google Scholar 

  • Abdallah B, Ismail A, Kashoua H, Zetoun W (2018b) Effects of deposition time on the morphology, structure, and optical properties of PbS thin films prepared by chemical bath deposition. J Nanomater 2018:1–8

    Article  Google Scholar 

  • Al-Khawaja S, Abdallah B, Abou Shaker S, Kakhia M (2015) Thickness effect on stress, structural, electrical and sensing properties of (0 0 2) preferentially oriented undoped ZnO thin films. Compos Interfaces 22:221–231

    Article  Google Scholar 

  • Alnama K, Abdallah B, Kanaan S (2017a) Deposition of ZnS thin film by ultrasonic spray pyrolysis: effect of thickness on the crystallographic and electrical properties. Compos Interfaces 24:1–15

    Article  Google Scholar 

  • Alnama K, Abdallah B, Kanaan S (2017b) Deposition of ZnS thin film by ultrasonic spray pyrolysis: effect of thickness on the crystallographic and electrical properties. Compos Interfaces 24:1–16

    Article  Google Scholar 

  • Barote MA, Yadav AA, Masumdar EU (2011) Effect of deposition parameters on growth and characterization of chemically deposited Cd1-XPbXS thin films. Chalcogenide Lett 8:129–138

    Google Scholar 

  • Beddek L, Messaoudi M, Guitouni S, Attaf N, Aida MS (2015) Structural, optical and electrical properties of PbS thin films deposited by CBD at different bath pH. Int J Sci Res Eng Technol (IJSET) 3:138–142

    Google Scholar 

  • Bhandari KP, Choi H, Jeong S, Mahabaduge H, Ellingson RJ (2014) Determination of heterojunction band offsets between CdS bulk and PbS quantum dots using photoelectron spectroscopy. Appl Phys Lett 105:131604

    Article  Google Scholar 

  • Bo Z, Guanghai L, Jun Z, Yong Z, Lide Z (2003) Synthesis and characterization of PbS nanocrystals in water/C 12 E 9/cyclohexane microemulsions. Nanotechnology 14:443–446

    Article  Google Scholar 

  • Buckley AN, Woods R (1984) An x-ray photoelectron spectroscopic study of the oxidation of galena. Appl Surf Sci 17:401–414

    Article  Google Scholar 

  • Chaudhur TK (1992) A solar thermophotovoltaic converter using Pbs photovoltaic cells. Int J Energy Res 16:481–487

    Article  Google Scholar 

  • Chi TC (2012) Structure, morphology, and optical properties of the compact, vertically-aligned ZnO nanorod thin films by the solution-growth technique. In: Yalçın O (ed) Nanorods InTech. InTech, Rijeka

    Google Scholar 

  • Das RK, Sahoo S, Tripathi GS (2004) Electronic structure of high density carrier states in PbS, PbSe and PbTe. Semicond Sci Technol 19:433

    Article  Google Scholar 

  • David T, Goldsmith S, Boxman RL (2005) Dependence of zinc oxide thin film properties on filtered vacuum arc deposition parameters. J Phys D Appl Phys 38:2407

    Article  Google Scholar 

  • Dawood YZ, Kadhim SM, Mohammed AZ (2015) Structure and optical properties of nano PbS thin film deposited by pulse laser deposition. Eng Technol J Part B 32:1723–1730

    Google Scholar 

  • Faraj MG (2015) Effect of thickness on the structural and electrical properties of spray pyrolysed lead sulfide thin films. Am J Condens Matter Phys 5(2):51–55

    Google Scholar 

  • Ghamsari MS, Araghi MK, Farahani SJ (2006) The influence of hydrazine hydrate on the photoconductivity of PbS thin film. Mater Sci Eng B 133:113–116

    Article  Google Scholar 

  • Gode F, Baglayan O, Guneri E (2015) P-type nanostructure PBS thin films prepared by the silar method. Chalcogenide Lett 12:519–528

    Google Scholar 

  • Guglielmi M, Martucci A, Fick J, Vitrant G (1998) Preparation and Characterization of HgxCd1-xS and PbxCd1-xS quantum dots and doped thin films. J Sol Gel Sci Technol 11:229–240

    Article  Google Scholar 

  • Günes S, Fritz KP, Neugebauer H, Sariciftci NS, Kumar S, Scholes GD (2007) Hybrid solar cells using PbS nanoparticles. Sol Energy Mater Sol Cells 91:420–423

    Article  Google Scholar 

  • Huaqiang C, Guozhi W, Sichun Z, Xinrong Z (2006) Growth and photoluminescence properties of PbS nanocubes. Nanotechnology 17:3280

    Article  Google Scholar 

  • Joshi RK, Kanjilal A, Sehgal H (2004) Solution grown PbS nanoparticle films. Appl Surf Sci 221:43–47

    Article  Google Scholar 

  • Kar A, Sain S, Rossouw D, Knappett BR, Pradhan SK, Wheatley AEH (2016) Facile synthesis of SnO2-PbS nanocomposites with controlled structure for applications in photocatalysis. Nanoscale 8:2727–2739

    Article  Google Scholar 

  • Khiew PS, Radiman S, Huang NM, Ahmad MS (2003) Studies on the growth and characterization of CdS and PbS nanoparticles using sugar-ester nonionic water-in-oil microemulsion. J Cryst Growth 254:235–243

    Article  Google Scholar 

  • Krauss TD, Wise FW, Tanner DB (1996) Observation of coupled vibrational modes of a semiconductor nanocrystal. Phys Rev Lett 76:1376–1379

    Article  Google Scholar 

  • Li HP, Liu B, Kam CH, Lam YL, Que W, Gan LM, Chew CH, Xu GQ (1999) Optical nonlinearity of surface-modified PbS and CdxPb1-xS nanoparticles in the femtosecond regime. Proc SPIE 3899:376–383

  • Li C, Shi G, Xu H, Guang S, Yin R, Song Y (2007) Nonlinear optical properties of the PbS nanorods synthesized via surfactant-assisted hydrolysis. Mater Lett 61:1809–1811

    Article  Google Scholar 

  • Luther JM, Law M, Song Q, Perkins CL, Beard MC, Nozik AJ (2008) Structural, optical, and electrical properties of self-assembled films of PbSe nanocrystals treated with 1,2-ethanedithiol. Am Chem Soc 2:271–280

    Google Scholar 

  • Malyarevich AM, Gaponenko MS, Savitski VG, Yumashev KV, Rachkovskaya GE, Zakharevich GB (2007) Nonlinear optical properties of PbS quantum dots in boro-silicate glass. J Non Cryst Solids 353:1195–1200

    Article  Google Scholar 

  • McNaughter PD, Bear JC, Mayes AG, Parkin IP, O’Brien P (2017) The in situ synthesis of PbS nanocrystals from lead(II) n-octylxanthate within a 1,3-diisopropenylbenzene–bisphenol A dimethacrylate sulfur copolymer. R Soc Open Sci 4:170383

    Article  Google Scholar 

  • Mrad O, Ismail IM, Abdallah B, Rihawy M (2014) Optical and chemical properties of vanadium oxide thin films prepared by vacuum arc discharge. J Optoelectron Adv Mater 16:1099–1103

    Google Scholar 

  • Obaid AS, Mahdi MA, Ramizy A, Hassan Z (2012) Structural properties of nanocrystalline PbS thin films prepared by chemical bath deposition method. Adv Mater Res 364:60–64

    Article  Google Scholar 

  • Orozco-Terán RA, Sotelo-Lerma M, Ramirez-Bon R, Quevedo-López MA, Mendoza-González O, Zelava-Angel O (1999) Pbs-Cds bilayers prepared by the chemical bath deposition technique at different reaction temperatures. Thin Solid Films 343–344:587–590

    Article  Google Scholar 

  • Ovsyannikov SV, Shchennikov VV, Cantarero A, Cros A, Titov AN (2007) Raman spectra of (PbS)1.18(TiS2)2 misfit compound. Mater Sci Eng A 462:422–426

    Article  Google Scholar 

  • Pentia E, Pintilie L, Matei I, Botila T, Ozbay E (2001) Chemically prepared nanocrystalline PbS thin films. J Optoelectron Adv Mater 3:525–530

    Google Scholar 

  • Pentia E, Draghici V, Sarau G et al (2004) Structural, electrical, and photoelectrical properties of CdxPb1-xS thin films prepared by chemical bath deposition. ETATS-UNIS: Electrochemical Society, Pennington

    Google Scholar 

  • Pérez-García CE, Ramírez-Bon R, Vorobiev YV (2015) PbS thin films growth with CBD and PCBD techniques: a comparative study. Chalcogenide Lett 12:579–588

    Google Scholar 

  • Pop I, Nascu C, Ionescu V, Indrea E, Bratu I (1997) Structural and optical properties of PbS thin films obtained by chemical deposition. Thin Solid Films 307:240–244

    Article  Google Scholar 

  • Preobrajenski AB, Chassé T (1999) Epitaxial growth and interface structure of PbS on InP(110). Appl Surf Sci 142:394–399

    Article  Google Scholar 

  • Ramin Y, Mohsen C, Farid J-S, Mahmoudian MR, Abdolhossein S, Nay Ming H (2014) Influences of anionic and cationic dopants on the morphology and optical properties of PbS nanostructures. Chin Phys B 23:108101

    Article  Google Scholar 

  • Reichea R, Thielschb R, Oswalda S, Wetziga K (1999) XPS studies and factor analysis of PbS nanocrystal-doped SiO thin films. J Electron Spectrosc Relat Phenom 104:161–171

    Article  Google Scholar 

  • Rivera-Nieblas JO, Alvarado-Rivera J, Acosta-Enríquez MC, Ochoa-Landin R, Espinoza-Beltrán FJ, Apolinar-Iribe A et al (2013) Resistance and resistivities of PbS thin films using polyethylenimine by chemical bath deposition. Chalcogenide Lett 10:349–358

    Google Scholar 

  • Scherrer P (1918) Determination of the size and internal structure of colloidal particles using x-ray. Nachr Ges Wiss Gottingen 2:98–100

    Google Scholar 

  • Schreck E, Dappe V, Sarret G, Sobanska S, Nowak D, Nowak J et al (2014) Foliar or root exposures to smelter particles: consequences for lead compartmentalization and speciation in plant leaves. Sci Total Environ 476–477:667–676

    Article  Google Scholar 

  • Seghaier S, Kamoun N, Brini R, Amara AB (2006) Structural and optical properties of PbS thin films deposited by chemical bath deposition. Mater Chem Phys 97:71–80

    Article  Google Scholar 

  • Takahashi M, Ohshima Y, Nagata K, Furuta S (1993) Electrodeposition of PbS films from acidic solution. J Electroanal Chem 359:281–286

    Article  Google Scholar 

  • Tang J, Kemp KW, Hoogland S, Jeong KS, Liu H, Levina L et al (2011) Colloidal-quantum-dot photovoltaics using atomic-ligand passivation. Nat Mater 10:765–771

    Article  Google Scholar 

  • Ubale AU, Junchara AR, Wadibhasme NH, Purkab ASD, Mankar RB, Sangawar VS (2007) Thickness dependent structural, electrical and optical properties of chemically deposited nano particle PbS thin film. Turk J Phys 31:279–286

    Google Scholar 

  • Valenzuela-Jáuregui JJ, Ramı́rez-Bon R, Mendoza-Galván A, Sotelo-Lerma M (2003) Optical properties of PbS thin films chemically deposited at different temperatures. Thin Solid Films 441:104–110

    Article  Google Scholar 

  • Yu X-R, Liu F, Wang Z-Y, Chen Y (1990) Auger parameters for sulfur-containing compounds using a mixed aluminum-silver excitation source. J Electron Spectrosc Relat Phenom 50:159–166

    Article  Google Scholar 

  • Zhang H, Ma X, Xu J, Yang D (2004) Synthesis of CdS nanotubes by chemical bath deposition. J Cryst Growth 263:372–376

    Article  Google Scholar 

Download references

Author information

Authors and Affiliations

  1. Department of Physics, Atomic Energy Commission, P. O. Box 6091, Damascus, Syria

    B. Abdallah, R. Hussein, N. Al-Kafri & W. Zetoun

Authors
  1. B. Abdallah
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. R. Hussein
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. N. Al-Kafri
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. W. Zetoun
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to B. Abdallah.

Rights and permissions

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Abdallah, B., Hussein, R., Al-Kafri, N. et al. PbS Thin Films Prepared by Chemical Bath Deposition: Effects of Concentration on the Morphology, Structure and Optical Properties. Iran J Sci Technol Trans Sci 43, 1371–1380 (2019). https://doi.org/10.1007/s40995-019-00698-1

Download citation

  • Received:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.1007/s40995-019-00698-1

Keywords

Search

Navigation