Abstract
The effects of minor Sr additions on the as-cast microstructure and mechanical properties of the ZA84 magnesium alloy were investigated. The results indicate that adding 0.05-0.15 wt.% Sr to the ZA84 alloy does not cause an obvious change in the morphology and distribution of the Mg32(Al,Zn)49 phase. However, the grains of the Sr-containing ZA84 alloys are effectively refined. Among the Sr-containing ZA84 alloys, the grains of the alloy added 0.10 wt.% Sr are relatively finer than other alloys. Furthermore, adding 0.05-0.15 wt.% Sr to the ZA84 alloy improves the tensile properties at room temperature and 150 °C but decreases the creep properties. Among the Sr-containing ZA84 alloys, the alloy added 0.10 wt.% Sr obtains the optimum tensile properties at room temperature and 150 °C.
Similar content being viewed by others
References
J.H. Chen, Z.H. Chen, H.G. Yan, F.Q. Zhang, and K. Liao, Effects of Sn Addition on Microstructure and Mechanical Properties of Mg-Zn-Al Alloys, J. Alloys Compd., 2008, 461, p 209–215
M.B. Yang, F.S. Pan, R.J. Cheng, and J. Shen, Effects of Holding Temperature and Time on Semi-Solid Isothermal Heat-Treated Microstructure of ZA84 Magnesium Alloy, Trans. Nonferrous Met. Soc. China, 2008, 18, p 566–572
Y.X. Wang, S.K. Guan, X.Q. Zeng, and W.J. Ding, Effects of RE on the Microstructure and Mechanical Properties of Mg-8Zn-4Al Magnesium Alloy, Mater. Sci. Eng. A, 2006, 416, p 109–118
N. Balasubramani, A. Srinivasan, and U.T.S. Pillai, Effect of Sb Addition on the Microstructure and Mechanical Properties of ZA84 Magnesium Alloy, J. Alloys Compd., 2008, 455, p 168–173
A. Srinivasan, S. Ningshen, U.K. Mudali, U.T.S. Pillai, and B.C. Pai, Influence of Si and Sb Additions on the Corrosion Behavior of AZ91 Magnesium Alloy, Intermetallics, 2007, 15, p 1511–1517
M.B. Yang, F.S. Pan, R.J. Cheng, and J. Shen, Comparison About Effects of Sb, Sn and Sr on As-Cast Microstructure and Mechanical Properties of AZ61-0.7Si Magnesium Alloy, Mater. Sci. Eng. A, 2008, 489, p 413–418
M.B. Yang, F.S. Pan, R.J. Cheng, and A.T. Tang, Effect of Mg–10Sr Master Alloy on Grain Refinement of AZ31 Magnesium Alloy, Mater. Sci. Eng. A, 2008, 491, p 440–445
M.B. Yang and F.S. Pan, Processing Effects on Grain Refinement of AZ31 Magnesium Alloy Treated with a Commercial Al-10Sr Master Alloy, J. Mater. Eng. Perform., 2009, 18, p 32–37
A. Srinivasan, U.T.S. Pillai, and J. Swaminathan, Observations of Microstructural Refinement in Mg-Al-Si Alloys Containing Strontium, J. Mater. Sci., 2006, 41, p 6087–6089
S.K. Guan, S.J. Zhu, L.G. Wang, Q. Yang, and W.B. Cao, Microstructures and Mechanical Properties of Double Hot-Extruded AZ80+xSr Wrought Alloys, Trans. Nonferrous Met. Soc. China, 2007, 17, p 1143–1151
X.Q. Zeng, Y.X. Wang, W.J. Ding, A.A. Luo, and A.K. Sachdev, Effect of Strontium on the Microstructure, Mechanical Properties, and Fracture Behavior of AZ31 Magnesium Alloy, Metall. Mater. Trans. A, 2006, 37, p 1333–1341
X.F. Wan, Y.S. Sun, F. Xue, J. Bai, and W.J. Tao, Effects of Sr and Ca on the Microstructure and Properties of Mg-12Zn-4Al-0.3Mn Alloy, Mater. Sci. Eng. A, 2009, 508, p 50–58
N. Balasubramani, U.T.S. Pillai, and B.C. Pai, Optimization of Heat Treatment Parameters in ZA84 Magnesium Alloy, J. Alloys Compd., 2008, 457, p 118–123
L. Bourgeois, B.C. Muddle, and J.F. Nie, The Crystal Structure of the Equilibrium Phase in Mg-Zn-Al Casting Alloys, Acta Mater., 2001, 49, p 2701–2711
Z. Zhang, R. Tremblay, and A. Coutune, Solidification Microstructure of ZA102, ZA104 and ZA106 Magnesium Alloys and Its Effect on Creep Deformation, Can. Metall. Q, 2000, 39, p 503–512
Y.C. Lee, A.K. Dahle, and D.H. Stjohn, The Role of Solute in Grain Refinement of Magnesium, Metall. Mater. Trans. A, 2000, 31, p 2895–2906
S.M. Zhu, B.L. Mordike, and J.F. Nie, Creep Properties of a Mg-Al-Ca Alloy Produced by Different Casting Technologies, Mater. Sci. Eng. A, 2008, 483–484, p 583–586
Acknowledgments
The present work was supported by the National Natural Science Foundation of China (No. 50725413), the National Basic Research Development Program of China (973 Program) (No. 2007CB613704), and the Chongqing Education Commission of China (KJ090628).
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Yang, M., Pan, F. & Cheng, L. Effects of Minor Sr on As-Cast Microstructure and Mechanical Properties of ZA84 Magnesium Alloy. J. of Materi Eng and Perform 19, 1043–1050 (2010). https://doi.org/10.1007/s11665-009-9577-5
Received:
Revised:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11665-009-9577-5