Abstract
The addition of manipulators to small autonomous underwater vehicles (AUVs) can pose significant control challenges due to hydrodynamic interactions between the arm and the vehicle. Experiments conducted at the Monterey Bay Aquarium Research Institute (MBARI) using the OTTER vehicle have shown that dynamical interactions between an arm and a vehicle can be very significant. For the experiments reported in this paper, a single-link “arm” was mounted on OTTER. Tests showed that for 90-degree, two-second repetitive slews of the arm, the vehicle would move as much as 18 degrees in roll and 14 degrees in yaw when no vehicle control was applied.
Using a new, highly accurate model of the arm/vehicle hydrodynamic interaction forces, which was developed as part of this research, a coordinated arm/vehicle control strategy was implemented. Under this model-based approach, interaction forces acting on the vehicle due to arm motion were predicted and fed into the vehicle controller. Using this method, station-keeping capability was greatly enhanced. Errors at the manipulator end point were reduced by over a factor of six when compared to results when no control was applied to the vehicle and by a factor of 2.5 when compared to results from a standard independent arm and vehicle feedback control approach. Using the coordinated-control strategy, arm end-point settling times were reduced by a factor three when compared to those obtained with arm and vehicle feedback control alone. These dramatic performance improvements were obtained with only a five-percent increase in total applied thrust.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
Anderson, J.M. 1992. Model development and control of the autonomous benthic explorer. Proceedings of the Second International Offshore and Polar Engineering Conference, International Society of Offshore and Polar Engineers, pp. 468–472.
Craig, J.J. 1989. Introduction to Robotics: Mechanics and Control. Addison-Wesley.
Cristi, R., Papoulias, F.A., and Healey, A.J. 1990. Adaptive sliding mode control of autonomous underwater vehicles in the dive plane. IEEE Journal of Oceanic Engineering, 15(3):152–160.
Dougherty, F., Sherman, T., Woolweaver, G., and Lovell, G. 1988. An autonomous underwater vehicle (AUV) flight control system using sliding mode control. Oceans'88, IEEE, pp. 1265–1270.
Goheen, K.R. and Jefferys, E.R. 1990. Multivariable self-tuning autopilots for autonomous and remotely operated underwater vehicles. IEEE Journal of Oceanic Engineering, 15(3):144–151.
Healey, A.J. and Lienard, D. 1993. Multivariable sliding-mode control for autonomous diving and steering of unmanned underwater vehicles. IEEE Journal of Oceanic Engineering, 18(3):327–339.
Healey, A.J., Rock, S.M., Cody, S., Miles, D., and Brown, J.P. 1995. Toward an improved understanding of thruster dynamics underwater vehicles. IEEE Journal of Oceanic Engineering.
Koval, E.V. 1994. Automatic stabilization system of underwater manipulation robot. Oceans '94 Proceedings, IEEE, pp. I-807–I-812.
Lévesque, B. and Richard, M.J. 1994. Dynamic analysis of a manipulator in a fluid environment. International Journal of Robotics Research, 13(3):221–231.
Mahesh, H., Yuh, J., and Lakshmi, R. 1991. A coordinated control of an underwater vehicle and robotic manipulator. Journal of Robotic Systems, 8(3):339–370.
McLain, T.W. 1995. Modeling of underwater manipulator hydrodynamics with application to the coordinated control of an arm/vehicle system. Stanford University.
McMillan, S., Orin, D.E., and McGhee, R.B. 1994. Efficient dynamic simulation of an unmanned underwater vehicle with a manipulator. Proceedings of the International Conference on Robotics and Automation, pp. 1133–1140.
Sarpkaya, T. 1963. Lift, drag, and added-mass coefficients for a circular cylinder immersed in a time-dependent flow. Journal of Applied Mechanics, pp. 13–15.
Sarpkaya, T. and Garrison, C.J. 1963. Vortex formation and resistance in unsteady flow. Journal of Applied Mechanics, pp. 16–24.
Tarn T.J., Shoults, G.A., and Yang, S. 1995. Dynamical model for a free-floating underwater robotic vehicle with an n-axis manipulator. Proceedings of the U.S.-Portugal Workshop on Undersea Robotics and Intelligent Control.
Wang, H.H., Marks, R.L., Rock, S.M., and Lee, M.J. 1993. Task-based control architecture for an untethered, unmanned submersible. Proceedings of the 8th Annual Symposium of Unmanned Untethered Submersible Technology, Marine Systems Engineering Laboratory, Northeastern University, pp. 137–147.
Wang, H.H., Marks, R.L., McLain, T.W., Fleischer, S.D., Miles, D.W., Sapilewski, G.A., Rock, S.M., Lee, M.J., and Burton, R.C. 1995. A testbed submersible for robotics research. Proceedings of the ANS 6th Topical Meeting on Robotics and Remote Systems, American Nuclear Society.
Wang, H., Rock, S.M., and Lee, M.J. 1996. The design and development of an intelligent underwater robot. Autonomous Robots, 3(2,3):297–320.
Yoerger, D.R. and Slotine, J-J.E. 1985. Robust trajectory control of underwater vehicles. IEEE Journal of Oceanic Engineering, 10(4):462–470.
Yoerger, D.R. and Slotine, J-J.E. 1991. Adaptive sliding control of an experimental underwater vehicle. Proceedings of the International Conference on Robotics and Automation, pp. 2746–2751.
Yuh, J. 1990. A neural net controller for underwater robotic vehicles. IEEE Journal of Oceanic Engineering, 15(3):161–166.
1992. Control Shell user's manual: A real-time software framework. Real-Time Innovations, Inc., 155A Moffett Park Drive, Suite III, Sunnyvale, CA 94089.
1993. Programmer's Guide 5.1, Wind River Systems, Inc., 1010 Atlantic Avenue, Alameda, CA 94501-1147.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
McLain, T.W., Rock, S.M. & Lee, M.J. Experiments in the coordinated control of an underwater arm/vehicle system. Auton Robot 3, 213–232 (1996). https://doi.org/10.1007/BF00141156
Issue Date:
DOI: https://doi.org/10.1007/BF00141156