Abstract
The colour of processed mealworms is an important attribute that affects their utilization in food industry. Totally 15 colour and related spectral variables of powders prepared from differently processed (oven drying, freeze-drying, microwave drying, blanching, and their combinations) mealworms larvae (Tenebrio molitor) were evaluated by UV/Vis spectroscopy and multivariate analysis. The results obtained confirmed deterioration of mealworms colour after processing. In general, processing led to a decrease of lightness (L*), hue angle (h°), whiteness-blue-reflectance, whiteness index (WI) and tinting index coinciding with an increase in the yellowness index (YI), redness (a*), browning index (BI) and total colour difference (ΔE) compared to untreated larvae. Oven drying at higher temperature caused the pronounced darkening described by the highest BI and ΔE values (ΔE = 28.54 ± 0.37, BI = 53.78 ± 0.31). On the other hand, freeze-drying was the most suitable colour protection method. Based on lower BI and ΔE values, the combination of 3 min blanching with microwave and oven drying can be recommended as a proper alternative to freeze-drying. Most of the colour descriptors of processed larvae differed significantly from each other (p < 0.05). Absolute discrimination of processed mealworms larvae was achieved through principal component analysis and discriminant analysis. Values of L*, yellowness (b*), chroma, BI, ΔE and whiteness-blue-reflectance were identified as the most discriminating. Moreover, mutual correlations of monitored parameters, e.g. tinting and WI; a*, b* and C* values; or L* and ΔE were revealed by principal component factoring.
Similar content being viewed by others
References
A. Cappelli, E. Cini, C. Lorini, N. Oliva, G. Bonaccorsi, Food Control (2020). https://doi.org/10.1016/j.foodcont.2019.106877
A. van Huis, Annu. Rev. Entomol. 58, 563 (2013)
A. Bordiean, M. Krzyżaniak, M.J. Stolarski, S. Czachorowski, D. Peni, Agriculture 10, 233 (2020)
Commission European Regulation (EU) 2015/2283 of the European Parliment and of the Council of 25 November 2015 on novel foods, amending regulation (EU) no 1169/2011 of the European Parliament and of the Council and repealing Regulation (EC) No 258/97 of the European Parliament and of the Council and Commission Regulation (EC) No 1852/2001 Official Journal of the European Union, vol. L 327/1, (2015)
D. Turck, J. Castenmiller, S. Henauw, J. Kearney, A. Maciuk, C. Pelaez, F. Thies, S. Tsabouri, F. Cubadda, T. Frenzel, R. Marchelli, M. Prieto, J. Schlatter, H. Knutsen, K. Hirsch-Ernst, A. Naska, M. Heinonen, M. Poulsen, H. Loveren, I. Mangelsdorf, EFSA J. (2021). https://doi.org/10.2903/j.efsa.2021.6344
H.-W. Kim, D. Setyabrata, Y.J. Lee, O.G. Jones, Y.H.B. Kim, Innov. Food Sci. Emerg. Technol. 38, 116 (2016)
T.K. Kim, H.I. Yong, Y.B. Kim, H.W. Kim, Y.S. Choi, Food Sci. Anim. Resour. 39, 521 (2019)
N. Kröncke, S. Grebenteuch, C. Keil, S. Demtröder, L. Kroh, A.F. Thünemann, R. Benning, H. Haase, Insects (2019). https://doi.org/10.3390/insects10040084
N. Ravzanaadii, S.-H. Kim, W.H. Choi, S.-J. Hong, N.-J. Kim, Int. J. Ind. Entomol. 25, 93 (2012)
A. Thévenot, J.L. Rivera, A. Wilfart, F. Maillard, M. Hassouna, T. Senga-Kiesse, S. Le Féon, J. Aubin, J. Clean. Prod. 170, 1260 (2018)
G. Huang, W. Feng, J. Xiong, T. Wang, W. Wang, C. Wang, F. Yang, Eur. Food Res. Technol. 245, 11 (2019)
S. Lenaerts, M. Van Der Borght, A. Callens, L. Van Campenhout, Food Chem. 254, 129 (2018)
R. Melis, A. Braca, G. Mulas, R. Sanna, S. Spada, G. Serra, M.L. Fadda, T. Roggio, S. Uzzau, R. Anadda, Innov. Food Sci. Emerg. Technol. 48, 138 (2018)
M. Elhassan, K. Wendin, V. Olsson, M. Langton, Foods (2019). https://doi.org/10.3390/foods8030095
H. Seo, H.R. Kim, I.H. Cho, Food Sci. Anim. Resour. 40, 649 (2020)
D. Azzollini, A. Derossi, C. Severini, J. Insects Food Feed. 2, 233 (2016)
B. Purschke, H. Brüggen, R. Scheibelberger, H. Jäger, Eur. Food Res. Technol. 244, 269 (2018)
G. Ssepuuya, D. Nakimbugwe, A. de Winne, R. Smets, J. Claes, M. Van Der Borght, Food Res. Int. (2020). https://doi.org/10.1016/j.foodres.2019.108831
C. Witzel, K.R. Gegenfurtner, Annu. Rev. Vis. Sci. 4, 475 (2018)
M. Mascan, J. Food Eng. 48, 169 (2001)
P.B. Pathare, U.L. Opara, F.J. Al-Said, Food Bioprocess Technol. 6, 36 (2013)
A. Dankowska, A. Domagała, W. Kowalewski, Talanta 172, 215 (2017)
M. Rafi, R. Jannah, R. Heryanto, R. Kautsar, D.A. Septaningsih, Int. Food Res. J. 25, 643 (2018)
M. Ferreiro-González, G.F. Barbero, J.A. Álvarez, A. Ruiz, M. Palma, J. Ayuso, Food Chem. 220, 331 (2017)
X.-L. Yu, Y. He, Spectrosc. Lett. 51, 112 (2018)
A. Bordagaray, S. Dávila, R. Garcia-Arrona, M. Vidal, M. Ostra, J. Chemom. (2019). https://doi.org/10.1002/cem.3176
E. Rohaeti, K. Muzayanah, D.A. Septaningsih, M. Rafi, Indones. J. Chem. 19, 668 (2019)
T. Afonso, R. Moresco, V.G. Uarrota, B.B. Navarro, E.C. Nunes, M. Maraschin, M. Rocha, J. Integr. Bioinform. (2017). https://doi.org/10.1515/jib-2017-0056
J. Mlcek, O. Rop, M. Borkovcoca, M. Bednarova, Pol. J. Food Nutr. Sci. 64, 147 (2014)
H.S.G. Tan, A.R.H. Fischer, P. Tinchan, M. Stieger, L.P.A. Steenbekkers, H.C.M. van Trijp, Food Qual. Prefer. 42, 78 (2015)
C.M. Collins, P. Vaskou, Y. Kountouris, Ann. Entomol. Soc. Am. 112, 518 (2019)
A.M. Gueli, G. Bonfiglio, S. Pasquale, S.O. Troja, Color Res. Appl. 42, 236 (2017)
C. Cheico, L. Morrone, G. Bertazza, S. Cappelloza, A. Saviane, F. Gai, N. Di Virgilio, F. Rosi, Animals (Basel) (2019). https://doi.org/10.3390/ani9030103
J.C. Senar, A.P. Møller, I. Ruiz, J.J. Negro, J. Broggi, E. Hohtola, PLoS ONE (2010). https://doi.org/10.1371/journal.pone.0010716
A.A. Gonçalves, A.R.M. de Oliveira, LWT - Food Sci. Technol. 65, 791 (2016)
LabCognition, Colorimetric analysis manual. (LabCognition online software help manual, 2009). https://www.labcognition.com/onlinehelp/en/definitions1.htm. Accessed 2 Dec 2020
R. Hirschler, in Color in food: technological and psychophysical aspects. ed. by J.L. Caivano, M.P. Buera (CRC Press, Boca Raton, 2012), pp. 93–103
N. Kotwaliwale, P. Bakane, A. Verma, J. Food Eng. 78, 1207 (2007)
J.J. Sheehan, A.D. Patel, M.A. Drake, P.L.H. McSweeney, Int. Dairy J. 19, 498 (2009)
B. Singh, D.V. Parwate, S.K. Shukla, AAPS PharmSciTech 10, 34 (2009)
Acknowledgements
This contribution is the result of the project APVV-17-0538, “Establishment of pilot facility and the development of mass rearing methods for edible insects production”, supported by the Slovak Research and Development Agency.
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
The authors declare that there is no conflict of interest.
Informed consent
All the authors participated/contributed to this study.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Tobolková, B., Takáč, P., Mangová, B. et al. A comparative study of colour characteristics of thermally/non-thermally treated mealworm larvae (Tenebrio molitor) by means of UV/Vis spectroscopy and multivariate analysis. Food Measure 15, 3791–3799 (2021). https://doi.org/10.1007/s11694-021-00957-z
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s11694-021-00957-z