Abstract
Nanoscale heat transfer at the head/disk interface is investigated for thermal flying height control sliders in hard disk drives. Near-field radiation effects due to evanescent photo tunneling are considered in addition to thermal conduction. It is found that the maximum value of the heat flux due to near-field thermal radiation is comparable to that from heat conduction. Near-field thermal radiation is shown to cause a decrease in the thermal protrusion, resulting in a larger flying height than predicted for the case that near-field radiation is neglected. Results from this study are useful for the design of high-performance disk drives.
Similar content being viewed by others
References
Kyder, M.H., Gustafson, R.W.: High-density perpendicular recording—advances, issues, and extensibility. J. Magn. Magn. Mater. 287, 449–458 (2005)
Yeack-Scranton, C.E., Khanna, V.D., Etzold, K.F., Praino, A.P.: An active slider for practical contact recording. IEEE Trans. Magn. 26, 2478–2483 (1990)
Zheng, J., Bogy, D.B., Zhang, S., Yan, W.: Effects of altitude on thermal flying-height control actuation. Tribol. Lett. 40, 295–299 (2010)
Chen, D., Bogy, D.: Simulation of static flying attitudes with different heat transfer models for a flying-height control slider with thermal protrusion. Tribol. Lett. 40, 31–39 (2010)
Dahl, J.B., Bogy, D.B.: Static and dynamic slider air-bearing behavior in heat-assisted magnetic recording under thermal flying height control and laser system-induced protrusion. Tribol. Lett. 54, 35–50 (2014)
Zheng, J., Bogy, D.B.: Investigation of flying-height stability of thermal fly-height control sliders in lubricant or solid contact with roughness. Tribol. Lett. 38, 283–289 (2010)
Zheng, H., Li, H., Talke, F.E.: Numerical simulation of a thermal flying height control slider with dual heater and insulator elements. IEEE Trans. Magn. 45, 3628–3631 (2009)
Zhang, S., Bogy, D.B.: A heat transfer model for thermal fluctuation in a thin slider/disk air bearing. Int. J. Heat Mass Transf. 42, 1791–1800 (1999)
Chen, L., Bogy, D.B., Strom, B.: Thermal dependence of MR signal on slider flying state. IEEE Trans. Magn. 36, 2486–2489 (2000)
Ju, Y.: Thermal conduction and viscous heating in microscale Couette flows. ASME J. Heat Transf. 122, 817–818 (2000)
Shen, S., Chen, G.: A kinetic theory analysis on the heat transfer in hard drive air bearing. J. Appl. Phys. 103, 054304 (2008)
Zhou, W., Liu, B., Yu, S., Hua, W., Wong, C.: A generalized heat transfer model for thin film bearings at head-disk interface. Appl. Phys. Lett. 92, 043109 (2008)
Volokitin, A.I., Persson, B.N.J.: Near-field radiative heat transfer and noncontact friction. Rev. Mod. Phys. 79, 1291–1329 (2007)
Basu, S., Zhang, Z., Fu, C.: Review of near-field thermal radiation and its application to energy conversion. Int. J. Energy Res. 33, 1203–1232 (2009)
Shen, S., Narayanaswamy, A., Chen, G.: Surface phonon polaritons mediated energy transfer between nanoscale gaps. Nano Lett. 9, 2909–2913 (2009)
Polder, D., Van Hove, M.: Theory of radiative heat transfer between closely spaced bodies. Phys. Rev. B 4, 3303 (1971)
Rytov, S.M.: Theory of Electric Fluctuations and Thermal Radiation. Air Force Cambridge Research Center, Bedford, MA (1959)
Pendry, J.B.: Radiative exchange of heat between nanostructures. J. Phys. Condens. Matter 11, 6621–6633 (1999)
Volokitin, A.I., Persson, B.N.J.: Resonant photon tunneling enhancement of the radiative heat transfer. Phys. Rev. B 69, 045417 (2004)
Fu, C.J., Zhang, Z.M.: Nanoscale radiation heat transfer for silicon at different doping levels. Int. J. Heat Mass Transf. 49, 1703–1718 (2006)
Basu, S., Lee, B.J., Zhang, Z.M.: Near-field radiation calculated with an improved dielectric function model for doped silicon. J. Heat Transf. 132, 023302 (2010)
Mirmoosa, M.S., Rüting, F., Nefedov, I.S., Simovski, C.R.: Effective-medium model of wire metamaterials in the problems of radiative heat transfer. J. Appl. Phys. 115, 234905 (2014)
Basu, S., Francoeur, M.: Penetration depth in near-field radiative heat transfer between metamaterials. Appl. Phys. Lett. 99, 143107 (2011)
Rodriguez, A.W., Reid, M.T.H., Johnson, S.G.: Fluctuating-surface-current formulation of radiative heat transfer: theory and applications. Phys. Rev. B 88, 054305 (2013)
Phan, A.D., Phan, T.L., Woods, L.M.: Near-field heat transfer between gold nanoparticle arrays. J. Appl. Phys. 114, 214306 (2013)
Budaev, B.V., Bogy, D.B.: Computation of radiative heat transport across a nanoscale vacuum gap. Appl. Phys. Lett. 104, 061109 (2014)
Budaev, B.V., Bogy, D.B.: Extension of Planck’s law of thermal radiation to systems with a steady heat flux. Ann. Phys. 523, 791–804 (2011)
Zheng, H., Zhang, S., Yan, W., Pust, L., Fowler, D., Talke, F.E.: The effect of thermal radiation on thermal flying height control sliders. IEEE Trans. Magn. 46(6), 2376–2378 (2010)
Zhang, Z.M.: Nano/Microscale Heat Transfer. McGraw-Hill, New York (2007)
Liu, X., Zhang, Z.M.: Graphene-assisted near-field radiative heat transfer between corrugated polar materials. Appl. Phys. Lett. 104, 251911 (2014)
Gervais, F., Piriou, B.: Anharmonicity in several-polar-mode crystals: adjusting phonon self-energy of LO and TO modes in Al2O3 and TiO2 to fit infrared reflectivity. J. Phys. C Solid State Phys. 7, 2374–2386 (1974)
Fukui, S., Kaneko, R.: Analysis of ultra-thin gas film lubrication based on linearized Boltzmann equation: first report-derivation of a generalized lubrication equation including thermal creep flow. ASME J. Tribol. 110, 253–262 (1988)
Li, H., Zheng, H., Yoon, Y., Talke, F.E.: Air bearing simulation for bit patterned media. Tribol. Lett. 33, 199–204 (2009)
Juang, J.: Transient characteristics of nanoscale air bearings subjected to Joule heating. Tribol. Lett. 53, 255–260 (2014)
Wahl, M., Lee, P., Talke, F.E.: An efficient finite element-based air bearing simulator for pivoted slider bearings using bi-conjugate gradient algorithms. STLE Tribol. Trans. 39(1), 130–138 (1996)
Acknowledgments
We gratefully acknowledge the help of Prof. Z.M. Zhang from Georgia Institute of Technology in the calculation of near-field thermal radiation and helpful discussions with Prof. Lubarda from UCSD.
Author information
Authors and Affiliations
Corresponding author
Rights and permissions
About this article
Cite this article
Li, L., Zheng, H. & Talke, F.E. Investigation of Nanoscale Heat Transfer and Flying Characteristics in Thermal Flying Height Control Sliders Considering Near-Field Radiation. Tribol Lett 59, 12 (2015). https://doi.org/10.1007/s11249-015-0546-x
Received:
Accepted:
Published:
DOI: https://doi.org/10.1007/s11249-015-0546-x