Skip to main content
SpringerLink
Log in

Study on Influence of Semi-carbonization Treatment on Co-gasification of Biomass and Coal

  • Published:
Solid Fuel Chemistry Aims and scope Submit manuscript

Abstract

The huge demand for energy has led to the massive consumption of coal, causing serious resource and environmental problems. Biomass energy resources are abundant, have a small impact on the environment, are renewable, and have great development potential. However, due to their inherent disadvantages, they are difficult to use on a large scale. Pre-treating biomass through pyrolysis can significantly improve its performance. At the same time, co-gasification of biomass and coal can fully exploit the advantages of high energy density of coal and high reactivity of biomass, making up for the shortcomings of gasification alone. This is of great significance for the industrial utilization of biomass energy on a large scale and the optimization of China’s energy structure. In this paper, corn stalks, rice straw, wheat straw and bituminous coal were used as experimental materials. Firstly, biomass was semi-carbonized at 200–600°C, and the changes in the structure and chemical properties of biomass were investigated. Then, thermal analysis technology was used to study the CO2 reaction characteristics of semi-carbonized biomass and biomass-coal mixture, and further explore the synergistic mechanism.

As the pyrolysis temperature increased, the fixed carbon and volatile content of semi-carbonized biomass increased, volatile matter decreased, O/C and H/C atomic ratios decreased, and the degree of coalification of biomass was transformed into anthracite. The chemical characteristics of biomass were studied using scanning electron microscopy (SEM), specific surface area, Fourier transform infrared absorption spectroscopy (FTIR), etc. The results showed that the polar functional groups in biomass decreased continuously, aromaticity increased continuously, carbon structure became more stable, and heat resistance increased. Higher fixed carbon content and more stable carbon structure increased the starting temperature, ending temperature and maximum weight loss rate of non-isothermal gasification process; isothermal gasification experiments determined that the gasification performance of biomass samples prepared at low temperature (200–300°C) would be slightly higher than that of raw samples, while the gasification performance of medium-high temperature (400–600°C) biomass carbon was lower than that of raw samples. The difference in gasification performance was the result of the combined effect of carbon structure stability and alkali metal content in biomass. Scanning electron microscopy-energy dispersive X-ray spectroscopy (SEM-EDX) was used to study the physicochemical structure of co-pyrolysis coke and gasification residue. The results showed that the aromaticity of co-pyrolysis coke decreased and the stacking height of aromatic layers decreased. Alkali metals in semi-coke hindered the ordering process of co-pyrolysis coke, inhibited graphitization, and alkali metals accumulated on the surface of coal coke and reacted with carbon matrix during gasification process to become active centers for gasification reaction, promoting co-gasification reaction.

This is a preview of subscription content, log in via an institution to check access.

Access this article

Log in via an institution

Price excludes VAT (USA)
Tax calculation will be finalised during checkout.

Instant access to the full article PDF.

Institutional subscriptions

Fig. 1.
Fig. 2.
Fig. 3.
Fig. 4.
Fig. 5.
Fig. 6.
Fig. 7.
Fig. 8.
Fig. 9.
Fig. 10.
Fig. 11.
Fig. 12.
Fig. 13.
Fig. 14.
Fig. 15.

REFERENCES

  1. BP p.l.c., BP Statistical Review of World Energy. https://www.bp.com/en/global/corporate/energy–economics/statistical–review–of–world–energy.html,2020.

  2. Rokni, E., Panahi, A., Ren, X., and Levendis, Yi.A., Curtailing the generation of sulfur dioxide and nitrogen oxide emissions by blending and oxy-combustion of coals, Fuel, 2001, vol. 181, pp. 772–784. https://doi.org/10.1016/j.fuel.2016.05.023

    Article  CAS  Google Scholar 

  3. Tumuluru, J.S., Wright, C.T., and Boardman, R.D., A review on biomass classification and composition, co-firing issues and pretreatment methods, Louisville, Ky.: American Society of Agricultural and Biological Engineers, 2011, p. 1. https://doi.org/10.13031/2013.37191

    Book  Google Scholar 

  4. Baxter, L.L., Miles, T.R., Miles, T.R., Jenkins, B.M., Milne, T., Dayton, D., Bryers, R.W., and Oden, L.L., The behavior of inorganic material in biomass-fired power boilers: field and laboratory experiences, Fuel Process. Technol., 1998, vol. 54, nos. 1–3, pp. 47–78. https://doi.org/10.1016/s0378-3820(97)00060-x

    Article  CAS  Google Scholar 

  5. Van der Stelt, M.J.C., Gerhauser, H., Kiel, J.H.A., and Ptasinski, K.J., Biomass upgrading by torrefaction for the production of biofuels: A review, Biomass Bioenergy, 2011, vol. 35, no. 9, pp. 3748–3762. https://doi.org/10.1016/j.biombioe.2011.06.023

    Article  CAS  Google Scholar 

  6. Patra, T.K. and Sheth, P.N., Biomass gasification models for downdraft gasifier: A state-of-the-art review, Renewable Sustainable Energy Rev., 2015, vol. 50, pp. 583–593. https://doi.org/10.1016/j.rser.2015.05.012

    Article  CAS  Google Scholar 

  7. Kim, K.H., Kim, J.-Yo., Cho, T.-S., and Choi, J.W., Influence of pyrolysis temperature on physicochemical properties of biochar obtained from the fast pyrolysis of pitch pine (Pinus rigida), Bioresour. Technol., 2012, vol. 118, pp. 158–162. https://doi.org/10.1016/j.biortech.2012.04.094

    Article  CAS  PubMed  Google Scholar 

  8. Ruiz, J.A., Juárez, M.C., Morales, M.P., Muñoz, P., and Mendívil, M.A., Biomass gasification for electricity generation: Review of current technology barriers, Renewable Sustainable Energy Rev., 2013, vol. 18, pp. 174–183. https://doi.org/10.1016/j.rser.2012.10.021

    Article  CAS  Google Scholar 

  9. Taba, L.E., Irfan, M.F., Daud, W.A.M.W., and Chakrabarti, M.H., The effect of temperature on various parameters in coal, biomass and CO-gasification: A review, Renewable Sustainable Energy Rev., 2012, vol. 16, no. 8, pp. 5584–5596. https://doi.org/10.1016/j.rser.2012.06.015

    Article  CAS  Google Scholar 

  10. Zhang, Y., Ashizawa, M., Kajitani, S., and Miura, K., Proposal of a semi-empirical kinetic model to reconcile with gasification reactivity profiles of biomass chars, Fuel, 2008, vol. 87, nos. 4–5, pp. 475–481. https://doi.org/10.1016/j.fuel.2007.04.026

    Article  CAS  Google Scholar 

  11. Mafu, L.D., Neomagus, H.W.J.P., Everson, R.C., Okolo, G.N., Strydom, C.A., and Bunt, J.R., The carbon dioxide gasification characteristics of biomass char samples and their effect on coal gasification reactivity during CO-gasification, Bioresour. Technol., 2018, vol. 258, pp. 70–78. https://doi.org/10.1016/j.biortech.2017.12.053

    Article  CAS  PubMed  Google Scholar 

  12. Ding, L., Zhang, Yo., Wang, Z., Huang, J., and Fang, Yi., Interaction and its induced inhibiting or synergistic effects during CO-gasification of coal char and biomass char, Bioresour. Technol., 2014, vol. 173, pp. 11–20. https://doi.org/10.1016/j.biortech.2014.09.007

    Article  CAS  PubMed  Google Scholar 

  13. Yang, X., Liu, X., Li, R., Liu, C., Qing, T., Yue, X., and Zhang, S., CO-gasification of thermally pretreated wheat straw with Shengli lignite for hydrogen production, Renewable Energy, 2018, vol. 117, pp. 501–508. https://doi.org/10.1016/j.renene.2017.10.055

    Article  CAS  Google Scholar 

  14. Kuo, P. and Wu, W., Thermodynamic analysis of a combined heat and power system with CO2 utilization based on CO-gasification of biomass and coal, Chem. Eng. Sci., 2016, vol. 142, pp. 201–214. https://doi.org/10.1016/j.ces.2015.11.030

    Article  CAS  Google Scholar 

  15. Jian, D., Experimental study on biomass and coal co-gasification and its synergistic effect, PhD Thesis, Shanghai: Shanghai Jiao Tong Univ.

  16. Zhang, Ya., Geng, P., and Liu, R., Synergistic combination of biomass torrefaction and co-gasification: Reactivity studies, Bioresour. Technol., 2017, vol. 245, pp. 225–233. https://doi.org/10.1016/j.biortech.2017.08.197

    Article  CAS  PubMed  Google Scholar 

Download references

Funding

This work was supported by Science and technology project of China Petroleum & Chemical Corporation (Grant No. 223141).

Author information

Authors and Affiliations

  1. School of Chemical Engineering, Anhui University of Science and Technology, 232001, Huainan, China

    Wu Chengli, Shen Shuhao, Li Hanxu, Fan Honggui & Gui Guoyang

Authors
  1. Wu Chengli
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Shen Shuhao
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Li Hanxu
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Fan Honggui
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. Gui Guoyang
    View author publications

    You can also search for this author in PubMed Google Scholar

Corresponding author

Correspondence to Wu Chengli.

Ethics declarations

The authors of this work declare that they have no conflicts of interest.

Additional information

Publisher’s Note.

Allerton Press remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Chengli, W., Shuhao, S., Hanxu, L. et al. Study on Influence of Semi-carbonization Treatment on Co-gasification of Biomass and Coal. Solid Fuel Chem. 57, 455–471 (2023). https://doi.org/10.3103/S0361521923080074

Download citation

  • Received:

  • Revised:

  • Accepted:

  • Published:

  • Issue Date:

  • DOI: https://doi.org/10.3103/S0361521923080074

Keywords:

Search

Navigation