Abstract
The degradation of cement mortar subject to combined chloride ingress and sulfate attack under cyclic wetting–drying condition was studied through microstructural analysis. The specimens were exposed alternatively to a designated salt solution (NaCl, Na2SO4, or a mixture of NaCl and Na2SO4 solution) and air drying to simulate the natural conditions of tidal zones in the marine environment. Backscattered electron micrographs obtained with scanning electron microscopy showed three distinct layers formed from the surface inwards after exposure. The elemental distribution and phase composition of these layers were studied with energy dispersive spectroscopy through elemental mapping and point analysis, respectively. Phase changes after exposure were identified and compared among layers to understand the interaction between chloride and sulfate ions. The results showed a progressively layered degradation of cement mortar subject to the wetting and drying cycle, including a leaching zone, a deposition layer, and an inner area with relatively unaltered microstructure but with signs of ion penetration. Sulfate and chloride ions had mutual inhibiting effects on each other in cement mortar and the penetration depths of these two types of ions were different. A mechanism of progressively layered degradation of cement mortar under the investigating condition was proposed and discussed.
Similar content being viewed by others
References
Yi Y, Zhu D, Guo S et al (2020) A review on the deterioration and approaches to enhance the durability of concrete in the marine environment. Cem Concr Compos. https://doi.org/10.1016/j.cemconcomp.2020.103695
Shi X, Xie N, Fortune K, Gong J (2012) Durability of steel reinforced concrete in chloride environments: an overview. Constr Build Mater 30:125–138
Santhanam M, Cohen MD, Olek J (2001) Sulfate attack research—Whither now? Cem Concr Res 31:845–851
Santhanam M, Cohen MD, Olek J (2003) Effects of gypsum formation on the performance of cement mortars during external sulfate attack. Cem Concr Res 33:325–332. https://doi.org/10.1016/S0008-8846(02)00955-9
De Weerdt K, Justnes H (2015) The effect of sea water on the phase assemblage of hydrated cement paste. Cem Concr Compos 55:215–222. https://doi.org/10.1016/j.cemconcomp.2014.09.006
De Weerdt K, Orsáková D, Geiker MR (2014) The impact of sulphate and magnesium on chloride binding in Portland cement paste. Cem Concr Res 65:30–40. https://doi.org/10.1016/j.cemconres.2014.07.007
Maes M, De Belie N (2014) Resistance of concrete and mortar against combined attack of chloride and sodium sulphate. Cem Concr Compos 53:59–72. https://doi.org/10.1016/j.cemconcomp.2014.06.013
Maes M, De Belie N (2017) Influence of chlorides on magnesium sulphate attack for mortars with Portland cement and slag based binders. Constr Build Mater 155:630–642. https://doi.org/10.1016/j.conbuildmat.2017.07.201
Maes M, Mittermayr F, De Belie N (2017) The influence of sodium and magnesium sulphate on the penetration of chlorides in mortar. Mater Struct Constr. https://doi.org/10.1617/s11527-017-1024-8
Zuquan J, Wei S, Yunsheng Z et al (2007) Interaction between sulfate and chloride solution attack of concretes with and without fly ash. Cem Concr Res 37:1223–1232. https://doi.org/10.1016/j.cemconres.2007.02.016
Glasser FP, Marchand J, Samson E (2008) Durability of concrete—Degradation phenomena involving detrimental chemical reactions. Cem Concr Res 38:226–246. https://doi.org/10.1016/j.cemconres.2007.09.015
Yuan Q, Shi C, De Schutter G et al (2009) Chloride binding of cement-based materials subjected to external chloride environment—A review. Constr Build Mater 23:1–13
Frias M, Goñi S, García R, De La Villa RV (2013) Seawater effect on durability of ternary cements. Synergy of chloride and sulphate ions. Compos Part B Eng 46:173–178. https://doi.org/10.1016/j.compositesb.2012.09.089
Ukpata JO, Basheer PAM, Black L (2019) Slag hydration and chloride binding in slag cements exposed to a combined chloride-sulphate solution. Constr Build Mater 195:238–248. https://doi.org/10.1016/j.conbuildmat.2018.11.055
Geng J, Easterbrook D, Li LY, Mo LW (2015) The stability of bound chlorides in cement paste with sulfate attack. Cem Concr Res 68:211–222. https://doi.org/10.1016/j.cemconres.2014.11.010
Yang Z, Jiang J, Jiang X et al (2019) The influence of sodium sulfate and magnesium sulfate on the stability of bound chlorides in cement paste. Constr Build Mater. https://doi.org/10.1016/j.conbuildmat.2019.116775
Yu LB, Jiang LH, Chu HQ et al (2019) Effect of electrochemical chloride removal and ground granulated blast furnace slag on the chloride binding of cement paste subjected to NaCl and Na2SO4 attack. Constr Build Mater 220:538–546. https://doi.org/10.1016/j.conbuildmat.2019.06.033
Cao Y, Guo L, Chen B, Wu J (2020) Thermodynamic modelling and experimental investigation on chloride binding in cement exposed to chloride and chloride-sulfate solution. Constr Build Mater. https://doi.org/10.1016/j.conbuildmat.2020.118398
Chen Z, Wu L, Bindiganavile V, Yi C (2020) Coupled models to describe the combined diffusion-reaction behaviour of chloride and sulphate ions in cement-based systems. Constr Build Mater. https://doi.org/10.1016/j.conbuildmat.2020.118232
Li G, Zhang A, Song Z et al (2018) Ground granulated blast furnace slag effect on the durability of ternary cementitious system exposed to combined attack of chloride and sulfate. Constr Build Mater 158:640–648. https://doi.org/10.1016/j.conbuildmat.2017.10.062
Xu F, Yang Z, Liu W et al (2020) Experimental investigation on the effect of sulfate attack on chloride diffusivity of cracked concrete subjected to composite solution. Constr Build Mater. https://doi.org/10.1016/j.conbuildmat.2019.117643
Lee ST, Park DW, Ann KY (2008) Mitigating effect of chloride ions on sulfate attack of cement mortars with or without silica fume. Can J Civ Eng 35:1210–1220. https://doi.org/10.1139/L08-065
Zhang M, Chen J, Lv Y et al (2013) Study on the expansion of concrete under attack of sulfate and sulfate-chloride ions. Constr Build Mater. https://doi.org/10.1016/j.conbuildmat.2012.05.003
Du J, Tang Z, Li G et al (2019) Key inhibitory mechanism of external chloride ions on concrete sulfate attack. Constr Build Mater 225:611–619. https://doi.org/10.1016/j.conbuildmat.2019.07.263
Du J, Ye J, Li G (2017) Inhibitory effects of chloride ions on concrete sulfate attack in the marine adsorption environment. Mar Georesour Geotechnol 35:371–375. https://doi.org/10.1080/1064119X.2016.1174759
Jiang L, Niu D (2016) Study of deterioration of concrete exposed to different types of sulfate solutions under drying-wetting cycles. Constr Build Mater 117:88–98. https://doi.org/10.1016/j.conbuildmat.2016.04.094
Shaheen F, Pradhan B (2020) Role of chloride ion and cation type accompanied by sulfate ion on durability performance of concrete in conjoint chloride-sulfate environment. J Mater Civ Eng 32:04020264. https://doi.org/10.1061/(asce)mt.1943-5533.0003319
Ukpata JO, Muhammed Basheer PA, Black L (2018) Performance of plain and slag-blended cements and mortars exposed to combined chloride-sulfate solution. Adv cem res 30(8):371–386
Ukpata JO, Muhammed Basheer PA, Black L (2019) Expansion of CEM I and slag-blended cement mortars exposed to combined chloride-sulphate environments. Cem Concr Res. https://doi.org/10.1016/j.cemconres.2019.105794
Yang Y, Zhang Y, She W et al (2018) In situ observing the erosion process of cement pastes exposed to different sulfate solutions with X-ray computed tomography. Constr Build Mater 176:556–565. https://doi.org/10.1016/j.conbuildmat.2018.05.093
Ye H, Jin N, Jin X et al (2016) Chloride ingress profiles and binding capacity of mortar in cyclic drying-wetting salt fog environments. Constr Build Mater 127:733–742. https://doi.org/10.1016/j.conbuildmat.2016.10.059
Brown PW, Badger S (2000) Distributions of bound sulfates and chlorides in concrete subjected to mixed NaCl, MgSO4, Na2SO4 attack. Cem Concr Res 30:1535–1542. https://doi.org/10.1016/S0008-8846(00)00386-0
Jakobsen UH, De Weerdt K, Geiker MR (2016) Elemental zonation in marine concrete. Cem Concr Res 85:12–27. https://doi.org/10.1016/j.cemconres.2016.02.006
Faucon P, Adenot F, Jacquinot JF et al (1998) Long-term behaviour of cement pastes used for nuclear waste disposal: review of physico-chemical mechanisms of water degradation. Cem Concr Res 28:847–857. https://doi.org/10.1016/S0008-8846(98)00053-2
Haga K, Sutou S, Hironaga M et al (2005) Effects of porosity on leaching of Ca from hardened ordinary Portland cement paste. Cem Concr Res 35:1764–1775. https://doi.org/10.1016/j.cemconres.2004.06.034
Jain J, Neithalath N (2009) Analysis of calcium leaching behavior of plain and modified cement pastes in pure water. Cem Concr Compos 31:176–185. https://doi.org/10.1016/j.cemconcomp.2009.01.003
Carde C, Escadeillas G, François R (1997) Use of ammonium nitrate solution to simulate and accelerate the leaching of cement pastes due to deionized water. Mag Concr Res 49:295–301. https://doi.org/10.1680/macr.1997.49.181.295
Carde C, François R (1997) Effect of the leaching of calcium hydroxide from cement paste on mechanical and physical properties. Cem Concr Res 27:539–550. https://doi.org/10.1016/S0008-8846(97)00042-2
Chen JJ, Thomas JJ, Jennings HM (2006) Decalcification shrinkage of cement paste. Cem Concr Res 36:801–809. https://doi.org/10.1016/j.cemconres.2005.11.003
De Windt L, Devillers P (2010) Modeling the degradation of Portland cement pastes by biogenic organic acids. Cem Concr Res 40:1165–1174. https://doi.org/10.1016/j.cemconres.2010.03.005
Famy C, Brough AR, Taylor HFW (2003) The C–S–H gel of Portland cement mortars: part I. The interpretation of energy-dispersive X-ray microanalyses from scanning electron microscopy, with some observations on C–S–H, AFm and AFt phase compositions. Cem Concr Res 33:1389–1398. https://doi.org/10.1016/S0008-8846(03)00064-4
Rossen JE, Scrivener KL (2017) Optimization of SEM-EDS to determine the C–A–S–H composition in matured cement paste samples. Mater Charact 123:294–306. https://doi.org/10.1016/j.matchar.2016.11.041
Scrivener K, Snellings R, Lothenbach B (2016) A practical guide to microstructural analysis of cementitious materials. CRC Press, Boca Raton
Faucon P, Le Bescop P, Adenot F et al (1996) Leaching of cement: study of the surface layer. Cem Concr Res 26:1707–1715. https://doi.org/10.1016/S0008-8846(96)00157-3
Stroh J, Meng B, Emmerling F (2016) Deterioration of hardened cement paste under combined sulphate-chloride attack investigated by synchrotron XRD. Solid State Sci 56:29–44. https://doi.org/10.1016/j.solidstatesciences.2016.04.002
Wang Y, Nanukuttan S, Bai Y, Basheer PAM (2017) Influence of combined carbonation and chloride ingress regimes on rate of ingress and redistribution of chlorides in concretes. Constr Build Mater 140:173–183. https://doi.org/10.1016/j.conbuildmat.2017.02.121
Acknowledgements
This research work was financially supported by the National Natural Science Foundation of China (Grant Nos. 51878412, 51520105012, and 51878413), the Shenzhen R&D Fund (Grant No. JCYJ20190808112019066), and the Guangdong Provincial Key Laboratory of Durability for Marine Civil Engineering (SZU) (Grant No. 2020B1212060074).
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
The authors declare that they have no known competing financial interests or personal relationships that could have appeared to influence the work reported in this paper.
Additional information
Publisher's Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
About this article
Cite this article
Sun, H., Liu, S., Cao, K. et al. Degradation mechanism of cement mortar exposed to combined sulfate–chloride attack under cyclic wetting–drying condition. Mater Struct 54, 138 (2021). https://doi.org/10.1617/s11527-021-01734-6
Received:
Accepted:
Published:
DOI: https://doi.org/10.1617/s11527-021-01734-6