Abstract
The kinetics of methanol transport in 2-hydroxyethyl methacrylate (HEMA) homopolymer and 75/25 and 50/50 mol fraction HEMA/DHPMA (2,3-dihydroxypropyl methacrylate) copolymers at five different temperatures has been investigated using the sorption experiment technique. A combined case I and case II diffusion model was used to describe the transport processes. Four replicates for each temperature of each material having a nominal thickness of 0.1 mm were immersed in methanol maintained at 35, 40, 45, 50, and 55 °C, and the mass uptake as a function of time was measured gravimetrically. Experimental results are found to be in good agreement with model prediction at all temperatures and for all three materials. Both the diffusion coefficients of case I transport and velocity of case II transport increase with increasing temperature. D values at low temperatures (35 and 40 °C), which are in the 10-9 cm2/s range, of the HEMA homopolymer are less than those of the copolymers. On the other hand, the activation energies of case I transport of the copolymers are substantially higher than those of the HEMA homopolymer; however, the level of DHPMA loading in the copolymer does not seem to affect the activation energy. In addition, thermodynamic heat and free energy of mixing values indicate heat is released when HEMA/DHPMA copolymers are exposed to methanol and that the solvent/copolymer systems exist as a continuous phase. In contrast, the methanol/HEMA homopolymer system exists as separate phases.
Similar content being viewed by others
References
M.F. Refojo: In Encyclopedia of Polymer Science and Technology, Supplement 1, edited by N.M. Bikales. (Wiley, New York, 1976), p. 195.
O. Wichterle and D. Linn: Hydrophilic gels for biological use. Nature 185, 117 (1960).
M.B. Huglin and D.J. Sloan: Release of ergotamine from poly(2-hydroxyethyl methacrylate). Br. Polym. J. 15, 165 (1983).
J.M. Teijon, R.M. Trigo, O. Garcia, and M.D. Blanco: Cytarabine trapping in poly(2-hydroxyethyl methacrylate) hydrogels. Drug Delivery Studies, Biomaterials 18, 383 (1997).
K.F. Chou, C.C. Han, and S. Lee: Buffer transport in hydroxyethyl methacrylate copolymer irradiated by gamma rays. Polymer 42, 4989 (2001).
K.P. Lu, S. Lee, and C.C. Han: Transmittance in irradiated poly(2- hydroxyethyl methacrylate) copolymer at elevated temperatures. J. Mater. Res. 17, 2260 (2002).
J. Brandrup, E.H. Immergut, and E.A. Grulke, editors: Polymer Handbook, 4th ed. (Wiley-Interscience, New York, 1999), Vol. 2, 692.
T. Caykara, C. Ozyurex, O. Kantoglu, and O. Guven: Influence of gel composition on the solubility parameter of poly(2- hydroxyethyl methacrylate-itaconic acid) hydrogels. J. Polym. Sci.: Part B: Polym. Phys. 40, 1995 (2002).
T.T. Wang and T.K. Kwei: Diffusion in glassy polymers: Reexamination of vapor sorption data. Macromolecules 6, 919 (1975).
J.P. Harmon, S. Lee, and J.C.M. Li: Methanol transport in PMMA: The effect of mechanical deformation, J. Polym. Sci. Part A: Polym. Chem. 25, 3215 (1987).
I.J. Chiang, C.C. Chau, and S. Lee: Ethyl acetate transport in syndiotactic polystyrene. Polym. Eng. Sci. 42, 724 (2000).
S. Lee, T. Nguyen, E. Byrd, and J. Martin: A quantitative study of water transport during the hydrolysis of coatings exposed to water vapor. J. Mater. Res. 18, 2268 (2003).
D.W. van Krevelen: Properties of Polymers, 2nd ed. (Elsevier, New York, 1976), p. 447.
G.W. Castellan: Physical Chemistry, 2nd ed. (Addison-Wesley, Menlo Park, CA, 1971), pp. 235–236.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Tsai, CS., Lee, S. & Nguyen, T. Transport kinetics of methanol in hydroxyethyl methacrylate homopolymer and its copolymers. Journal of Materials Research 19, 3359–3363 (2004). https://doi.org/10.1557/JMR.2004.0443
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1557/JMR.2004.0443