Abstract
Auger Electron Spectroscopy (AES) has been used to examine as-received and oxidized silicon carbide whiskers and their respective whisker/matrix interfaces after fabrication into SiC-whisker-reinforced alumina composites. As-received whisker surfaces exhibited a 2–3 nm-thick near-surface region that was C-rich. Oxygen was detected at the outer surface, but diminished to near zero within 25 nm of the surface. Oxidized whiskers had 60 nm-thick SiO2 surface layers, which was in agreement with the transmission electron microscopy observations. The whisker/matrix interfaces in both composites consisted of thin (<0.5 nm) layers of a C-Si-O noncrystalline material. The thick SiO2 layers on the oxidized whiskers were ejected from the interfaces during hot-pressing. It was concluded that (i) the higher toughness of the composite fabricated with as-received SiC whiskers may be related to the higher C and lower O in its SiCw/Al2O3 interfaces, and (ii) interface composition cannot be reliably predicted using the surface composition of free whiskers prior to fabrication.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
P. F. Becher and G.C. Wei, J. Am. Ceram. Soc. 67 (12), C267 (1984).
P. F. Becher, C. H. Hsueh, P. Angelini, and T. N. Tiegs, J. Am. Ceram. Soc. 71 (12), 1050 (1988).
S.M. Smith, J. P. Singh, and R. O. Scattergood, J. Am. Ceram. Soc. 76 (2), 497 (1993).
E. Yasuda, T. Akatsu, and Y. Tanabe, J. Ceram. Soc. Jpn., Int. Ed. 99, 51 (1991).
T. Akatsu, Y. Tanabe, S. Matsuura, M. Yamada, H. Ishii, M. Munakata, and E. Yasuda, J. Ceram. Soc. Jpn., Int. Ed. 99, 416 (1991).
T. N. Tiegs, P. F. Becher, and L. A. Harris, in Ceramics Microstructure ‘86: Role of Interfaces, edited by J. A. Pask and A. G. Evans (Plenum Press, Mater. Sci. Res., New York, 1987), Vol. 21, p. 911.
K.R. Karasek, S.A. Bradley, J.T. Donner, H.C. Yeh, J.L. Schienle, and H.T. Fang, J. Am. Ceram. Soc. 72 (10), 1907 (1989).
J. Homeny, W. L. Vaughn, and M. K. Ferber, J. Am. Ceram. Soc. 73 (2), 394 (1990).
S. Iio, M. Watanabe, M. Matsubara, and Y. Matsuo, J. Am. Ceram. Soc. 72 (10), 1880 (1989).
W. Braue, R. W. Carpenter, and D. J. Smith, J. Mater. Sci. 25, 2949 (1990).
G.H. Campbell, M. Rühle, B.J. Dalgleish, and A.G. Evans, J. Am. Ceram. 73 (3), 521 (1990).
K. B. Alexander, P. Angelini, and P. F. Becher, Ceram. Trans. 19, 245 (1991).
J.J. Brennan and S.R. Nutt, J. Am. Ceram. Soc. 75 (5), 1205 (1992).
K. B. Alexander, P. Angelini, and P. F. Becher, in High Resolution Electron Microscopy of Defects in Materials, edited by R. Sinclair, D. J. Smith, and U. Dahmen (Mater. Res. Soc. Symp. Proc. 183, Pittsburgh, PA, 1990), p. 273.
G.C. Wei and P.F. Becher, Am. Ceram. Soc. Bull. 64 (2), 298 (1985).
S-L. Hwang and P.F. Becher, Abstracts for the 96th Annual Am. Ceramic Soc. Meeting & Exposition, April 24–28, 1994, Indianapolis, IN (American Ceramic Society, Westerville, OH, 1994), p. 155.
Author information
Authors and Affiliations
Rights and permissions
About this article
Cite this article
Braski, D.N., Alexander, K.B. Auger electron spectroscopy analysis of SiC-whisker surfaces and SiC-whisker/alumina interfaces. Journal of Materials Research 10, 1016–1023 (1995). https://doi.org/10.1557/JMR.1995.1016
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1557/JMR.1995.1016