Abstract
Background
Tissues are valuable specimens in diagnostic microbiology because they are often obtained by invasive methods, and effort should thus be taken to maximize microbiological yield. The objective of this study was to evaluate the added value of using tissue pre-processing (tissue homogenizer instrument gentleMACS Dissociator) in detecting microorganisms responsible for infections.
Methods
We included 104 randomly collected tissue samples, 41 (39.4 %) bones and 63 (60.6 %) soft tissues, many of those (42/104 (40.4 %)) were of periprosthetic origins. We compared the agreement between pre-processing tissues using tissue homogenizer with routine microbiology diagnostic procedure, and we calculated the performance of these methods when clinical infections were used as reference standard.
Results
There was no significant difference between the two methods (McNemar test, p = 0.3). Among the positive culture using both methods (n = 62), 61 (98.4 %) showed at least one similar microorganism. Exactly similar microorganisms were found in 42/62 (67.7 %) of the samples. From the included tissues, 55/ 104 (52.9 %) were deemed as infected. We found that the sensitivity of homogenized tissue procedure was lower (83.6 %) than when tissue was processed using tissue homogenizer (89.1 %). Sub-analysis on periprosthetic tissues and soft or bone tissues showed comparable results.
Conclusions
The added value of GentleMACS Dissociator tissue homogenizer is limited in comparison to routine tissue processing.
Similar content being viewed by others
Introduction
Tissues are valuable specimens in diagnostic microbiology because they are often obtained by invasive methods such as synovectomy or osteotomy [1]. Effort should thus be taken to maximize microbiological yield and to prevent contamination. In routine procedure, tissue specimens are often streaked and rolled on solid culture media. Yet, this method does not allow exposition of all parts of the tissue to the surface of the solid culture media. Consequently, this may reduce the detection rate of the microorganisms. To increase the probability of detecting microorganisms, many routine microbiological laboratories also incubate tissue in enrichment media or broth, but this may increase contamination rate.
Tissue homogenizers have been used in research setting to homogenize tissue to increase the release of cells from tissue specimens [2, 3]. Arguably, they may also be used to release the microorganisms attached to the tissues. Additional benefit of tissue homogenizers is a standardized manner of tissue specimen processing. One of the tissue homogenizers available in the market is gentleMACS Dissociator (Miltenyi Biotec GmbH, Bergisch Gladbach, Germany), a benchtop instrument that uses a rotor - stator for the semi-automated dissociation of tissues into single-cell suspensions or thorough homogenates. To the best of our knowledge, no earlier study has evaluated the performance of gentleMACS Dissociator tissue homogenizers in tissues from clinical samples.
The aim of this study is to evaluate the performance of gentleMACS Dissociator in detecting microorganisms responsible for infections in comparison with conventional microbiology diagnostic without tissue homogenizers.
Materials and methods
Tissue samples and sample size
Tissue samples were convenient samples, randomly selected from tissues originated from patients admitted to the Erasmus University Medical Center, Rotterdam between October 2017 and April 2020. Only one sample per patient was selected, and from these samples, data on anatomical origin and clinical infection diagnosis were obtained. The study was retrospective in nature using limited demographic data and not subjected to Medical Research Involving Human Subjects Act (waiver was granted by Erasmus MC medical ethical commission (MEC 2015 − 306).
No formal sample size calculation was performed, and we aimed at around 100 samples, in line with previous publications regarding microbiological culture of tissue samples [4,5,6].
Microbiological procedure
The samples were processed with gloved hands in a class 2 microbiological safety cabinet. A tissue specimen was brought to a sterile petri dish and cut into several pieces with a diameter around 3mm using sterile scalpel. Determined visually, half part of the tissues was subjected to routine procedure and the other half to pre-processing using gentleMACS Dissociator. The processing and reading of microbiological results were performed by various experienced laboratory technicians, blinded for clinical and the results of other microbiological tests.
In the routine procedure, the following solid agar plates were inoculated by rolling the tissue and printing the tissue into the agar: Columbia with 5 % sheep blood, Chocolate, and MacConkey. The inoculated plates were incubated under aerobic and 5 % CO2 atmospheres at 35 °C. The suspension was also seeded on Brucella blood agar plate and incubated under anaerobic condition at 35 °C. All plates were incubated for seven days except for plates of tissues originated from clinical suspicion of prosthetic or osteosynthesis material infection that were incubated for fourteen days. For fungal culture, Sabouraud Glucose Agar was used and incubated at 26 °C, and 35 °C for 21-days. All used agar plates were commercially obtained from BD Diagnostics, Erembodegem, Belgium. No broth cultures of tissue specimens was performed due to often limited amount of tissues.
Growth of microorganism was identified using matrix-assisted laser desorption/ionisation time-of-flight mass spectrometry (Bruker Daltonik, Bremen, Germany) and reported when > 2 colonies on the agar was found.
Gram staining of the tissues was performed using Aerospray® Gram Series 2 Slide Stainer/Cytocentrifuge (ELITech Group, Puteaux, France), and the stained slides were then assessed using an Olympus light microscope with 10x to 100x objective augmentation to assess the presence of microorganisms (cocci or rods) and leukocytes.
Tissue homogenizing using gentleMACS dissociator
The half part of the tissue was put into a disposable gentleMACS M Tube, and 1.5 ml of sterile physiologic NaCl solution was added. The tube was inserted into the gentleMACS Dissociator and the program RNA_01 was run to homogenize all types of tissue. The duration of this program was optimized at 1 min.
The resulting homogenized suspension then underwent the same routine procedures as mentioned above. The homogenized samples were processed at same time as routine procedure.
Statistical analysis
We performed two analyses. First, analysis comparing the pre-processing and routine tissue processing results. To this aim, we created 2 × 2 tables and performed McNemar test. Since this comparison may cause circular reasoning (i.e. which method should be used a reference standard), we also performed a second analysis. In this analysis, we used clinical infections as reference standard in order to have fair comparison between the two methods. The clinical infection data were obtained from the patient charts, and evaluated by a clinical microbiologist, who was blinded to the tissue pre-processing information. The clinical infection diagnosis was made using clinicians clinical judgement and standardized criteria. For example for the diagnosis of periprosthetic joint infection or osteomyelitis, the patient should have clinical symptoms and signs (such as pain and swelling) and laboratory findings (such as increasing C-reactive protein) in combination with multiple tissue cultures positive with the same microorganism. For endocarditis, Duke’s criteria was used. We calculated the sensitivity and the specificity with its 95 % confidence interval (95 %CI) of routine and tissue homogenizer procedure by comparing the number of positive tissue cultures with this infection status. We performed the sub-analysis on periprosthetic tissues and for bone and joint tissue. We also performed sensitivity analysis by excluding tissues that were expected to grow microorganisms due to commensals such as tissues from ear, nose, and throat (ENT) and gastrointestinal tracts. Further, we investigated in case of polymicrobial growth, whether tissue pre-processing lead to detection of additional microorganism, and whether this additional microorganism was of clinical importance (i.e. the culture of this additional microorganism would lead to different antibiotics choice). Further, we compared the proportion of positive microorganisms and leukocytes on Gram-staining when the tissue was processed routinely or using tissue homogenizer by using chi-square test. Data were analysed using SPSS Statistics 26 (SPSS Inc., Chicago, Ill, USA).
Results
Samples
We included 104 tissue samples (41 (39.4 %) bones and 63 (60.6 %) soft tissues). The tissues were originated mostly from the extremities (n = 29/ 104, 27.9 %), and periprosthetic tissues (n = 42/104, 40.4 %). Most bone samples were from the extremities (n = 21/41, 51.2 %) (Supplementary Table 1). The majority of soft tissues was also obtained from periprosthetic location (n = 34/104, 32.7 %).
Agreement between pre-processing and routine processing
The 2 × 2 table comparing the culture results when tissue pre-processing was performed with routine tissue processing is presented in Table 1. Culture using routine procedure were positive for 69 tissues, 25/69 (36.2 %) of them were polymicrobial (Supplementary Table 1). There was no significant difference between the two methods (p = 0.3). In 62 samples growth of any microorganism was found in both methods, and in 61 (98.4 %) of them at least one similar microorganism was found. Exactly similar microorganisms were found in 42/62 (67.7 %) of the samples.
Comparison of culture performance using clinical infection as reference standard
From the included tissues, 55/ 104 (52.9 %) were originated from clinical infection. The sensitivity of routine procedure was lower (83.6 %) than when tissue was processed using tissue homogenizer (89.1 %) (Table 2). The subgroup analysis including periprosthetic tissues only also showed that the sensitivity using pre-processing tissue method was lower than routine procedure only (96.3 % vs. 77.8 %). While the sensitivity of culture of bone tissues was comparable whether tissue homogenizer was used or not, the culture sensitivity using tissue homogenizers was lower than routine procedure (77.1 % vs. 88.6 %). Further comparison between tissue homogenizers and routine procedure is presented in Table 3.
From the nine tissues with discordant microbiology results (Table 1), in one tissue, the growth of microorganism was deemed as contamination rather than infection (Cutibacterium acnes in the tissue from a patient who had tibia fracture). Eight other tissues were deemed as infected. Tissue homogenizer detected one S. aureus (endocarditis) and one E. faecium (prosthetic joint infection) that would be otherwise missed by routine procedure, but it also missed three coagulase negative Staphylococci (two prosthetic joint infection and one low-grade osteosynthesis material infection), two Serratia marcescens (both prosthetic joint infection), and one Staphylococcus aureus (prosthetic joint infection) which were detected using routine procedures (Supplementary Table 1).
Comparison of Gram -staining findings
Gram-staining for microorganisms were positive in 16/ 55 (29.1 %) of infected tissues processed using routine procedure and in 14 (25.5 %) using tissue homogenizer. Leukocytes were found in of infected tissues processed routinely in 20/55 (36.4 %) samples in comparison with 15/55 (27.3 %) samples processed using tissue homogenizers (p = 0.774 and 0.424, respectively).
Discussion
There is a clear need to improve the sensitivity of tissue culture, especially in processing periprosthetic tissue [7,8,9,10]. Simple direct streaking the tissue on the agar plates may have limited sensitivity. Vortexing the tissue, or culturing the tissues in broth or blood culture bottles have been proposed to increase the yield of the cultures [11, 12]. Yet, these approaches can lead to contamination of the culture. Chemical lysis and automatic tissue homogenizer are other methods that have been proposed to increase the diagnostic sensitivity of microbiological tissue culture [2].
In our study, we found that gentleMACS Dissociator tissue homogenizers (that used rotor- stator method) showed no difference when it was compared with routine microbiological processing of tissues. Yet, using clinical infection as reference standard, it has lower performance. To the best of our knowledge, this is the first study which evaluates the performance of this tissue homogenizer in clinical samples, therefore we cannot make any comparison. The results of our study do show some parallel with the results from an animal study [13]. In that study, Mycobacterium leprae was injected to the hind legs of six mice, and after euthanasia, the tissues from the hindleg were obtained and cultured. The results of that study showed that bacteria yield of the tissue processed using gentleMACS Dissociator was lower than without tissue processing [13]. Another study with another tissue homogenizer instrument (MagNA Lyser Rotor, Roche) in pork tissue inoculated with S. aureus and E. coli, also showed that the number of viable bacteria was reduced compared to control [12]. Next to rotor – stator method, bead mills can be used to homogenize tissue. This bead mills method also performed worse than routine microbiological method, as shown in a study using Ultra-TurrAX bead mills instrument (Axonlab AG) in 38 periprosthetic tissues of patients with knee arthroplasty [2]. We can only hypothesize that the tissue homogenizer had lower yield in comparison to routine procedure because part of the bacteria population were destructed in the tissue during the homogenization process, leading to dead cells, or viable but non culturable state [14] Yet, when a homogenizer is used to release bacteria from swabs, the destruction does not seems to occur, perhaps due to protection of synthetic material (swab) to the bacteria, as shown in a study in a study using Precellys 24 (Bertin Technologies) in swabs inoculated with ATCC bacteria [15]. Yet, swab sample is not a preferred type of samples for periprosthetic joint infection or osteomyelitis [16]. In our protocol, 1.5 mL went in with the tissue, and there is a possibility that dilution of the sample may explain the lower yield of tissue homogenizer. However, by the time the tissue homogenization was completed, the final volume was more concentrated. The dilution effect is thus perhaps not significant. Despite its limited performance, the gentleMACS™ Dissociator was convenient to use. The program took 1 min to run and did not have regular mechanical problems. The hand-on time was also relatively short (< 5 min).
This study used relatively large amount of (periprosthetic) tissues used as it can be seen in relatively narrow confidence interval. Positive tissue culture is one of the criteria in diagnosing prosthetic joint infection [10, 17] and the sensitivity of tissue culture is often limited in low grade prosthetic joint infection,. This study also benefits from the use of various clinical samples that reflect routine practice. Despite these strengths, it should be noticed that this study is not designed to study the performance of pre-processing tissue with other microbiological methods in detecting specific infection such as prosthetic joint infection where sonication can be used to enhance the microbiological culture results [18]. Moreover, the generalizability of the results may be limited in case of low grade prosthetic joint infection, since the included tissues mostly originated from revision surgery in which the clinical suspicion of infection was already high, as can be seen in high sensitivity.
The results presented in this study can help the clinical microbiologists, infectious disease specialists and laboratory manager in interpreting the results and implementing tissue homogenizer in routine clinical microbiology.
Conclusions
Despite of being convenient to use, gentleMACS Dissociator tissue homogenizer was of limited additional value in comparison to conventional tissue processing in routine clinical samples.
Availability of data and materials
The datasets during and/or analysed during the current study available from the corresponding author on reasonable request.
References
Public Health England. Investigation of tissues and biopsies from deep-seated sites and organs [Internet]. UK Standards for Microbiology Investigations. Colindale; 2018. Available from: https://www.gov.uk/government/publications/smi-b-17-investigation-of-tissues-and-biopsies
Suren C, Harrasser N, Pohlig F, Banke IJ, Lenze U, Lenze F, et al. Prospective analysis of a sterile, semi-automated tissue biopsy homogenization method in the diagnosis of prosthetic joint infections. In Vivo (Brooklyn). 2017;31(5):937–42.
Redanz S, Podbielski A, Warnke P. Improved microbiological diagnostic due to utilization of a high-throughput homogenizer for routine tissue processing. Diagn Microbiol Infect Dis. 2015;82(3):189–93.
Kim CJ, Kang SJ, Choe PG, Park WB, Jang HC, Jung SI, et al. Which tissues are best for microbiological diagnosis in patients with pyogenic vertebral osteomyelitis undergoing needle biopsy? Clin Microbiol Infect. 2015;21(10):931–5.
Vural MK, Altoparlak U, Celebi D, Akcay MN. Comparison of surface swab and quantitative biopsy cultures dependent on isolated microorganisms from burn wounds. Eurasian J Med. 2013;45(1):34–8.
Steer JA, Papini RPG, Wilson APR, McGrouther DA, Parkhouse N. Quantitative microbiology in the management of burn patients. II. Relationship between bacterial counts obtained by burn wound biopsy culture and surface alginate swab culture, with clinical outcome following burn surgery and change of dressings. Burns. 1996;22(3):177–81.
Tande AJ, Patel R. Prosthetic joint infection. Clin Microbiol Rev. 2014;27(2):302–45.
Kapadia BH, Berg RA, Daley JA, Fritz J, Bhave A, Mont MA. Periprosthetic joint infection. Lancet. 2016;387(10016):386–94.
Berbari EF, Marculescu C, Sia I, Lahr BD, Hanssen AD, Steckelberg JM, et al. Culture-negative prosthetic joint infection. Clin Infect Dis. 2007;45(9):1113–9.
Atkins BL, Athanasou N, Deeks J, Crook DWM, Simpson H, Peto T, et al. Prospective evaluation of criteria for microbiological diagnosis of prosthetic-joint infection at revision arthroplasty. J Clin Microbiol. 1998;36(10):2932–9.
Peel TN, Dylla BL, Hughes JG, Lynch DT, Greenwood-Quaintance KE, Cheng AC, et al. Improved diagnosis of prosthetic joint infection by culturing periprosthetic tissue specimens in blood culture bottles. MBio. 2016;7(1):e01776–15.
Askar M, Ashraf W, Scammell B, Bayston R. Comparison of different human tissue processing methods for maximization of bacterial recovery. Eur J Clin Microbiol Infect Dis. 2019;38(1):149–55.
Williams DL, Adams LB, Lahiri R. Semi-automated protocol for purification of Mycobacterium leprae from tissues using the gentleMACS™ Octo Dissociator. J Microbiol Methods. 2014;105:80–1.
Li L, Mendis N, Trigui H, Oliver JD, Faucher SP. The importance of the viable but non-culturable state in human bacterial pathogens. Frontiers in Microbiology. 2014. p. 1–1.
Warnke P, Redanz S, Zaatreh S, Podbielski A. Augmented recovery of microorganisms from swabs by homogenization: A novel standardizable high-throughput approach. Diagn Microbiol Infect Dis. 2016;84(1):16–8.
Aggarwal VK, Higuera C, Deirmengian G, Parvizi J, Austin MS. Swab cultures are not as effective as tissue cultures for diagnosis of periprosthetic joint infection. In: Clinical Orthopaedics and Related Research. 2013.
Parvizi J, Gehrke T. Definition of periprosthetic joint infection. Journal of Arthroplasty. 2014. p. 1331.
Trampuz A, Piper KE, Jacobson MJ, Hanssen AD, Unni KK, Osmon DR, et al. Sonication of removed hip and knee prostheses for diagnosis of infection. N Engl J Med [Internet]. 2007;357(7):654–63. Available from: http://www.nejm.org/doi/full/10.1056/NEJMoa061588%5Cnhttp://www.ncbi.nlm.nih.gov/pubmed/17699815
Acknowledgements
Not applicable.
Funding
No additional funding was received in performing this study than routine salaries.
Author information
Authors and Affiliations
Contributions
EY, MP, and MvW conceived the presented idea. EY drafted the article and performed data analysis, EY and MvW interpreted the results of data analysis. EY, and MP performed data collection. EY, MP, and MvW discussed the results, gave critical revision and gave final approval of the version to be published.
Corresponding author
Ethics declarations
Ethics approval and consent to participate
The study was retrospective in nature using limited demographic data and not subjected to Medical Research Involving Human Subjects Act. Waiver was granted by Erasmus MC medical ethical commission (MEC 2015 − 306).
Consent for publication
The manuscript does not contain any individual person’s data in any form.
Competing interest
The authors declare that they do not have any conflict of interest.
Additional information
Publisher’s Note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Supplementary information
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/. The Creative Commons Public Domain Dedication waiver (http://creativecommons.org/publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated in a credit line to the data.
About this article
Cite this article
Yusuf, E., Pronk, M. & van Westreenen, M. Pre-processing tissue specimens with a tissue homogenizer: clinical and microbiological evaluation. BMC Microbiol 21, 202 (2021). https://doi.org/10.1186/s12866-021-02271-6
Received:
Accepted:
Published:
DOI: https://doi.org/10.1186/s12866-021-02271-6