Abstract
Trials of oxidative cracking of ethane—propane—n-butane mixtures were performed on an installation with the productive capacity with respect to the gaseous feed of 5 m3 h−1. Ethylene, CO, and hydrogen are the major products of oxidative cracking of oil refinery gases; their total yield can exceed 90%. The yield of ethylene and CO is determined by the total concentration of alkanes in the mixture and is independent on the length of their hydrocarbon chain, whereas the hydrogen yield appreciably decreases with an increase in the alkane chain length. The trials demonstrated high efficiency of the production of ethylene, CO, and hydrogen by oxidative cracking of oil refinery gas mixture components.
Similar content being viewed by others
References
Melero, J.A., Iglesias, J., and Garcia, A., Energy Environ. Sci., 2012, vol. 5, pp. 7393–7420. https://doi.org/10.1039/c2ee21231e
Luo, X.B., Wang, M.H., Li, X.G., Li, Y., Chen, C., and Sui, H., Fuel, 2015, vol. 158, pp. 424–434. https://doi.org/10.1016/j.fuel.2015.05.035
Li, X.G., Li, Y., Zhang, L.H., and Li, H., Chem. Eng. Res. Des., 2016, vol. 109, pp. 258–272. https://doi.org/10.1016/j.cherd.2016.01.022
Gorbunov, D.N., Terenina, M.V., Kardasheva, Y.S., Karakhanov, E.A., and Maksimov, A.L., Petrol. Chem., 2017, vol. 57, no. 12, pp. 1137–1140. https://doi.org/10.1134/S0965544117060159
Wang, D.L. and Feng, X., Int. J. Hydrogen Energy, 2013, vol. 38, no. 29, pp. 12968–12976. https://doi.org/10.1016/j.ijhydene.2013.04.077
Nikitin, A.V., Sedov, I.V., Ozerskii, A.V., Afaunov, A.A., Artamonova, N.E., and Arutyunov, V.S., in XII Mezhdunarodnaya konferentsiya molodykh uchenykh po neftekhimii (XII Int. Conf. of Young Scientists on Petroleum Chemistry), Zvenigorod, Sept. 17–21, 2018, pp. 531–533.
Gorbunov, D.N., Semernina, V.A., Terenina, M.V., Kardasheva, Yu.S., Maksimov, A.L., and Karakhanov, E.A., Petrol. Chem., 2019, vol. 59, no. 5, pp. 560–568. https://doi.org/10.1134/S0965544119090056
Magomedov, R.N., Nikitin, A.V., Savchenko, V.I., and Arutyunov, V.S., Kinet. Catal., 2014, vol. 55, no. 5, pp. 556–565. https://doi.org/10.1134/S0023158414050127
Arutyunov, V.S., Savchenko, V.I., Sedov, I.V., Fokin, I.G., Nikitin, A.V., and Strekova, L.N., Chem. Eng. J., 2015, vol. 282, pp. 206–212. https://doi.org/10.1016/j.cej.2015.02.082
Hu, C., Wu, J., Zhang, H., and Qin, S., AIChE J., 2007, vol. 53, no. 11, pp. 2925–2931. https://doi.org/10.1002/aic.11326
Arutyunov, V.S., Savchenko, V.I., Sedov, I.V., Nikitin, A.V., Magomedov, R.N., and Proshina, A.Y., Russ. Chem. Rev., 2017, vol. 86, no. 1, pp. 47–74. https://doi.org/10.1070/RCR464
Magomedov, R.N., Proshina, A.Yu., Arutyunov, V.S., and Peshnev, B.V., Kinet. Catal., 2013, vol. 54, no. 4, pp. 394–399. https://doi.org/10.1134/S0023158413040125
Funding
The study was financially supported by the Ministry of Science and Higher Education of the Russian Federation (subsiding agreement no. 14.607.21.0171, identifier RFMEFI60717X0171).
Author information
Authors and Affiliations
Corresponding author
Additional information
Russian Text © The Author(s), 2019, published in Zhurnal Prikladnoi Khimii, 2019, Vol. 92, No. 13, pp. 1688–1694.
Rights and permissions
About this article
Cite this article
Ozerskii, A.V., Zimin, Y.S., Komarov, I.K. et al. Oxidative Cracking of Oil Refinery Gases. Russ J Appl Chem 92, 1745–1750 (2019). https://doi.org/10.1134/S1070427219120162
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1134/S1070427219120162