Abstract
Structural and phase states of the eutectic alloy Sn-38 wt % Pb, which exhibits superplastic properties at room temperature, have been studied using samples that were cast, forged in a hydraulic press to ∼73%, aged in the as-cast state, as well as preliminarily forged samples and samples deformed in the regime of superplasticity. It has been shown that the phase state of the alloy in as-cast condition does not correspond to the equilibrium tin-lead phase diagram. The superplastic flow of the alloy occurs against the background of processes of decomposition of the supersaturated solid solution. In the preliminarily forged samples, the aging is accompanied by an increase in the concentration of lead in the surface layers. This is related, in particular, to the existence of tensile stresses in the tin-based phase and to their relaxation in the process of aging. In the structure of cast and preliminarily forged samples, an amorphous-crystalline component has been revealed, which most likely is located at grain boundaries. The experimental results agree well with the previously obtained results that are indicative of the nonequilibrium character of the initial structural phase state of the Sn-38 wt % Pb alloy and of the occurrence of structural-phase transformations under conditions of superplastic deformation, and substantially supplement them.
Similar content being viewed by others
References
M. V. Grabski, Nadplasticzność Strukturalna Metali (Śląsk, Katowice, 1972; Metallurgiya, Moscow, 1975)
A. A. Presnyakov and R. K. Aubakirova, Superplasticity of Metal Materials (Nauka, Alma-Ata, 1982) [in Russian].
V. F. Korshak, V. M. Arzhavitin, and A. S. Razumnyi, “Young’s Modulus Change of the Pb-62% Sn Superplastic Alloy upon Deformation,” Vestn. Khark. Gos. Univ., Ser. Fiz. 440(3), 76–79 (1999).
V. F. Korshak, V. M. Arzhavitin, A. L. Samsonik, and P. V. Mateichenko, “Metastability and Structure-Phase Transformations in a Tin-Lead Superplastic Eutectic Alloy,” Izv. Akad. Nauk, Ser. Fiz. 69, 1374–1378 (2005).
V. F. Korshak, A. P. Kryshtal’, P. V. Mateichenko, and A. F. Sirenko, “Strain-Induced Structural and Phase Transitions in Superplastic Eutectic,” Bull. Russ. Acad. Sci., Ser. Phys. 71, 1680–1684 (2007).
V. F. Korshak, Yu. A. Shapovalov, P. V. Mateichenko, and I. A. Danilina, “Change of Structure-Phase State and Superplastic Properties of Tin-Lead Eutectic during Aging,” Metallofiz. Noveishie Tekhnol. 30, 385–396 (2008).
V. F. Korshak and Yu. A. Shapovalov, “Some Aspects of Superplastic Flow of Eutectic Alloys Connected with Metastability,” Phys. Met. Metallogr. 107, 394–399 (2009).
V. F. Korshak and A. L. Samsonik, “X-ray Diffraction Study of the Preliminary-Deformation Effect on the Structure and Phase State of Superplastic Eutectic Alloy,” Vestn. Khark. Nat. Univ., Ser. Fiz., 600, No. 7, 98–100 (2003).
A. P. Babichev, N. A. Babushkina, A. M. Bratkovskii, et al., Physical Values: A Handbook, Ed. by I. S. Grigor’ev and E. Z. Meilikhov (Energoatomizdat, Moscow, 1991) [in Russian].
B. E. Warren and B. L. Averbakh, “Diffuse Scattering of X-ray Beams,” in Contemporary Physical Methods of Research in Physical Metallurgy (GONTI, Moscow, 1958), pp. 109–149 [in Russian].
L. N. Larikov and O. A. Shmatko, Discontinuous Decomposition of Supersaturated (Naukova Dumka, Kiev, 1976) [in Russian].
V. F. Korshak and A. L. Samsonik, “X-ray Diffraction Study of Pb-62% Sn Superplastic Alloy Aging Processes,” Vestnik Khar. Nat. Univ., Ser. Fiz., No. 6, 107–109 (2002).
V. F. Korshak, A. P. Kryshtal’, Yu. A. Shapovalov, and A. L. Samsonik, “Hydrodynamic Flow of the Eutectic under the Conditions of Superplasticity,” Phys. Met. Metallogr. 110, 385–393 (2010).
B. M. Drapkin and V. K. Kononenko, “Temperature Dependence of Young Modulus of Pb-Sn, Pb-Bi and Sn-Bi Alloys,” Izv. Akad. Nauk SSSR, Met. No. 2, 162–165 (1987).
R. B. Vastava and T. G. Langdon, “An Investigation of Intercrystalline and Interphase Boundary Sliding in the Superplastic Pb-62%Sn,” Acta Metall. 27, 251–257 (1979).
O. A. Kaibyshev, Superplasticity of Industrial Alloys (Metallurgiya, Moscow, 1984) [in Russian].
Author information
Authors and Affiliations
Additional information
Original Russian Text © V.F. Korshak, Yu.A. Shapovalov, A.L. Samsonik, P.V. Mateichenko, 2012, published in Fizika Metallov i Metallovedenie, 2012, Vol. 113, No. 2, pp. 201–211.
Rights and permissions
About this article
Cite this article
Korshak, V.F., Shapovalov, Y.A., Samsonik, A.L. et al. X-ray diffraction study of structural and phase states of a superplastic Sn-38 wt % Pb alloy and their variations under the effect of external mechanical stresses and aging. Phys. Metals Metallogr. 113, 190–199 (2012). https://doi.org/10.1134/S0031918X1202007X
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1134/S0031918X1202007X