Abstract
This paper studies the effect of different ultrasonic parameters on the yield of extraction and antioxidant activity of selected phenolic compounds from Sorbus intermedia berries. The sonication was carried out in two modes: continuous and pulse. In the pulse mode, the samples were sonicated with the following processor settings: 1 s on–2 s off. The effective ultrasonic processor times were 5, 10, and 15 min, and the total extraction times were 15, 30, and 45 min. The results showed that the duty cycle significantly affected the antioxidant activity of the extracts and the yield of chlorogenic acid, rutin, and total flavonoids. Compared to the continuous mode, the pulse ultrasound increased the extraction yield of rutin by 5–27%, chlorogenic acid by 12–29%, and total flavonoids by 8–42%. The effect of the duty cycle on the extraction yield was dependent on the intensity and duration of the ultrasound treatment. The mechanism of the influence of the pulsed ultrasound field on the extraction process has been elucidated. This research clearly demonstrated the superiority of pulsed ultrasound-assisted extraction for production of antioxidants from Sorbus intermedia berries.
Similar content being viewed by others
Introduction
Given the rising costs of energy and the need to reduce greenhouse gas emissions, the food, pharmaceutical, and natural pharmaceutical industries are focused on the use of more efficient and environmentally friendly techniques for extraction of bioactive substances1. Ultrasound-Assisted Extraction (UAE) may be one of such methods. Compared to other techniques, this type of separation has many advantages, e.g. higher efficiency, lower process temperature, low consumption of solvents, and relatively low costs of equipment2 . Moreover, this economical method shortens the process time and lowers energy consumption3,4.
The mechanism of the ultrasound-assisted extraction process consists in intensification of the extraction of bioactive compounds from plant raw materials with the use of high-intensity sound waves. Sonication contributes to partial disintegration of plant tissue through acoustic cavitation and accelerates the release of extracted components into the solvent by increasing the mass transport5.
The efficiency of ultrasound-assisted extraction is influenced by the following factors: the ultrasound intensity and frequency, the process time and temperature, the liquid-to-solid ratio, the type, concentration, and pH of the solvent, and the sonicator duty cycle (continuous or pulse)6,7.
The UEA efficiency increases with increasing ultrasound intensity and then decreases after reaching a certain critical value specific for a given bioactive substance8,9. The higher efficiency of the process is related to increased disintegration of plant tissue and increased solvent penetration related to a rapid collapse of cavitation bubbles. However, high-intensity ultrasound may degrade the bioactive compound, thereby reducing the extraction yield10.
Another determinant of the extraction efficiency is the ultrasound frequency. The number of reports on this issue is limited, and most research has been carried out at a constant frequency of ultrasound. Researchers usually use low ultrasound frequencies due to the possibility of induction of the cavitation phenomenon at a lower level of ultrasound intensity11,12,13,14,15,16.
Another important parameter of the extraction process is the selection of an appropriate solvent. Ethanol and its solutions are used most commonly. It has been found that ethyl alcohol has the highest affinity for phenolic compounds in many systems and is therefore the first choice for the extraction of phenolic compounds from plant materials17. An increase in the concentration of ethanol in an aqueous solution initially increases the yield of phenolic compound extraction and then reduces the efficiency10. The efficiency of ultrasound-assisted extraction also rises with the increasing liquid-to-solid ratio. A greater difference in solute concentrations increases the diffusivity and dissolution of the solute in the solvent, thereby supporting the extraction process. The cavitation intensity at a high liquid-to-solid ratio is higher and causes greater fragmentation, erosion, and pore-formation, thus increasing the extraction efficiency. However, the bioactive substance may undergo degradation after a certain level of cavitation intensity has been exceeded18,19.
The number of reports on the impact of solvent pH on the extraction of phenolic compounds is limited, and only Rodrigues et al.20,21 determined the optimal solvent pH to be in the range of 1–3.
The temperature is an important determinant of the extraction efficiency. It improves the desorption properties and solubility of the substance dissolved in the solvent. Additionally, it reduces the viscosity of the solvent, which increases the diffusivity of the solvent and the solute. In turn, an excessive temperature rise weakens the cavitation effect10,22.
The effect of the ultrasound-assisted extraction time on the content of bioactive compounds has been extensively studied. It is known that a longer sonication time initially increases but then reduces the efficiency. The initial extension of the sonication time accelerates the processes of raw material swelling and hydration as well as fragmentation of plant cells in which the soluble substance is dissolved. An extremely long ultrasonic extraction time results in solute degradation and reduces the extraction efficiency. In the case of the extraction of phenolic compounds, the optimal extraction time has been estimated at 10–90 min, depending on the type of raw material10,11,12,13,14,15,16.
A less known issue is the effect of the ultrasonic processor duty cycle on the efficiency of extraction of bioactive substances. Pan et al.23 reported no significant differences in the extraction yield and duration related to the ultrasound duty cycle, but approximately 50% lower electricity consumption was observed in the pulse mode. Similar results were obtained by Patience et al.24 during the extraction of pectins from orange peels. There was no significant difference in the yield between the continuous and pulse modes despite the large difference in power consumption (190 kJ vs. 80 kJ).
In contrast, Christou et al.25 recovered polyphenols from mature and unripe carob (carob flour) and achieved slightly higher yields with the use of pulse-mode UAE. In turn, Kobus et al.26 showed that the use of the pulsed ultrasonic field resulted in a 1.14–34% increase in the yield of extracted polyphenols and anthocyanins in comparison with the continuous ultrasonic field variant. Xu et al.19 showed that, compared to CHE (conventional heating extraction), ultrasound-assisted extraction in the pulse mode (2 s on–2 s off) improved the efficiency of the process by 26.74% and shortened the extraction time (51.79 min).
Currently, there is increasing interest in extraction methods and research of bioactive substances contained in less known fruit species due to their potential health benefits in the prevention of chronic diseases27. Sorbus L. species are widely distributed in the northern hemisphere28. Sorbus intermedia is native to north-western Europe but now naturally found in other parts of Europe29. Extracts of various Sorbus L. species are used as a traditional remedy for various digestive disorders, treating respiratory tract infections, flu, fever, cold, rheumatism, anaemia, gout, oedema, dyspepsia30. The chemical composition of fruits of various species of rowan is similar31. Rowan fruits contain organic acids: sorbic, parasorbic, citric, malic, tartaric and succinic, phenolic acids: vanillin, coffee, gallic, p-coumaric, ellagic, syringic, ferulic, benzoic and protocatechic31,32. It has also been found flavonoids: quercetin, kaempferol, isorhamnetin, rutin, isoquercetin and jaceosidin, anthocyanins, vitamins and bioelements31. Phytochemical studies on Sorbus intermedia are limited. Articles refer to the presence of flavonoids and phenolic acids33,34,35,36. Sołtys et al.37 analyzed of Sorbus intermedia fruits with regard to their triterpenoid composition.
The promising results of the research on the extraction of polyphenols and anthocyanins from hawthorn with the ultrasound-assisted method have prompted us to extend the scope of the research to include other raw material and other bioactive substances. Hence, the aim of the study was to compare the effect of the ultrasonic processor duty cycle on the yield of bioactive compounds and the antioxidant activity of the extracts.
Materials and methods
Study material
Plant material (fruits) of Sorbus intermedia (Ehrh.) Pers was collected in October of 2020 in Lublin Upland in Poland. DSc Wojciech Durlak identified it as Sorbus intermedia. The specimen vouchers (S. intermedia No. 12/2021) were deposited by DSc Wojciech Durlak in the herbarium of the Horticultural Production Institute, Faculty of Horticulture and Landscape Architecture, University of Life Sciences in Lublin. The collection of plant material and experiment had been conducted in compliance with relevant guidelines and regulations. Immediately after harvesting, the raw material was freeze-dried in a lyophilizer. Next, the material was crushed and divided into 5 fractions. Three fractions were selected for further analyses. They were obtained by sieving through sieves with different mesh diameters: fraction 1—0.25–0.5 mm mesh diam., fraction 2—0.5–1.0 mm mesh diam., and fraction 3—1.0–2.0 mm mesh diam.
Ultrasonic treatment
Four grams of raw material from each fraction were placed in the extraction cell and covered with an aqueous solution of 60% ethyl alcohol. Next, the extraction cell was placed in a cooling jacket connected to an ultra-thermostat to stabilize the temperature. The extraction cell was closed with a 19-mm diameter. ultrasonic probe on the top. The experimental samples were sonicated with a VC750 Sonics processor (Sonics and Materials Inc., USA) operating at a frequency of 20 kHz. The sonication was performed at three amplitudes of 12, 24, and 36 µm corresponding to ultrasound intensities of 2.5, 9.5, and 19 W/cm2, respectively, in the case of continuous mode. In the case of the pulse mode, the mean ultrasound intensities were lower, i.e. 1.3, 7.5, and 14 W/cm2 for the amplitudes of 12, 24, and 36 µm, respectively26.
The ultrasonic treatment was carried out in continuous and pulse modes. In the pulse mode, the samples were sonicated at the 1 s on–2 s off processor duty cycle. The effective operation times were 5, 10, and 15 min, and the total extraction times were 15 min, 30 min, and 45 min, respectively. In the continuous mode, the samples were sonicated for 5, 10, and 15 min, respectively, and then kept in the extraction cells for 10, 20, and 30 min to achieve the same extraction times as in the pulse mode. The extracts were stored under refrigeration (2 °C) and collected for further chemical analyses26.
Chemical analyses
Determination of flavonoid content (TFC)
The content of flavonoids was determined with the spectrophotometric method using quercetin as a reference standard38. First, the sample extract (1.0 mL) was mixed with 1 mL of a 2% AlCl3 × 6 H2O solution (in methanol), and the mixture was made up to 10 mL with distilled water. After incubation of the mixture for 10 min at room temperature in the dark, the absorbance was measured at 430 nm. A calibration curve was prepared with quercetin and the results were expressed as mg quercetin equivalent per 1 g of dry matter (mg QE g−1 dry matter).
Determination of chlorogenic acid and rutin by HPLC
Chlorogenic acid and rutin in the extracts were quantified using a modified version of the HPLC (High Performance Liquid Chromatography) method proposed by Alberti et al.39. The analysis was conducted using HPLC System S 600 Series equipment (Sykam GmbH, Eresing, Germany) coupled to a photodiode arrangement detector (PDA S 3345, Sykam). All extract were filtered through a 0.20 µm syringe filter (Nylon, Macherey–Nagel, Düren, Germany), and 20 µL of the sample was injected in the system in triplicate. The separation was carried out using a Bionacom Velocity STR (3.0 mm × 250 mm, 5.0 µm) column at 25 °C40.
The mobile phases consisted of 25 mL·L−1 of acetic acid (solvent A) and acetonitrile (solvent B). The system was run with at a flow rate of 1.0 mL·min−1 in the following gradient program: 3–9% B (0–5 min), 9–11% B (5–13 min), 13–30% B (13–20 min), 30% B (20–25 min), and 30–3% B (25–27 min). The peaks of the compounds were identified and quantified by comparison of the retention times and spectra of the samples with calibration curves that had been previously prepared with standards. The runs were monitored at 260 nm40.
Determination of antioxidant activity
Determination of free radical scavenging activity with the DPPH assay
The antioxidant activity of the extracts was evaluated using the DPPH (2,2-diphenyl-1-picrylhydrazyl) assay41. For this analysis, 0.2 mL of the extract was mixed with an aliquot of 5.8 mL of freshly prepared 6·10−5 M DPPH radical in methanol. The mixture was allowed to stand at room temperature for 30 min, and the spectrophotometric absorbance was measured at 516 nm using methanol as a blank. 40 The measurement was performed in three replicates for each sample. Antioxidant activity was expressed as a Trolox equivalent in µg per g of dry matter.
Ferric reducing antioxidant power assay (FRAP)
The ferric reducing antioxidant power of the extract was evaluated according to the method described by Benzie & Strain42 with some modifications. First, the working reagent was prepared as a mixture of 20 mM FeCl3, 300 mM acetic acid, and 10 mM of TPTZ in 10:1:1 (v/v/v) proportion in 40 mMHCl. Next, 30-μL of the extracts were mixed with 5 mL of the FRAP solution. After incubation at 37 °C for 10 min, absorbance of the mixture was measured at 593 nm. The FRPA values of the extracts were expressed as a Trolox equivalent in µg per g of dry matter.
Statistical analyses
The results were statistically analyzed with Statistica software via analysis of variance (ANOVA). The significance of differences between the evaluated mean values (in figures) was analyzed with the Tukey test at a significance level of p < 0.0526.
The tables present the mean values with standard deviations, while the graphs present the mean values and whiskers representing standard deviations. The results of the chemical properties are presented as average values of three measurements in each sample.
Results
Flavonoids
Flavonoids are bioactive compounds with multiple health-enhancing properties, e.g. antioxidant, anti-inflammatory, anti-cancer, and detoxifying activity. Figure 1 shows the effect of the type of treatment (continuous, pulse) on the content of flavonoids in Sorbus intermedia alcoholic extracts. The highest content of flavonoids, i.e. 0.502 mg QE/g, was detected in extracts obtained in the pulse mode at the 36 µm amplitude and 15 min treatment time. The lowest amounts of flavonoids, i.e. 0.132 mg QE/g, were extracted in the continuous mode (12 µm amplitude and 5-min time). The increase in the pulse amplitude from 12 µm to 36 µm resulted in an increase in the flavonoid content from 105 to 216%. Another important determinant of the yield was the extraction time. The differences in the extraction between the shortest and longest extraction time ranged from 12 to 45%. The duty cycle of the ultrasonic processor also had a positive effect on the content of flavonoids. The difference in the flavonoid content between the pulse and continuous mode variants ranged from 8 to 42%. In the case of the 12 µm amplitude, the processor duty cycle did not exert a statistically significant effect on the content of flavonoids, whereas the differences in the case of the 24 and 36 µm amplitudes turned out to be statistically significant.
The antioxidant activity of S. intermedia berry extracts was assessed using the FRAP and DPPH methods
DPPH
Table 1 shows the effect of the sonication parameters on the antioxidant activity of Sorbus intermedia extracts determined with the DPPH method. The highest values were obtained in the case of the pulse mode with the following processing parameters: 24 µm amplitude and 15 min time. The lowest values were noted in the continuous mode with 12 µm amplitude and 5 min time. The difference in between the variants with these processing parameters was 129%. The extracts obtained with the use of the pulsed ultrasound field exhibited higher antioxidant activity than the extracts from the continuous mode treatment. These differences turned out to be statistically significant for the 12 µm amplitude and 15 min time and for the 24 µm amplitude and the time of 5, 10, and 15 min. The greatest impact on the antioxidant activity was exerted by the ultrasonic vibration amplitude. The increase in the vibration amplitude from 12 µm to 36 µm resulted in an increase in the DPPH value from 66 to 120%. Another important parameter was the ultrasonic treatment time. An increase in the treatment time from 5 to 15 min resulted in an increase in the DPPH value from 1.5% to 37%.
FRAP
Table 2 shows the effect of the treatment type (continuous, pulse) on the antioxidant activity of the Sorbus intermedia extracts determined with the FRAP method. The highest antioxidant activity was detected in extracts obtained in the pulse-mode treatment with the following parameters: 36 µm amplitude and 15 min time. The lowest values were noted in the continuous-mode treatment with the 12 µm amplitude and 5 min time. The difference between the extreme values reached 287%. The amplitude had the greatest effect on the ability to scavenge free radicals. The increase in the vibration amplitude from 12 µm to 36 µm resulted in an increase in the FRAP value from 96 to 196%. Another important determinant of the antioxidant capacity in the Sorbus intermedia extracts was the extraction time. The increase in the sonication time from 5 to 15 min resulted in an increase in the FRAP value from 12 to 48%. The difference in the FRAP values between the pulse and continuous modes ranged from 11 to 26%. The processor duty cycle was found to exert a statistically significant effect on the reducing power.
Chromatographic analysis
Chlorogenic acid
Chlorogenic acid is a phenolic compound from the hydroxycinnamic acid family and it is one of the most common compounds among the polyphenol group contained in Sorbus intermedia raw material. Chlorogenic acid possesses many health-promoting properties, most of them related to the treatment of metabolic syndrome, including anti-oxidant, antilipidemic, antidiabetic, anti-inflammatory, and antihypertensive activities. This polyphenol has shown antimicrobial activity against a wide range of organisms43. Figure 2 shows the effect of the treatment mode (continuous, pulse) on the content of chlorogenic acid in the Sorbus intermedia alcoholic extracts. In the case of the 12 and 24 µm amplitudes, there was a statistically significant effect of the processor duty cycle on the chlorogenic acid content. The highest values were found in the case of the pulse-mode treatment with the following processing parameters: 36 µm amplitude and 10 min time. The lowest values were obtained in the continuous-mode sonication at the 12 µm amplitude and 15 min time. The difference between these values was estimated at 176%. The ultrasonic vibration amplitude exerted the greatest impact on the chlorogenic acid content. The increase in the vibration amplitude from 12 µm to 36 µm resulted in an increase in the chlorogenic acid content from 84 to 146%. The increase in the treatment time from 5 to 15 min contributed to an increase in the chlorogenic acid content in the range from 1 to 23%. The differences in the content of this acid between the variants with the different processor duty cycles ranged from 12 to 29%.
Rutin
Rutin is an organic chemical compound from the group of flavonoid glycosides. Rutin demonstrated a lot of medical activities, including anticarcinogenic, antioxidant, chemotherapeutic, cytoprotective, neuroprotective, vasoprotective, and cardioprotective. Rutin has an effect on the prevention of neuroinflammation, promotion of neural crest cell survival, sedative activity, anticonvulsant activity, anti- Alzheimer activity, and treatment of hyperkinetic movement disorder, antidepressant, analgesic and antinociceptive, antiarthritic, antidiabetic, anti-hypercholesterolemic, antiplatelet aggregatory, antiulcer antiasthmatic activity and other associated, antiosteoporotic and antiosteopenic, anticataract and ophthalmic, diuretic, anticancer44. Figure 3 shows the effect of the treatment mode (continuous, pulse) on the content of rutin in the Sorbus intermedia alcoholic extracts. At the amplitudes of 12 and 24 µm, there were statistically significant differences between extracts obtained in the pulse-mode treatment and those from the continuous-mode process. Higher levels of rutin were observed in the case of the pulse mode. The difference in the rutin content between the pulse and continuous modes ranged from 5 to 27%. The highest values were found for the continuous-mode treatment at the 36 µm amplitude and 15 min time, and the lowest values were obtained at the 12 µm amplitude and 5 min time. The difference between these values reached 367%. The increase in the vibration amplitude from 12 µm to 36 µm resulted in an increase in the rutin content from 150 to 329%. The growth in the treatment time from 5 to 15 min contributed to a rise in the rutin content from 19 to 86%.
Discussion
The content of bioactive compounds is strongly determined by the genotype and habitat conditions. This indicates that, in addition to the species, such factors as plant height, light, temperature, content of nutrients available in the soil, the sampling site, and the harvesting time (maturity stage) play an important role45. Moreover, the content of bioactive compounds depends on the extraction method.
There are no literature reports on the analysis of the TFC content in Sorbus intermedia. The number of available literature reports on the content of chlorogenic acids, rutin and values of DPPH and FRAP in Sorbus intermedia is limited, and the comparison of the present results poses many problems. Therefore, the discussion refers to other Sorbus species.
The values of TFC obtained in the present experiment ranged from 0.132 to 0.502 mg QE/g DM. Jin et al.46 evaluated the chemical composition of Sorbus commixta fruit extracts prepared with different ethanol concentrations. The total flavonoid content ranged from 2.49 to 8.65 μg QE/mg of extract. Turumtay et al. 32 showed that the values of TFC for Sorbus aucuparia was 12.336 mg QE/g dried extract and for endemic Sorbus caucasica var. yaltirikii was 17.128 mg QE/g dried extract. Majić et al. 47 assess service tree (Sorbus domestica L.) bark, fruit exocarp and mesocarp, and seeds. The value of TFC ranged from 6.8 to 37.0 mg QE/g DM.
Several methods have been developed to determine antioxidant activity of plant materials. In our study, two methods (DPPH and FRAP) were used to evaluate the antioxidant potential of Sorbus intermedia fruit. FRAP is based on ferric reducing power and DPPH is based on the ability to scavenge DPPH radical. The antioxidant activity of the extracts analyzed in the present study determined with the DPPH method ranged from 32.79 to 74.38 µmol TE/g DM, while the extracts determined with the FRAP method ranged from 11.72 to 45.31 µmol TE/g DM. There are very little data in the literature with which our results could be easily compared, given the methods of extraction, analysis, units and plant species. Mrkonjić et al. 48 determined DPPH and FRAP values in methanolic extracts from the fruits of Sorbus intermedia, but they express their results in ascorbic acid equivalents. They obtained the following data: DPPH 0.20 ± 0.01 mg of AAEc/g DW and FRAP 4.47 ± 0.39 mg of AAEc/g DW. Olszewska and Michel36 evaluated the antioxidant potential of 70% methanolic extracts from the fruits of Sorbus aucuparia, Sorbus aria and Sorbus intermedia. According to their research the fruits of Sorbus intermedia showed antiradical efficiency of 86.9 µmol TE/g DM for DPPH method and 221.1 µmol TE/g DM for FRAP method. The results of the present experiment show that the levels of DPPH values coincide with the values reported by Olszewska and Michel36, but FRAP values are much lower. Probably the main reason for the differences in antioxidant activity determined by the FRAP method was the different incubation time of the samples. Both Olszewska and Mitchel36 and Stratil et al.49 proved that DPPH and FRAP tests are strongly depended on incubation time and the reactivity of various phenolic standards and plant extracts. Antioxidant activity of extracts are also related with the polarity of solvent. Bobinaite et al.50 demonstrated that antioxidant capacity of Sorbus aucuparia for water extracts in DPPH and FRAP system were 309 µmol TE/g and 323 µmol TE/g, while ethanol extracts were 103 µmol TE/g and 118 µg TE/g, respectively.
The results of the present experiment show that the levels of chlorogenic acid ranged from 436.43 µg/g DM to 1202.66 µg/g DM. Olszewska and Michel36 evaluated the content of chlorogenic acid isomers quantified by HPLC in 70% methanolic extracts from the fruits of Sorbus intermedia and the value of chlorogenic acid was 0.23 ± 0.01%. Šavikin et al.51 showed that the levels of chlorogenic acid in Sorbus aucuparia extracts ranged from 0.35 to 10.01 mg/g DW, while in Sorbus aria ranged from 0.22 to 2.30 mg/g DW. Kylli et al. 52 indicated that the value of chlorogenic acid in wild rowanberries (Sorbus aucuparia) was 5.36 ± 0.10 mg/g D. Mrkonjić et al.53 determined chlorogenic acid in water and methanol extracts, and in the jam of Sorbus aucuparia. The chlorogenic acid content was were 5.69, 5.80 and 2.60 mg/g DW, respectively. Bobinaitė et al.50 evaluated acetone, ethanol and water extracts of rowanberry (Sorbus aucuparia L.) pomace. The value of chlorogenic acid was the highest in ethanol extract (3970 µg/g extract). Jin et al.46 showed that the concentration of chlorogenic acid ranged from 111.81 to 344.7 µg/g extract.
Olszewska35 showed that rutin and isoquercitrin were predominant components of the extracts. In the present study, the rutin levels ranged from 37.22 to 173.76 µg/g DM. The concentrations of rutin in water and methanol extracts of Sorbus aucuparia were 82.3 and 80.4 mg/g DW, respectively48. Šavikin et al.51 indicated that rutin content ranged from 138.4 to 892.0 μg/g DW in Sorbus aria and 40.1 to 598.3 μg/g DW in Sorbus aucuparia extracts. Bobinaitė et al.50 showed that the value of rutin in ethanol extract was 123.9 µg/g extract. Rutin content in ethanolic extracts of Sorbus commixta ranged from 0.28 to 0.6 µg/g extract46.
The growing interest in green chemistry and the possibility of using ultrasounds have contributed to the increasing application of this method in the extraction of bioactive compounds. Ultrasounds increase mass transfer and contribute to disintegration of plant tissues and cells, which results in a shorter extraction time and higher yields. The available literature provides many examples of the application of ultrasounds to intensify the polyphenol extraction process. Phenolic compounds and antioxidant compounds have been extracted from mango peel12, coconut shell powder20, pomegranate peel23, jabuticaba peel21, grape by-product16, black chokeberry by-products17 and used coffee grounds22.
Pulsed ultrasonic field is increasingly being used to support the extraction process. However, the number of studies focused on the direct comparison of the continuous and pulse ultrasonic processor modes in the extraction of phenolic compounds is highly limited. Pan et al.23 found no significant differences between the processor duty cycles during extraction of polyphenols from pomegranate peel. However, the pulsed ultrasonic field was found to save approximately 50% of energy in comparison with the continuous sonication mode.
Kobus et al.26 demonstrated a statistically significant effect of the ultrasonic processor duty cycle on the extraction of bioactive substances. The increase in the yield of extracted total polyphenols and anthocyanins ranged from 1.14% to 34% in the case of the pulse mode. The study also showed a reduction in energy consumption from 20 to 51% in the process of extraction assisted with the pulsed ultrasonic field. As reported by Ravanfar et al.54, this mode (1 s on–1 s off) had an approx. 1.5-fold higher efficiency than the continuous mode in the case of anthocyanin extraction.
There are also ambiguous reports on the impact of the duty cycle length on the efficiency of pulsed field-assisted extraction. Xu et al.19 observed an increase in the yield of pectin extraction from grapefruit peel along with the increase in the pulse duration/pulse interval ratio from 30 to 50% followed by a decrease after exceeding this threshold. More and Arya55 reported a significant effect of the interactions between the ultrasonic power and the duty cycle on the efficiency of extraction of polyphenolic compounds from pomegranate peel. Maximum extraction efficiency was achieved with an 80% duty cycle. A similar statistically significant effect of the duty cycle on the yield was obtained by Li et al.56 during extraction of curcuminoids from dried turmeric and by Kazemi57 during extraction of phenolics from pomegranate peel. Jain et al.58 studied the effect of various parameters such as extraction time (min), ultrasonic amplitude (%) and pulse interval (s) with 2 M concentration of hydrotropes and showed that the highest composition of patchoulol i.e. 70.06% was obtained at a 5-min extraction time, 40% ultrasonic amplitude, and a 30:30 s pulse interval. Rakshit et al.59 showed that an increase in the duty cycle from 60 to 90% was accompanied by an increase in the concentration of punicalagin (98–152 mg/g). A study conducted by Kaderides et al.60 showed that the combination of 10-s intervals with 10-s pauses in the ultrasonic processor work was the best scheme for extraction of polyphenols from pomegranate peel and ensured low energy consumption. The authors demonstrated that the ultrasonic pulse/pause duration ratio of 1.2/1 should be applied in the process of pomegranate peel extraction. Appropriate selection of the pulse duration and intervals between pulses is highly important for reduction of the total extraction time and energy consumption. The extraction yields increased with the decreasing value of the pulse duration/pause ratio61. A further reduction in this ratio may cause degradation of plant material60. This indicates that an adequate use of the duty cycle may have a beneficial effect on the extraction efficiency. In contrast, Luque-Garcia and De Castro62 reported that the duty cycle exerted an insignificant effect on fat recovery from oleaginous seeds.
In the present study, there was a positive and statistically significant effect of the ultrasonic processor duty cycle on the extraction efficiency of all substances, i.e. total flavonoids, rutin, and chlorogenic acid, and on the antioxidant activity of the extracts determined with the FRAP and DPPH methods. The increase in the extraction yield in the pulse mode variant ranged from 8 to 42% for TFC, from 11 to 26% for FRAP, from 7 to 23% for DPPH, from 12 to 29% for chlorogenic acid, and from 5 to 27% for rutin and depended on the amplitude of ultrasonic vibrations and the processing time.
The higher extraction efficiency can be explained by the slight differences in the mechanism of the pulsed acoustic field compared to the continuous field. The short duration of ultrasonic pulses results in the formation of fewer cavitation bubbles than in the case of the continuous field treatment. The collapse of such bubbles generates a stronger shock wave, which results in greater fragmentation of plant tissue. The pause following the collapse of the cavitation bubbles allows soluble substances to diffuse into the surrounding solvent. The implosion of cavitation bubbles in the subsequent duty cycle of the ultrasonic processor induces defragmentation of further parts of the plant tissue and contributes to release of another portion of soluble substances. This mode of interaction causes gradual destruction of plant tissue and a lower concentration of the soluble substance in the boundary layer than in the case of the continuous field treatment. Additionally, the smaller number of cavitation bubbles at the surface of the ultrasonic probe reduces the likelihood of the so-called the saturation effect, which reduces the transmission of acoustic energy to the solvent surrounding the probe. The lower concentration of the soluble substance within the solid matrix accelerates the diffusion of the extracted component into the surrounding solvent.
The extraction temperature is an important parameter that may be responsible for the differences in the efficiency of the ultrasonic processor duty cycle. The increase in temperature results in an increase in the yield on the one hand but substantially reduces the cavitation effect of ultrasounds on the other hand. This has been confirmed in many studies63,64.
It should also be noted that despite the use of a temperature stabilizing system directly under the ultrasonic probe, the solvent temperature in the continuous mode may temporarily reach considerably higher values than in the case of the pulse mode. In the pulse-mode treatment, the cooling system has substantially more time to dissipate successively generated portions of heat from the surroundings of the ultrasonic probe. The increasing temperature under the ultrasonic probe may be another element that reduces the efficiency of extraction in the continuous field mode.
Summing up, taking into account the type of the processor duty cycle, at least the same or higher extraction yield of each bioactive substance was achieved using the pulse mode. The phenomenon of the different effects of the processor duty cycle on the efficiency of extraction of bioactive components from Sorbus intermedia requires further research.
Conclusions
The present study has shown that the efficiency of the extraction process is strongly determined by the ultrasonic processor duty cycle. This analysis is the first that compares the two operating modes of an ultrasonic processor during extraction of polyphenols from Sorbus intermedia berries.
A higher statistically significant value of the process efficiency was obtained in the pulse-mode variant. The largest difference, i.e. in the range from 8 to 42%, was observed during the extraction of total flavonoids analyzed by spectrophotometry. Smaller differences were found for individual polyphenols analyzed with the chromatographic method. In the case of chlorogenic acid, the differences were from 12 to 29% and in the case of rutin from 5 to 27%. The effect of the processor operating mode on individual polyphenolic compounds depended on the amplitude of ultrasonic vibrations.
The higher content of the extracted bioactive compounds was also confirmed by their higher antioxidant activity. The research method was found to exert a significant effect on the antioxidant activity of the extracts. Higher antioxidant activity was revealed by the determinations conducted with the use of the DPPH reagent.
References
Chemat, F. et al. Ultrasound assisted extraction of food and natural products. Mechanisms, techniques, combinations, protocols and applications. A review. Ultrason. Sonochem. 34, 540–560 (2017).
Babić, S., Petrović, M. & Kaštelan-Macan, M. Ultrasonic solvent extraction of pesticides from soil. J. Chromatogr. A. 823, 3–9 (1998).
Hou, M. et al. Ultrasound-assisted extraction of total flavonoids from Pteris cretica L.: Process optimization, HPLC analysis, and evaluation of antioxidant activity. Antioxidants. 8, 425 (2019).
Sharayei, P., Azarpazhooh, E., Zomorodi, S. & Ramaswamy, H. S. Ultrasound assisted extraction of bioactive compounds from pomegranate (Punica granatum L.) peel. LWT-Food Sci. Technol. 101, 342–350 (2019).
Ashokkumar, M. Applications of ultrasound in food and bioprocessing. Ultrason. Sonochem. 25, 17–23 (2015).
Débora, P. J., Rosane, R., Ligia, D. F. M. & Giovana, D. M. Ultrasound as an alternative technology to extract carotenoids and lipids from Heterochlorella luteoviridis. Bioresour. Technol. 224, 753–757 (2017).
Hierro Del Hierro, D. et al. Ultrasound-assisted extraction and bioaccessibility of saponins from edible seeds: quinoa, lentil, fenugreek, soybean and lupin. Food Res. Int. 109, 440–447 (2018).
Chen, Y., Luo, H., Gao, A. & Zhu, M. Ultrasound-assisted extraction of polysaccharides from litchi (Litchi chinensis Sonn.) seed by response surface methodology and their structural characteristics. Innov. Food Sci. Emerg. Technol. 12(3), 305–309 (2011).
Raza, A., Li, F., Xu, X. & Tang, J. Optimization of ultrasonic-assisted extraction of antioxidant polysaccharides from the stem of Trapa quadrispinosa using response surface methodology Int. J. Biol. Macromol. 94, 335–344 (2017).
Kumar, K., Srivastav, S. & Sharanagat, V. J. Ultrasound assisted extraction (UAE) of bioactive compounds from fruit and vegetable processing by-products: A review. Ultrason. Sonochem. 70, 105325 (2021).
Freitas de Oliveira, D. et al. Extraction of pectin from passion fruit peel assisted by ultrasound. LWT. Food Sci. Technol. 71, 110–115 (2016).
Guandalini, B. B. V., Rodrigues, N. P. & Marczak, L. D. F. Sequential extraction of phenolics and pectin from mango peel assisted by ultrasound. Food Res. Int. 119, 455–461 (2019).
Hosseini, S. S., Khodaiyan, F., Kazemi, M. & Najari, Z. Optimization and characterization of pectin extracted from sour orange peel by ultrasound assisted method. Int. J. Biol. Macromol. 125, 621–629 (2019).
Samaram, S. et al. Optimisation of ultrasound-assisted extraction of oil from papaya seed by response surface methodology: Oil recovery, radical scavenging antioxidant activity, and oxidation stability. Food Chem. 172, 7–17 (2015).
Minjares-Fuentes, R. et al. Ultrasound-assisted extraction of pectins from grape pomace using citric acid: A response surface methodology approach. Carbohydr. Polym. 106, 179–189 (2014).
Corrales, M., Toepfl, S., Butz, P., Knorr, D. & Tauscher, B. Extraction of anthocyanins from grape by-products assisted by ultrasonics, high hydrostatic pressure or pulsed electric fields: a comparison. Innov. Food Sci. Emerg. Technol. 9(1), 85–91 (2008).
Ramić, M. et al. Modeling and optimization of ultrasound-assisted extraction of polyphenolic compounds from Aronia melanocarpa by-products from filter-tea factory. Ultrason. Sonochem. 23, 360–368 (2015).
Maran, J. P. & Priya, B. Ultrasound-assisted extraction of polysaccharide from Nephelium lappaceum L. fruit peel. Int. J. Biol. Macromol. 70, 530–536 (2014).
Xu, Y. et al. Effects of ultrasound and/or heating on the extraction of pectin from grapefruit peel. J. Food Eng. 126, 72–81 (2014).
Rodrigues, S., Pinto, G. A. & Fernandes, F. A. Optimization of ultrasound extraction of phenolic compounds from coconut (Cocos nucifera) shell powder by response surface methodology. Ultrason. Sonochem. 15(1), 95–100 (2008).
Rodrigues, S., Fernandes, F. A. N., De Brito, E. S., Sousa, A. D. & Narain, N. Ultrasound extraction of phenolics and anthocyanins from jabuticaba peel. Ind. Crops Prod. 69, 400–407 (2015).
Al-Dhabi, N. A., Ponmurugan, K. & Jeganathan, P. M. Development and validation of ultrasound-assisted solid-liquid extraction of phenolic compounds from waste spent coffee grounds. Ultrason. Sonochem. 34, 206–213 (2017).
Pan, Z., Qu, W., Ma, H., Atungulu, G. G. & McHugh, T. H. Continuous and pulsed ultrasound-assisted extractions of antioxidants from pomegranate peel. Ultrason. Sonochem. 19(2), 365–372 (2012).
Patience, N. A., Schieppati, D. & Boffito, D. C. Continuous and pulsed ultrasound pectin extraction from navel orange peels. Ultrason. Sonochem. 73, 105480 (2021).
Christou, A., Stavrou, I. J. & Kapnissi-Christodoulou, C. P. Continuous and pulsed ultrasound-assisted extraction of carob’s antioxidants: Processing parameters optimization and identification of polyphenolic composition. Ultrason. Sonochem. 76, 105630 (2021).
Kobus, Z., Krzywicka, M., Pecyna, A. & Buczaj, A. process efficiency and energy consumption during the ultrasound-assisted extraction of bioactive substances from hawthorn berries. Energies 14, 7638 (2021).
Jurikova, T. et al. Polyphenolic profile and biological activity of Chinese hawthorn (Crataegus pinnatifida BUNGE) fruits. Molecules 17, 14490–14509 (2012).
Aldasoro, J. J. & Aedo, C. The genus Sorbus (Maloideae, Rosaceae) in Europe and in North Africa: Morphological analysis and systematics. Syst. Bot. 23, 189–212 (1998).
Sorbus intermedia. European Forest Genetic Resources Programme http://www.euforgen.org/species/sorbus-intermed (2022).
Hukkanen, A. T. et al. Antioxidant capacity and phenolic content of sweet rowanberries. J Agric. Food Chem. 54(1), 112–119 (2006).
Singh, P. & Mijakovic, I. Rowan berries: a potential source for green synthesis of extremely monodisperse gold and silver nanoparticles and their antimicrobial property. Pharmaceutics 14(1), 82 (2022).
Turumtay, H. et al. Gram (-) microorganisms DNA polymerase inhibition, antibacterial and chemical properties of fruit and leaf extracts of Sorbus acuparia and Sorbus caucasica var. yaltirikii. Biomed. Chromatog. 31(6), e3901 (2017).
Yu, X. et al. Effect and mechanism of Sorbus pohuashanensis (Hante) Hedl. flavonoids protect against arsenic trioxide-induced cardiotoxicity. Biomed. Pharmacother. 88, 1–10 (2017).
Olszewska, M. A. Separation of quercetin, sexangularetin, kaempferol and isorhamnetin for simultaneous HPLC determination of flavonoid aglycones in inflorescences, leaves and fruits of three Sorbus species. J. Pharm. Biomed. Anal. 48, 629–635 (2008).
Olszewska, M. A. Flavonoid profile of Sorbus intermedia. Chem. Nat. Compd. 45, 722–724 (2009).
Olszewska, M. A. & Michel, P. Antioxidant activity of inflorescences, leaves and fruits of three Sorbus species in relation to their polyphenolic composition. Nat. Prod. Res. 23, 1507–1521 (2009).
Sołtys, A., Galanty, A., Zagrodzki, P. & Podolak, I. Relationship between maturity stage, triterpenoid content and cytotoxicity of Sorbus intermedia (EHRH.) PERS. fruits – A chemometric approach. Chem. Biodivers. 18(11), e2100552 (2021).
Aryal, S. et al. Total phenolic content, flavonoid content and antioxidant potential of wild vegetables from western Nepal. Plants. 8(4), 96–108 (2019).
Alberti, A. et al. Optimisation of the extraction of phenolic compounds from apples using response surface methodology. Food Chem. 149, 151–158 (2014).
Rydzak, L. et al. Analysis of selected physicochemical properties of commercial apple juices. Processes 8(11), 1457 (2020).
Blois, M. S. Antioxidant determinations by the use of a stable free radical. Nature 181, 1199–1200 (1958).
Benzie, I. & Strain, J. The ferric reducing ability of plasma (FRAP) as a measure of “Antioxidant Power: The FRAP Assay”. Anal. Biochem. 239, 70–76 (1996).
Santana-Gálvez, J., Cisneros-Zevallos, L. & Jacobo-Velázquez, D. A. Chlorogenic acid: Recent advances on its dual role as a food additive and a nutraceutical against metabolic syndrome. Molecules 22(3), 358 (2017).
Ganeshpurkar, A. & Saluja, A. K. The pharmacological potential of rutin. Saudi Pharm. J. 25, 149–164 (2017).
Zhang, Z. et al. Characterization of antioxidants present in hawthorn fruits. J. Nutr. Biochem. 12, 144–152 (2001).
Jin, S., Kim, K. C., Kim, J. S., Jang, K. I. & Hyun, T. K. Anti-melanoma activities and phytochemical compositions of sorbus commixta fruit extracts. Plants (Basel, Switzerland). 9(9), 1076 (2020).
Majić, B. et al. Minerals and phenolics in Sorbus domestica L.. Food Technol. Biotechnol. 53(4), 463–471 (2015).
Mrkonjić, Z. et al. Fresh fruits and jam of Sorbus domestica L. and Sorbus intermedia (Ehrh.) Pers.: Phenolic profiles, antioxidant action and antimicrobial activity. Bot. Serb. 43(2), 187–196 (2019).
Stratil, P., Klejdus, B. & Kuban, V. Determination of total content of phenolic compounds and their antioxidant activity in vegetables – evaluation of spectrophotometric methods. J. Agric. Food Chem. 54(3), 607–616 (2006).
Bobinaite, R. et al. Chemical composition, antioxidant, antimicrobial and antiproliferative activities of the extracts isolated from the pomace of rowanberry (Sorbus aucuparia L.). Food Res. Int. 136, 109310 (2020).
Šavikin, K. P. et al. Sorbus aucuparia and Sorbus aria as a source of antioxidant phenolics, tocopherols, and pigments. Chem. Biodivers. 14, 1–11 (2017).
Kylli, P. et al. Rowanberry phenolics: Compositional analysis and bioactivities. J. Agric. Food Chem. 58, 11985–11992 (2010).
Mrkonjić, Z. O. et al. Phenolic profiling and bioactivities of fresh fruits and jam of Sorbus species. J. Serbian Chem. Soc. 82, 651–664 (2017).
Ravanfar, R. et al. Extraction and fractionation of anthocyanins from red cabbage: Ultrasonic-assisted extraction and conventional percolation method. Food Measure. 12, 2271–2277 (2018).
More, P. & Arya, S. Intensification of bio-actives extraction from pomegranate peel using pulsed ultrasound: Effect of factors, correlation, optimization and antioxidant bioactivities. Ultrason. Sonochem. 72, 105423 (2021).
Li, M., Ngadi, M. O. & Ma, Y. Optimisation of pulsed ultrasonic and microwave assisted extraction for curcuminoids by response surface methodology and kinetic study. Food Chem. 165, 29–34 (2014).
Kazemi, M., Karim, R., Mirhosseini, H. & Abdul Hamid, A. Optimization of pulsedultrasound-assisted technique for extraction of phenolics from pomegranate peel of Malas variety: Punicalagin and hydroxybenzoic acids. Food Chem. 206, 156–166 (2016).
Jain, P.L.B., Patel, S.R. & Desai, M.A. An innovative ultrasonic-assisted extraction process for enhancing the patchoulol from Pogostemon cablin essential oil using hydrotropes. Mater. Today: Proc. 57(6), 2377–2380 (2021).
Rakshit, M., Srivastav, P. P. & Bhunia, K. Kinetic modeling of ultrasonic-assisted extraction of punicalagin from pomegranate peel. J. Food Process Eng. 43, e13533 (2020).
Kaderides, K., Goula, A. M. & Adamopoulos, K. G. A process for turning pomegranate peels into a valuable food ingredient using ultrasound-assisted extraction and encapsulation. Innov. Food Sci. Emerg. Technol. 31, 204–215 (2015).
Roldán-Gutiérrez, J. M., Ruiz-Jiménez, J. & Luque De Castro, M. D. Ultrasound-assisted dynamic extraction of valuable compounds from aromatic plants and flowers as compared with steam distillation and superheated liquid extraction. Talanta. 75, 1369–1375 (2008).
Luque-García, J. L. & Luque de Castro, M. D. Ultrasound-assisted Soxhlet extraction: An expeditive approach for solid sample treatment. Application to the extraction of total fat from oleaginous seeds. J. Chromatogr. A. 1034(1–2), 237–242 (2004).
Zhang, H. et al. Study on transient characteristics and influencing of temperature on cavitation bubbles in various environments. Optik 187, 25–33 (2019).
Da Fonseca Machado, A. P. et al. Extraction of polyphenols and antioxidants from pomegranate peel using ultrasound: influence of temperature, frequency and operation mode. Int. J. Food Sci. 54, 2792–2801 (2019).
Funding
No funding sources.
Author information
Authors and Affiliations
Contributions
Z.K. conceptual work, methodology, investigation, formal analysis, participation in experimental work, writing – original draft preparation. M.K. conceptual work, participation in experimental work, processing of statistical data, participation in manuscript’s writing. A.S.-W. - investigation, formal analysis, founding acquisition. A.S. - investigation, formal analysis, founding acquisition.
Corresponding author
Ethics declarations
Competing interests
The authors declare no competing interests.
Additional information
Publisher's note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Kobus, Z., Krzywicka, M., Starek-Wójcicka, A. et al. Effect of the duty cycle of the ultrasonic processor on the efficiency of extraction of phenolic compounds from Sorbus intermedia. Sci Rep 12, 8311 (2022). https://doi.org/10.1038/s41598-022-12244-y
Received:
Accepted:
Published:
DOI: https://doi.org/10.1038/s41598-022-12244-y
- Springer Nature Limited