Abstract
Nine odorless laboratory-collected hydro-distilled aqueous extracts (basil, calendula, centrifuged oregano, corn silk, laurel, oregano, rosemary, spearmint, thyme) and one industrial steam-distilled oregano hydrolate acquired as by-products of essential oils purification were screened for their in vitro antimicrobial activity against three Salmonella Typhimurium strains (4/74, FS8, FS115) at 4 and 37 °C. Susceptibility to the extracts was mainly plant- and temperature-dependent, though strain dependent effects were also observed. Industrial oregano hydrolate eliminated strains immediately after inoculation, exhibiting the highest antimicrobial potential. Hydro-distilled extracts eliminated/reduced Salmonella levels during incubation at 4 °C. At 37 °C, oregano, centrifuged oregano, thyme, calendula and basil were bactericidal while spearmint, rosemary and corn silk bacteriostatic. A strain-dependent effect was observed for laurel. The individual or combined effect of marinades and edible coatings prepared of industrial hydrolate and hydro-distilled oregano extracts with or without oregano essential oil (OEO) was tested in pork meat at 4 °C inoculated with FS8 strain. Lower in situ activity was observed compared to in vitro assays. Marinades and edible coatings prepared of industrial oregano hydrolate + OEO were the most efficient in inhibiting pathogen. Marination in oregano extract and subsequent coating with either 50% oregano extract + OEO or water + OEO enhanced the performance of oregano extract. In conclusion, by-products of oregano essential oil purification may be promising alternative antimicrobials to pork meat stored under refrigeration when applied in the context of multiple hurdle approach.
Similar content being viewed by others
Introduction
Naturally derived antimicrobial compounds are increasingly gaining commercial attention as label-friendly alternatives to synthetic food preservatives1. Among them, phenolic compounds are a diverse group of plant secondary metabolites. They exhibit a wide range of physiological properties, including antimicrobial activity against a broad spectrum of pathogenic and spoilage bacteria2,3. Phenolic compounds are ubiquitous in plants4, with aromatic plants such as herbs and spices being especially rich in their phenolic content5. By-products of plant origin foods4,6 and essential oil industry7 are also good sources of phenolics. Given that the volume and economic burden of agro-industrial by-products processing are substantial8, their commercial exploitation as sources of phenolic compounds can provide an economical and environmentally-friendly way to enhance food safety2,6. Nevertheless, limited research is available regarding their potential antibacterial activity2,6.
The in vitro antimicrobial effect of plant extracts has been widely documented. However, fewer studies are available pertaining their in situ efficacy, probably due to the reduced effectiveness of plant extracts in food products9. Indeed, due to the complex and diverse nature of food environments, the extrapolation of the in vitro results to food products cannot be ensured9 at concentrations that maintain antimicrobial potential without compromising the sensory properties. Therefore, the in situ evaluation of their antimicrobial profile, as well as seeking alternative ways to optimize their efficacy, such as combining different treatments, are of utmost important for their systematic application in food matrices.
Phenolic compounds may either extend the shelf life of several food products10,11 or improve food safety, e.g., by promoting inactivation or growth inhibition of foodborne pathogens7,12. Among foodborne pathogens, Salmonella spp. is the second most common cause of reported zoonosis in Europe13 and the leading cause of hospitalization in the States14. With more than 2500 distinct serotypes, this pathogen consists a major health problem worldwide15, evolved to survive in a wide range of environments and across multiple hosts16. Its prevalence has been highly associated with products of animal origin, such as eggs, meat and poultry13. S. Typhimurium is one of the most common serovars isolated from pig meat13.
Differences in the innate characteristics among strains of the same species identically treated consist a major source of variation in microbiological studies, referred to as strain variability17. Differences in the phenotypic responses among strains of foodborne pathogens with regard to their inactivation potential can be extensive and therefore, should systematically be taken under consideration18.
Considering the above, the current study aimed primarily to screen the in vitro antimicrobial potential of nine laboratory (hydro-distilled) and one industrial (steam-distilled hydrolate) plant aqueous extracts acquired as by-products of essential oil purification procedure, against three strains of Salmonella spp. The second part aimed to evaluate the in situ antimicrobial activity of hydro-distilled oregano extract and industrial oregano hydrolate on improving the safety of pork meat against Salmonella.
Results
In vitro antimicrobial activity
Ten plant aqueous extracts acquired as by-products of essential oil production, either hydro-or steam-distilled, were screened for their in vitro antibacterial profiles against three strains of S. Typhimurium at 4 and 37 °C. The chemical composition of the extracts is presented in Table 1. Hydro-distilled aqueous extracts were consisted mainly of phenolic compounds, such as flavonoids and phenolic acids (e.g. hesperidin, luteolin, rosmarinic acid, chlorogenic acid). On the other hand, industrial oregano hydrolate collected by steam-distillation was composed of carvacrol (92.3%) and to a lesser extent of thymol (7.1%).
A marked variability was observed in the antimicrobial potential of the extracts. Their antimicrobial activity was mainly dependent on plant and incubation temperature. Industrial oregano hydrolate had the highest bactericidal activity, irrespectively of the incubation temperature. It reduced strains cell densities below the threshold of detection (1.3 log CFU/ml) immediately after inoculation. On the other hand, enumeration of cells inoculated in TSB adjusted to pH 3.5 was performed for several hours after incubation at both 4 and 37 °C (Fig. 1), indicating a higher antimicrobial potential of industrial oregano hydrolate compared to pH controls. Among the hydro-distilled aqueous extracts, oregano exhibited the strongest antimicrobial activity in both temperatures, followed by thyme, calendula and centrifuged oregano extracts with activities that varied dependent on the temperature and the strain used (Table 2 and Fig. 2). On the other hand, corn silk had the lowest impact on the survival of Salmonella strains within the incubation period at both temperatures (Table 2 and Fig. 2). At 4 °C, all extracts effectively reduced pathogen levels. The time needed for a four-log reduction (t4D) is presented at Table 2, whereas the order of antimicrobial potential based on the calculated t4D estimates is given in supplementary data (see supplementary Table S3 online). Among the three strains, small differences (P < 0.05) in their sensitivity were observed when exposed to basil, calendula, c. oregano and corn silk (Table 2). Cultures inoculated in TSB and TSB pH 5.5 remained practically stable to their initial levels, with populations ranging between 5.0 and 5.8 logs throughout incubation period (Table 3). On the other hand, an approximately 2.0 log reduction was observed during incubation to de-ionized water (Table 3), although this reduction was lower compared to the effect of the extracts (Table 2).
At 37 °C, oregano, centrifuged oregano, thyme, calendula and basil decreased pathogen population within 24 h of incubation (Fig. 2). Oregano almost eliminated initial populations within the first 9 h of incubation. Basil, calendula, centrifuged oregano and thyme extracts, also reduced/inactivated Salmonella within 24 h of incubation, though at a lower rate compared to oregano (Fig. 2). On the other hand, corn silk, spearmint and rosemary had only a bacteriostatic effect, permitting pathogen growth in a lower growth rate and up to lower final populations (P < 0.05) compared to controls (TSB and TSB adjusted to pH 5.5) (Fig. 2). At the end of incubation period (24 h), the highest number of survivors were found in corn silk, whereas lower log counts (P < 0.05) were enumerated in rosemary (Fig. 2, see Supplementary Table S2 online). A strain-dependent effect was observed for laurel aqueous extract: FS8 strain was increased by 1.2 logs, while strains 4/74 and FS115 were reduced by 2.3 and 1.5 logs, respectively (Fig. 2, see Supplementary Table S2 online). Populations among the three strains inoculated to the same plant extract (apart from laurel) and for the same time interval, though significant in some cases, did not exceed 0.5–0.8 logs (Fig. 2, see Supplementary Table S2 online).
Overall, the aqueous extracts effectively reduced the in vitro levels or growth rate of three S. Typhimurium strains, in a plant-, temperature- and strain-dependent manner.
Antimicrobial activity of hydro-distilled oregano extract and industrial oregano hydrolate against S. Typhimurium FS8 in pork meat
Hydro-distilled oregano extract and industrial oregano hydrolate were further examined for their efficacy in improving the safety of pork meat stored at 4 °C. These extracts were selected since they exhibited the strongest in vitro antimicrobial performance. The individual or combined effect of marination and edible coatings supplemented with or without low concentrations of OEO was assessed for the application of the extracts on the meat surface. Since the in vitro inactivation profiles of the three strains did not significantly differ during their exposure to oregano at 4 °C, FS8 strain (minced pork isolate) was chosen to be inoculated to the pork meat samples (in situ exposure to the oregano extracts).
Effect of marination
Depending on the treatment, application of 3 h marination resulted in 0.6–2.4 log reductions (P < 0.05) of the initial bacterial population (Fig. 3). When samples were marinated in water and water + OEO, a 1.2 and 1.6 log reduction (P < 0.05), respectively, was observed compared to the inoculated untreated samples immediately after the application of the treatment. No further reduction (P < 0.05) of Salmonella populations was observed when oregano, oregano + OEO or industrial oregano hydrolate were applied as marination solutions. On the contrary, industrial oregano hydrolate + OEO had the highest antimicrobial activity (P < 0.05), lowering the initial bacterial population by 2.4 log CFU/g compared to the inoculated untreated samples and by ~ 1 log CFU/g compared to the samples marinated in water + OEO (Fig. 3, see Supplementary Table S4 online). Significant differences were not observed between samples marinated in extracts with and those without OEO (P > 0.05). Furthermore, there was not any residual antimicrobial activity after storage at 4 °C for 4 days, regardless of the marination solution (P > 0.05) (Fig. 3, see Supplementary Table S4 online). Therefore, marination of pork meat samples resulted in a rapid decrease of Salmonella populations, especially when industrial + OEO was used in the marinades.
Effect of edible coatings
The effect of sodium alginate edible coatings prepared of water, 50% oregano, centrifuged oregano, 50% centrifuged oregano, industrial oregano and 50% industrial oregano supplemented with or without 0.5% OEO on pathogen survival was studied (Fig. 4). Application of coatings with no added OEO resulted in ~ 1.0 log CFU/g reduction (P < 0.05) during storage for all extract-treated samples (Fig. 4a, see Supplementary Table S5 online). At the end of storage period, no differences (P > 0.05) were found among the extract-coated samples, though lower survivors were enumerated compared to uncoated and water-coated meat samples (P < 0.05) (Fig. 4a, see Supplementary Table S5 online).
Supplementation of edible coatings with OEO was initially performed using a concentration of 0.2% (data not shown). Since no effect was found, a higher concentration of 0.5% was tested. Incorporation of 0.5% OEO increased the antibacterial effect of the coatings compared to those with no added OEO: all treated samples had 1.0–1.5 log (P < 0.05) lower bacterial levels compared to the inoculated untreated samples immediately after treatment, regardless of the film-forming solution (Fig. 4b, see Supplementary Table S6 online). In addition, a gradual reduction of up to 1.3 log CFU/g (P < 0.05) was observed at the end of storage period (5th day of storage) for most of the samples tested, apart from those coated in centrifuged oregano + OEO (P > 0.05). Nonetheless, coatings prepared of industrial oregano hydrolate + OEO were the most potent in decreasing the levels of Salmonella, resulting in a total reduction of 2.6 log CFU/g on day 5 compared to inoculated uncoated samples and ~ 1 log CFU/g compared to samples coated with water + OEO (Fig. 4b, see Supplementary Table S6 online). Therefore, addition of low levels of OEO enhanced the antimicrobial activity of industrial oregano hydrolate incorporated through edible coatings.
Combined effect of marination and edible coatings
The combined effect of antimicrobial marination and edible coatings on the survival of S. Typhimurium FS8 on pork meat was evaluated (Table 4). Edible coatings enhanced the antimicrobial effect of marination for some of the treatments tested, resulting in log reductions during storage. Combination of marination in hydro-distilled oregano extract and water + OEO coatings or hydro-distilled 50% oregano + OEO coatings enhanced the performance of the extract, leading to a reduction of 0.9 and 1.4 log units (P < 0.05) during storage, respectively. The total reduction was 1.4 and 2.0 log CFU/g, respectively, compared to the inoculated untreated pork meat samples (Table 4).
In all experiments, no Salmonella populations were detected in none of the uninoculated untreated meat samples.
Changes in the pH during storage
Slight/no alterations were recorded at the pH values of most treated samples. On the contrary, pH of untreated samples increased from 5.8 to approximately 6.4–6.5 during storage (see Supplementary Figs. S1–S3 online).
Discussion
The last decades, natural antimicrobials, such as essential oils and plant extracts other than essential oils, are increasingly gaining scientific and commercial attention as label-friendly alternatives to synthetic food preservatives. So far, the majority of the scientific research regarding the effect of natural antimicrobials has been focused on essential oils19,20,21,22. Despite the perceived inhibitory effect of some of these naturally occurring substances, their practical application is often restricted due to their strong flavor and aroma, their application cost and their potential toxicity in human health when applied in high levels23. On the other hand, the bactericidal activity of plant derived extracts other than essential oils has been attributed to the presence of polyphenolic fraction5,7,24, which has a reported antimicrobial effect against foodborne bacteria, e.g. Salmonella spp., Listeria monocytogenes, Staphylococcus aureus and Escherichia coli25,26,27,28,29,30,31. Polyphenols can be obtained from agricultural by-products and food waste and used for several applications due to their antioxidant and antimicrobial activities32. Among the potential sources, by-products of essential oil distillation are rich in phenolic compounds and have been found effective in delivering an important bactericidal effect when applied as antimicrobial agents in lettuce7. Nevertheless, their commercial or industrial utilization has not been established yet, despite their reported antimicrobial activity and their low production cost7.
Although a significant amount of scientific work has been published so far, the industrial application of natural antimicrobials is one of the greatest challenges that food industry has to meet in the twenty-first century33. Seeking for new natural antimicrobials that could be used instead or in combination with low levels of essential oils to overcome the above limitations is of paramount importance towards this direction.
This study was motivated by the notion that the application of essential oil distillation by-products, apart from their ecological and eco-friendly character, can pose a significant antimicrobial activity without having the strong sensory effects of the essential oils. Nine laboratory rich-phenolic hydro-distilled aqueous extracts and one industrial hydrolate acquired as by-products of essential oil purification procedure were tested against three S. Typhimurium strains (4/74, FS8 and FS115). Τhe collected hydro-distilled extracts were odorless since the essential oil was removed and, thus, they can be used without compromising the sensory characteristics (odor and flavor) of the food products. Industrial hydrolate collected as by-product of steam distillation, the most commonly applied method of essential oil production34, can contain only a small amount of essential oils, that is usually discarded35. Although the odor of the hydrolate can vary, it is far from the strong scent of essential oils that can cause headache, eye and skin irritations, etc.36. According to the manufacturer, the industrial hydrolate used in the current study contained less than 0.5 ‰ of the essential oil compounds.
All of the extracts tested inhibited or reduced Salmonella strains when in vitro examined. However, the susceptibility of the strains was mainly affected by incubation temperature and plant extract. At 37 °C, incubation in the extracts caused either inactivation/reduction or growth inhibition of the strains. On the other hand, the combination of low temperature and antimicrobial compounds during incubation at 4 °C resulted in inactivation/reduction of all pathogens. A temperature-dependent effect regarding the antimicrobial activity of phenolic compounds has been previously reported37. In addition, a marked variability in the antimicrobial potential of the extracts was observed at both incubation temperatures. This may be attributed to variations of the phytocompounds present in the extracts26,29,38 as well as variations in their volatile nature (industrial hydrolate vs hydro-distilled extracts)26,29. For instance, a unique composition was observed for each one of the hydro-distilled extracts composed of phenolic compounds, even though rosmarinic acid was the most abundant component in half of the extracts tested. Nevertheless, these extracts had a milder in vitro antimicrobial activity compared to the industrial oregano hydrolate. The latter was composed of the volatile compounds thymol and carvacrol, the main components of oregano essential oil39. The superior antimicrobial effect of essential oils compared to their corresponding water extracts has also been reported elsewhere40,41. The absence of carvacrol and thymol from the hydro-distilled oregano and thyme extracts can be attributed to the volatilization of these compounds in the essential oil-fraction during the distillation process.
The antimicrobial effect of laurel extract at 37 °C on Salmonella was strain-dependent. Strain variations were also observed regarding the sensitivity of the strains inoculated in basil, calendula, c. oregano and corn silk at 4 °C. Miceli et al.28 also reported that the susceptibility of several strains of Listeria monocytogenes, Salmonella enterica, Staphylococcus aureus and Enterobacter spp. to two different plant water extracts was strain-specific. Food preservation methods or stresses widely occurring in the food chain can stimulate diverse strain-specific phenotypic responses. For instance, variations in the thermal42 or acid42,43 resistance has been reported among Salmonella strains. Gavriil et al.44 reported considerable variability regarding the innate resistance of six Salmonella strains to mayonnaise stored at 4 °C. According to Melo et al.45, three strains of Listeria monocytogenes adapted to a cheese stimulated medium used different proteomic repertoires in order to survive gastric stress, leading to a unique proteomic profile for each strain.
The in situ efficacy of both hydro-distilled oregano extract and industrial oregano hydrolate having the most prominent in vitro antimicrobial potency was further evaluated in pork meat under refrigeration (4 °C). Extract-based marination, edible coatings or their combinations supplemented without or with low concentrations of OEO were used as antimicrobial interventions for distributing the extracts onto the food surface. In accordance to the in vitro results, industrial oregano hydrolate was the most potent in reducing Salmonella populations on meat samples when applied in marinades or incorporated in edible films, though low levels of OEO were also required for the in situ antimicrobial activity to be manifested. Nevertheless, the type of the applied treatment (marination or edible coatings) affected the antimicrobial performance of the extract. Marination proved a rapid and effective intervention, even though no residual activity was observed during storage. Direct application of phytochemicals into the food system results in rapid diffusion of the antimicrobial agents into the mass of the food23. Application of edible coatings prepared with industrial oregano hydrolate + OEO, on the other hand, apart from a rapid reduction immediately after application, had also a gradual reduction during storage. Edible coatings are reported to allow a gradual and controlled diffusion of bioactive compounds into the food system6,46, maintaining, therefore, their concentrations on the surface of the foods at appropriate levels over time46. Application of a multi-hurdle approach combining both different antimicrobials and different interventions was required in the case of the hydro-distilled oregano extract that had showed lower in vitro antimicrobial activity to enhance its in situ antimicrobial performance. With regard to antagonistic effects that can take place when combining different chemical compounds47, this result demonstrate that rich phenolic by-products can effectively be combined with low levels of essential oils. The above in situ results are in line with other studies, demonstrating that the combination of natural antimicrobials or their use together with other preservation technologies may enhance their effectiveness7,48,49.
Nevertheless, the in situ activity of the extracts was lower compared to the in vitro assays. It is generally accepted that the antimicrobial effect of plant extracts may be markedly moderated in food substrates27,28,49. Food with a complex composition such as meat and poultry products can limit effective application of natural antimicrobials due to their inherent characteristics, such as their nonhomogeneous substrate, their neutral pH and their high concentrations of lipids and proteins1. Indeed, in complex matrices, lipids and proteins can strongly interact with bioactive phenolic compounds, lowering their antimicrobial efficacy50. Del Campo et al.51 demonstrated that the presence of serum albumin in TSB and dairy cream in TSB and zucchini broth reduced the inhibitory effect of a rosemary extract. Similarly, Bouarab-Chibane et al.31 reported that the antimicrobial activity of some phenolics against Staphylococcus aureus was reduced/abolished in the presence of bovine meat proteins, probably due to a decrease in the active free quantity of these antimicrobials. The level of the initial bacterial concentration has been also found to affect the antimicrobial profile of the extracts, with low levels of Campylobacter jejuni cell populations being more susceptible compared to high inocula levels49. Furthermore, the lower water content of food substrates compared to the laboratory media could also hinder the transfer of antimicrobial molecules into the active site within the microbial cell52. Regarding edible coatings, interactions of the forming biopolymer with the bioactive compounds may also affect the free residual concentration of the bioactive compounds. Gómez-Estaca et al.53 demonstrated reduced free phenol content in tuna-skin gelatin films as a result of polyphenol-protein interactions. Interactions of alginates with polyphenols has also been reported54. The effectiveness of the aqueous extracts other than essential oils in reducing pathogen load in foods has been previously reported, with regard to factors such as food matrix, storage temperature and type and concentration of plant extract7,12,37,55,56,57.
Despite the limited (on average), yet significant in situ reductions caused by the antimicrobial interventions studied, they are considered of great importance in the field of food safety, especially when it comes to substances with a milder antimicrobial nature compared to essential oils. The results of the current study highlight the potential of these extracts as antimicrobial food agents and leave room for further studying new ways that could maximize their antimicrobial performance. The concentrations of essential oils in food products required for sufficient antimicrobial activity usually exceeds their organoleptically acceptable levels58. Therefore, their combination with plant extracts could minimize the required dose59, leading to acceptable sensory properties of treated products.
In conclusion, the aqueous by-products of essential oil production effectively controlled S. Typhimurium in a temperature-, plant- and strain-dependent manner when in vitro examined. Oregano essential oil by-products exhibited prominent bactericidal properties against FS8 strain inoculated on pork meat at 4 °C. Despite their mild antimicrobial activity when applied in situ, the utilization of these extracts in combination with low levels of essential oils can adequately control the safety of pork meat when applied in the concept of a multi-hurdle approach, in an eco-friendly and cost-effective way, without compromising the sensory properties (odor and flavor) of the food products. Future work could focus on finding new ways for maximizing their antimicrobial performance, e.g. combining hydro-distilled extracts with different chemical composition in a variety of food products. Furthermore, future studies might also unravel the mechanisms behind the strain-dependent effects that were observed in this study by exploring the proteomic profiles of the strains, during exposure to the class of antimicrobials tested.
Methods
Bacterial strains and inoculum preparation
Ten plant aqueous extracts were screened for their in vitro antimicrobial profile against three different strains of Salmonella enterica subspecies enterica serovar Typhimurium (strains 4/74, FS8 and FS115). Strain 4/74 isolated from calf bowlel was kindly provided by the Laboratory of Food Microbiology and Biotechnology, Agricultural University of Athens, Greece whereas strains FS8 and FS115 were isolated from meat samples (pork minced meat and chicken meat, respectively) collected from a food industry. Stock cultures were maintained in Tryptone Soy Broth (TSB, Lab M Limited, Lancashire, UK) at − 20 °C supplemented with 20% glycerol and were monthly subcultured to Tryptic Soy Agar (TSA, Lab M Limited, Lancashire, UK) stored at 0–4 °C. Before every experiment, one colony from each strain was transferred into 10 ml TSB (37 °C, 24 h), followed by a second transfer of 100 μl from 24-h cultures to 10 ml of fresh TSB (37 °C, 18 h). Before their use, activated cells were centrifuged (2709×g, 10 min, 4 °C), washed twice with ¼ Ringer solution (Lab M Limited, Lancashire, UK) and resuspended in 10 ml of the appropriate medium (aqueous extracts, de-ionized sterile water, TSB, TSB adjusted to pH 5.5 or 3.5), as described below. Antimicrobial activity of hydro-distilled oregano extract and industrial oregano hydrolate in pork meat was evaluated using only FS8 strain. The strain was prepared as described above and resuspended in 10 ml of ¼ Ringer solution.
Extraction of aqueous plant extracts
Basil, calendula, corn silk, laurel, oregano, rosemary, spearmint and thyme were purchased in a dried form from a local supermarket. Each plant was mixed with de-ionized water at a 1:10 ratio and hydro-distilled in a Clevenger apparatus for 3 h, according to Gardeli et al.60. After the end of hydro-distillation, both essential oil and hydrolate were discarded, whereas the remaining liquid waste where the plant was boiled was collected by removing the solid retentate. Centrifuged oregano extract was collected by centrifuging the hydro-distilled oregano extract (2709×g, 5 min, 4 °C) and using the supernatant as a new antimicrobial aqueous phase. All the aqueous fractions were covered with silver foil and stored at 4 °C for 48 h before further use.
An industrially acquired oregano hydrolate collected as by-product of oregano essential oil steam distillation was also used throughout this study. The aqueous extract was purchased by an industry in Northern Greece and was transferred to the laboratory. Steam distillation was performed for at least 3 h. According to the manufacturer, the hydrolate contained less than 0.5 ‰ of the essential oil compounds. The extract was covered in silver foil and stored at 4 °C until use.
In vitro antimicrobial activity of plant extracts
The activated cultures of Salmonella strains were serially diluted and inoculated in the appropriate medium (aqueous extracts, de-ionized sterile water, TSB, TSB adjusted to pH 5.5 or 3.5 with HCl 6 N; Merck, Darmstadt, Germany) at a final concentration of approximately 106 CFU/ml. De-ionized water and TSB were used as controls. Inoculation in TSB adjusted to pH 5.5 or 3.5 (HCl 6 N) was performed in order to simulate the lower pH values of hydro-distilled extracts (pH 5.2–5.6) and industrial oregano hydrolate (pH 3.5), respectively. The inoculated solutions were incubated at either 37 or 4 °C; sampling was performed at 0, 3, 6, 9 and 24 h or at regular time intervals for up to 44 days (depending on the plant extract), respectively. Enumeration was carried out by plating 50 μl of the appropriate dilution on TSA supplemented with 0.1% sodium pyruvate (AppliChem, Lot 600104 67) (TSA/SP). The detection limit was set at 1.3 log CFU/ml. Petri dishes were incubated at 37 °C for 48 h.
All experiments were conducted in triplicate in two independent replicates.
Preparation of antimicrobial edible coatings
Edible coatings made of sodium alginate 1.5% w/v were prepared using water, hydro-distilled oregano extract and industrial oregano hydrolate. For the preparation of the coatings, appropriate quantity of the sodium alginate base was added to the extracts, previously heated at 50–60 °C, and stirred until its total dissolution. Coatings prepared of hydro-distilled oregano extract did not form the film matrix when immersed to CaCl2. Therefore, preparation of these coatings was performed either by mixing the extract with de-ionized sterile water in a ratio 1:1 (50% oregano), by using centrifuged oregano extract as the film forming material or by using their combination (i.e. centrifuged oregano extract diluted 1:1 in de-ionized sterile water; 50% centrifuged oregano). The ratio 1:1 was selected after several trials as the only proportion of sterile water and hydro-distilled oregano extract that enabled the formation of the coatings without minimizing the quantity of the oregano extract. Industrial oregano hydrolate was also diluted 1:1 in de-ionized water (50% industrial) in order to further compare their activity. Coatings prepared of de-ionized water were used as control. All coatings were supplemented with or without 0.2 or 0.5% v/v oregano essential oil (OEO). Incorporation of OEO into the extract alginate solutions was performed using an Ultra Turrax (5 min, 26,000 rpm) under aseptic conditions. In summary, the coatings used were the followings: de-ionized sterile water, de-ionized sterile water + OEO, 50% v/v oregano, 50% v/v oregano + OEO, centrifuged oregano, centrifuged oregano + OEO, 50% v/v centrifuged oregano, 50% v/v centrifuged + OEO, industrial oregano, industrial oregano + OEO, 50% v/v industrial oregano, 50% v/v industrial oregano + OEO.
Meat preparation and inoculation
Pork meat thigh was purchased from a local supermarket and transferred to the laboratory within 20 min. Pieces of 10 ± 0.2 g were aseptically cut and stored at 4 °C until their use. For their inoculation, 100 μl of the culture were gently spread on the entire upper surface of the sample and allowed to adhere for 15 min at 4 °C. The same process was carried out for the bottom surface of the samples, followed again by a fifteen-minute adhesion of the inoculum. The final cell concentration of Salmonella on the meat was approximately 106 CFU/g.
Εvaluation of oregano aqueous extracts antimicrobial activity against S. Typhimurium FS8 on pork meat
After their inoculation with S. Typhimurium FS8, pork meat samples were subjected to three types of antimicrobial treatments, all based on hydro-distilled oregano extract and industrial oregano hydrolate: (a) marination, (b) edible coatings, (c) combined marination and edible coatings.
Evaluation of marination antimicrobial activity against S. Typhimurium FS8 on pork meat
Hydro-distilled oregano extract, industrial oregano hydrolate and de-ionized sterile water (control) supplemented with or without 0.2% oregano essential oil were used as marinating solutions and tested for their antimicrobial activity against FS8 strain. Inoculated pork samples were immerged in 300 ml of each solution and marinated for 3 h at 25 °C (room temperature). Samples were, then, placed in capped petri dishes and stored at 4 °C for 4 days. Sampling was performed immediately after treatment and after 4 days of storage.
Evaluation of edible coatings antimicrobial activity against S. Typhimurium FS8 on pork meat
Sodium alginate (1.5% w/v) edible coatings of de-ionized sterile water, de-ionized sterile water + 0.5% OEO, 50% oregano, 50% oregano + 0.5% OEO, centrifuged oregano, centrifuged oregano + 0.5% OEO, 50% centrifuged oregano, 50% centrifuged + 0.5% OEO, industrial oregano, industrial oregano + 0.5% OEO, 50% industrial oregano, 50% industrial oregano + 0.5% OEO were prepared as described above. Inoculated pork samples were first immersed in the coating solution for 2 min, allowed to drain for 2–3 s and then dipped into calcium chloride (CaCl2) solution (2% w/v) for 3 min. Finally, they were placed in capped petri dishes and stored at 4 °C for 5 days. Sampling was performed immediately after coating and once per day for up to 5 days of storage.
Evaluation of combined marination and edible coatings antimicrobial activity against S. Typhimurium FS8 on pork meat
Inoculated pork meat samples were marinated with hydro-distilled oregano extract, industrial oregano hydrolate or de-ionized sterile water supplemented with or without 0.2% OEO as described above and then covered with sodium alginate (1.5% w/v) edible coatings made of de-ionized sterile water, de-ionized sterile water + 0.2% OEO, 50% oregano, 50% oregano + 0.2% OEO, industrial oregano, industrial oregano + 0.2% OEO, as described above. Samples were finally placed in capped petri dishes and stored at 4 °C for 4 days. Sampling was performed immediately after marination and on the 2nd and 4th day of storage.
In each of the above experiments, uninoculated untreated samples and inoculated untreated samples were used as controls. Experiments were performed in duplicate in three independent replicates.
Microbiological analysis
Microbiological analysis of pork samples was performed by homogenizing each sample (10 ± 0.2 g) with 90 ml ¼ Ringer solution in a stomacher apparatus (Seward, London, UK) for 60 s. Enumeration of surviving Salmonella populations was performed by plating 100 μl of the appropriate dilution in Xylose Lysine Decarboxylase (XLD; Lab M Limited, Lancashire, UK). Plates were incubated for 24 h at 37 °C.
pH measurement
Changes in the pH of pork samples were determined at the end of microbiological analysis by immersing the electrode of a digital pHmeter (pH 526, Metrohm Ltd, Switzerland) in the homogenized pork samples.
Composition of the aqueous extracts
The chemical composition of hydro-distilled aqueous extracts and industrial oregano hydrolate was determined by Ultra High Performance Liquid Chromatography Heated Electrospray Ionization—Tandem Mass Spectrometry (UPLC-HESI-MS/MS) and High Performance Liquid Chromatography coupled to Diode Array detector (HPLC–DAD), respectively, as described in details in supplementary data (see Supplementary Methods online).
Determination of inactivation parameters
Determination of the time needed for a 4-log reduction (t4D) was determined for the in vitro data at 4 °C by fitting the log transformed populations to Weibull model according to the equation logN/No = − (t/δ)p61, where No the populations at time to, N the population at time t, Nres the residual bacterial concentration log CFU/ml at the end of microbial inactivation, δ the time needed for the first decimal reduction and p a shape parameter corresponding to different concavities (downward concave survival for curves p > 1, upward concave survival curves for p < 1 or linear curves for p = 1). GinaFit, a freeware Add-ins for Microsoft®Excel62 was used for data fitting. In total, six curves per experimental case were fitted.
Statistical analysis
Analysis of Variance (SPSS 22.0 for Mac) was used for data analysis of the log transformed cell populations collected from the in vitro screening at 37 °C and the in situ treatments and for the t4D estimates of the in vitro screening at 4 °C. Means were compared using Tukey’s Honestly Significant Test (HSD). For pairwise comparisons, t-test (Microsoft Excel 16 for Mac) was used. Differences were considered significant at 95% level.
Data availability
All data generated or analyzed during this study are included in this published article (and its Supplementary Information files).
References
Davidson, P. M., Critzer, F. J. & Taylor, T. M. Naturally occurring antimicrobials for minimally processed foods. Ann. Rev. Food Sci. Technol. 4, 163–190 (2013).
Nazir, F. et al. Natural antimicrobials for food preservation. J. Pharmacogn. Phytochem. 6, 2078–2082 (2017).
Giannenas, I., Sidiropoulou, E., Bonos, E., Christaki, E. & Florou-Paneri, P. The history of herbs, medicinal and aromatic plants, and their extracts: past, current situation and future perspectives. In Feed Additives: Aromatic plants and herbs in animal nutrition and health (eds Florou-Paneri, P. et al.) 1–18 (Academic Press, 2020) https://doi.org/10.1017/CBO9781107415324.004.
Balasundram, N., Sundram, K. & Samman, S. Phenolic compounds in plants and agri-industrial by-products: Antioxidant activity, occurrence, and potential uses. Food Chem. 99, 191–203 (2006).
Chun, S.-S., Vattem, D. A., Lin, Y.-T. & Shetty, K. Phenolic antioxidants from clonal oregano (Origanum vulgare) with antimicrobial activity against Helicobacter pylori. Process Biochem. 40, 809–816 (2005).
Gyawali, R. & Ibrahim, S. A. Natural products as antimicrobial agents. Food Control 46, 412–429 (2014).
Poimenidou, S. V. et al. Effect of single or combined chemical and natural antimicrobial interventions on Escherichia coli O157:H7, total microbiota and color of packaged spinach and lettuce. Int. J. Food Microbiol. 220, 6–18 (2016).
Oreopoulou, V. & Tzia, C. Utilization of plant by-products for the recovery of proteins, dietary fibers, antioxidants, and colorants. In Utilization of By-Products and Treatments of Waste in the Food Industry (eds Oreopoulou, V. & Russ, W.) 209–232 (Springer Science and Business Media, 2007) https://doi.org/10.1007/978-0-387-35766-9.
Negi, P. S. Plant extracts for the control of bacterial growth: Efficacy, stability and safety issues for food application. Int. J. Food Microbiol. 156, 7–17 (2012).
Choulitoudi, E. et al. Antimicrobial and antioxidant activity of Satureja thymbra in gilthead seabream fillets edible coating. Food Bioprod. Process. 100, 570–577 (2016).
Shahamirian, M. et al. Incorporation of pomegranate rind powder extract and pomegranate juice into frozen burgers: Oxidative stability, sensorial and microbiological characteristics. J. Food Sci. Technol. 56, 1174–1183 (2019).
Hayrapetyan, H., Hazeleger, W. C. & Beumer, R. R. Inhibition of Listeria monocytogenes by pomegranate (Punica granatum) peel extract in meat paté at different temperatures. Food Control 23, 66–72 (2012).
EFSA-ECDC. The European Union summary report on trends and sources of zoonoses, zoonotic agents and food-borne outbreaks in 2017. EFSA J. 16, e05500 (2018).
Scallan, E. et al. Foodborne illness acquired in the United States-Major pathogens. Emerg. Infect. Dis. 17, 7–15 (2011).
Pui, C. F. et al. Salmonella: A foodborne pathogen. Int. Food Res. J. 18, 465–473 (2011).
Foley, S. L., Johnson, T. J., Ricke, S. C., Nayak, R. & Danzeisen, J. Salmonella pathogenicity and host adaptation in chicken-associated serovars. Microbiol. Mol. Biol. Rev. 77, 582–607 (2013).
Whiting, R. C. & Golden, M. H. Variation among Escherichia coli O157:H7 strains relative to their growth, survival, thermal inactivation, and toxin production in broth. Int. J. Food Microbiol. 75, 127–133 (2002).
Lianou, A. & Koutsoumanis, K. P. Strain variability of the behavior of foodborne bacterial pathogens: A review. Int. J. Food Microbiol. 167, 310–321 (2013).
Skandamis, P. N. & Nychas, G. E. Preservation of fresh meat with active and modified atmosphere packaging conditions. Int. J. Food Microbiol. 79, 35–45 (2002).
Zinoviadou, K. G., Koutsoumanis, K. P. & Biliaderis, C. G. Physico-chemical properties of whey protein isolate films containing oregano oil and their antimicrobial action against spoilage flora of fresh beef. Meat Sci. 82, 338–345 (2009).
Mith, H. et al. Antimicrobial activities of commercial essential oils and their components against food-borne pathogens and food spoilage bacteria. Food Sci. Nutr. 2, 403–416 (2014).
Restuccia, C. et al. Efficacy of different citrus essential oils to inhibit the growth and B1 aflatoxin biosynthesis of Aspergillus flavus. Environ. Sci. Pollut. Res. Int. 26, 31263–31272 (2019).
Aloui, H. & Khwaldia, K. Natural antimicrobial edible coatings for microbial safety and food quality enhancement. Compr. Rev. Food Sci. Food Saf. 15, 1080–1103 (2016).
Shan, B., Cai, Y.-Z., Brooks, J. D. & Corke, H. The in vitro antibacterial activity of dietary spice and medicinal herb extracts. Int. J. Food Microbiol. 117, 112–119 (2007).
Côté, J. et al. Antimicrobial effect of cranberry juice and extracts. Food Control 22, 1413–1418 (2011).
Gonelimali, F. D. et al. Antimicrobial properties and mechanism of action of some plant extracts against food pathogens and spoilage microorganisms. Front. Microbiol. 9, 1639 (2018).
Higginbotham, K. L., Burris, K. P., Zivanovic, S., Davidson, P. M. & Stewart, C. N. J. Antimicrobial activity of Hibiscus sabdariffa aqueous extracts against Escherichia coli O157:H7 and Staphylococcus aureus in a microbiological medium and milk of various fat concentrations. J. Food Prot. 77, 262–268 (2014).
Miceli, A. et al. Antibacterial activity of Borago officinalis and Brassica juncea aqueous extracts evaluated in vitro and in situ using different food model systems. Food Control 40, 157–164 (2014).
Mostafa, A. A. et al. Antimicrobial activity of some plant extracts against bacterial strains causing food poisoning diseases. Saudi J. Biol. Sci. 25, 361–366 (2018).
Liu, Y., Mckeever, L. C. & Malik, N. S. A. Assessment of the antimicrobial activity of olive leaf extract against foodborne bacterial pathogens. Front. Microbiol. 8, 113 (2017).
Bouarab-Chibane, L. et al. Effect of interactions of plant phenolics with bovine meat proteins on their antibacterial activity. Food Control 90, 189–198 (2018).
Mourtzinos, I. & Goula, A. Polyphenols in agricultural byproducts and food waste. In Polyphenols in Plants (ed. Watson, R. R.) 23–44 (Academic Press, 2019) https://doi.org/10.1016/B978-0-12-813768-0.00002-5.
Christaki, S., Moschakis, T., Kyriakoudi, A., Biliaderis, C. G. & Mourtzinos, I. Recent advances in plant essential oils and extracts: Delivery systems and potential uses as preservatives and antioxidants in cheese. Trends Food Sci. Technol. 116, 264–278 (2021).
Burt, S. Essential oils: Their antibacterial properties and potential applications in foods—A review. Int. J. Food Microbiol. 94, 223–253 (2004).
Aćimović, M. et al. Hydrolates: By-products of essential oil distillation: Chemical composition, biological activity and potential uses. Adv. Technol. 9, 54–70 (2020).
Rajeswara Rao, B. R. Hydrosols and water-soluble essential oils of aromatic plants: Future economic products. Indian Perfum. 56, 29–33 (2012).
Stojković, D. et al. In situ antioxidant and antimicrobial activities of naturally occurring caffeic acid, p-coumaric acid and rutin, using food systems. J. Sci. Food Agric. 93, 3205–3208 (2013).
Moreno, S., Scheyer, T., Romano, C. S. & Vojnow, A. A. Antioxidant and antimicrobial activities of rosemary extracts linked to their polyphenol composition. Free Radic. Res. 40, 223–231 (2006).
De Souza, G. T. et al. Effects of the essential oil from Origanum vulgare L. on survival of pathogenic bacteria and starter lactic acid bacteria in semihard cheese broth and slurry. J. Food Prot. 79, 246–252 (2016).
Iturriaga, L., Olabarrieta, I. & de Marañón, I. M. Antimicrobial assays of natural extracts and their inhibitory effect against Listeria innocua and fish spoilage bacteria, after incorporation into biopolymer edible films. Int. J. Food Microbiol. 158, 58–64 (2012).
Tepe, B., Daferera, D., Sökmen, M., Polissiou, M. & Sökmen, A. In vitro antimicrobial and antioxidant activities of the essential oils and various extracts of Thymus eigii M. Zohary et P.H. Davis. J. Agric. Food Chem. 52, 1132–1137 (2004).
Lianou, A. & Koutsoumanis, K. P. Evaluation of the strain variability of Salmonella enterica acid and heat resistance. Food Microbiol. 34, 259–267 (2013).
Jørgensen, F. et al. Invasiveness in chickens, stress resistance and RpoS status of wild-type Salmonella enterica subsp. enterica serovar Typhimurium definitive type 104 and serovar Enteritidis phage type 4 strains. Microbiology 146, 3227–3235 (2000).
Gavriil, A. et al. Prior exposure to different combinations of pH and undissociated acetic acid can affect the induced resistance of Salmonella spp. strains in mayonnaise stored under refrigeration and the regulation of acid-resistance related genes. Food Microbiol. 95, 103680 (2020).
Melo, J., Schrama, D., Andrew, P. W. & Faleiro, M. L. Proteomic analysis shows that individual Listeria monocytogenes strains use different strategies in response to gastric stress. Foodborne Pathog. Dis. 10, 107–119 (2013).
Bouarab-Chibane, L., Degraeve, P., Ferhout, H., Bouajila, J. & Oulahal, N. Plant antimicrobial polyphenols as potential natural food preservatives. J. Sci. Food Agric. 99, 1457–1474 (2019).
Rodríguez Vaquero, M. J., Aredes Fernández, P. A., Manca De Nadra, M. C. & Strasser De Saad, A. M. Phenolic compound combinations on Escherichia coli viability in a meat system. J. Agric. Food Chem. 58, 6048–6052 (2010).
Careaga, M. et al. Antibacterial activity of Capsicum extract against Salmonella typhimurium and Pseudomonas aeruginosa inoculated in raw beef meat. Int. J. Food Microbiol. 83, 331–335 (2003).
Piskernik, S., Klančnik, A., Riedel, C. T., Brøndsted, L. & Možina, S. S. Reduction of Campylobacter jejuni by natural antimicrobials in chicken meat-related conditions. Food Control 22, 718–724 (2011).
Weiss, J., Loeffler, M. & Terjung, N. The antimicrobial paradox: Why preservatives loose activity in foods. Curr. Opin. Food Sci. 4, 69–75 (2015).
Del Campo, J., Amiot, M.-J. & Nguyen-The, C. Antimicrobial effect of rosemary extracts. J. Food Prot. 63, 1359–1368 (2000).
da Cruz Cabral, L., Pinto, V. F. & Patriarca, A. Application of plant derived compounds to control fungal spoilage and mycotoxin production in foods. Int. J. Food Microbiol. 166, 1–14 (2013).
Gómez-Estaca, J., Bravo, L., Gómez-Guillén, M. C., Alemán, A. & Montero, P. Antioxidant properties of tuna-skin and bovine-hide gelatin films induced by the addition of oregano and rosemary extracts. Food Chem. 112, 18–25 (2009).
Plazinski, W. & Plazinska, A. Molecular dynamics study of the interactions between phenolic compounds and alginate/alginic acid chains. New J. Chem. 35, 1607–1614 (2011).
Vodnar, D. C. Inhibition of Listeria monocytogenes ATCC 19115 on ham steak by tea bioactive compounds incorporated into chitosan-coated plastic films. Chem. Cent. J. 6, 6–74 (2012).
Chen, C. H., Ravishankar, S., Marchello, J. & Friedman, M. Antimicrobial activity of plant compounds against Salmonella Typhimurium DT104 in ground pork and the influence of heat and storage on the antimicrobial activity. J. Food Prot. 76, 1264–1269 (2013).
Kim, K. Y., Davidson, P. M. & Chung, H. J. Antibacterial activity in extracts of Camellia japonica L. petals and its application to a model food system. J. Food Prot. 64, 1255–1260 (2001).
Ribeiro-Santos, R., Andrade, M., de Melo, N. R. & Sanches-Silva, A. Use of essential oils in active food packaging: Recent advances and future trends. Trends Food Sci. Technol. 61, 132–140 (2017).
Gutierrez, J., Barry-Ryan, C. & Bourke, P. The antimicrobial efficacy of plant essential oil combinations and interactions with food ingredients. Int. J. Food Microbiol. 124, 91–97 (2008).
Gardeli, C., Papageorgiou, V., Mallouchos, A., Kibouris, T. & Komaitis, M. Essential oil composition of Pistacia lentiscus L. and Myrtus communis L.: Evaluation of antioxidant capacity of methanolic extracts. Food Chem. 107, 1120–1130 (2008).
Mafart, P., Couvert, O., Gaillard, S. & Leguerinel, I. On calculating sterility in thermal preservation methods: Application of the Weibull frequency distribution model. Int. J. Food Microbiol. 72, 107–113 (2002).
Geeraerd, A. H., Valdramidis, V. P. & Van Impe, J. F. GInaFiT, a freeware tool to assess non-log-linear microbial survivor curves. Int. J. Food Microbiol. 102, 95–105 (2005).
Acknowledgements
The authors would like to acknowledge the Greek industry “Olympus” for their collaboration and eagerness to participate to the current study.
Author information
Authors and Affiliations
Contributions
A.G., E.Z. and P.N.S. conceived and designed the study. A.G., E.Z., A.E.P., D.S. performed the microbiological experiments and K.M.K. the chemical analysis of the extracts. A.G. and K.M.K. analyzed the data. S.A.H. and C.G. provided the equipment required for the hydro-distillation of the extracts. S.A.H. provided the equipment required for the freeze-drying of the extracts and the HPLC analysis of the industrial oregano hydrolate. A.G., E.Z., K.M.K., I.G. and P.N.S. wrote the manuscript. Finally, all authors reviewed and approved the manuscript for submission.
Corresponding author
Ethics declarations
Competing interests
The authors declare no competing interests.
Additional information
Publisher's note
Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.
Supplementary Information
Rights and permissions
Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article's Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article's Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/.
About this article
Cite this article
Gavriil, A., Zilelidou, E., Papadopoulos, AE. et al. Evaluation of antimicrobial activities of plant aqueous extracts against Salmonella Typhimurium and their application to improve safety of pork meat. Sci Rep 11, 21971 (2021). https://doi.org/10.1038/s41598-021-01251-0
Received:
Accepted:
Published:
DOI: https://doi.org/10.1038/s41598-021-01251-0
- Springer Nature Limited