Abstract
This paper presents an experimental investigation wherein two different composites are compared based on their strengthening effectiveness. The composites selected here for comparison are ferrocement and two variants of fibre-reinforced polymer (FRP), namely carbon FRP (CFRP) and glass FRP (GFRP). The performances of these three composites were compared in strengthening reinforced concrete exterior beam-column joints under reversed cyclic loading. Initially, the selected composites were made equivalent in terms of their tensile strength to make the comparative study on a level playing field. Seven beam-column joint specimens were subjected to different levels of distress and were strengthened using equivalent laminates of these composites. The rehabilitated joints were tested up to failure and compared their behaviour in terms of load–deflection relationships, failure modes, displacement ductility, energy dissipation capacity, and stiffness degradation. The experimental results indicate that ferrocement performs superior to GFRP and moderately similar to CFRP in improving the load-carrying capacity. The results obtained were in good agreement with the theoretical predictions based on ACI codes. A cost analysis done on these strengthening schemes shows that ferrocement can effectively be an economical alternative to FRPs in strengthening beam-column joints.
Similar content being viewed by others
References
ACI 318-19 (2019) Building code requirements for structural concrete. American Concrete Institute, Farmington Hills
ACI 352R-02 (2002) Recommendations for design of beam–column joints in monolithic reinforced concrete structures. American Concrete Institute, Farmington Hills
ACI 440.2R-17 (2017) Guide for the design and construction of externally bonded FRP systems for strengthening concrete structures. American Concrete Institute, Farmington Hills
ACI 549.1R-18 (2018) Design guide for ferrocement. American Concrete Institute, Farmington Hills
Akın E, Canbay E, Binici B, Ozcebe G (2011) Testing and analysis of infilled reinforced concrete frames strengthened with CFRP reinforcement. J Reinf Plastics Compos 30(19):1605–1620. https://doi.org/10.1177/0731684411424631
Allam K, Mosallam AS, Salama MA (2019) Experimental evaluation of seismic performance of interior RC beam-column joints strengthened with FRP composites. Eng Struct 196:109308. https://doi.org/10.1016/j.engstruct.2019.109308
Al-Salloum YA, Siddiqui NA, Elsanadedy HM, Abadel AA, Aqel MA (2011) Textile-reinforced mortar versus FRP as strengthening material for seismically deficient RC beam-column joints. J Compos Constr 15(6):920–933. https://doi.org/10.1061/(ASCE)CC.1943-5614.0000222
Antonopoulos CP, Triantafillou TC (2003) Experimental investigation of FRP strengthened RC beam–column joints. J Compos Constr 7(2):39–49. https://doi.org/10.1061/(ASCE)1090-0268(2003)7:1(39)
Araby MZ, Rizal S, Abdullah AM, Hasan M (2022) Deformation capacity of RC beam-column joints strengthened with ferrocement. Sustainability 14:4398. https://doi.org/10.3390/su14084398
ASTM (2017a) Standard test method for tensile properties of polymer matrix composite materials (D3039/D3039M-17). ASTM International, West Conshohocken
ASTM (2017b) Standard test method for determining tensile properties of fiber reinforced polymer matrix composites used for strengthening of civil structures (D7565/D7565M-10). ASTM International, West Conshohocken
Attari N, Youcef YS, Amziane S (2019) Seismic performance of reinforced concrete beam–column joint strengthening by FRP sheets. Struct 20(12):353–364. https://doi.org/10.1016/j.istruc.2019.04.007
Azarm R, Maheri MR, Torabi A (2017) Retrofitting RC joints using flange-bonded FRP sheets. Iran J Sci Technol Trans Civ Eng 41:27–35. https://doi.org/10.1007/s40996-016-0028-x
Bansal PP, Kumar M, Dar MA (2016) Retrofitting of exterior RC beam-column joints using ferrocement jackets. Earthq Struct 10(2):313–328. https://doi.org/10.12989/eas.2016.10.2.313
Banu WB, Jaya KP, Vidjeapriya R (2022) Seismic behaviour of exterior beam-column joint using steel fibre-reinforced concrete under reverse cyclic loading. Arab J Sci Eng. https://doi.org/10.1007/s13369-022-07139-z
Beiraghi H, Kheyroddi A, Nafechi F (2022) Behavior of reinforced concrete frames retroftted by diferent confgurations of concentric steel braces. Iran J Sci Technol Trans Civ Eng 46:2039–2052. https://doi.org/10.1007/s40996-021-00799-1
Beydokhty EZ, Shariatmadar H (2016) Behavior of damaged exterior RC beam-column joints strengthened by CFRP composites. Lat Am J Solids Struct 13(5):880–896. https://doi.org/10.1590/1679-78252258
Bindurani P, Ganesan N, Indira PV (2021) Tensile properties of FRP and ferrocement—a comparative study. In: Singh RM, Sudheer KP, Kurian B (eds) Adv Civ Eng Lec Note Civ Eng. Springer, Singapore, pp 391–405. https://doi.org/10.1007/978-981-15-5644-9_29
Bolognini D, Pampanin S, Magenes G, Calvi G, Pavese A (2004) Multi-level seismic rehabilitation of existing frame systems and subassemblies using FRP composites. In: FRP composites in civil engineering—CICE 2004, pp 659–669. https://doi.org/10.1201/9780203970850.ch74
Bousselham A (2010) State of research on seismic retrofit of RC beam-column joints with externally bonded FRP. J Compos Constr 14(1):49–61. https://doi.org/10.1061/(ASCE)CC.1943-5614.0000049
CFR Membrane 230 (2017) Unidirectional carbon fibre reinforcement membranes for structural strengthening. Cera-Chem Private Limited, Chennai, India. www.cerachemindia.com
Cho J, Kim N, Cho N, Choun Y (2004) Stress–strain relationship of reinforced concrete subjected to biaxial tension. ACI Struct J 101(2):202–208. https://doi.org/10.14359/13017
Dalalbashi A, Eslami A, Ronagh HR (2013) Numerical investigation on the hysteretic behavior of RC joints retrofitted with different CFRP configurations. J Compos Constr 17(3):371–382. https://doi.org/10.1061/(ASCE)CC.1943-5614.0000361
Ebanesar A, Gladston H, Farsangi EN, Sharma SV (2022) Strengthening of RC beam-column joints using steel plate with shear connectors: experimental investigation. Structures 35:1138–1150. https://doi.org/10.1016/j.istruc.2021.08.042
Esmaeeli E, Danesh F, Tee KF, Eshghi S (2017) A combination of GFRP sheets and steel cage for seismic strengthening of shear-deficient corner RC beam-column joints. Compos Struct 159:206–219. https://doi.org/10.1016/j.compstruct.2016.09.064
EW200 (200±20gsm) (n.d.) E-Glass fiberglass cloth/fabric/ woven roving. https://chinageomembrane.en.made-in-china.com/product/sXyJhQwrrIYF/China-E-Glass-Fiberglass-Cloth-Fabric-Woven-Roving.html. Accessed 06 May 2020
Fakharifar M, Sharbatdar MK, Lin Z, Dalvand A, Sivandi-Pour A, Chen G (2014) Seismic performance and global ductility of RC frames rehabilitated with retrofitted joints by CFRP laminates. Earthq Eng Eng Vib 13(1):59–73. https://doi.org/10.1007/s11803-014-0212-6
Faleschini F, Gonzalez-Libreros J, Zanini MA, Hofer L, Sneed L, Pellegrino C (2019) Repair of severely-damaged RC exterior beam-column joints with FRP and FRCM composites. Compos Struct 207:352–363. https://doi.org/10.1016/j.compstruct.2018.09.059
Fayaz Q, Kaur G, Bansal PP (2022) Numerical modelling of seismic behaviour of an exterior RC beam column joint strengthened with UHPFRC and CFRP. Arab J Sci Eng 47:4971–4986. https://doi.org/10.1007/s13369-021-06334-8
Ganesan N, Indira PV, Thadathil SP (2010) Hysteretic behaviour of RC frames retrofitted at two different levels of distress using ferrocement wrapping technique. Int J Earth Sci Eng 3:100–107
Ganesan N, Indira PV, Sabeena MV (2014) Behaviour of hybrid fibre reinforced concrete beam-column joints under reverse cyclic loads. Mater Des 54:686–693. https://doi.org/10.1016/j.matdes.2013.08.076
Ganesan N, Nidhi M, Indira PV (2017) HFRHPC interior beam-column-joints with slab under reverse cyclic loading. Ind Concr J 91:17–25
Ghobarah A, Said A (2002) Shear strengthening of beam-column joints. Eng Struct 24(7):881–888. https://doi.org/10.1016/S0141-0296(02)00026-3
Hadi MNS, Tran TM (2014) Retrofitting nonseismically detailed exterior beam-column joints using concrete covers together with CFRP jacket. Constr Build Mater 63:161–173. https://doi.org/10.1016/j.conbuildmat.2014.04.019
Hung C, Hsiao H, Shao Y, Yen C (2023) A comparative study on the seismic performance of RC beam-column joints retrofitted by ECC, FRP, and concrete jacketing methods. J Build Eng 64:105691. https://doi.org/10.1016/j.jobe.2022.105691
ICRI 310.2R (2013) Selecting and specifying concrete surface preparation for sealers, coatings, and polymer overlays, and concrete repair. International Concrete Repair Institute, Rosemont
IS 383 (2016) Coarse and fine aggregate for concrete—specification. Bureau of Indian Standards, New Delhi
IS 456 (2000) Plain and reinforced concrete—code of practice. Bureau of Indian Standards, New Delhi
IS 10262 (2019) Concrete mix proportioning-guidelines. Bureau of Indian Standards, New Delhi
Jiuru T, Chaobin H, Kaijian Y, Yongchen Y (1992) Seismic behaviour and shear strength of framed joint using steel fiber reinforced concrete. J Struct Eng 118(2):341–357
Kantarcı F, Maras MM (2022) Formulation of a novel nano TiO2-modified geopolymer grout for application in damaged beam-column joints. Constr Build Mater 317:125929. https://doi.org/10.1016/j.conbuildmat.2021.125929
Karayannis CG, Sirkelis GM (2008) Strengthening and rehabilitation of RC beam–column joints using carbon-FRP jacketing and epoxy resin injection. Earthq Eng Struct Dyn 37(5):769–790. https://doi.org/10.1002/eqe.785
Le-Trung K, Lee K, Shin M, Lee J (2011) Analytical assessment and modeling of RC beam-column connections strengthened with CFRP composites. Compos Part B Eng 42(7):1786–1798. https://doi.org/10.1016/j.compositesb.2011.07.002
Li B, Kai Q (2011) Seismic behavior of reinforced concrete interior beam-wide column joints repaired using FRP. J Compos Constr 15(3):327–338. https://doi.org/10.1061/(ASCE)CC.1943-5614.0000163
Li B, Lam ES, Wu B, Wang Y (2013) Experimental investigation on reinforced concrete interior beam-column joints rehabilitated by ferrocement jackets. Eng Struct 56:897–909. https://doi.org/10.1016/j.engstruct.2013.05.038
Li B, Lam ES, Wu B, Wang Y (2015) Effect of high axial load on seismic behavior of reinforced concrete beam-column joints with and without strengthening. ACI Struct J 112(6):713–724. https://doi.org/10.14359/51687938
Ma C, Wang D, Wang Z (2017) Seismic retrofitting of full-scale RC interior beam-column-slab subassemblies with CFRP wraps. Compos Struct 159:397–399. https://doi.org/10.1016/j.compstruct.2016.09.094
Maheri MR, Yasdani S (2016) Seismic performance of different types of connections between steel bracing and RC frames. Iran J Sci Technol Trans Civ Eng 40:287–296. https://doi.org/10.1007/s40996-016-0034-z
Maras MM, Kantarcı F (2021) Structural performance of reinforced concrete (RC) moment frame connections strengthened using FRP composite jackets. Arab J Sci Eng 46:10975–10992. https://doi.org/10.1007/s13369-021-06120-6
Marthong C (2019a) Rehabilitation and strengthening of exterior RC beam-column connections using epoxy resin injection and FRP sheet wrapping: experimental study. Struct Eng Mech 72(6):723–736. https://doi.org/10.12989/sem.2019.72.6.723
Marthong C (2019b) Behavior of repaired RAC beam-column joints using steel welded wire mesh jacketed with cement mortar. Adv Concr Constr 8(2):91–100. https://doi.org/10.12989/acc.2019.8.2.091
Mimura Y, Yoshitake I, Zhang W (2011) Uniaxial tension test of slender reinforced early age concrete members. Mater 4:1345–1359. https://doi.org/10.3390/ma4081345
Obaidat YT, Abu-Farsakh GAFR, Ashteyat AM (2019) Retrofitting of partially damaged reinforced concrete beam-column joints using various plate-configurations of CFRP under cyclic loading. Constr Build Mater 198:313–322. https://doi.org/10.1016/j.conbuildmat.2018.11.267
Ong C, Chin C, Ma C, Tan J, Awang AZ, Omar W (2022) Seismic retrofit of reinforced concrete beam-column joints using various confinement techniques: a review. Struct 42:221–243. https://doi.org/10.1016/j.istruc.2022.05.114
Parsa E, Sharbatdar MK, Kheyroddin A (2019) Investigation of the flexural behavior of RC frames strengthened with HPFRCC subjected to lateral loads. Iran J Sci Technol Trans Civ Eng 43:231–240. https://doi.org/10.1007/s40996-018-0133-0
Parvin A, Altay S, Yalcin C, Kaya O (2010) CFRP rehabilitation of concrete frame joints with inadequate shear and anchorage details. J Compos Constr 14(1):72–82. https://doi.org/10.1061/(ASCE)CC.1943-5614.0000055
Paulay T, Priestly MJN (1992) Seismic design of reinforced concrete and masonry buildings. Wiley, New York
Pohoryles DA, Melo J, Rossetto T, D’Ayala D, Varum H (2018) Experimental comparison of novel CFRP retrofit schemes for realistic full-scale RC beam–column joints. J Compos Constr 22(5):04018027
Pohoryles DA, Melo J, Rossetto T, Varum H, Bisby LA (2019) Seismic retrofit schemes with FRP for deficient RC beam-column joints: state-of-the-art review. J Compos Constr 23(4):03119001
Primer EP18 (2013) High performance epoxy primer for fiber wrapping. Cera-Chem Private Limited, Chennai, India. www.cerachemindia.com
Primer EPS (2013) High performance epoxy saturant for fiber wrapping. Cera-Chem Private Limited, Chennai, India. www.cerachemindia.com
Realfonzo R, Napoli A, Pinilla JGR (2014) Cyclic behavior of RC beam-column joints strengthened with FRP systems. Constr Build Mater 54:282–297. https://doi.org/10.1016/j.conbuildmat.2013.12.043
Sathish KV (2019) Strength and behaviour of hybrid fibre reinforced ternary blend geopolymer concrete structural elements. Dissertation, National Institute of Technology Calicut
Saghafi MH, Golafshar A (2022) Seismic retrofit of deficient 3D RC beam–column joints using FRP and steel PT rods. Mater Struct 55:210. https://doi.org/10.1617/s11527-022-02046-z
Sezen H (2012) Repair and strengthening of reinforced concrete beam-column joints with fiber-reinforced polymer composites. J Compos Constr 16(5):499–506. https://doi.org/10.1061/(ASCE)CC.1943-5614.0000290
Shaaban IG, Seoud OA (2018) Experimental behavior of full-scale exterior beam-column space joints retrofitted by ferrocement layers under cyclic loading. Case Stud Constr Mater 8:61–78. https://doi.org/10.1016/j.cscm.2017.11.002
Shahbazpanahi S, Hejazi F, Rahimipour A, Paknahad M (2019) Experimental and numerical model of interior reinforced concrete beam–column joints strengthened with carbon fiber-reinforced polymer sheets. Iran J Sci Technol Trans Civ Eng 43:405–417. https://doi.org/10.1007/s40996-018-0198-9
Shen D, Li M, Kang J, Liu C, Li C (2021) Experimental studies on the seismic behavior of reinforced concrete beam-column joints strengthened with basalt fiber-reinforced polymer sheets. Constr Build Mater 287:122901. https://doi.org/10.1016/j.conbuildmat.2021.122901
Sheela S, Anu Geetha B (2012) Studies on the performance of RC beam–column joints strengthened using different composite materials. J Inst Eng Ser A 93(1):63–71. https://doi.org/10.1007/s40030-012-0008-5
Shin SW, Ghosh SK, Moreno J (1989) Flexural ductility of ultra-high strength concrete members. ACI Struct J 86(4):394–400
Singh V, Bansal PP, Kumar M, Kaushik SK (2014) Experimental studies on strength and ductility of CFRP jacketed reinforced concrete beam-column joints. Constr Build Mater 55:194–201. https://doi.org/10.1016/j.conbuildmat.2014.01.047
Tahir MF (2016) Response of seismically detailed beam column joints repaired with CFRP under cyclic loading. Arab J Sci Eng 41:1355–1362. https://doi.org/10.1007/s13369-015-1943-z
Tayeh BA, Bakar BHA, Johari MAM, Voo YL (2013) Utilization of ultra-high performance fibre concrete (UHPFC) for rehabilitation a review. Proc Eng 54:525–538. https://doi.org/10.1016/j.proeng.2013.03.048
Torabi A, Maheri MR (2017) Seismic repair and retrofit of RC beam–column joints using stiffened steel plates. Iran J Sci Technol Trans Civ Eng 41:13–26. https://doi.org/10.1007/s40996-016-0027-y
Tsonos AG (1999) Lateral load response of strengthened reinforced concrete beam to column joint. ACI Struct J 96:46–56
Tsonos AG (2008) Effectiveness of CFRP-jackets and RC-jackets in post-earthquake and pre-earthquake retrofitting of beam–column subassemblages. Eng Struct 30(3):777–793. https://doi.org/10.1016/j.engstruct.2007.05.008
Wang B, Wu X, Liu Q, Wu Y, Huang F, Xu L, Wu X, Deng Y (2022) Effectiveness and efficiency of externally bonded CFRP sheets for shear strengthening of RC beam-column joints. Polymers 14:1347. https://doi.org/10.3390/polym14071347
Zanganeh E, Esfandiari J (2022) Experimental investigation on retroftted RC moment-resisting frames using NSD yielding dampers. Iran J Sci Technol Trans Civ Eng 46:2989–3000. https://doi.org/10.1007/s40996-021-00773-x
Zhang J, Pei Z, Rong X (2022) Experimental seismic study of an innovative precast steel-concrete composite beam-column joint. Soil Dyn Earthq Eng 161:107420. https://doi.org/10.1016/j.soildyn.2022.107420
Acknowledgements
The authors would like to acknowledge the National Institute of Technology Calicut, Kerala, for extending the facilities for the successful completion of this project.
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
The authors declare that there is no conflict of interest regarding the publication of this article.
Ethical approval
The authors received no financial support for the research, authorship, and/or publication of this article.
Rights and permissions
Springer Nature or its licensor (e.g. a society or other partner) holds exclusive rights to this article under a publishing agreement with the author(s) or other rightsholder(s); author self-archiving of the accepted manuscript version of this article is solely governed by the terms of such publishing agreement and applicable law.
About this article
Cite this article
Bindurani, P., Ganesan, N. & Indira, P.V. Strengthening of Exterior RC Moment-Resisting Beam-Column Connections Using Fibre-Reinforced Polymers and Ferrocement. Iran J Sci Technol Trans Civ Eng 47, 2775–2797 (2023). https://doi.org/10.1007/s40996-023-01078-x
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s40996-023-01078-x