Abstract
Evolution of automotive air conditioning was a remarkable milestone in the history of mankind. It has played an important role in human comfort and to some extent in human safety during vehicle driving in varied atmospheric conditions. This research focuses on providing comfort conditioning of a tractor cab which is a key factor in ensuring optimum working performance of the driver. A closed tractor cab acts like a greenhouse and its interior could become unbearable and sometimes even dangerous. Conventionally, vapor-compression refrigeration systems are standard for air conditioning in automobiles and account for up to 25 % of fuel consumption in the cooling season. Apart from conventional vapor-compression technology, this paper explores applicability of evaporative cooling in comfort conditioning of a tractor cabin which is an economical and eco-friendly alternative. The prototype performance lowered cabin temperature close to acceptable limit with less than 10 % of energy consumption compared to vapor-compression units when tested under similar hot-dry conditions.
Similar content being viewed by others
Abbreviations
- A :
-
Area (m2)
- h o :
-
Specific enthalpy of air in the cabin at steady state (kJ/kg)
- h o′ :
-
Specific enthalpy of air at fan exit (kJ/kg)
- M air :
-
Mass flow rate of air (kg/s)
- M w :
-
Water consumption rate (kg/h)
- RH:
-
Relative humidity
- Tidbt :
-
Inlet air dry-bulb temperature (ambient)
- To′dbt :
-
Dry-bulb temperature of air at fan exit
- V air :
-
Volume flow rate of air (m3/s)
- v :
-
Velocity of air (m/s)
- w i :
-
Humidity ratio of inlet air (kg moisture/kg dry air)
- w o :
-
Humidity ratio of air at fan exit (kg moisture/kg dry air)
- µ :
-
Effectiveness
- ρ :
-
Density of air (kg/m3)
References
Daly S (2006) Automotive air-conditioning and climate control systems, Chapter 1 and 2. Elsevier, Chennai
Bhatti MS (1999) Riding in comfort, part 2: evolution of automotive air conditioning. ASHRAE J 41(9):44–52
Foster R, Bom GJ, Dijkstra E, Tummers M (1999) Evaporative air-conditioning, World Bank Technical Paper No. 421, Energy Series, March 1999
Middlebrook AM, Tolbert MA (2000) Stratospheric ozone depletion, Chapter 4 and 5. University Science Books, Sausalito
Shindell D, Faluvegi G (2010) The net climate impact of coal-fired power plant emissions. Atmos Chem Phys 10:3247–3260
http://www.nrdc.org/air/pollution-standards/. Accessed 31 July 2015
Goetzler W, Zogg R, Young J, Johnson C (2014), Energy savings potential and RD&D opportunities for non-vapor-compression HVAC technologies. Technical Report, U.S. Department of Energy, March 2014. http://www.osti.gov. Accessed 13 Nov 2014
ASHRAE Handbook (2007)
Pesaran AA, Parent YO, Bharathan D (1992) Non-CFC air conditioning for transit buses. Technical report, NREL, Colorado, USA
http://www.nrel.gov/docs/fy11osti/46524.pdf. Accessed 31 July 2015
Ružić D, Časnji F (2011) Agricultural tractor cab characteristics relevant for microclimatic conditions. J Appl Eng Sci 2(9):323–330
http://www.sanden.com. Accessed 8 Jan 2015
Ružić D, Časnji F (2012). Thermal interaction between a human body and a vehicle cabin, Chapter 11. In: Kazi SN (ed) Heat transfer phenomena and applications. Croatia, Intech. ISBN: 978-953-51-0815-3
ANSI/ASHRAE Standard 55-2004, Thermal environmental conditions for human occupancy, ASHRAE Inc.
http://climate.nasa.gov/evidence/. Accessed 31 July 2015
http://www.weatheronline.in. Accessed 13 Dec 2014
ANSI/ASHRAE Standard 133-2008
http://www.powerstream.com/battery-isolator.htm. Accessed 4 Feb 2015
http://www.agrievolution.com/EconomicReports/. Accessed 4 March 2015
http://www.daytonashrae.org/psychrometrics_si.html. Accessed 22 April 2015
Author information
Authors and Affiliations
Corresponding author
Additional information
Technical Editor: Jose A. dos Reis Parise.
Appendix 1
Appendix 1
1. Air flow rate
2. Air mass flow rate
3. The effectiveness of the cooling system can be estimated as follows (as per data in Fig. 5):
4. Cooling load of the cabin (as per data in Fig. 5) [20]
5. Water consumption (as per data in Fig. 5) [20]
Rights and permissions
About this article
Cite this article
Kushwaha, S.K., Tiwari, A.C. Evaporative cooling comfort in agricultural tractor cabin. J Braz. Soc. Mech. Sci. Eng. 38, 965–976 (2016). https://doi.org/10.1007/s40430-015-0442-1
Received:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s40430-015-0442-1