Abstract
This work proposes a sludge purging procedure from upflow anaerobic sludge blanket reactors in small wastewater treatment plants. The following characteristics of the anaerobic sludge supported its development: specific methanogenic activity, biodegradability and dewaterability. The sludge samples from the reactor blanket zone presented low specific methanogenic activity, low biodegradability and good dewaterability. On the other hand, sludge samples from its bed zone showed higher biodegradability and specific methanogenic activity, as well as equivalent dewaterability and excellent sedimentability. These characteristics indicate that the common practice of sludge purging from the bed zone is a mistake and must be avoided. Nevertheless, the sludge blanket usually presents high water contents (total solids < 3%), which can overload hydraulically the drying beds. To prevent this problem, the sludge purge from the blanket zone should be fractionated into three discharges of lower volume during the first 3 days of the dewatering cycle.
This is a preview of subscription content, log in via an institution to check access.
Similar content being viewed by others
References
ABNT (2011) NBR 12209—sewage treatment plants design—procedure. Brazilian National Standards Organization, Rio de Janeiro, Brazil (in Portuguese)
Aisse MM et al (1999) Sewage treatment by anaerobic processes and controlled disposal in the soil. Cap. 11. FINEP/PROSAB. Rio de Janeiro, Brazil, ISBN 85-7022-137-1 (in Portuguese)
Al-Nozaily FA, Taher TM, Al-Rawi MHM (2013) Evaluation of the sludge drying beds at Sana’a wastewater treatment plant. In: Electronic proceedings 17th international water technology conference. http://iwtc.info/wp-content/uploads/2013/11/99.pdf. Accessed 20 Sep 2017
APHA (2012) Standard methods for the examination of water and wastewater. APHA, Washington, DC
Bastos et al (2007) The sludge management in a UASB + BF system. Revista AIDIS. vol 1, no 2. http://www.revistas.unam.mx/index.php/aidis/article/view/14379. Accessed 10 May 2018
Batstone DJ et al (2002) IWA task group on modelling of anaerobic digestion processes. Anaerobic digestion model no. 1 (ADM1). IWA Publishing, London
Bhunia P, Ghangrekar MM (2007) Required minimum granule size in UASB reactor and characteristics variation with size. Bioresour Technol 99(78):2132–2140
Cavalcanti PFF (2003) Integrated application of the UASB reactor and ponds for domestic sewage treatment in tropical regions. PhD Thesis, Wageningen University Wageningen, The Netherlands
Chen C et al (2017) Evaluation of an up-flow anaerobic sludge bed (UASB) reactor containing diatomite and maifanite for the improved treatment of petroleum wastewater. Bioresour Technol 243:620–627. https://doi.org/10.1016/j.biortech.2017.06.171
Chong C et al (2012) The performance enhancements of upflow anaerobic sludge blanket (UASB) reactors for domestic sludge treatment—a state-of-the-art review. Water Res 46(11):3434–3470. https://doi.org/10.1016/j.watres.2012.03.066
Haandel AC, Lettinga G (1994) Anaerobic sewage treatment: a practical guide for regions with a hot climate. Wiley, Michigan
Khan AA et al (2011) Sustainable options of post treatment of UASB effluent treating sewage: a review. Resourc Conserv Recycl 55(12):1232–1251. https://doi.org/10.1016/j.resconrec.2011.05.017
Khan AA, Mehrotra I, Kazmi AA (2015) Sludge profiling at varied organic loadings and performance evaluation of UASB reactor treating sewage. Biosyst Eng 131:32–40. https://doi.org/10.1016/j.biosystemseng.2014.12.011
Leitão RC et al (2009) The effect of operational conditions on the hydrodynamic characteristics of the sludge bed in UASB reactors. Water Sci Technol 64(9):1935–1941. https://doi.org/10.2166/wst.2011.628
Leitão RC et al (2011) The effect of operational conditions on the sludge specific methanogenic activity and sludge biodegradability. Water Sci Technol 59(9):1847–1853. https://doi.org/10.2166/wst.2009.188
Li J et al (2011) Evaluation of performance and microbial community in a two-stage UASB reactor pretreating acrylic fiber manufacturing wastewater. Bioresour Technol 102(10):5709–5716. https://doi.org/10.1016/j.biortech.2011.02.111
Lier JBV et al (2010) Anaerobic sewage treatment using UASB reactors: engineering and operational aspects. In: Environmental anaerobic technology: applications and new developments. https://doi.org/10.1142/p706
Lu X et al (2015) Operation performance and granule characterization of upflow anaerobic sludge blanket (UASB) reactor treating wastewater with starch as the sole carbon source. Bioresour Technol 180:264–273. https://doi.org/10.1016/j.biortech.2015.01.010
Mgana SM (2003) Towards sustainable and robust on-site domestic wastewater treatment for all citizens. PhD Thesis, Wageningen University Wageningen, The Netherlands
Nicolella C, van Loosdrecht MCM, Heijnen JJ (2000) Wastewater treatment with particulate biofilm reactors. J Biotechnol 80(1):1–33. https://doi.org/10.1016/S0168-1656(00)00229-7
Noyola A, Rivera AP, Sagastume JMM, Güereca LP, Padilla FH (2012) Typology of municipal wastewater treatment technologies in Latin America. CLEAN Soil Air Water 40(9):926–932. https://doi.org/10.1002/clen.201100707
Oliveira SC, von Sperling M (2009) Performance evaluation of UASB reactor systems with and without post-treatment. Water Sci Technol 59(7):1299–1306. https://doi.org/10.2166/wst.2009.138
Pompeo RP et al (2016). Influence of drying beds on the reduction of helminth eggs and thermotolerant coliforms in sewage sludge from anaerobic sludge blanket reactors (UASB). In: XXXV Congreso AIDIS, Colombia (in Portuguese). http://www.aidisnet.org/PDF_mem/35INT/ID%201791_ed.pdf. Accessed 25 May 2017
PROBIOGAS (2017) Technical guide of biogas energy recovery in sewage treatment plants. ISBN 978-85-7958-041, Brazil (in Portuguese). https://www.giz.de/en/downloads/probiogas-guia-etes.pdf. Accessed 18 April 2017
Rizvi H et al (2015) Start-up of UASB reactors treating municipal wastewater and effect of temperature/sludge age and hydraulic retention time (HRT) on its performance. Arab J Chem 8(6):780–786. https://doi.org/10.1016/j.arabjc.2013.12.016
Santos DS et al (2017) Effect of bed drying on the physico-chemical and microbiological characteristics of sludge from upflow anaerobic blanket reactor used in sewage treatment. Eng Sanit Ambient 22(2):341–349. https://doi.org/10.1590/s1413-41522016100531(in Portuguese)
Silva ALB et al (2005) Methanogenic biomass behavior in a UASB reactor treating sewage and sludge from submerged aerated biofilters. In: Congresso Brasileiro de Engenharia Sanitária e Ambiental, vol 23, ABES, pp 1–6 (in Portuguese). http://www.bvsde.paho.org/bvsacd/abes23/II-231.pdf. Accessed 25 May 2017
Sperling MV (2016) Urban wastewater treatment in Brazil. Technical note no IDB-TN-970. Inter-American Development Bank, Brazil. https://publications.iadb.org/bitstream/handle/11319/7783/Urban-wastewater-treatment-in-Brazil.pdf. Accessed 28 May 2017
Sperling MV, Chernicharo CAL (2005) Biological wastewater treatment in warm climate regions. IWA Publishing, London
Sperling MV, Chernicharo CAL (2007) Basic principles of wastewater treatment, Biological wastewater treatment series, Chapter 2. IWA publishing, London
Strande L, Ronteltap M, Brdjanovic D (2014) Faecal sludge management systems approach for implementation and operation. IWA Publishing, London
Tchobanoglous GH et al (2013) Wastewater engineering: treatment and reuse. IWA Publishing, New York
Tilley E et al (2014) Compendium of sanitation systems and technologies. Swiss Federal Institute of Aquatic Science and Technology (Eawag), Dübendorf, Switzerland
Vlyssides A, Barampouti EM, Mai S (2008) Determination of granule size distribution in a UASB reactor. J Environ Manag 86(4):660–664. https://doi.org/10.1016/j.jenvman.2006.12.018
Wang LF et al (2017) Response of extracellular polymeric substances to thermal treatment in sludge dewatering process. Environ Pollut 231:1388–1392. https://doi.org/10.1016/j.envpol.2017.08.119
Wanke R (2005) Natural drainage of free water from UASB sludge conditioned with polyelectrolytes in vertical permeameter. Master Thesis, Federal University of Espírito Santo, Brazil (in Portuguese)
Ye F, Liu X, Li Y (2014) Extracellular polymeric substances and dewaterability of waste activated sludge during anaerobic digestion. Water Sci Technol 70(9):1555–1560. https://doi.org/10.2166/wst.2014.401
Yu GH, He PJ, Shao LM, He PP (2008) Stratification structure of sludge flocs with implications to dewaterability. Environ Sci Technol 42(21):7944–7949. https://doi.org/10.1021/es8016717
Acknowledgements
The authors acknowledge the financial support provided by the following agencies that support scientific and technological development in the country: National Council for Scientific and Technological Development (CNPq), Espírito Santo Research Foundation (FAPES) and Project and Study Funding Agency (FINEP) (Grant Number: 01.06.0593.00—CHAMADA PÚBLICA MCT/FINEP—AÇÃO TRANSVERSAL, BRAZIL).
Author information
Authors and Affiliations
Corresponding author
Ethics declarations
Conflict of interest
The authors declare that they have no conflict of interest.
Additional information
Editorial responsibility: BV Thomas.
Rights and permissions
About this article
Cite this article
Gonçalves, R.F., Louzada, L.M. & Wanke, R. A sludge purging procedure that increases the robustness of upflow anaerobic sludge blanket reactors in sewage treatment. Int. J. Environ. Sci. Technol. 16, 7943–7952 (2019). https://doi.org/10.1007/s13762-019-02397-1
Received:
Revised:
Accepted:
Published:
Issue Date:
DOI: https://doi.org/10.1007/s13762-019-02397-1